2003 Ford F-150 Visibility & Wipers Problems

TL* THE CONTACT OWNS A 2003 FORD F-150. THE CONTACT STATED THAT WATER WAS LEAKING INTO THE VEHICLE FROM THE WINDSHIELD, CAUSING DAMAGE TO THE GEM MODULAR. THE VEHICLE WAS INSPECTED BY AN INDEPENDENT MECHANIC WHO ADVISED THAT THE GEM MODULAR AND THE WINDSHIELD HAD TO BE REPLACED. THE WINDSHIELD PRIMER HAD BECOME LOOSE ALLOWING WATER TO LEAK INTO THE VEHICLE. THE VEHICLE WAS REPAIRED. THE APPROXIMATE FAILURE MILEAGE WAS 74,000.

PASSENGER WINDOW REGULATOR FAILURE ON 2003(2004 BODY STYLE) F150 LARIAT. REGULATOR FAILED ON ROAD TRIP IN 95 PLUS DEGREE WEATHER IN EASTERN NC ON JUNE 26, 2010. THIS IS THE SECOND ONE. *TR

FORD TAURUS 2003, WINDSHIELD WAS HIT WITH A STONE WHILE DRIVING ON HIGHWAY ON MAY 10, 2007, A CHIP WAS VISIBLE AND WITHIN A FEW DAYS BECAME A 12 INCH CRACK. HAD REPLACED AT A COST OF $197.34. *TR

ON SEPT 31 ALL WAS WELL. THE TEMPERATURE DROPPED DOWN TO 40+ DEGREE'S THAT NIGHT. WELL MUCH TO MY SURPRISE I WENT TO GET IN MY 03 F150 TO GO TO THE STORE, AND THE REAR GLASS WAS ALL SHATTERED. NOTHING HIT, NOTHING AROUND IT. THE TEMP ONLY GOT UP TO 78 TODAY OCT.1-2006. WE HAVE HAD STRANGER WEATHER THEN THIS WHY WOULD THE GLASS JUST SHATTER LIKE THAT. THERE HAS TO BE SOME DEFECT IN THE GLASS TO DO THAT?I LIVE OFF A BUDGET AND CAN NOT AFFORD TO PAY FOR REPLACING THE GLASS. SO WHAT CAN BE DONE TO HELP ME REPLACE THE REAR GLASS,I SURE CAN'T DRIVE TO WORK WITH NO REAR GLASS. MY 03 F150 IS STILL UNDER FACTORY WARRANTY. SO PLEASE HELP ME REPLACE THE GLASS. *NM

DT*: THE CONTACT STATED THE ENTIRE FRONT WINDSHIELD GLASS SLIPPED OUT OF PLACE WITHOUT ANY PRIOR WARNING. ALTHOUGH THE WINDSHIELD GLASS BECAME DISLODGED FROM THE MOLDING, THE GLASS DID NOT CRACK OR BREAK. THE GLASS RESTED BETWEEN THE HOOD SLIT AND THE GLASS MOLDING. THE VEHICLE WAS TAKEN TO A DEALER. THE SERVICE DEPARTMENT CONTACTED A GLASS COMPANY IN REFERENCE TO THE ISSUE. THE GLASS COMPANY INSPECTED THE VEHICLE AND REINSTALLED THE WINDSHIELD GLASS WITH NEW GLUE AROUND THE WINDSHIELD MOLDING. UPDATED 3/17/2006 - *NM

2004 EXPEDITION EDDIE BAUER WITH 45K MILES WINDSHIELD BUBBLED MAKING VIEWING DIFFICULT AND DRIVING DANGEROUS. THIS STARTED SMALL AND THEN WENT ON TO INVOLVE MOST OF THE WINDSHIELD IN LITTLE OVER A WEEK. DEALER REPLACED WINDSHIELD FOR $150.00. WINDSHIELD DEFINITELY DEFECTIVE AND DANGEROUS NEEDS REPORTING. *JB

AFTER HEARING AN ANNOYING WHISTLE AND/OR WIND SOUND IN OUR 2003 FORD F150 SUPER CREW FX4 TRUCK FOUND THAT THE WINDSHIELD WAS NOT ATTACHED TO THE UPPER PART OF THE CAR (WE COULD SEE DAYLILGHT). WE TOOK IT TO A BODY SHOP THE NEXT DAY WHERE THEY DISCOVERED THAT THE WINDSHIELD WAS NOT ATTACHED BY ANY SEALANT, IT WAS BEING HELD IN BY THE MOLDING ONLY. A AUTO GLASS COMPANY WAS CALLED AND THEY DISCOVERED THAT THE POLY THAT IS SUPPOSE TO BE ON THE WINDSHIELD WAS ON THE RUBBER MOLDING.

