1999 Ford F-150 Complaint Log

TL* THE CONTACT OWNS A 1999 FORD F-150. THE CONTACT STATED WHILE REFUELING THE VEHICLE, FUEL EMITTED FROM THE FUEL TANK. THE CONTACT ALSO STATED THE UNDER CARRIAGE WAS CORRODED. THE VEHICLE WAS TAKEN TO THE DEALER FOR DIAGNOSTIC TESTING. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE VEHICLE WAS NOT REPAIRED AND THE VIN WAS UNKNOWN. THE FAILURE AND CURRENT MILEAGE WAS 223,000.

CYLINDER 5 SPARK PLUG BLEW OUT WHILE DRIVING, WRECKING THE THREADING IN THE SPARK PLUG HOLE AND THE COIL. *TR

TL* THE CONTACT OWNS A 1999 FORD F150. THE CONTACT RECEIVED NOTIFICATION OF NHTSA RECALL NUMBER: 11V385000 ( FUEL SYSTEM, GASOLINE:STORAGE:TANK ASSEMBLY:MOUNTING) AND TOOK THE VEHICLE TO THE DEALER FOR REPAIR. THE DEALER ADVISED THAT THERE WAS A HOLE IN THE FUEL TANK, WHICH NEEDED TO BE REPLACED. THE MANUFACTURER WAS NOT NOTIFIED NOR WAS THE VEHICLE REPAIRED. THE CURRENT AND FAILURE MILEAGES WERE 157,000. THE VIN WAS UNAVAILABLE.

TL* THE CONTACT OWNS A 1999 FORD F-150. THE CONTACT STATED THAT THE VEHICLE WAS TAKEN TO AN AUTHORIZED DEALER TO BE REPAIRED UNDER THE RECALL ASSOCIATED WITH NHTSA CAMPAIGN ID NUMBER 11V385000 (FUEL SYSTEM, GASOLINE:STORAGE:TANK ASSEMBLY:MOUNTING). THE CONTACT WAS INFORMED THAT THE FUEL TANK ALSO LEAKING, BUT THAT FAILURE WAS NOT COVERED UNDER THE RECALL. THE FUEL TANK WAS NOT REPAIRED. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE AND OFFERED NO ASSISTANCE. THE FAILURE MILEAGE WAS 123,800. UPDATED 12/14/11

WATER LEAKING THROUGH WINDSHIELD CAUSING DAMAGE TO ELECTRICAL COMPONENTS UNDER DASH. GEM MODULE NEED S TO BE REPLACED. POSSIBLY FUSE BOX AS WELL. *TR

TL* THE CONTACT OWNS A 1999 FORD F-150. THE CONTACT RECEIVED A NHTSA RECALL CAMPAIGN NUMBER: 11V385000, FUEL SYSTEM, GASOLINE: STORAGE: TANK ASSEMBLY: MOUNTING. THE FORD RECALL CAMPAIGN NUMBER WAS 11S21. HE TOOK HIS VEHICLE TO THE DEALER TO BE REPAIRED BUT THERE WAS A BOLT THAT WAS HOLDING THE STRAPS WHICH WAS COVERED WITH RUST AND CORRODED. THE DEALER STATED THEY WOULD NOT REPAIR THE RECALL SINCE THE BOLT WAS COVERED WITH RUST. THE CONTACT WAS INFORMED THAT THE BOLT REPAIR WOULD COST THE CONTACT $300 OR THEY WILL NOT RETURN HIS VEHICLE TO HIM. THE CONTACT DOES NOT WANT THE BOLT REPAIRED IF IT WAS NOT A PART OF THE RECALL REPAIR. THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURE. THE FAILURE MILEAGE WAS 64,000.

TL* THE CONTACT OWNS A 1999 FORD F150. THE CONTACT STATED THAT THERE WAS RUST AND CORROSION ON THE FUEL TANK. NEITHER THE DEALER NOR THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE VEHICLE WAS NOT REPAIRED. THE FAILURE MILEAGE WAS 117,000.

TL* THE CONTACT OWNS A 1999 FORD F-150. THE CONTACT STATED THAT WHILE DRIVING 10 MPH, THE VEHICLE EXHIBITED A STRONG FUEL ODOR. THE VEHICLE WAS TAKEN TO A LOCAL MECHANIC WHO PERFORMED A DIAGNOSTIC THAT LOCATED THE FAILURE AS THE FUEL TANK BEING CORRODED AND CAUSING THE FUEL TANK TO LEAK. THE MANUFACTURER WAS CONTACTED AND A COMPLAINT WAS FILED. IN ADDITION, THE MANUFACTURER ADVISED THAT THEY COULD ASSIST BY REPLACING THE FUEL TANK STRAPS ONLY AND THAT THE VEHICLE WAS NOT INCLUDED IN NHTSA CAMPAIGN ID NUMBER: 11V385000 (FUEL SYSTEM, GASOLINE:STORAGE:TANK ASSEMBLY:MOUNTING). THE VEHICLE WAS NOT REPAIRED. THE FAILURE AND THE CURRENT MILEAGE WAS 115,000.

