2018 Ford Ecosport Complaint Log

The contact owns a 2018 Ford EcoSport. The contact stated while driving 40 MPH, the vehicle started making a rattling sound. No warning lights were illuminated. The vehicle was taken to the residence. The contact stated that the vehicle then failed to restart. The vehicle was towed to the dealer and the contact was informed that the engine needed to be replaced. The vehicle was not repaired. The manufacturer was contacted, and a case was opened. The failure mileage was 63,500.

The vehicle had an intense loss of power and slowed down to a few miles per hour even with the gas pedal pushed down all the way. This put us in harms way until we could get out of the way of moving traffic. In a parking lot, the vehicle stopped and would not start. The engine light came on briefly before the event. The vehicle was towed to the dealer. The service department indicated that the engine was bad and a new one would be needed. The vehicle was held by the service department for about a month until another engine became available. The failed engine was then replaced. The service documentation indicated that there was debris in the failed engine. Due to the extended warranty in place, only the $100 deductible fee was paid. While we are grateful that we did not have to pay the full price for the repair, our main concern is the sudden failure of the engine.

The contact owns a 2018 Ford EcoSport. The contact stated while driving 65 MPH, the contact heard an abnormal sound and the vehicle decelerated to 40 MPH unintendedly. The vehicle failed to accelerate as needed. The wrench and low oil pressure warning light was illuminated. The vehicle was taken to a dealer to be diagnosed. The contact was informed that the failure was due to a faulty engine. The vehicle had not been repaired. The manufacturer was not made aware of the failure. The failure mileage was approximately 59,000.

The contact owns a 2018 Ford EcoSport. The contact stated that while her daughter was driving approximately 60 MPH, the check engine warning light illuminated, and the vehicle stalled. The vehicle was towed to the local dealer but was not diagnosed or repaired. The vehicle was taken to an independent mechanic, who stated that there were metal shavings in the pan, and that there was no oil in the engine. The manufacturer was not contacted. The failure mileage was approximately 65,000.

Urgent Complaint - Engine Failure Issue in 2018 Ford EcoSport I am writing to bring to your attention a critical safety concern regarding the engine failure in my 2018 Ford Eco Sport. This incident not only endangered the lives of my wife and daughter but also highlights a pervasive issue that appears to be affecting a significant number of vehicles. On 10/28/2023, my wife and daughter were driving on the freeway when the engine began to sputter and ultimately shut down. Simultaneously, an oil light illuminated, indicating a catastrophic engine failure was imminent. They narrowly managed to reach a safe location at the airport before the car completely ceased functioning. This situation posed a severe threat to their safety, especially considering the high-speed freeway conditions. Upon inspection by a certified Ford dealership, it was confirmed that the engine experienced a critical failure. This dealership also conveyed that such failures have been observed in numerous vehicles of the same make and model due to a belt-related issue. It is disconcerting to learn that Ford has introduced an updated engine design post-2018, which implies an acknowledgment of this inherent flaw. Regrettably, our vehicle is no longer under warranty, leaving us with the substantial financial burden of replacing the engine. It is deeply unjust that we, as consumers, should bear the expense for a systemic manufacturing defect that has affected countless individuals. I implore you to investigate this matter thoroughly and take appropriate action to rectify the situation. It is imperative that Ford assumes responsibility for the faulty engine in our 2018 model, as well as in all affected vehicles, by initiating a recall or offering financial assistance for repairs. I appreciate your prompt attention to this urgent matter and trust that you will prioritize the safety and well-being of consumers who have placed their trust in Ford's products.

The car, (oil pump), stopped pumping oil to the engine. Was driving along, the check oil light came on, then it stopped moving. All the warning lights lit up. There was plenty of oil in the car.

10/27/23 Driving and "Low Engine Oil Pressure Warning" came on. Pulled over as soon as I could. Husband loaded it up on a trailer the next morning to the Ford dealership. They called that afternoon to tell us that a NEW ENGINE is required!!!! It took until 11-24-23 and OVER $5,500 for a new engine to get my vehicle back! There is a 3 year warranty on the new engine, but no reassurance that this will not occur again. The vehicle had only 58,xxx miles on it.

