2003 Ford Escape Brakes Problems

The contact owns a 2003 Ford Escape. The contact stated that upon starting the vehicle, and while driving at unknown speeds, the vehicle was smoking. There were no warning lights illuminated. The owner disconnected the battery. The vehicle was taken to an independent mechanic who informed the owner that the ABS module and wiring harness needed to be replaced. The local dealer was not contacted. The vehicle was not diagnosed or repaired. The manufacturer was contacted, but no assistance was provided. The failure mileage was approximately 130,000.

TL* THE CONTACT OWNS A 2003 FORD ESCAPE. THE CONTACT STATED THAT WHILE ENTERING THE DRIVEWAY TO PARK, THERE WAS SMOKE PRESENT. THE CONTACT EXITED THE VEHICLE AND OPENED THE HOOD WHEN A FIRE WAS DISCOVERED. THE CONTACT GRABBED A WATER HOSE AND EXTINGUISHED THE FIRE. THE ABS MODULE CONNECTOR WAS MELTED ALONG WITH WIRES. AT THE TIME OF THE INCIDENT THE CONTACT WAS PREGNANT AND HAD HER 4-YEAR-OLD DAUGHTER IN THE VEHICLE. NO INJURIES WERE SUSTAINED. THE FIRE DEPARTMENT WAS NOT CONTACTED. NO POLICE REPORT WAS FILED. THE VEHICLE HAD NOT BEEN DIAGNOSED OR REPAIRED. THE MANUFACTURER WAS CONTACTED BUT THERE WAS A RECORDING STATING THAT NO CALLS WERE BEING ACCEPTED AT THE MOMENT. THE LOCAL DEALER (UNKNOWN DEALER INFORMATION) WAS THEN CALLED WHERE THEY MENTIONED THAT NHTSA ACTION NUMBER: PE06048 (SERVICE BRAKES, HYDRAULIC) WAS PREVIOUSLY PERFORMED ON THE VEHICLE. THE FAILURE MILEAGE WAS APPROXIMATELY 115,000.

TL* THE CONTACTS OWNS A 2003 FORD ESCAPE. THE CONTACT STATED THAT WHILE PARKED, THE VEHICLE CAUGHT ON FIRE FROM UNDER THE HOOD. A POLICE REPORT WAS FILED AND IT WAS STATED THAT THE FIRE STARTED NEAR THE ABS BRAKES. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE AND STATED THAT THE VIN NUMBER WAS NOT INCLUDED IN NHTSA CAMPAIGN NUMBER: 07V156000 (SERVICE BRAKES, HYDRAULIC). THE FAILURE AND CURRENT MILEAGE WAS 162,063.

TL* THE CONTACT OWNS A 2003 FORD ESCAPE. THE CONTACT STATED THAT WHILE DRIVING 40 MPH, THE BRAKES FAILED AFTER THE CONTACT APPLIED FORCE TO THE BRAKE PEDAL. THE STEERING WHEEL BEGAN PULLING TO THE RIGHT. THE VEHICLE CAME TO A COMPLETE STOP AFTER APPLYING FORCE TO THE BRAKE PEDAL. THE MANUFACTURER WAS NOTIFIED AND DID NOT OFFER A REMEDY. THE VEHICLE WAS DRIVEN TO A LOCAL MECHANIC, WHO DIAGNOSED THAT THE ABS ANTI-LOCK SYSTEM NEEDED TO BE REPLACED. THE REPAIRS WERE NOT COMPLETED ON THE VEHICLE. THE FAILURE AND CURRENT MILEAGE WERE 127,000.

TL* THE CONTACT OWNS A 2003 FORD ESCAPE. WHILE DRIVING 75 MPH, THE CONTACT SMELLED SMOKE COMING FROM THE ENGINE. THE CONTACT NOTICED THE VEHICLE WAS SMOKING AND RUSHED HOME. THE VEHICLE WAS TAKEN TO A DEALER WHERE IT WAS DIAGNOSED THAT THE BRAKE SYSTEM MODULE HARNESS AND MASTER CYLINDER NEEDED TO BE REPLACED. IN ADDITION, THE ABS WARNING LIGHT ILLUMINATED AND THE BRAKING SYSTEM CAUGHT FIRE. THE VEHICLE WAS REPAIRED. THE MANUFACTURER WAS NOT MADE AWARE OF THE FAILURES. THE FAILURE MILEAGE WAS 148,000. THE VIN WAS NOT AVAILABLE.

