2015 BMW X1 Engine Problems

The contact owned a 2015 BMW X1. The contact stated that upon starting the vehicle, she noticed there was smoke emerging from underneath the hood, and it caught fire. The contact was able to exit the vehicle safely. The fire department was able to extinguish the fire. The service warning light was illuminated prior to the failure. There were no reported injuries, air bag deployments, or crashes. A police report was filed. The vehicle was towed to her residence. The local dealer was contacted, but there was no assistance provided. The vehicle was not diagnosed or repaired. The vehicle was deemed a total loss. The manufacturer was contacted, but no assistance was provided. The failure mileage was approximately 95,800.

The contact owns a 2015 BMW X1. The contact stated that while starting the vehicle, the vehicle hesitated while starting. Additionally, while stopped in traffic, the vehicle was shaking abnormally. The check engine warning light was illuminated. The vehicle was taken to an independent mechanic, who determined that the camshaft position sensor needed to be replaced. The vehicle was not yet repaired. The manufacturer was made aware of the failure. The failure mileage was approximately 97,000.

The timing chain jumped, shredding the plastic teeth which ended up in oil pump causing complete engine shut down. The certified mechanic says this is a known design flaw in the N20 engines.

I had to replace the Oil Fliter housing with oil cooler because it was made out of plastic and caused an oil and antifreeze. The repair man told me that engine part were made out of plastic and tend to fail over time.

On Sunday, [XXX] while driving the 2015 BMW X1 on [XXX] , the car overheated. The vehicle was brought to the side of the road, stopped turned off and towed to BMW of Warwick, Rhode Island. On Monday, August 4, 2025, at my home residence I received a recall notice from BWM indicating that there was a recall for the water pump control module and/or water pump. Water could get to the area and cause a short or fault into a fire. It was determined that the vehicle's water pump failed by the dealership and that the module was not the cause. This is way too coincidental. The dealership and/or BMW refused to replace the pump under warranty and only installed a shield over the unit. It is my contention that the module was exposed to moisture for over 10 years such that the electrical pump suffered premature wear and tear. The parts match the recall description. I am seeking reimbursement of $955.44 for the cost of replacement. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

The contact owns a 2015 BMW X1. The contact received notification of NHTSA Campaign Number: 24V608000 (Engine and Engine Cooling, Electrical System); however, the part to do the recall repair was not yet available. The local dealer was contacted. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was made aware of the issue. The contact had not experienced a failure. VIN tool confirms parts not available.

The contact owns a 2015 BMW X1. The contact stated that while the vehicle was at an independent mechanic for maintenance, the contact was informed that the water pump had failed. The vehicle was not repaired. The contact stated that prior to the visit, the vehicle was taken to the dealer; however, the cause of the failure was not found. The failure persisted. On a separate occasion, while the vehicle was parked, the front passenger's side door failed to open as intended from the outside, and the front passenger's side door only opened from the inside of the vehicle. No warning lights were illuminated. The vehicle was taken to the dealer and an independent mechanic. The vehicle was not repaired due to the cost. The contact stated that on a separate occasion, the front passenger’s side rear window failed to function as intended. There was an abnormal sound while rolling up the window, and the window failed to roll up. The vehicle was not taken to the dealer or an independent mechanic. The vehicle was not repaired, and the failure persisted. The contact stated that prior to the other failures, the sliding cover on the sunroof failed to function as intended. The sliding cover was stuck, and the contact was unable to move the sliding cover. The contact related the failure to NHTSA Campaign Number: 24V608000 (ENGINE AND ENGINE COOLING, ELECTRICAL SYSTEM). However, the VIN was not included. The vehicle was not repaired for the failure. Most recently, when the vehicle was restarted, the message "Passenger Restraint System Malfunction" was displayed. The contact used a personal scanner to clear the message. The vehicle was not repaired after the most recent failure. The manufacturer was not notified of the failure. The failure mileage was approximately 110,000.

The contact owns a 2015 BMW X1. The contact received notification of NHTSA Campaign Number: 24V608000 (ENGINE AND ENGINE COOLING, ELECTRICAL SYSTEM); however, the part to do the recall repair was not yet available. The local dealer was contacted. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was made aware of the issue. The contact had not experienced a failure. VIN tool confirms parts not available.

The contact owns a 2015 BMW X1. The contact stated while driving at an undisclosed speed, there was smoke coming from the engine compartment, after which the temperature gauge indicated that the engine was overheating. The engine overheating warning light was illuminated. The vehicle was taken to the dealer, who diagnosed failures with the thermostat and radiator hose. The vehicle was repaired, but the failure reoccurred. The vehicle was taken to the dealer and was diagnosed with engine failure. The vehicle was not repaired. After investigating the failure, the contact related the failure to NHTSA Campaign Number: 24V608000 (Engine and Engine Cooling, Electrical System); the VIN was included, but parts were not yet available. The manufacturer was made aware of the issue and confirmed that parts were not yet available. The failure mileage was 134,000.