Driving and oil light came on suddenly pulled over asap then check engine light and battery light came on car quit working. Checked oil and was filled to line on dip stick. Tried restarting engine wouldn’t start. Towed to repair shop engine seized up needs new engine.

The contact owns a 2018 Ford EcoSport. The contact stated while driving at an undisclosed speed, the low engine oil warning light illuminated, and the vehicle stalled. The vehicle was towed to a local dealer where the failure was linked to NHTSA Campaign Number: 23V905000 (Engine and Engine Cooling); however, the part to do the recall repair was not yet available. The contact stated that the vehicle had been at the local dealer for 8-months. The vehicle was not repaired. The manufacturer was not made aware of the failure. The failure mileage was unknown.

My oil pump went out at 73,000 miles. With no oil flowing through the engine I have to replace the pump, turbo, and entire engine. My car was working fine in the morning but driving home was scary. My car could’ve blown up on the tollway. On my way home October 22nd I got a “low engine oil pressure” warning. No warning that morning and car was fine till after 5pm. I’ve had two mechanics look at it and confirmed it was the oil pump that went out and was a problem ford production caused. My engine is on back order and I’m stuck making payments on a car I don’t have

The contact owns a 2018 Ford EcoSport. The contact received notification of NHTSA Campaign Number: 23V905000 (Engine and Engine Cooling) however, the part to do the recall repair was not yet available. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was made aware of the issue. The contact stated while driving approximately 55 MPH, the vehicle began to lose motive power. The contact stated that the "low oil pressure" warning light was illuminated, and there was an audible chime heard. The contact depressed the accelerator pedal and the vehicle failed to respond. The contact stated that the vehicle decelerated to 20 MPH. The contact was able to pull off the highway and stopped and then had the vehicle towed to a dealer. The dealer diagnosed the vehicle and determined that the engine long block and the turbo charger needed to be replaced. The vehicle was not repaired. The contact stated that after the engine failure she received notification of NHTSA Campaign Number: 23V905000 (Engine and Engine Cooling). The contact related the failure to the NHTSA Campaign. The manufacturer was made aware of the failure. The failure mileage was 40,257. VIN tool confirms parts not available.

On Saturday my low oil pressure light came on suddenly as I was pulling into my driveway. I had just gotten my oil changed 2 months ago. The next day I took my car to Jiffy Lube, and as I was getting there the check engine light came on. The mechanics at Jiffy Lube stated it could be the oil pump valve. After that I decided to have my car towed to the local ford dealership to have it checked out. Today the dealership called me to inform me that my engine needed to be replaced and the cost would be $7500. The car is only 5 years old and has 84K miles. I am an extremely good driver with a clean record, and I also get my oil changed at the recommended interval at the ford dealership, so I do not believe that it is a driver issue.

Oil pressure failure on highway. Loss of speed and power.

The contact owns a 2018 Ford EcoSport. The contact stated that after stopping at a stop light, the light turned green and the accelerator pedal was depressed; however, the vehicle lost motive power. The contact was able to restart the vehicle and drive the vehicle to her destination. The vehicle was not diagnosed or repaired by an independent mechanic or dealer. The manufacturer was made aware of the failure and advised the contact to report the failure to the NHTSA Hotline. The failure mileage was approximately 44,000.

I own the 2018 Ford Ecosport 1.0 lt. engine with Ecoboost engine I was 100 miles from home on a business trip when the low oil pressure warning came on with chimes alerting me about the low oil pressure. The notice and chimes remained until I stopped. I've never seen this warning before and nor have I had any problems whatsoever in the 3 years I've owned it. While waiting for a tow back to my home, I looked up some info and found that Ford knew about the oil pressure/oil pump problems and chose to do nothing about it. Luckily I was able to pull over fairly quickly but if I hadn't been able to, I was on a very busy freeway and a mountain pass that could have resulted in a much worse situation like some of the other reports of this issue in their Ecosport. Once home, I had it serviced by a AAA endorsed automotive shop and they determined that the oil pump failed causing the low oil pressure and is basically not replaceable. My engine and my vehicle are totaled. You would only be able to replace the faulty oil pump with the same pump since this is what they use in this vehicle. It's just wrong that Ford knew about this and continues to sell this vehicle. I also can't afford another car. I'd just paid this one off and I loved it. They should pay me for my loss.