WE PURCHASED THE VEHICLE 30 MINUTES PRIOR. WE WERE IN STOP AND GO TRAFFIC UNTIL LEAVING THE FREEWAY 1 LIGHTS PRIOR TO THE ACCIDENT. WHEN MY DAUGHTER TRIED TO USE THE BRAKES THE PEDAL WENT STRAIGHT TO THE FLOOR. WHEN SHE PUMPED THEM NUMEROUS TIMES, THERE WASN'T ANY CHANGE. SHE DIDN'T HAVE ANY BRAKES. SHE REAR ENDED MY NEWLY PURCHASED VEHICLE FROM THE SAME DEALERSHIP. POLICE WERE AT THE LIGHT WHERE SHE REARENDED ME. THEY CONFIRMED NO BRAKES, MY HUSBAND DID, THE TOW TRUCK DRIVER TOO. WHEN IT WAS RECEIVED TO THE BODY SHOP ON MONDAY MORNING THE BRAKES WERE VERY SOFT ACCORDING TO THE TECHNICIAN. AFTER SITTING FOR A WEEK, THE BRAKES WORKED FINE. THEY CANT DETERMINE WHY THE BRAKES FAILED. THE DEALERSHIP WAS THE FIRST CALL I MADE AT THE ACCIDENT AND THEY TOLD ME THEY KNOW IT HAD LEGAL BRAKES. COME TO FIND OUT THE BRAKE FLUID WAS BLACK AND HAS AN OUTSTANDING RECALL WITH THE ABS THAT HAD NEVER BEEN TAKEN CARE OF. THERE IS ALSO A RECALL ON CERTAIN MASTER CYLINDERS WHICH WERE FAULTY/LEAKING AND THE STOCK NUMBERS. UNFORTUNATELY THE STOCK NUMBER WAS REMOVED FROM THE MASTER CYLINDER. WE HAVE A VEHICLE THAT NEVER EVEN MADE IT TO OUR HOME THAT IS NOW TOTALED. THE DEALERSHIP IS ONLY GOING TO "MAKE IT RIGHT" WITH PROOF THAT THE BRAKES FAILED. THE POLICE REPORT STATES SUCH AND I HAVE THE REPORT FROM THE BODYSHOP, BUT AFTER WAITING FOR THE INSURANCE TO HAVE THE TEST DONE, THEY CANT CONFIRM LOSS OF BRAKES. THEY CAN ONLY STATE THE FLUID BEING BLACK. WE NOW ARE HAVING TO FIGHT TO NOT LOSE OUR TRADE IN VALUE AND TO NOT HAVE A REPORTABLE ACCIDENT AGAINST MY DAUGHTER VS A MECHANICAL FAILURE. THIS IS A NIGHTMARE BOTH THE DEALERSHIP AND THE INSURANCE ARE NOT MAKING THIS EASY. THE MOST EXPENSIVE VEHICLE I EVER OWNED FOR 30 MINUTES IS ALL I CAN SAY. *TR

LOSS OF USE OF BRAKES WHILE COMING TO A STOP AT A BUSY INTERSECTION. JAMMING THE BRAKES ALL THE WAY TO THE FLOOR BROUGHT THE CAR TO A STOP, BUT WAS VERY SLOW TO RESPOND. MECHANIC INSPECTED HOSES AND LINES AND FOUND THE PASSENGER FRONT BRAKE HOSE TO BE SPLIT AND LEAKING. THIS WAS A HORRIFYING EXPERIENCE AS I HAD MY YOUNG KIDS IN THE VEHICLE. FORTUNATELY, I WAS NOT STOPPING FROM A FASTER VELOCITY WHEN THIS ISSUE OCCURRED. I HAVE LEARNED THAT THE TIGHT BENDS IN THE BRAKE HOSE(S) ON THIS MAKE/MODEL OF VEHICLE MAY BE A FACTOR FOR HIS HAPPENING TO VARIOUS CONSUMERS, SO THIS IS WORTH INVESTIGATING. *TR