TL* THE CONTACT OWNS A 1999 FORD F-150. THE CONTACT STATED THAT THERE WAS A FUEL LEAK IN THE VEHICLE. THE VEHICLE WAS TAKEN TO THE DEALER FOR REPAIRS UNDER NHTSA CAMPAIGN ID NUMBER: 11V385000 (FUEL SYSTEM: GASOLINE: STORAGE: TANK: MOUNTING) BUT THE CONTACT WAS ADVISED THAT THE FUEL LEAK THE CONTACT WAS EXPERIENCING WOULD NOT BE REPAIRED UNDER THE RECALL. THE CONTACT STATED THAT THE LEAK WAS CAUSED BY RUST AND FRACTURED STRAPS ON THE FUEL TANK. THE CONTACT BELIEVED THE FAILURE WAS A MANUFACTURING DEFECT AND SHOULD HAVE BEEN ADDED TO THE ORIGINAL RECALL. THE FAILURE MILEAGE WAS 185,000.

TL* THE CONTACT OWNS A 1999 FORD F-150. WHILE THE VEHICLE WAS PARKED THE CONTACT INSPECTED THE VEHICLE AND NOTICED THE FUEL TANK WAS CORRODED. THE VEHICLE WAS INCLUDED IN THE NHTSA RECALL ID NUMBER: 11V385000 (FUEL SYSTEM, GASOLINE:STORAGE:TANK ASSEMBLY:MOUNTING). THE MANUFACTURER WAS MADE AWARE OF THE FAILURE AND STATED THE FUEL TANK WOULD NOT BE REPLACED UNDER THE RECALL. THE VEHICLE WAS NOT REPAIRED. THE APPROXIMATE FAILURE MILEAGE WAS 69,000.

GAS LEAKING FROM BACK END OF GAS TANK. GAS TANK RUSTED THROUGH ON BACK OF TANK WERE A PLASTIC SHIELD WAS AFIXED BY FORD. REMOVED PLASTIC SHIELD AND ENTIRE END OF GAS TANK RUSTED AND LEAKING. BRUSHED AWAY LOOSE RUST AND MULTIPLE HOLES APPEARED AND GAS POURED OUT. THE PLASTIC SHIELD HAS A SPACE BETWEEN IT AND THE TANK WHICH COLLECTS DIRT/SNOW AND ROAD SALT CAUSING THE GAS TANK TO FAIL AND LEAK. THE REST OF THE GAS TANK IS SOUND EXCEPT FOR THE STRAPS THAT HOLD IT IN PLACE. FORD HAS ISSUED A RECALL FOR THE STRAPS. FORD SHOULD CONSIDER THE ENTIRE GAS TANK FOR RECALL BECAUSE OF THIS PLASTIC COVER THAT CAUSE THE GAS TANK TO FAIL AND LEAK. A VERY SERIOUS DANGER OF FIRE. *TR

TL* THE CONTACT OWNS A 1999 FORD F-150. THE CONTACT STATED THE INSIDE COVERING ON THE SIDEVIEW MIRRORS WAS DEFECTIVE MAKING IT DIFFICULT TO SEE. THE DEALER ADVISED THERE WAS NOTHING THEY COULD OTHER THAN REPLACE THE MIRRORS. THE VEHICLE WAS NOT REPAIRED. THE VIN INFORMATION WAS NOT AVAILABLE. THE FAILURE MILEAGE WAS 15,000 AND THE CURRENT MILEAGE WAS 122,000.

TL* THE CONTACT OWNS A 1999 FORD F150. THE CONTACT WAS ATTEMPTING TO PARK THE VEHICLE. AS THE BRAKES WERE APPLIED, THE BRAKE PEDAL WAS ABNORMALLY DEPRESSED INTO THE FLOORBOARD. AFTER INSPECTING THE FAILURE HE NOTICED CORROSION AND RUST ON THE BRAKE LINE AND THE FUEL STRAPS. THE DEALER WAS NOTIFIED OF THE RUST AND INFORMED THE CONTACT THERE WERE NO RECALLS AND OFFERED NO FURTHER ASSISTANCE. THE MANUFACTURER WAS ALSO NOTIFIED WHO OFFERED NO ASSISTANCE. THE FAILURE MILEAGE WAS 100,000.