The first and last time I drove my vehicle with this issue was [XXX]. I was driving over the pass in WA state and all sides of me were semi's and other vehicles going over the pass. I had a warning message stating I had low oil pressure and to pull over asap. I came to a stop when I could and stopped the car and while I was waiting for the tow truck, I looked up possible issues on my phone and everything I found was very disturbing and accurate. I tried to get an appt. the same day this happened but none of the dealerships close to my hoe had any openings. In order to have AAA pay for the tow, I had to have it towed to a dealership or a certified mechanic on the AAA list. I was over 100 miles from home but I was able to get it towed to a certified mechanic that day. That day was the last time I drove my car. I've tried to get an appt. at a local Ford dealers but nobody returns my calls. They will have to have my car towed to their dealership because it does not run also. The mechanic that did the diagnostic the next day determined the engine had been affected by what he felt was the failure of the oil pump. I submitted a complaint when it happened and was notified of the recall that has since been issued. In my opinion, that recall is more geared to the cars that have not had engine failure yet. It really doesn't address the cars that the engine has already failed due to the oil pump failure. Because this problem is not specifically being addressed on the recall, they will use that as an excuse to not help me at all. Getting the parts they suggest in the recall won't help me with a dead motor. There has to be other alternatives listed in order for me to get help from Ford. They are in total denial as are the dealerships. I don't want to wait until Quarter 2 for the parts when that won't help me at all. I'm getting tired of the runaround and there should be better accountability by ford. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

The contact owns a 2018 Ford EcoSport. The contact stated while driving 60-65 MPH, the low oil pressure warning light illuminated, and a chime sounded. Additionally, the vehicle started losing motive power. The contact veered to the side of the road. The vehicle was towed to an independent mechanic, where it was determined that the engine had seized. The vehicle was then towed to the residence and was later towed to the dealer. The dealer determined that the engine had seized and needed to be replaced. The vehicle was not repaired. The contact received notification of NHTSA Campaign Number: 23V905000 (Engine and Engine Cooling); however, the part to do the recall repair was not yet available. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was made aware of the failure. The failure mileage was approximately 87,023. VIN tool confirms parts not available. The contact stated she needs a car replacement and her loan paid off. Further stating she's still financing this car and as long as she has to do that, and can't get another loan.

My 2018 Ford Ecosport is in recall for oil pump failure which in turn damaged my engine and is not repairable. The recall issued by Ford is attempting to find a fix for the vehicles that have not had the oil pump fail. There's nothing mentioned in the recall about the people whose engines have been destroyed because the oil pump has already failed. We don't have the luxury of being able to continue to drive our cars and the expenses we have incurred because of this disaster is much more than those cars that have not had it happen. What about us? Ford left out the many reports that if the oil pump failed, the engine would need to be replaced or consider replacement. NHTSA NEEDS TO KEEP THIS RECALL OPEN AND REISSSUE IT WITH THE REMEDY FOR THE ENGINES THAT HAVE HAD CATASTROPHIC DAMAGE DUE TO THE OIL PUMP FAILURE.

I've already addressed what happened to my vehicle and a recall has since been issued in Dec 2023. The problem I have is the recall doesn't address the vehicles that have already failed due to the defective oil pump. Mine failed and totaled my engine leaving me without a vehicle on October 17, 2023. You even state in your description of the safety risk if this were to happen by saying it could damage your engine and possibly seize. It needs to be more prominent and highlite the fact that if this happens, your engine is gone, no more engine and no more car. It's more geared to the cars in the recall that haven't had it fail yet! Ford hopes to fix a part in those oil pumps and make it all better. But what about me!! At least everybody else still has a car to drive. I don't. It's gone and I'm still financing it. Ford has repeatedly told me they have no program for me. Nothing they can do. I still am part of that recall and they are breaking the law by not doing something. I need them to replace my car and pay me for everything I've had to incur due to this failure. They have no sense of urgency at all. It doesn't bother them one little bit that people are devastated when something like this happens because how do we get around. How do we get to work. Why can they get away with doing nothing for me and not held responsible. Recalls need to be split when they have vehicles damaged beyond repair for the exact issue the recalls address. They are more for just stating the safety issue if any instead of addressing what happened to each person and how they need to fix it or make it right for the consumer. I'm sick of this and I need to have them make this right.