The contact owns a 2015 BMW X1. The contact stated while driving 40-45 MPH, the engine overheated. The service engine warning light was illuminated. The thermostat symbol was displayed. The vehicle was towed to an independent mechanic who determined that an unknown hose was cracked. The mechanic performed a compression test, and the top of the radiator was cracked. The vehicle was repaired, but the failure recurred. The contact was adding coolant to the reservoir occasionally. The contact stated that coolant was leaking from the vehicle. The contact stated that while driving at an undisclosed speed, the vehicle shut off. The contact stated that the vehicle failed to shift into gear. The vehicle was towed to the residence. The contact received notification of NHTSA Campaign Number: 24V608000 (Engine and Engine Cooling, Electrical System); however, the part to do the recall repair was not yet available. The local dealer was contacted. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was not made aware of the issue. The failure mileage was approximately 118,000. VIN tool confirms parts not available.

The contact owns a 2015 BMW X1. The contact received notification of NHTSA Campaign Number: 24V608000 (Engine and Engine Cooling, Electrical System); however, the part to do the recall repair was not yet available. The local dealer was not contacted. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was made aware of the issue. The contact had not experienced a failure. VIN tool confirms parts not available.

This is a complaint surrounding the recall on the vehicle. I have called the dealerships closest to me 4 times over the last month and a half to remedy with no such luck. My car 12/15, was smoking from the water pump location in the engine. It has done this when driving for more than 20 minutes or driving for the first time if taking the weekend off from doing so. There is a burning smell that comes in from the vents. I have had the oil changed and inspected, there was no leak found either time. there is "no remedy available" according to the dealership but this has been ongoing for 4 months. There is a fire hazard, I have relayed that I have seen smoke but have to drive the car as it is a daily driver for my family. no solution, even temporary has been discussed from the dealer.

The contact owns a 2015 BMW X1. The contact received notification of NHTSA Campaign Number: 24V608000 (Engine and Engine Cooling, Electrical System); however, the part to do the recall repair was unavailable. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was not made aware of the issue. The contact had not experienced a failure. VIN tool confirms parts not available.

Water pump recall has not been provided since the month of August . Engine light warning light just appeared on my vehicle

The contact owns a 2015 BMW X1. The contact received notification of NHTSA Campaign Number: 24V608000 (Engine and Engine Cooling, Electrical System). The contact stated that on several occasions while the vehicle was parked, the contact observed condensation under the engine compartment. The vehicle was taken to an independent mechanic where it was diagnosed and determined that unknown parts needed to be replaced. The vehicle was not repaired. The vehicle was then towed to a dealer but was not diagnosed. The manufacturer was notified of the failure. The failure mileage was approximately 100,000.

The contact owns a 2015 BMW X1. The contact received notification of NHTSA Campaign Number: 24V608000 (Engine and Engine Cooling, Electrical System). The contact stated that there was a whistling sound coming from the vehicle while driving. Additionally, there was an abnormal burning odor coming from the vehicle. The “Service Soon” message was displayed. The service and oil messages were displayed on the information screen. The local dealer was contacted, but the vehicle was not diagnosed or repaired. The manufacturer was contacted, and confirmed that parts were not yet available. The failure mileage was approximately 50,000.

The contact owns a 2015 BMW X1. The contact stated that the coolant temperature warning light was illuminated. The contact stated that while driving at various speeds and depressing the accelerator pedal, the vehicle hesitated to respond and there was smoke coming out from underneath the hood. An unknown warning light was illuminated. The vehicle was taken to the dealer, where the contact was informed that there was a coolant leak. The dealer diagnosed that the oil filter gasket housing had failed and needed to be replaced. The vehicle was then taken to an independent mechanic, where the oil filter gasket housing was replaced, however the failure progressively worsened. The contact stated that there was oil leaking in the engine compartment, and there was a strong oil odor coming through the A/C vents. The contact received notification of NHTSA Campaign Number: 24V608000 (Engine and Engine Cooling, Electrical System); however, the part to do the recall repair was not yet available. The local dealer was contacted. The vehicle was not diagnosed or repaired. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was not made aware of the failure. The failure was approximately 109,000. VIN tool confirms parts not available.

The contact owns a 2015 BMW X1. The contact stated while driving approximately 50 MPH, the vehicle lost automotive power with the check engine warning light illuminated. The local dealer was not contacted. The vehicle was not diagnosed or repaired. The vehicle was towed and left at the residence. The contact related the failure to NHTSA Campaign Number: 24V608000 (Engine and Engine Cooling, Electrical System); however, parts were not yet available. The manufacturer was not made aware of the failure. The failure mileage was approximately 88,000.

The contact owns a 2015 BMW X1. The contact received notification of NHTSA Campaign Number: 24V608000 (ENGINE AND ENGINE COOLING, ELECTRICAL SYSTEM); however, the part to do the recall repair was unavailable. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was made aware of the issue. The contact had not experienced a failure. VIN tool confirms parts not available.

While driving, an engine malfunction message appeared on the X1's panel display. The warning message was to proceed, under "reduced power", to a dealer as soon as possible to initiate repairs before engine damage could occur. Under these emergency conditions all panel functions, such as GPS, were blocked. I believe this failure, occurring under normal operating conditions, puts passengers at risk. At the dealer engine error codes identified the N55 engine's internal failure to be of the Valvetronic system. The 2015 X1 was out of warranty even though its mileage was 46,600 which, if still under the 4 year, 50,000 mile warranty, would have qualified for a warranty repair.