2005 Chevrolet Tahoe Fuel System Problems

FUEL BACK FLOWS OUT THE GAS TANK ON THE GROUND NO MATTER THE FUEL LEVEL. FUEL WILL DUMP ONTO THE GROUND AT VARYING DEGREES. MULTIPLE REPORTS BY THE FORUMS. I WILL BE SUBMITTING THIS LINK SO OTHERS CAN POST TO PROVE THIS IS NOT A ONE TIME THING

TL* THE CONTACT OWNS A 2005 CHEVROLET TAHOE. WHILE ADDING FUEL TO THE FUEL TANK, THE FUEL PUMP SHUT OFF AND THE FUEL SPILLED OUT. THE CONTACT STATED THAT THE FAILURE OCCURRED EACH TIME THE VEHICLE WAS FUELED. THE VEHICLE WAS NOT TAKEN TO A DEALER OR AN INDEPENDENT MECHANIC FOR DIAGNOSTIC TESTING. THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 122,836.

VERY BAD FUEL LEAK ON TOP OF GAS TANK GAS POURING ALL OVER THE TANK

THE FUEL LINE RUSTED THROUGH WHERE IT EXITS THE GAS TANK CAUSING FUEL TO LEAK ALL OVER THE TOP OF THE GAS TANK.

TIGHTEN FUEL CAP WARNING STARTED COMING ON AND NOW HAVING ISSUES WITH REFUELING. GAS PUMP SHUTS OFF CONSTANTLY WHILE TRYING TO REFUEL AND GAS SPEWS OUT ALL OVER, TAKES FOREVER JUST TO MANAGE TO PUMP 10.00 WORTH OF GAS IN IT, VERY FRUSTRATING TO SAY THE LEAST ALONG WITH MONEY WASTED FROM FUEL SHOOTING OUT WHILE TRYING TO PUMP GAS. SEEMS LIKE GM WOULD HAVE A RECALL ON THIS ISSUE AS FROM DOING RESEARCH THERE ARE MANY OTHERS WITH THIS SAME PROBLEM !!!!

TL* THE CONTACT OWNS A 2005 CHEVROLET TAHOE. THE CONTACT SMELLED FUEL INSIDE AND OUTSIDE THE VEHICLE. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC WHO STATED THAT THE FUEL PUMP NEEDED TO BE REPLACED. THE VEHICLE WAS REPAIRED. THE MANUFACTURER WAS NOT NOTIFIED. THE APPROXIMATE FAILURE MILEAGE WAS 113,000.

TL* THE CONTACT OWNS A 2005 CHEVROLET TAHOE. THE CONTACT STATED THAT THE FUEL GAUGE FAILED TO OPERATE. THE CONTACT MENTIONED THAT WHEN THE VEHICLE WAS TURNED OFF AND RESTARTED; THE FUEL GAUGE LEVEL WOULD DISPLAY A DIFFERENT AMOUNT. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC. THE TECHNICIAN DIAGNOSED THAT THE FUEL SENDING UNIT NEEDED TO BE REPAIRED. THE VEHICLE HAD NOT BEEN REPAIRED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 103,000.

FUEL LINE RUSTED OUT. *TR

I OWN A 2005 CHEVY TAHOE I BOUGHT NEW. LAST YEAR IN 2012 THE FUEL LINES COMING OUT OF THE FUEL PUMP ROTTED OUT AND I HAD TO REPLACE THE WHOLE PUMP. EARLY THIS YEAR (2013) THE TRANSMISSION LINES ROTTED OUT AND ALL HAD TO BE REPLACED, IN SEPTEMBER THIS YEAR (2013) THE BRAKE LINES ROTTED OUT AND HAD TO BE REPLACED. LUCKY FOR ME I WAS JUST LEAVING MY DRIVEWAY. I AM VERY DISAPPOINTED WITH THIS GM VEHICLE. I DON'T KNOW IF I WOULD EVER BUY A GM VEHICLE AGAIN. *JS

TL* THE CONTACT OWNS A 2005 CHEVROLET TAHOE. THE CONTACT STATED THAT WHILE DRIVING 35 MPH, THE VEHICLE STALLED. THE CONTACT STATED THAT THE VEHICLE RAN OUT OF FUEL WHEN THE FAILURE OCCURRED, BUT THE FUEL GAUGE DID NOT DISPLAY AN EMPTY READING. THE VEHICLE WAS TAKEN TO AN AUTHORIZED DEALER AND THE CONTACT WAS INFORMED THAT THE FUEL LEVEL SENSOR NEEDED TO BE REPAIRED. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER OFFERED NO ASSISTANCE. THE FAILURE MILEAGE WAS 97,000 UPDATED 10/17/12*LJ