The contact owns a 2018 Ford EcoSport. The contact stated while driving approximately 35 MPH, the engine started to make an abnormal rattling sound which made the vehicle vibrate. The contact stated no warning light was illuminated. The contact had taken the vehicle to a local dealer. The vehicle was not diagnosed; however, the contact was informed that the vehicle had experienced engine failure. The vehicle had not been repaired. The contact stated that the engine was replaced March 13, 2023, due to an oil pump failure that damaged the engine block. The contact stated that she researched online and related the failure to the Eco Boost engine design. The manufacturer had been informed of the failure. The failure mileage was approximately 69,000.

The contact owns a 2018 Ford EcoSport. The contact received notification of NHTSA Campaign Number: 23V905000 (Engine and Engine Cooling); however, the part to do the recall repair was not yet available. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The contact stated that while driving at an undisclosed speed, the oil pressure warning light illuminated and caused the vehicle to stall. The vehicle failed to restart. The vehicle was towed to the dealer and diagnosed with engine failure. The contact was informed that parts were not yet available. The vehicle was not repaired. The manufacturer was made aware of the failure and referred the contact to the NHTSA Hotline. The failure mileage was approximately 135,000. VIN tool confirms parts not available.

The engine cracked internally, and coolant intrusion is what has been diagnosed by the dealership's service department. A brand new engine is required. I am more than happy to ask the dealer to keep the old engine for inspection, and I have attached photos provided to me from the diagnosis. In these photos, coolant can be seen dripping along the engine walls. There also appears to be a crack between two pistons. This is incredibly disheartening to see at only 38,996 miles. Thankfully, I was parked when the engine had an incredibly rough start and idle. With only three cylinders and two misfiring according to early code retrievals, this might have been nasty had it occurred during travel. It was giving very aggressive shakes before turning off entirely in park. Check engine lights occurred after the engine was failing to work properly, and it was showing piston misfiring codes for two cylinders. This may be a design flaw with the engine design, but I am worried the replacement will have the same issue in the future if a new design was not implemented to correct or amend these issues.

On October 11th my wife’s EcoSport showed a check engine light, so we started to head towards David McDavid’s service. En route, the oil pressure light came on and the car died in the middle of the road right as schools were getting out. A White Settlement Police Officer kindly helped me push the car out of the middle of the road and it was towed to David McDavid Ford. The dealership confirmed that the engine had died as a result of failed oil pressure. We take care of our cars (spending about $1200 annually per vehicle) and for this to happen on a 2018 vehicle is greatly concerning.

The contact owns a 2018 Ford EcoSport. The contact stated that while driving at 3 MPH, the vehicle independently stopped. The contact was able to pull to the side of the road. The check engine warning light was illuminated. The vehicle was towed to a dealer to be diagnosed. The contact was informed that the failure was due to a faulty engine oil pump drive belt. The vehicle had not been repaired. The manufacturer was made aware of the failure and advised the contact to call NHTSA Hotline for assistance. The failure mileage was approximately 87,745.

On or about October 2023, as I was driving my car it started to lose power. I had to pull over, out of traffic, into a parking lot. The car then stalled out and would not start. I had to call AAA to have it towed to SunAuto in North Las Vegas to have it inspected as to the problem. The manager subsequently called me to tell me the engine would have to be replaced as they found metal fragments in the engine cause by the oil pump. The car was out of warranty. I had to replace the engine at an out of pocket cost of $7,300!! Luckly I wasn't driving on the highway at 65 MPH when the engine died!!

The car shut down while driving. The tech explained that the oil pump failed and ruined the engine. The tech also alerted us to this being an issue that the NHTSA was investigating.

-Oil pump failed causing complete engine and turbo failure. It can be inspected. - I was driving at interstate speed in traffic on the interstate and the engine lost power. - Independent service center looked at it and suspected oil pump as issue and sent it to ford dealer and they confirmed oil pump failed and caused total engine and turbo failure. - Ford Dealer has inspected - after the failure occurred, the low oil pressure light came on. after adding oil and restarting the engine, the light remained on.