TL* THE CONTACT OWNS A 1999 FORD F-150. THE CONTACT RECEIVED A RECALL NOTICE IN THE MAIL FOR REPAIRS UNDER THE NHTSA CAMPAIGN ID NUMBER: 11V385000 (FUEL SYSTEM, GASOLINE:STORAGE:TANK ASSEMBLY:MOUNTING). THE CONTACT TOOK THE VEHICLE IN TO BE REPAIRED AND DURING A DIAGNOSTIC TEST WAS ADVISED THAT THE MOUNTING WAS COVERED WITH RUST. THE DEALER AND MANUFACTURER DENIED THE RECALL STATING THAT THE CONTACT WOULD HAVE TO PURCHASE A NEW MOUNT BEFORE THE RECALL COULD BE PERFORMED ON THE VEHICLE. THE VEHICLE WAS NOT REPAIRED. THE FAILURE AND CURRENT MILEAGE WAS 160,000.

TL* THE CONTACT OWNS A 1999 FORD F150. THE CONTACT STATED THAT WHILE HE WAS ENTERING A PARKING SPACE, HE HEARD A LOUD SOUND AND NOTICED THAT THE FUEL TANK HAD DROPPED. THE CONTACT MENTIONED THAT BOTH OF THE STRAPS FRACTURED AS A RESULT OF CORROSION. ALSO, HE STATED THAT AS A TEMPORARY FIX HE PLACED TWO RATCHET STRAPS TO HOLD THE TANK IN PLAC. THE VEHICLE WAS NOT TAKEN TO THE DEALER. THE MANUFACTURER WAS MADE AWARE OF THE PROBLEM AND REFERRED HIM TO THE DEALER. THE VEHICLE WAS NOT REPAIRED. THE VIN WAS NOT AVAILABLE. THE FAILURE AND CURRENT MILEAGE WAS 190,000.

TL* THE CONTACT OWNS A 1999 FORD F-150. THE CONTACT STATED THAT WHILE PARKING, THE VEHICLE STALLED. THE DRIVER INSPECTED THE VEHICLE AND NOTICED THAT THE FUEL TANK HAD DETACHED AND APPROXIMATELY ONE HALF TANK OF FUEL WAS SPILLED. THE CONTACT ALSO MENTIONED THAT BOTH OF THE STRAPS FRACTURED DUE TO CORROSION. THE VEHICLE WAS TOWED TO THE DEALER WHO VERIFIED THE FAILURE BUT DID NOT PROVIDE AN OFFICIAL DIAGNOSTIC. THE MANUFACTURER WAS NOT MADE AWARE OF THE FAILURE. THE VEHICLE WAS NOT REPAIRED. THE FAILURE AND CURRENT MILEAGE WAS 105,000.

THE ODOMETER IN MY 1999 FORD F150 PICKUP DOES NOT LIGHT UP WHEN THE IGNITION IS TURNED ON UNTIL IT HAS BEEN DRIVEN FOR A WHILE. IT DOES EVENTUALLY COME ON BUT HAS TAKEN LONGER AND LONGER AS THE VEHICLE HAS AGED. THIS HAS BEEN A PROBLEM FOR MORE THAN 2 YEARS AND SEEMS TO BE GETTING WORSE. *TT

THE FILLER TUBE IS RUSTING AWAY CAUSING IT TO POUR GAS ON THE GROUND AS YOU ARE FILLING THE TANK. THEY NEED TO CHANGE THESE ALONG WITH THE STRAPS THAT ARE RUSTING AWAY. MY TRUCK IS THE 2ND ONE I KNOW OF WITH THIS PROBLEM. THE DEALER HAS SAID THEY HAVE CHANGED MANY TUBES ALSO DUE TO RUSTING OUT. *KB

VEHICLE IS ON CURRENT RECALL FOR STRAP SECURING THE GAS TANK RUSTING. NOT ONLY THE STRAPS ARE RUSTING BUT THE GAS TANK IS ALSO RUSTING. WHEN ONE OF MY STRAPS BROKE THE GAS TANK DROPPED 2 ". BOTH STRAPS WERE REPLACED AND THEN GAS TANK STARTED TO LEAK. I WOULD RECOMMEND THAT THE GAS TANKS ALSO BE CHECKED FOR RUSTING BY THE SUPPORT STRAPS. I HAD TO PAY FOR A NEW GAS TANK TO GET MY TRUCK BACK ON THE ROAD SAFELY.

TL* THE CONTACT OWNS A 1999 FORD F-150. THE CONTACT STATED THAT WHILE DRIVING APPROXIMATELY 20 MPH HE HEARD A LOUD DRAGGING NOISE. THE VEHICLE WAS PULLED OVER TO THE SIDE OF THE ROAD AND THE CONTACT NOTICED THAT THE FUEL TANK WAS HALF WAY DETACHED FROM THE VEHICLE. ONE OF THE STRAPS WHICH HELD THE FUEL TANK IN PLACE WAS FRACTURED AND THE OTHER WAS SEVERELY RUSTED. NO FUEL LEAKED FROM THE TANK. THE MANUFACTURER WAS NOTIFIED AND THEY STATED THAT THERE WERE NO RECALLS RELATED TO THE FAILURE. THE OWNER PURCHASED NEW STRAPS FROM AN INDEPENDENT MECHANIC AND REPAIRED THE VEHICLE HIMSELF. THE FAILURE AND CURRENT MILEAGES WERE APPROXIMATELY 200,000. THE VIN WAS UNAVAILABLE.