FUEL SENDING UNIT NOT FUNCTIONING ON 2005 CHEVROLET TAHOE. SPOKE WITH MY MECHANIC WHO STATED IT WAS A VERY COMMON PROBLEM WITH CHEVROLET TAHOE. THE SENDING UNIT MADE IT SO THE GAS DID NOT REGISTER ON THE FUEL GAUGE MAKING IT LIKELY TO RUN OUT OF GAS AT AN INOPPORTUNE TIME, POSSIBLY CREATING A TRAFFIC HAZARD OR CRASH. *TR

THE INCIDENT IS THE VEHICLE STALLING ON THE INTERSTATE WHICH COULD HAVE LEAD TO A ACCIDENT IF THE VEHICLE BEHIND ME HAD NOT SWIRVED AT THE LAST MOMENT. THE FUEL GUAGE REGISTERD 3/4 TANK OF GAS. ONCE STOPPED AT THE NEXT EXIT I WAS ABLE TO PUT 25 GALLONS IN THE TANK. I HAVE SINCE NOTICED THAT THE GUAGE WILL READ SPORATIC READINGS BUT THEN SETTLE BACK TO AROUND THE 3/4 TANK MARK. *TR

THE OIL GAUGE ON MY 2005 CHEVROLET TAHOE WAS REPLACED ON APRIL 6, 2011. THE NEEDLE WAS AS FAR OVER ON THE RIGHT SIDE OF THE GAUGE (LOOKING AT IT) AS IT COULD GO. IT CLEARLY WAS NOT READING THE AMOUNT OF OIL PRESSURE. THE ENTIRE DASH PANEL HAD TO BE REPLACED TO CORRECT THIS PROBLEM AFTER IT WAS DETERMINED THERE WERE NO BAD CONNECTIONS TO THE UNIT. THE DASH PART WAS $350.00. *TR

TL* THE CONTACT OWNS A 2005 CHEVROLET TAHOE. THE CONTACT STATED THAT AS HE REFUELED THE VEHICLE, GASOLINE BEGAN SPEWING FROM THE FILLER NECK PREVENTING HIM FROM REFUELING. THE VEHICLE WAS TAKEN TO THE DEALER BUT WAS NOT DIAGNOSED FOR THE FAILURE. THE MANUFACTURER WAS CONTACTED WHO STATED THAT IT WOULD BE AT THE DISCRETION OF THE DEALER IF THEY WANTED TO COVER THE COSTS OF REPAIR. THE VEHICLE WAS NOT REPAIRED. THE FAILURE AND CURRENT MILEAGE WAS 65,000.

FUEL GAUGE ON 2005 CHEVROLET TAHOE DOES NOT ACCURATELY REPORT FUEL LEVEL. *TR

2005 TAHOE-DUE TO FAULTY PURGE CANISTER SOLENOID (EVAP) CANNOT PUT GAS IN VEHICLE DUE TO THE AIR HAS NOWHERE TO ESCAPE WHILE FILLING. GAS SPURTS BACK OUT OF FUEL NECK CAUSING POTENTIAL SAFETY AND ENVIRONMENTAL HAZARD. GM HAS A NEW REDESIGNED PART BUT DOES NOT REPLACE OR REPAIR AT THEIR COST. CONSUMER IS GETTING CHARGED AND REQUIRED PAY FOR THEIR ACKNOWLEDGED PROBLEMS. *TR

2005 CHEVROLET TAHOE. FUEL PUMP ERUPTION, DUE TO THE SMELL OF COMING FROM THE VEHICLE. THE CONSUMER ALSO NOTICED A LEAK FROM UNDER THE VEHICLE. THE FUEL PUMP AND FUEL LINE NEEDED TO BE REPLACED. *MW ALSO, THE WINDOW SWITCH WAS REPLACED AND THE KEY BECAME STUCK IN THE IGNITION. *JB

EVERY TIME I START MY VEHICLE, MY GAS LIGHT GOES ON AND INDICATES I AM LOW ON FUEL WHEN I HAVE GAS IN IT. AFTER DRIVING FOR AWHILE THE NEEDLE WILL GO UP BUT IT IS NOT GIVING AN ACCURATE READING OF HOW MUCH GAS IS IN THE TANK. *TR

FUEL GAUGE IS NEVER ACCURATE. SOMETIMES IT TAKES 15 MINUTES AFTER DRIVING FOR FUEL TO REGISTER ON GAUGE. THEY LIGHT USUALLY STAYS ON EVEN WHEN I HAVE GAS???

FUEL GAUGE IS CONSTANTLY INACCURATE. THE CAR HAS A 26 GALLON TANK, AFTER FILLING UP AND DRIVING SOMETIMES 50 MILES THE GAS LIGHT WILL COME ON TELLING ME I AM OUT OF GAS. I HAVE SIT ON LEVEL SURFACES WATCHING THE GAUGE GO FROM FULL DOWN TO COMPLETELY EMPTY SEVERAL TIMES. THIS PROBLEM COULD POTENTIALLY LEAVE A PERSON STRANDED AS THEY DO NOT KNOW HOW MUCH GAS IS IN THE VEHICLE. *TR