In October 2023, my oil pump failed while on the freeway, resulting in total engine and turbo failure, severe emotional distress, and a substantial financial burden. I had to pay out of pocket to replace both components. In February 2024, the transmission failed on the freeway, increasing the financial burden already on my shoulders as Ford notified me they would not consider reimbursement for the money already spent on the engine and turbo replacement until 6-8 weeks after I file a report, and they will not allow me to file the reimbursement request until some point in April-June of this year. I drive for work and am now in an extremely difficult position due to the failure of multiple components resulting in serious mental, emotional, and financial duress. My safety was endangered in both cases as I was driving on the freeway in traffic. I do not believe a car less than 6 years old should have an engine, turbo, and transmission failure all just outside of the 5 year warranty within a few months of each other. I believe this violates the implied warranty of merchantability and presents a serious hazard for other owners of this make and model.

I was driving on a trip when without any other warning my low oil pressure light came on and started dinging. I lost the ability to accelerate. Thankfully I was able to get off interstate without causing an accident. The next day I was told I needed a new engine. I have researched this engine and have discovered many other incidents of complete engine failure with these cars. Ford should recall these cars before someone does get killed

I was driving to Temecula and hot a notification on my dash that said ‘Engine Oil Pressure Low’. I was worried so I found an oil change place close by and pulled off the freeway, but then I noticed the car wasn’t accelerating, my foot was flat down on the accelerator and it was crawling along the road. SO I pulled over to the side and that was it, it wouldn’t go on again. All of the accessories still worked, but it absolutely wouldn’t turn on. It was towed to a local repair shop. I was told the engine had 'seized' and needed to be replaced. I've only done 42k miles and bought it 2nd hand 2 years ago. I've only done 10k miles since then, surely at 42k miles the engine shouldn't need to be replaced. Ford said their warranty only goes to 5 years so there's nothing they can do to help.

Never had a problem with car. Driving from Omaha to Austin tx and on the interstate outside of Ft Worth, oil pressure light came on and started dinging and I lost my ability accelerate. Thankfully was able to get off interstate safely. My car was towed and I was told by repair shop that I need a new engine. Ford knows that these engines are bad and refuses to recall the vehicle. I just want my voice to be heard!

After receiving an oil change the day before and getting the “all good,” I set out for a cross state road trip to see family. Less than halfway through our drive, about 400 miles in, my 2018 Ford EcoSport shut down on the side of the highway. I could not get my vehicle to turn on or move. I was given a warning on my dash that stated I needed service on my vehicle and less than ten seconds later the vehicle would not turn on. Considering I was on the highway, I was more than lucky that I was able to pull over in time. We sat in the vehicle for four hours waiting for a ($400) tow - when the tow got there he spent an hour getting the vehicle onto skates. The engine is locked and my wheels will not turn. I towed it to the nearest ford dealership where they told me I had complete engine failure. The dealership is charging $2,500 to figure out exactly what went wrong with the engine, and another $7,500 to fix it. The car has less than 70,000 miles on it. It’s not under warranty as the cutoff is 65,000 miles. It’s not covered by insurance. I now live across the country from where my car is, meaning I currently don’t have a vehicle (and have not for this whole 3 month process).

Brakes locked up. Been paying 11 months on my loan and the vehicle is in Texas while I live in Minnesota. Have had to buy another car and continue payments on my loan for this one though Ford will do nothing to resolve it.

The low engine oil pressure light came on and within seconds the entire car lost acceleration. This car only has 54,000 miles on it and has always had regular maintenance. Ford made a lemon engine and is refusing to fix it.

The contact owns a 2018 Ford EcoSport. The contact stated while driving 65 MPH, the low oil pressure warning light and the check engine warning light illuminated. Additionally, the vehicle stalled. The contact was able to veer to the side of the road. The vehicle was towed to an independent mechanic, where it was diagnosed that the oil pump belt had failed, and there were metal shavings in the engine due to rod bearing damage. The mechanic replaced the oil pump; however, the failure persisted. The vehicle remained at the independent mechanic for further diagnostic tests. The contact related the failure to NHTSA Action Number: PE23015 (Engine and Engine Cooling). The dealer and the manufacturer were not notified of the failure. The vehicle was not repaired. The failure mileage was approximately 32,000. The VIN was unavailable.