MY DAUGHTER WAS DRIVING MY 1999 FORD F150 TRUCK (APPROX. 145,000 ODOMETER MILES) AT 35 MPH WHEN ONE (PROBABLY THE FRONT), OR BOTH, GAS TANK STRAPS BROKE. SHE DRAGGED THE TANK ABOUT 300 YARDS BEFORE STOPPING. BOTH STRAPS WERE BROKEN BY THAT TIME AND THE TANK WAS ON THE GROUND WITH A DEEP DENT THE SIZE OF A BASEBALL AND THE METAL SCRAPED CLEAN IN THE FRONT RIGHT BOTTOM CORNER OF THE TANK. IN ATTEMPTING TO STRAP UP THE TANK, THE DAMAGED PORTION WAS SCRAPED ON THE GROUND, WHICH OPENED A SEAM UP AND FUEL BEGAN LEAKING. I HAD TO UNBOLT AND TAKE OUT THE FUEL PUMP BECAUSE I COULDN'T FIGURE OUT HOW TO DISCONNECT THE FUEL LINE FITTINGS. THE FUEL INTAKE HOSE WAS SNAPPED OFF. I HAD TO CLIP/CUT THE FUEL SENSOR WIRES BECAUSE I COULDN'T UNLATCH THE SENSOR WIRES. ANOTHER SMALL HOSE CAME OFF (FUEL OVERFLOW HOSE?) EASILY. I WAS THEN ABLE TO PULL THE TANK OUT FROM UNDER THE TRUCK AND DRAIN THE LEAKING GASOLINE INTO A GAS CAN AND HAVE THE TRUCK TOWED. A USED TANK WAS FOUND WITH THE ORIGINAL FUEL PUMP IN IT TO REPLACE THE DAMAGED TANK AND A NEW GAS GAUGE SENSOR ATTACHED. *KB

ON 7/16/11 THE GAS TANK STRAPS BROKE AND DROPPED THE GAS TANK ON THE GROUND WHILE I WAS DRIVING TO THE STORE AT ABOUT 35 MPH. I PAID $94.00 TOWING FEE, $242.03 TO REPLACE THE STRAPS ETC. FORTUNATELY THE TANK DID NOT BREAK OPEN, OR GET RIPPED FROM THE VEHICLE CAUSING A FIRE OR SPILL TWO WEEKS PRIOR I PAID OVER $300.00 TO GET THE BOLTS REMOVED FOR THE STARTER AS THEY HAS CORRODED IN PLACE - STEEL BOLTS INTO AN ALUMINUM TRANSMISSION - GENIUS! *KB

THE ENGINE SURGES OR QUITS AS I AM DRIVING. THIS HAPPENS EVERY 8 TO 10 MILES. I CAN BE GOING 75 MPH ON THE FREEWAY WHEN IT QUITS AND I HAVE TO SHUT OFF THE IGNITION TO RESTART IT. THIS IS AT LEAST THE NINTH TIME THIS TRUCK HAS DONE THIS SINCE IT WAS NEW. I THINK YOU CAN IMAGINE WHAT IT'S LIKE TO BE GOING 75 MILES PER HOUR AND YOUR ENGINE QUITS AND YOU ARE LEFT WITH NO POWER STEERING, OR BRAKES. THIS WILL BE THE NINTH COIL I HAVE REPLACED ON THIS MOTOR. FORD IS COMPLETELY AWARE THAT THERE HAS BEEN A PROBLEM FOR YEARS WITH THIS SIZE MOTOR. I CAN'T BELIEVE AN ENGINE THAT SHUTS OFF AT 75 MILES PER HOUR HAS NOT BEEN CONSIDERED A SAFETY CONCERN BEFORE. *TR

BRAKE LINE IS RUSTED COULD CAUSE FAILURE OF BRAKES. GAS TANK AND SUPPORTS ARE RUSTED REPLACED ONCE BUT STILL ALL RUSTED. ALL FRAME UNDERNEATH IS RUSTED IMPOSSIBLE TO DO REPAIRS. *KB

TL* THE CONTACT OWNS A 1999 F-150. THE CONTACT STATED THAT THE FUEL STRAPS WHICH HELD THE FUEL TANK IN PLACE FRACTURED, ALLOWING THE FUEL TANK TO DETACH FROM THE VEHICLE AND FALL ONTO THE GROUND. AS A RESULT, FUEL SPILLED OUT FROM THE FUEL TANK. THE DEALER AND MANUFACTURER WERE MADE AWARE OF THE FAILURE, BUT OFFERED NO ASSISTANCE. THE FAILURE AND CURRENT MILEAGES WERE 115,000.