THE FRONT BRAKE LINE HOSES BLEW OUT (R & L) WHILE DRIVING IN THE CITY. THE PARKING BRAKE WAS INEFFECTIVE IN SLOWING THE VEHICLE AS IT WAS TRAVELING DOWN HILL. WITH NO MEANS OF SLOWING, THE VEHICLE WAS TURNED INTO A PARKING LOT IN AN ATTEMPT TO GET ON LEVEL GROUND WHERE IT WAS MORE CONTROLLABLE AND COULD BE STOPPED MORE EASILY. THE PARKING LOT WAS NOT LARGE ENOUGH TO SLOW THE VEHICLE AND A CHOICE HAD TO BE MADE TO CRASH INTO A BUILDING OR DRIVE OFF THE EDGE OF THE PARKING LOT TO ANOTHER LOT THAT WAS APPROXIMATELY 4 FEET LOWER. THE 2ND OPTION WAS CHOSEN. ONCE THE VEHICLE HAD LANDED WITH GREAT FORCE, IT WAS DIRECTED UPHILL WHERE IT EVENTUALLY CAME TO A STOP AND PUT INTO PARK. UNFORTUNATELY, EXTENSIVE DAMAGE WAS DONE TO THE FRAME AND UNDERSIDE OF THE VEHICLE INCLUDING OIL PAN, EXHAUST SYSTEM, ENGINE MOUNTS, RADIATOR SUPPORT FRAME AND UNDER BODY ENGINE AND TRANSMISSION MOUNTING POINTS. I WAS TOLD BY THE TOW TRUCK DRIVER, THE FIRESTONE AUTO CENTER AND FOUND IN OTHER RESEARCH THAT FORD ESCAPES ARE KNOWN FOR RUBBER BRAKE LINE FAILURES. I HAVE HAD VEHICLES MUCH OLDER THAN THIS AND HAVE NEVER HAD A RUBBER BRAKE LINE DRY ROT AND RUPTURE LIKE THESE. THIS SEEMS TO BE A KNOWN ISSUE AND SHOULD BE ADDRESSED BEFORE MORE DAMAGE IS DONE AND MORE PEOPLE INJURED OR WORSE. WE WERE LUCKY. THIS COULD HAVE BEEN MUCH WORSE. SAFETY ISSUES LIKE THIS NEED TO BE ADDRESSED WITH AN IMMEDIATE RECALL. *TR

WHILE DRIVING MY ESCAPE, THE FRONT BRAKES STARTED TO MAKE A KNOCKING/THUMPING NOISE. WHEN I GOT HOME, I REMOVED THE TIRES AND NOTICE THAT BOTH THE FRONT DISK BRAKES ROTORS WHERE DE-LAMINATING. WITH YOU FINGER NAIL YOU COULD PULL OFF HUNKS OF METAL. I STILL HAVE BOTH ROTORS. AND THE BRAKES HAD ONLY ABOUT 15,000 MILES ON THEM. BRAKE JOB WAS DONE BY A FORD DEALER. THE DISK WHERE TURNED AND THEY ARE ORIGINAL EQUIPMENT. *TR

SUDDEN ABS FAILURE SMALL ACCIDENT.TOOK ABS RELAY OUT AFTER THIS BRAKES WORK FINE. *JS

TL* THE CONTACT OWNS A 2003 FORD ESCAPE. THE CONTACT STATED THE ABS LIGHT ILLUMINATED INTERMITTENTLY AND THE BRAKE PEDAL BOUNCED ABNORMALLY WHEN DEPRESSED. IN ADDITION, THERE WAS A BURNING ODOR RELEASED FROM UNDER THE HOOD. THE VEHICLE WAS TAKEN TO THE LOCAL MECHANIC WHO INSPECTED THE VEHICLE AND LOCATED THE FAILURE AT THE ABS MODULE. THE MANUFACTURER WAS MADE A WARE OF THE FAILURE AND DENIED ASSISTANCE WITH THE REPAIR, STATING THAT THE VEHICLE WAS NOT INCLUDED IN NHTSA CAMPAIGN ID NUMBER: 07V156000 (SERVICE BRAKES, HYDRAULIC: ANTILOCK: CONTROL UNIT/MODULE). THE VEHICLE WAS NOT REPAIRED. THE FAILURE AND THE CURRENT MILEAGE WAS 60,000.