2018 Ford Ecosport with 57k miles - no issues or sounds from the engine up until day of engine failure. On 9/26/23, the low oil pressure light came on while driving. Immediately took to a shop for an oil change (even though just had one 1k miles before) thinking oil was the problem. Then 30 minutes later the entire car seized up and the check engine light came on. Was not able to turn engine and had the car towed. The engine is completely destroyed and matches other complaints exactly about the faulty oil pump then causing issues with belt and ultimately the engine. Looking for any help to move this forward to protect other Ecosport drivers. I did everything correctly, constant 3k mile oil changes, no accidents - and this happened after less then 60k miles. Because over 4 months since powertrain warranty expired - Ford is refusing to help.

I drove 2 hours to see family. As I was leaving my oil pressure light came on, the first time ever. I pulled over and checked my oil and checked for leaks and everything was okay. I started driving it back and only got around the corner when my car stalled and the engine light, low oil pressure light, and battery light turned on. I had it towed to a dealership and the service mechanic says it needs a new engine. The car is 5 years old and only has 54,000 miles on it.

Car will not produce oil pressure despite having a full reservoir. Car has 51,000 miles on it and has been serviced according to recommendations.

I was driving on the highway and my oil light came on and it said 'oil pressure low'. I pulled over because the car would not go above 20 mph and the engine was making sputtering noises. Very scary! I had it towed to the dealership who said the oil pump failed and the belt. This was one MONTH after my warranty expired. They quoted me $4,000 as a fix but also said it was not guaranteed it wouldn't happen again. I argued with Ford who agreed to pay some of it. I am very mad that a car I've only had for two years completely died and had no fix. Also very dangerous for a car to completely die while on the highway.

The contact owns a 2018 Ford EcoSport. The contact received notification of NHTSA Campaign Number: 23V905000 (Engine and Engine Cooling) however, the part to do the recall repair was unavailable. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was not made aware of the issue. The contact stated while driving at approximately 40 MPH, the check engine warning light illuminated, and the steering wheel was vibrating abnormally. The contact depressed the brake pedal; however, the vehicle was still vibrating abnormally. The contact stated that the failure was intermittent but had become a recurring failure at various speeds. The contact had not taken the vehicle to a dealer or independent mechanic. The contact called a local dealer and was advised to take the vehicle for a diagnostic test. The vehicle was not repaired. The failure mileage was approximately 53,000. VIN tool confirms parts not available.

The oil pump went out and ruined the motor. The low engine oil pressure alarm didn't go off until after the car quit. Had it towed to the dealership. They've had it for 2 months. Waiting on them to call for me to pick it up.

The contact owns a 2018 Ford EcoSport. The contact stated while driving 50 MPH, there was an abnormal knocking sound coming from the engine compartment, and the vehicle lost motive power. The contact stated that the accelerator pedal was depressed to the floorboard however, the vehicle struggled to reach 40 MPH while driving. The low oil pressure warning light was illuminated. The vehicle was not taken to the dealer or an independent mechanic to be diagnosed or repaired. The vehicle was not repaired. The manufacturer was not notified of the failure. The failure mileage was 46,700.

Low engine pressure messaged came on and check engine light. Overheating light beeped saying coolant is hot so I turned on heater to cool down and pulled over. Made an appointment with ford dealership for them to tell me cracked cylinder head due to coolant leaking into system. Of course by the time it got looked at the dealership it was slightly over 100000 miles. I’ve read along with hearing from ford that this has been common complaint with this model. Then I’m told to get a new engine that it’s on back order for 6 months to a year! This issue is scary and to think of the possibility of car engulfing with ford not doing anything to fix the issue. Now I’m stuck paying $15,000 left on and low chance to get a new engine if that engine doesn’t cause the same issues!