TL * THE CONTACT OWNS A 1999 FORD F-150. THE CONTACT WAS DRIVING 55 MPH WHEN THE FUEL TANK STRAPS FRACTURED DUE TO CORROSION. AS A RESULT, THE FUEL TANK DETACHED FROM THE VEHICLE. THE CONTACT MENTIONED THAT NO FUEL SPILLED AND BOTH OF THE STRAPS WERE FRACTURED. THE VEHICLE WAS TAKEN TO A LOCAL REPAIR SHOP WHERE THE FAILURE WAS CONFIRMED AND THE CONTACT WAS ADVISED TO HAVE THE FUEL TANK STRAPS REPLACED. THE MANUFACTURER WAS NOT MADE AWARE OF THE FAILURE AND THE VEHICLE WAS NOT REPAIRED. THE FAILURE AND CURRENT MILEAGE WAS 175,000. UPDATED 09/02/11*LJ UPDATED 09/14/11

1999 FORD F-150. CONSUMER STATES GAS TANK DEFECT *TGW THE CONSUMER STATED WHEN HE SON BACKED THE TRUCK OUT OF THE GARAGE, THE ENTIRE GAS TANK FELL TO THE GROUND. THE STRAPS SUPPORTING THE GAS TANK BROKE. THE VEHICLE WAS TOWED TO A REPAIR SHOP AND THE GAS TANK WAS REPLACED. *JB

TL* THE CONTACT OWNS A 1999 FORD F150. THE CONTACT STATED WHILE DRIVING APPROXIMATELY 25 TO 35 MPH THE FUEL TANK SEPARATED FROM THE VEHICLE, AND THE FUEL SPILLED ONTO THE GROUND. THE VEHICLE WAS TOWED TO THE DEALER. THE FAILURE WAS NOT DIAGNOSED. THE CONTACT DOES NOT KNOW IF THE FUEL TANK STRAPS WERE CORRODED. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER TOOK A REPORT 1405151861 AND DENIED ASSISTANCE WITH THE REPAIR. THE FAILURE AND CURRENT MILES WERE 160,000. UPDATED 08/05/11*LJ ACCORDING TO THE INVOICE, THE FUEL TANK STRAPS RUSTED OFF WHICH CAUSED THE TANK TO FALL TO THE GROUND, CREATING A HOLE IN THE TANK/ UPDATED 08/12/11*JB

I PURCHASED MY 1999 FORD F-150 4X 4 WITH A TRITON 5.4 V-8 ENGINE USED. THE ENGINE HAD APPROXIMATELY 140,000 WHEN I PURCHASED IT. I ONLY DRIVE IT TO AND FROM WORK IN LAS VEGAS, NV (APPROXIMATELY 25 MILES ROUND TRIP) AT SPEEDS BELOW 50 MPH. THE ENGINE BLEW THE BACK PLUG AT 163,000. BECAUSE IT WAS THE BACK PLUG THE LABOR TO REPAIR WAS HIGH (PULL THE ENGINE). THE DIFFERENCE IN PUTTING HELICOILS (ALL EIGHT PLUGS) IN AND A NEW ENGINE WAS NOT THAT MUCH DIFFERENCE SO I ORDER A LONG BLOCK FULL ENGINE FROM FORD WITH STIPULATIONS IT CORRECTED THE DESIGN FLAW. THE ENGINE COST ALMOST $7000 WHEN ALL WAS DONE AND COMPLETE. FORD WARRANTY THE ENGINE 3 YEARS AND 75,000 MILES. I FIGURED THIS CORRECTED THE ISSUES WITH THE SPARK PLUGS BLOWING OUT. WELL AT THE 4 YEAR POINT AND APPROXIMATE 25,000 MILES THE NEW ENGINE BLEW A PLUG. FORD AND THE DEALER (WHOM WE PURCHASED THE ENGINE FROM) SAY IT IS OUR PROBLEM. THE DEALER (PARTS MANAGER) ACTUALLY SAID SINCE I WAS NOT A FREQUENT CUSTOMER AND HAD PURCHASED THE TRUCK USED THEY DID NOT SEE A WAY TO HELP. I HAVE RESEARCHED THIS ISSUE ON THE INTERNET AND BELIEVE IT IS DESIGN FLAW IN THE HEAD. I AM IN THE PROCESS OF HAVING STEEL INSERTS PUT IN ALL OF THE SPARK PLUG HOLES SO I MIGHT GET USE OUT OF A HEFTY INVESTMENT IN A MOTOR WITH A KNOWN ISSUE WHICH FORD WILL NOT BACK. I OWN A FORD CROWN VICTORY, A MERCURY MARQUIS LS, AND THE F-150 TRUCK . . . THESE ARE THE LAST VEHICLES I WILL OWN FROM FORD. *TR

