There are 50 owner-reported fuel system complaints for the 2008 Chevrolet Corvettein NHTSA's database. These are unverified consumer reports and may not reflect confirmed defects.
My recently purchased 2008 was taken to the local chevy dealer for gas fumes in the garage. The technician reported "The smell is coming from the sending unit on the driver side. There was fuel dripping down the side of the tank and the tank was wet. So the sending unit needs to be replaced" The car has only 16,427 miles on it and has been garage kept. I believe that leaking fuel is a very serious safety issue and that the now expired special service bulletin 150682 should have been a mandatory recall.
Fuel sending unit in gas tank behind the drivers side is leaking gas making it impossible to park the car in the garage. There is a great possibility of fire due to this issue. No, I have not taken it to the dealer as of today but I am going to schedule it. No. No.
cracked fuel pump housing causing vapors to vent out possibly causing a fire if stored extended periods of time indoors, and if crack is big enough fuel will drip down the back of the fuel tank onto the exhaust and possibly starting a vehicle fire
Bought this vehicle recently and filled it up with fuel and fumes overtook the cabin area and some leaked out the top of the tank down through the tank support. From the research I have done, this is a common problem that Chevy has ignored. The parts are too expensive to just replace everything with new.
There is a strong smell of gas in the passenger compartment and a very strong smell of gas gas on the drivers side near the rear tire. The Chevy dealer has confirmed the the gas smell is due to a know defect where the fuel pump develops cracks in the housing because of the poor quality plastic used. The dealer estimates that it will cost between $3,000 to $4,000 to repair. This is a very dangerous problem. I'm afraid with the very strong smell of gas that an electric spark might cause the car to explode or when it's stored inside cause a vehicle and structure fire. Why has the NHTSA not made GM do a recall for this defect. It is a very serious problem. Owners of any C6 corvette are sitting on a time bomb and their life is in danger. GM has already admitted that it is a design defect but has only issued a service bulletin. Do something before people die.
This car has suffered a known defect that causes fuel to leak out of the tank when the tank is more than 1/2 full. Unfortunately, the leak in my vehicle occurred outside the window that GM arbitrarily set up. (10 years after vehicle put in service or 120,000 miles whichever comes first. My vehicle is a 2008 with 94,000 miles and the problem occurred recently and after GM's window. Therefore, GM will not fix this leaking fuel tank and correct a potentially life-threatening issue. The problem is that this is a serious safety issue with strong fumes inside the cars cabin and strong fumes outside the vehicle with leaking fuel on the tank. The fumes and the leaking fuel are both extreme fire issues. This is a known issue and a known condition that could cause fire and loss of life. NHTSA needs to issue an immediate safety recall to have GM fix all of these leaking fuel tanks.
Gas smells when tank is over half full it’s the plastic fuel system on to of tank is starting to crack and I was reading they have been recalled before but has gone off and this is danger and might cause a fire with the saddle bags across the back and only 30,700 miles on car
After refilling my car with gas and parking it in my garage, I noticed that fuel was actively LEAKING from the bottom of my car!@#! Within a few minutes, fuel was pooling under my car on the garage floor. I immediately moved it outside and ran the car for an hour to use up enough fuel so that it was no longer actively leaking. Unfortunately, there still remains an extremely strong fuel smell, even inside the car when driving. With this fuel smell there are strong vapors in my garage. I have to park the car outside all the time, otherwise my garage will be filled with gas vapors immediately (kind of like an air-fuel bomb). The dealer tells me that it will cost $3000-4000 to fix it. This is a HUGE safety issue and should be covered under a factory recall!!!!