TL* THE CONTACT OWNS A 2003 FORD ESCAPE. THE CONTACT STATED THAT THE ANTI-LOCK BRAKE LIGHT ILLUMINATED ON THE INSTRUMENT PANEL. THE VEHICLE WAS TAKEN TO AN AUTHORIZED DEALER, WHERE THE CONTACT WAS INFORMED THAT THE CONTROL UNIT MODULE WAS CORRODED. THE CONTACT WAS ALSO INFORMED BY THE DEALER AND MANUFACTURER THAT THE VEHICLE WAS NOT INCLUDED IN THE RECALL ASSOCIATED WITH NHTSA CAMPAIGN ID NUMBER 07V156000 (SERVICE BRAKES, HYDRUALIC:ANTILOCK:CONTROL UNIT/MODULE). THE FAILURE AND CURRENT MILEAGES WERE 89,000.

TL* THE CONTACT OWNS A 2003 FORD ESCAPE. THE CONTACT STATED THAT THE VEHICLE WAS PARKED FOR THIRTY MINUTES WHEN SMOKE STARTED TO EMIT FROM THE ENGINE. THE HOOD WAS THEN RAISED AND FLAMES WERE ALSO COMING FROM THE ENGINE. THE FIRE DEPARTMENT REPORTED TO THE SCENE, BUT THE CONTACT EXTINGUISHED THE FIRE HIMSELF. THE FIRE DEPARTMENT FILED A REPORT WHICH WAS AVAILABLE IF NEEDED. NO INJURIES WERE REPORTED AND THE ORIGIN OF THE FIRE WAS LOCATED AT THE ANTI LOCK BRAKE CONTROL BOX. THE VEHICLE WAS TOWED TO AN AUTHORIZED DEALER, WHO WOULD INSPECT THE VEHICLE AND REPORT THEIR FINDINGS TO THE CONTACT. NEITHER THE MANUFACTURER, NOR INSURANCE COMPANY WERE MADE AWARE OF THE FAILURE. THE FAILURE MILEAGE WAS 170,000.

ABS LIGHT ON 2003 FORD ESCAPE KEEPS COMING ON....WAS NEVER NOTIFIED BY FORD ABOUT A RECALL ON THIS...ALSO HAVE HAD TO REPLACE AN ENGINE IN IT ONLY HAD IT FOR 37,000 MILES WHEN I HAD TO REPLACE THE ENGINE....FORD DOES NOT NOTIFY CUSTOMERS OF POTENTIAL PROBLEMS WITH THIS VEHICLE. *TT

FIRE EMERGING FROM HYDRAULIC ANTI-LOCK CONTROL UNIT THE SUBJECT TO FORD RECALL # 07S51 AFTER RECALL WORK WAS COMPLETED, *KB

2008 FORD RECALLED MY 2003 ESCAPE FOR ABS MODULE CONNECTOR. I HAD IT REPAIRED. MY ESCAPE HAS BEGAN TO "GRAB" WHEN I APPLY BRAKES. NEW ROTORS & PADS DID NOT HELP. WHILE ONLINE TO CARCOMPLAINTS.COM, I SAW ANOTHER RECALL FOR ABS MODULE CONNECTION FOR 2003 FORD ESCAPE HAS BEEN REOPENED.(JAN 2010) BUT I WAS NOT NOTIFIED. I HAVE HAD TROUBLE WITH BRAKES ON THIS VEHICLE FOR THE PAST 4 YEARS. *TR