TL* THE CONTACT OWNS A 1999 FORD F150. WHILE DRIVING APPROXIMATELY 5 MPH OVER RAILROAD TRACKS, THE CONTACT HEARD A LOUD NOISE OUTSIDE OF THE VEHICLE AND MANEUVERED TO THE SIDE OF THE ROAD. HE NOTICED THE FUEL TANK PARTIALLY DETACHED TO THE GROUND IN A TILTED POSITION. THE FUEL TANK WAS NOT DAMAGED AND BOTH METAL FUEL TANK STRAPS WERE COMPLETELY RUSTED. THE CONTACT PERFORMED A TEMPORARY FIX AND WAS ABLE TO RESUME WITH CAUTION. AFTER REACHING THE DESTINATION BOTH FUEL TANK STRAPS WERE REPLACED WITH NEW ONES. THE MANUFACTURER WAS MADE AWARE OF THE DEFECT. CURRENTLY, THERE WAS AN OPEN INVESTIGATION ASSOCIATED WITH NHTSA ACTION NUMBER EA11006 (FUEL SYSTEM, OTHER: STORAGE: TANK ASSEMBLY). THE FAILURE MILEAGE WAS 132,000. THE VIN WAS UNAVAILABLE. UPDATED 08/31/2011 *LN *TR

AT 11 PM LAST NIGHT, AFTER I DROVE OVER A SMALL BUMP, THE GAS TANK STRAPS ON MY 1999 FORD F150 BROKE, CAUSING THE GAS TANK TO FALL TO THE GROUND AND LEAK A FULL TANK OF GASOLINE ONTO THE STREET. FORTUNATELY THERE WAS NO FIRE, BUT I NEEDED TO CONTACT THE LOCAL FIRE DEPARTMENT IN ORDER TO HAVE THE GASOLINE CLEANED UP. I HAD THE VEHICLE TOWED TO A FORD DEALERSHIP AND I AM CURRENTLY AWAITING CONTACT FROM THE SERVICE DEPARTMENT. UPDATED 09/14/11 *BF THE CONSUMER STATED THE STRAPS BROKE OFF COMPLETELY AND HE DROVE A BLOCK WITHOUT RECOVERING THEM. THE METAL PORTIONS OF THE STRAPS WERE RUSTED PRIOR TO THE BREAK. UPDATED 09/21/11 *TR

TL* THE CONTACT OWNS A 1999 FORD F-150. THE CONTACT STATED WAS DRIVING APPROXIMATELY 20 MPH WHEN HE DROVE OVER A ROAD BUMP AND THE FUEL TANK DETACHED FROM THE VEHICLE. THE VEHICLE WAS TOWED TO AN INDEPENDENT REPAIR SHOP WHERE THE CONTACT WAS INFORMED THAT BOTH STRAPS WHICH HELD THE FUEL TANK IN PLACE WERE FRACTURED DUE TO CORROSION. THE VEHICLE WAS NOT REPAIRED. THE FAILURE AND CURRENT MILEAGES WERE 142,000.

TL* THE CONTACT OWNS A 1999 FORD F150. WHILE DRIVING 70 MPH, THE CONTACT STATED THAT BOTH STRAPS FRACTURED CAUSING THE FUEL TANK TO HANG FROM UNDERNEATH THE VEHICLE. THE VEHICLE WAS TOWED TO THE DEALER AND IT WAS REPAIRED. THE MANUFACTURER WAS NOT NOTIFIED. THE APPROXIMATE FAILURE MILEAGE WAS 112,000.

TL*THE CONTACT OWNS A 1999 FORD F-150. THE CONTACT STATED WHILE DRIVING APPROXIMATELY 15 MPH HE HEARD A LOUD NOISE. HE THEN PULLED INTO A OPEN LOT AND NOTICED THAT THE FUEL TANK DETACHED FROM THE VEHICLE AND BOTH STRAPS FRACTURED AND WERE CORRODED. FUEL WAS SPILLED AND APPROXIMATELY EIGHT GALLONS OF FUEL LEAKED OUT OF THE VEHICLE. THE POLICE AND FIRE DEPARTMENT WERE CALLED TO DETAIN THE AREA. THE VEHICLE WAS THEN TOWED TO AN INDEPENDENT MECHANIC WHO ADVISED HIM THAT BOTH STRAPS AND THE TANK NEEDED TO BE REPLACED. THE VEHICLE WAS REPAIRED. THE MANUFACTURER WAS NOT CONTACTED. THE FAILURE MILEAGE WAS APPROXIMATELY 126,000.

TL* THE CONTACT OWNS A 1999 FORD F-150. THE CONTACT STATED THAT THE FUEL TANK STRAPS FRACTURED. WHILE THE CONTACT WAS PERFORMING AN OIL CHANGE ON THE VEHICLE, HE NOTICED THAT ONE STRAP WAS ALREADY FRACTURED AND FRACTURED THE SECOND STRAP WHILE REPAIRING. IN ADDITION, THE CONTACT STATED THAT EVERY BRAKE LINE ON THE VEHICLE HAD TO BE REPLACED BECAUSE OF RUST. THE FAILURE MILEAGE WAS UNKNOWN AND THE CURRENT MILEAGE WAS 105,000. THE VIN WAS NOT AVAILABLE.