WHILE DRIVING IN INCLEMENT WEATHER, THE WINDSHIELD WIPERS WOULD COME ON AND GO OFF INTERMITTENTLY. THE DEALER WAS AWARE OF THE INTERMITTENT PROBLEM. THE MECHANIC INFORMED THE DRIVER THAT THE WINDSHIELD WIPER MOTOR NEEDED TO BE REPLACED. PLEASE FILL IN ADDITIONAL INFORMATION. *JB

THE CONSUMER FEELS, "THAT THE POSITION OF THE POWER WINDOW SWITCH POSES A SAFETY RISK. A CHILD OR AN ANIMAL CAN ACTIVATE THE SWITCH JUST BY STICKING THEIR HEAD OUT OF THE WINDOW." THE CONSUMER'S DOG WAS ABLE TO ENGAGE THE SWITCH AND ALMOST CRUSHED HIS HEAD IN THE WINDOW. *LA THE WINDOW ON THE DRIVERS SIDE WAS DISCONTINUED IN THE 2003 MODEL. *SC *JB

WHILE PARKED REAR WINDOW SHATTERED INTO PIECES WITHOUT WARNING. *AK

THE WINDSHIELD WIPER BLADE DOESN'T REACH OUT ENOUGH IN ORDER FOR THE CONSUMER TO SEE. PLEASE PROVIDE ADDITIONAL INFORMATION. DEALER IS AWARE OF THE PROBLEM. PH *TS

I HAVE A 2003 FORD F150, WITH A 5.4L ENGINE. I FOUND OUT THAT MY WINDSHIELD IS LEAKING AND SEEPING WATER ONTO MY GEM/CJB AND MAKING IT SO IN RAIN MY WINDSHIELD WIPERS SHUT OFF, MY HEATER BLOWER TO STAY ON OR GO ON WHEN THE KEY IS NOT IN THE IGNITION, AND HAS DRAINED MY BATTERY. HERE IS A COPY OF THE NOTICE FORD SENT TO THERE DEALERSHIPS IN 2004, *FORD SPECIAL MESSAGE #15773 VARIOUS ELECTRICAL CONDITIONS RESULTING FROM WATER INTRUSION INTO THE GEM/CJB SOME 1997-2002 EXPEDITION AND 1998-2002 NAVIGATOR VEHICLES MAY EXHIBIT VARIOUS UNUSUAL ELECTRICAL CONDITIONS, INCLUDING BUT NOT LIMITED TO: FRONT OR REAR BLOWER OR EATC STAYING ON WITH KEY OUT OF THE IGNITION, RADIO STAYING ON AFTER DOORS OPENED AND KEY OUT OF IGNITION, WIPER CIRCUIT FAILURE CODES, AND MULTIPLE SYSTEM WARNING LIGHTS WITH 'SHORT TO POWER' OR 'LOW BATTERY VOLTAGE' DTCS. THESE SYMPTOMS MOST OFTEN OCCUR AFTER A RAIN OR SNOW. THIS MAY BE DUE TO GEM/CJB WATER INTRUSION RESULTING FROM A WINDSHIELD WATER LEAK. TO SERVICE, REMOVE THE GEM AND CJB FROM THE VEHICLE, SEPARATE THEM AND INSPECT FOR WATER CONTAMINATION OR CORROSION. IF FOUND IN EITHER COMPONENT, REPLACE BOTH COMPONENTS AND COMPLETELY RESEAL THE WINDSHIELD. EFFECTIVE DATE: 04/05/2002 SO THIS IS A KNOWN ISSUE AND THEY ARE CHARGING BETWEEN $900 - $1500+ FOR REPAIRS AND THEN ON TOP OF THAT CHARGING FOR THE WINDSHIELD TO BE REPLACED. THE HAZARDS OF THIS POTENTIALLY SHORTING OUT AND HAVING A FIRE IS A RISK THAT I THINK SHOULD BE ADDRESSED FOR THE SAFETY OF THE CONSUMERS. HAVING MY WINDSHIELD WIPERS STOP ON ME IN HEAVY RAIN ON THE HIGHWAY ALMOST CAUSED ME TO GET INTO A POTENTIAL ACCIDENT. *TR

VEHICLE DOESN'T COME EQUIPPED WITH A REAR DEFOGGER SYSTEM. AS A RESULT, DRIVER IS UNABLE TO SEE OUT THE REAR IN RAINY OR SNOWY WEATHER. *AK