FRONT BRAKES AND ROTORS SHOT AT 50 THOUSAND MILES AND WERE REPLACED, REAR BRAKES SHOWED VERY LITTLE WEAR, 100,000 MILES AND ROTOR AND BRAKE WEAR ARE AGAIN EXCESSIVE AND NEED REPLACEMENT SOON, REAR BRAKES STILL OK AND ARE THE ORIGINALS. THE BRAKES ON THIS VEHICLE ALWAYS HAVE SEEMED INADEQUATE, AS IF THE REAR BRAKES DO NOT SELF ADJUST THEY WERE CHECKED AND CLEANED AND DETERMINED TO BE WORKING OK. I DO PERFORM THE REVERSE AND BRAKE TECHNIQUE TO ADJUST THEM. BOTTOM LINE "THE REAR BRAKES DO NOT SELF ADJUST AND BRAKING IS WHOLLY ON THE FRONT BRAKES PREMATURELY WEARING OUT ROTORS AND PADS!" *TR

SUDDEN FAILURE OF ABS SYSTEM. ABS LIGHT NOT OPERATING ON DASHBOARD INDICATOR PANEL.

TL*THE CONTACT OWNS A 2003 FORD ESCAPE. WHILE DRIVING 5 MPH THE BRAKES FAILED. THE BRAKE PEDAL EXTENDED TO THE FLOOR WITHOUT STOPPING THE VEHICLE. THE VEHICLE CRASHED INTO A SNOW BANK. THERE WAS NO DAMAGED TO THE CONTACT OR THE VEHICLE. THE VEHICLE WAS TAKEN TO A MECHANIC WHO REPAIRED THE BRAKE HOSES AT THE CONTACTS EXPENSE. THE MANUFACTURER WAS NOT CONTACTED. THE VIN WAS UNAVAILABLE. THE FAILURE MILEAGE WAS 114,120.

2003 FORD ESCAPE RECALL - #07V156000 RECALL FOR SERVICE BRAKES, HYDRAULIC : ANTILOCK : CONTROL UNIT/MODULE I HAVE OWNED THIS VEHICLE SINCE AUGUST 2005. APPARENTLY IN 2007 THERE WAS A RECALL ON THIS BRAKE ISSUE. I WAS NEVER NOTIFIED, NOR DID ANY DEALER ATTEND TO THIS ISSUE DURING A ROUTINE SERVICE. I CONTACTED FORD SEPTEMBER 2010 WHEN MY ANTI LOCK LIGHT STARTED TO APPEAR ON MY DASH. FORD DID NOT LIST ME AS THE OWNER EVEN THOUGH I PURCHASED THIS VEHICLE THROUGH A REPUTABLE DEALER AND HAD MY INFO STORED ON THEIR OWNERS WEB PAGE, AND HAVE ALL BILL OF SALES INFO ON FILE. WHILE TALKING TO THE FORD CUSTOMER SERVICE PERSON IT WAS CLEAR THAT HE WAS EDITING THE RECORD TO SOMEHOW SHOW THAT I EITHER KNEW ABOUT THE RECALL OR THAT SOME DEALER INSPECTED THIS ISSUE AND FOUND NOTHING WRONG. WHEN I ASKED TO TALK TO A MANAGER, I WAS PUT ON HOLD FOR OVER 30 MINUTES AND FINALLY HUNG UP. I THEN SENT AN EMAIL COMPLAINING. FORD WROTE BACK THEY WILL DO NOTHING ABOUT THIS AS THE CAMPAIGN IS OVER. I NOW HAVE A VERY SERIOUS ANTI LOCK BRAKE ISSUE. THE ANTI LOCK MECHANISM HAS NOW FAILED. I WISH THE NHTSA TO HELP ME GET FORD TO FIX THIS ISSUE SINCE I OWNED THE VEHICLE SINCE 2005, THE RECALL WAS IN 2007, FORD NEVER TRIED TO CONTACT ME ON THIS RECALL, AND NO FORD DEALER EVER INSPECTED MY VEHICLE FOR THIS ISSUE. THANK YOU FOR YOUR TIME. [XXX] INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6). *TR