EXTENSIVE CORROSION ON FUEL TANK RETAINING STRAPS. *TR

MY PROBLEM IS THE FRAME AT THE BACK IS RUSTED OUT, THE GAS TANK IS RUSTED, THE STRAPS THAT HOLDS THE GAS TANK IS RUSTED AND IN BAD SHAPE JUST ABOUT TO LET THE GAS TANK TO FALL. TOYOTA WAS FORCED TO BUY THEIR TRUCKS BACK. HOW DOES FORD GET AWAY WITH THIS

TL* THE CONTACT OWNS A 1999 FORD F-150. WHILE DRIVING APPROXIMATELY 55 MPH, THE CONTACT HEARD A DRAGGING NOISE FROM UNDER THE VEHICLE. THE CONTACT PULLED OVER TO THE SIDE OF THE ROAD AND NOTICED TWO OF THE FUEL TANK STRAPS HAD DETACHED FROM THE FUEL TANK AND WERE RUSTED. THE CONTACT STATED THAT NO FUEL LEAKED. THE VEHICLE WAS TOWED TO THE DEALER WHERE THE TECHNICIAN STATED THAT THE FUEL TANK, THE STRAPS AND A VALVE WOULD NEED TO BE REPLACED. THE VEHICLE WAS REPAIRED. THERE WAS AN OPEN INVESTIGATION UNDER NHTSA ACTION NUMBER: EA11006 (FUEL SYSTEM, OTHER:STORAGE:TANK ASSEMBLY FUEL SYSTEM, OTHER:STORAGE:TANK ASSEMBLY:MOUNTING FUEL SYSTEM, GASOLINE:STORAGE:TANK ASSEMBLY:MOUNTING) THAT COULD POTENTIALLY HAVE BEEN RELATED TO THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 203,000. UPDATED 08/24/11*LJ UPDATED 3/01/2012 *LN *TR

I FILLED MY VEHICLE UP FULL OF FUEL (26 GALLONS) THE NIGHT BEFORE THE INCIDENT. WHEN LEAVING WORK FOR LUNCH I PULLED OUT OF THE DRIVE AND DROVE APPROX. 400 FEET AT 25 MPH AND HEARD A LOUD GRINDING NOISE THAT WAS CONSTANT, I PULLED INTO THE PARKING LOT 20 FEET AHEAD AND PARKED THE TRUCK. THE FRONT AND CENTER FUEL TANK STRAP GAVE OUT AND THE FRONT OF THE FUEL TANK WAS LAYING ON THE GROUND. THERE WAS A HOLE IN THE FRONT OF THE TANK FROM DRAGGING IT APPROX. 100 FEET. I LOST APPROX. 10 GALLONS OF FUEL AND WAS ABLE TO GET THE REST OUT THE TANK. THE CONSUMER STATED THE STRAPS HAD SURFACE RUST, BUT WAS STILL SOLID AND IN TACT. THE TOP PART WHERE THE STRAP ATTACHES TO THE FRAME OF THE VEHICLE WAS GREAT. THE BREAK OCCURRED AT THE BOTTOM OF THE TANK WITH A FULL LOAD OF FUEL. UPDATED 09/16/11.

TL* THE CONTACT OWNS A 1999 FORD F-150. THE CONTACT STATED THAT ONE OF THE FUEL TANK STRAPS WAS FRACTURED DUE TO CORROSION. THE VEHICLE WAS NOT INSPECTED BY A DEALER NOR REPAIRED. THE FUEL TANK STRAP WAS TEMPORARILY REPAIRED. THE MANUFACTURER WAS NOT MADE AWARE OF THE FAILURE. THE FAILURE AND CURRENT MILEAGE WAS APPROXIMATELY 148,000.

TL* THE DRIVER OWNS A 1999 FORD F-150. THE CONTACT STATED THAT THE FUEL TANK DETACHED FROM THE VEHICLE WHILE DRIVING 45 MPH. THE VEHICLE WAS TOWED TO AN AUTHORIZED DEALER WHERE THE CONTACT WAS INFORMED THAT BOTH STRAPS WHICH HELD THE FUEL TANK IN PLACE HAD FRACTURED DUE TO CORROSION. THE VEHICLE WAS IN THE PROCESS OF BEING REPAIRED. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE. THE FAILURE AND CURRENT MILEAGES WERE 220,000. THE VIN WAS UNAVAILABLE.