Hello NHTSA, Fuel leaks from drivers side fuel tank. I see fuel tracks down side of tank, so conclude fuel is leaking from top of tank or from fuel pump. Fuel components are plastic, and now 17 years old, so they are probably cracked from age. I have strong smell of fuel in my garage, and puddle of fuel under drivers side tank. This is a safety fire hazard gas can leak down to the exhaust system. ' Searching Corvette forums - this is a known issue many years. Searching nhtsa - there are a number of complaints logged by other C6 Corvette owners with the identical issue. GM must fix or at least share to fix this issue. The defect is caused by GM making the conscious decision to swap more durable metal parts for less durable plastic parts in the fuel pump/tank assembly. Please put pressure on GM to reach out to current Corvette owners and their dealership network to get this issue corrected and at a minimum share the cost with Corvette Owners. Let's not allow this issue be one that causes injury or even death. Thank you
Just bought 2008 corvette with 46,000 miles. Very strong smell of fuel in car and in garage after fill up. This issue is definitely a safety issue
The other day from my garage i smelled a overtaking smell of gas coming from my 2008 Corvette with only 22,300 miles on it. I thought it was coming from my gas cap , so i replace the cap. Replacing the gas cap didn't help there was still a overwhelming gas smell coming from the left side of the car. I also notice when the gas tank drops below a 1/2 tank the smell seams to go away. I found out there are hundreds of complaints about this issue and that there was a special coverage adjustment issued covering this problem with the Primary Tank Module Flange Fuel and Vapor Leaks for a limited time and miles. I believe such a serious safety issue there should have been a recall to fix this problem by GM regardless of time and mileage. I have taken the car to Chevrolet dealer which has confirmed the problem.
Extreme gas fumes because of faulty fuel pump assembly. When in a closed garage area fuel leaks out of plastic fuel pump top then the vehicle is half full or more. GM to this day has not changed the part design. So you have replace it the same kind of faulty part if you can even find one. They claim since no one has died they feel a recall is not needed. I just replaced mine for $3000.00 at a Chevrolet dealership. Don't mind paying once but how long will this part with the faulty design last? I can't believe they can get away with this. Someone's going to get hurt or killed by an explosion if something isn't done. Long time GM customer but this is not except able. I know the car is 16 years old but this has been a problem since day one.
Fuel pump module leaking fuel causing fuel to drip onto the exhaust pipe. Potential fire hazard to occupants and occupants of area it is parked near. Yes the dealer and repair shop have confirmed it has cracked when it should not. It has only been inspected by the repair shop due to immediate safety concern. The symptoms were a very strong fuel odor and a puddle of fuel on the ground in the beginning of November.
Fuel smell when filling tank to full
The car is leaking fuel from the gas tank. I just purchased it 4/20/24. There was a safety recall years ago. This vehicle may not have had the issue at the time of the recall.
The contact owns a 2008 Chevrolet Corvette. The contact stated that on several occasions while driving at various speeds with a half tank of fuel or more, the contact observed a strong fuel odor inside the vehicle. The contact stated that the vehicle was parked multiple times and he also observed a strong fuel odor from outside of the vehicle. The vehicle was not diagnosed or repaired. The manufacturer was not notified of the failure. The failure mileage was approximately 32,600. The contact stated the vehicle was taken to the dealer May 15 and was confirmed to have a fuel leak at the fuel pump.
I purchased this car just 10 days ago. The first night that I got it I went in the garage and smelled a lot of gas smell. Many people including myself have their gas water heater in the garage and I started to really panic. I googled the issue and it's apparent that this is a very common issue on the 2008-2013 corvettes and GM has used a faulty fuel pump module that started deteriorating over short period of time. I had a very sleepless and stressful night that night in fear of me waking up to a garage fire. I beg of you to please start a recall on this before anyone loses their life and their house
fuel leak and smell from fuel pump
The car is giving off a STRONG smell of gas.
Gas vapors caused by leaking gas tank see service bulletin 15682.
Showing 1–20 of 50 complaints
Complaints are unverified consumer reports submitted to NHTSA. A high complaint count may reflect vehicle popularity, not defect severity. Data sourced from NHTSA public records.
Data synced from NHTSA on Apr 25, 2026