2005 Ford Explorer Sport Trac Suspension Problems

DISCOVERED UNDERNEATH THE BODY WHERE THE BODY AND FRAME MEET FOR THE BODY MOUNT BUSHINGS, THEY HAVE NEARLY DISINTEGRATED ON ALL FOUR BUSHINGS LOCATED UNDER THE DRIVER AND PASSENGER SEATS. THESE BUSHINGS WERE MADE OF SOME INFERIOR FOAM MATERIAL WHEREAS THE REAR BUSHINGS ARE RUBBER AND STILL IN VERY GOOD CONDITION. THE REPAIR FOR THIS DEFECT WILL COST AROUND $600 TO $1,300 AND IF NOT DONE WILL RESULT IN THE CAB FALLING DIRECTLY ONTO THE FRAME THUS CREATING NUMEROUS SAFETY PROBLEMS INCLUDING STRUCTURAL INTEGRITY FAILURE OF THE TRUCK. THIS PROBLEM AFFECTS ALL SPORT TRACS MADE FROM 2001 TO 2005. THE INCLUDED PICS BEGIN WITH THE DRIVER SIDE (DRIVER SEAT) FRONT BUSHING, DRIVER SIDE (REAR SEAT) BUSHING, PASSENGER SIDE (FRONT SEAT) BUSHING, PASSENGER SIDE (REAR SEAT) BUSHING AND FINALLY THE PASSENGER SIDE REAR AND DRIVER SIDE REAR BUSHINGS (BOTH IN EXCELLENT SHAPE AND MADE OF ENTIRELY DIFFERENT MATERIAL) DISCLAIMER: THIS TRUCK HAS NEVER BEEN EXPOSED TO ANY SALT WATER (BEACH) ENVIRONMENT NOR WINTER WEATHER ENVIRONMENT (WHERE SALT WAS USED), OR MUD RIDING OF ANY TIME NOR HAS BEEN DRIVEN THROUGH FLOODED AREAS WHICH COULD LEAD TO THE CONDITION OF THE BUSHINGS. VEHICLE ODOMETER READING IS 125,496.

THIS REPLACES FILE #10134158 WHILE TRAVELING APPROXIMATELY 25 MPH THE CAR SUDDENLY SWERVED TO THE RIGHT AND THE PASSENGER FRONT WHEEL FELL OFF. SHEARING AT THE CAST IRON KNUCKLE BEHIND THE WHEEL. THERE ARE NO SCUFF MARKS OF ANY KIND ON THE TIRE INDICATING THAT IT WAS A PART FAILURE AS OPPOSED TO IMPACT WITH THE CURB. FORD WAS CONTACTED. AFTER A MEETING WITH THE ZONE REPRESENTATIVE I WAS TOLD IT HAD TO CLEAR LITIGATION PREVENTION BEFORE ENGINEERS COULD LOOK AT IT AFTER 4 WEEKS I WAS TOLD FORD HAS NO INTEREST IN CHECKING IT OUT AND BLAMED THE DRIVER NOT THE VEHICLE. I AM CONCERNED WE ARE DEALING WITH A SAFETY DEFECT. LITIGATION OVER RODE THE SAFETY ENGINEERS AS FAR AS INSPECTING THE DAMAGED PARTS. *JB