The contact owns a 2018 Ford EcoSport. The contact stated while driving 50 MPH, the RPM rose to 7,000 RPM, and vehicle was making an abnormal sound coming from the engine compartment. The contact stated that the engine oil pressure message was displayed. The vehicle was taken to the residence. The dealer was contacted. The vehicle was not diagnosed or repaired. The manufacturer was notified of the failure. The failure mileage was 72,290.

The contact owns a 2018 Ford EcoSport. The contact stated that while driving at approximately 45 MPH, the vehicle stalled. The vehicle was not able to be restarted. The vehicle was towed to an independent mechanic where it was diagnosed that the oil pump drive belt had fractured into pieces and the engine needed to be replaced. The vehicle was repaired but the failure persisted. The manufacturer was not notified of the failure. The failure mileage was 57,819.

We were driving from an out of town trip and the warning "low engine oil pressure" came on dashboard, car lost power. My husband checked oil, was good. He turned car off and did not re-start. It was towed to nearest Ford dealer. We finally got a call on 9/25/23 that it will require a new engine! We have been researching and this issue has come up with this vehicle, even the Ford representative told me this has been an issue. It is covered under 3rd party warranty, we are waiting to get claim approved. Since this has been an issue, is there anything that can be done? I still owe vehicle and am concerned that I will continue to have issues after engine gets replaced. Thank you in advance for any help on this matter.

The contact owns a 2018 Ford EcoSport. The contact stated that while driving at an undisclosed speed, the contact was stopped at a stop light and the vehicle shut off. The contact was unable to restart the vehicle. The vehicle was towed to the dealer where it was diagnosed with a failed starter. The vehicle was currently being repaired. The contact stated that the failure had occurred before and the starter had been replaced by the dealer twice within 6-months. The manufacturer was not made aware of the failure. The failure mileage was approximately 24,000.

On 9/17/2023, I was driving on the interstate when I got a notification telling me low engine oil pressure. After that, my car essentially shut off. I could no longer accelerate and had to carefully maneuver to the right side of the interstate so I could pull over. After being towed to the Cavalier Ford Chesapeake Square dealership, I was notified that my oil pump belt tensioner had failed. The service technician working on the vehicle stated he immediately knew the issue upon starting the vehicle. In June/July 2023, I received the same notification and was told it was a sensor that needed to be replaced. We are unsure if the two incidents are related. As of 9/24/2023 the vehicle is at Cavalier Ford Chesapeake Square waiting for the engine to be replaced .

The contact owns a 2018 Ford EcoSport. The contact stated that while his daughter was driving at an undisclosed speed and attempting to slow down, there was an abnormal sound coming from the engine compartment before the vehicle lost motive power and stalled. The vehicle failed to restart. No warning lights were illuminated. The vehicle was towed to the dealer, who diagnosed a failure with the oil pump, resulting in damage to the engine. The contact was informed that the engine needed to be replaced. The vehicle was not repaired. After investigating the failure, the contact related it to SSM 48093. The manufacturer was notified of the failure but referred the contact to the NHTSA Hotline for assistance. The failure mileage was 54,600. The contact stated he is being charged $7500 for a new engine because the warranty for the vehicle expired a couple of months previous and leaving his daughter stranded on the side of the road.

Brakes were squeaking when I brought vehicle off lot initially. Santa Monica Ford Lincoln Dealership notified me it is likely "dust on the tires, and would wear off in time." It never did. Later, vehicle was stalling in middle of intersections. Starter was replaced. Vehicle began lagging again to restart after idle at lights. Disgusting smell coming from vents described by dealership as "old socks." Brought it in, filter replaced. Smell continued. Brought it back again, issue was never fixed. They told me to run the vents. Shortly after, check engine light appeared with note "Low Oil Pressure." Car began making loud sounds. Brought car to dealership, has been 2 weeks with no diagnosis. Was notified of a rodent infestation. Dealership asked me to get approval from Ford for an engine tear down to find the root of the issue. Ford corporate was notified of this issue and is working with me on repairs. All repairs of past were under warranty. Current issue should be under power train, however, failing to give diagnostic after 2 weeks. I have covered 2 weeks of rentals out of pocket- Ford told me to go through Enterprise which I did. One week in, they notified me it has to be from their preferred Enterprise location. Nothing has been diagnosed or covered, dealership is stalling the issue.