TL* THE CONTACT OWNS A 1999 FORD F150. THE CONTACT STATED THAT WHILE DRIVING 65 MPH, THERE WAS AN ABNORMAL GRINDING FROM THE VEHICLE. THE CONTACT DISCOVERED THAT THE FUEL TANK HAD DETACHED FROM THE VEHICLE AND CAUSED FUEL TO SPILL. THE VEHICLE WAS TOWED TO THE LOCAL MECHANIC WHO FOUND THAT THE FUEL TANK STRAPS WERE CORRODED. THE VEHICLE WAS NOT REPAIRED. THE FIRE AND POLICE DEPARTMENT WERE DISPATCHED AND A POLICE REPORT WAS FILED. THE FAILURE AND CURRENT MILEAGE WAS 110,000. THE VIN WAS NOT AVAILABLE.

1999 FORD F150 GAS TANK STRAPS FAILED. VEHICLE WAS TRAVELING ON A SMOOTH ROAD AT ABOUT 35 MPH. HUSBAND AND DAUGHTER IN THE TRUCK, PULLED OVER RIGHT AWAY, TRUCK WAS TOWED TO A MECHANIC. GAS TANK WAS DRAGGING ON THE GROUND. GAS SPILLED OUT. *TR

HAVE HAD A SPARK PLUG EJECTED TWICE NOW WITHIN 3000 MILES. AFTER SOME RESEARCH THIS SEEMS TO BE A COMMON PROBLEM WITH SOME FORD ENGINES. IT WAS ACTUALLY PRETTY SCARY DUE TO THE STRONG ODOR OF GAS AFTERWARDS WITH THE ENGINE BEING SO HOT. IT NOW SEEMS LIKE ITS GOING TO BE A COSTLY PROBLEM TO FIX. EVEN WORSE, THE FIX IS NO GUARANTEE THAT IT WON'T HAPPEN TO THE REPLACEMENT CYLINDER HEADS. *TR

TL* THE CONTACT OWNS A 1999 FORD F-150. THE CONTACT WAS DRIVING A MODERATE SPEEDS WHEN THE FUEL TANK STRAP FRACTURED AND CAUSED THE FUEL TANK TO DRAG. THE CONTACT STATED THAT BY THE TIME HE WAS ABLE TO STOP THE VEHICLE, A HOLE WAS CREATED IN THE FUEL TANK AND CAUSED A LEAK. THE CONTACT HAD THE VEHICLE TOWED TO THEIR PERSONAL MECHANIC FOR REPAIRS. THE VIN WAS UNAVAILABLE. THE FAILURE AND CURRENT MILEAGE WAS 105,000.

AFTER HEARING OF A RECALL OF THIS VEHICLE FOR CORROSION OF FUEL TANK STRAPS AND CHECKING MY VEHICLE THEY ARE CORRODING. I HAVE TALKED TO THE DEALERSHIP, FORD CUSTOMER CARE AND E-MAILED THE COMPANY I AM TOLD THAT THIS VEHICLE IS NOT INCLUDED IN THE RECALL AND THEY CAN DO NOTHING. WHY ARE ALL FORD F-150'S NOT INCLUDED INTO RECALL, ESPECIALLY IF THEY ARE DEFECTIVE. WHAT OTHER ACTION CAN I TAKE TO HAVE THIS TAKEN CARE OF? *TR

TL* THE CONTACT OWNS A 1999 FORD F150. WHILE DRIVING APPROXIMATELY 10 MPH INTO A DRIVEWAY, A LOUD NOISE EMITTED OUTSIDE OF THE VEHICLE. THE CONTACT TURNED THE ENGINE OFF AND DETECTED BOTH FUEL TANK STRAPS WERE FRACTURED DUE TO RUST. AS A RESULT OF THE FAILURE, THERE WAS A SMALL AMOUNT OF FUEL LEAKAGE ON THE GROUND. THE MANUFACTURER WAS NOTIFIED AND THEY ADVISED THERE WAS NOT A RECALL PERTAINING TO THE DEFECT. THE FAILURE MILEAGE WAS APPROXIMATELY 146,000. UPDATED 07/08/11 *BF THE GAS TANK WAS PUNCTURED AS A RESULT OF THE STRAPS BREAKING. THE TRUCK WAS TOWED TO A REPAIR SHOP WHERE THE STRAPS AND GAS TANK WERE REPLACED AT A COST OF $1000. UPDATED 09/21/11

TL*THE CONTACT OWNS A 1999 FORD F-150. THE CONTACT STATED THE FUEL TANK WAS LEAKING; WHEN THE VEHICLE WAS INSPECTED HE NOTICED THAT THE FUEL TANK AND ONE OF THE STRAPS WERE CORRODED. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURE. THE FAILURE AND THE CURRENT MILES WERE 109,393. UPDATED 6/8/11 *CN UPDATED 06/24/11

GAS TANK STRAPS ERODED OFF-TANK WAS DRAGGING ON GROUND. *TR

ONE OF THE METAL STRAPS HOLDING ON THE GAS TANK HAS RUSTED AND BROKEN OFF. THE GAS TAKE IS UNSTABLE AND TILTED. THE OTHER METAL STRAP IS RUSTED BUT NOT BROKEN YET.