2004 Ford F-150 Visibility & Wipers Problems

IN MID NOVEMBER 2019, I WAS ENTERING MY VEHICLE AND NOTICED THE REAR CENTER GLASS WINDOW COMPLETELY SHATTERED THE MOMENT I OPEN THE TRUCK DOOR FOR NO REASON. NO INDICATION OF AN OBJECT STRIKING OR ANYTHING. THE VEHICLE WAS COMPLETELY STATIONARY IN MY DRIVEWAY. THE TEMPERATURE HAD DROPPED DOWN PAST 20 DEGREES THE DAY THIS HAPPENED. I REPLACED THE ENTIRE REAR WINDOW AND THEN,NOT EVEN A WEEK LATER, THE REAR RIGHT SIDE OF THE WINDOW IS COMPLETELY SHATTERING AND IS ABOUT TO BREAK....THE SAME PROBLEM AGAIN! NOW, I GO OUT TODAY, 12/12/19 TO MY PASSENGER SIDE DOOR WINDOW COMPLETELY SHATTERED FOR NO APPARENT REASON! IN ALL 3 INSTANCES, THE TEMPERATURE DROPPED BELOW 35 DEGREES. I HAVE NO IDEA WHAT'S GOING ON AND IT'S DRIVING ME INSANE TRYING TO FIGURE OUT WHY THE WINDOWS ARE RANDOMLY SHATTERING WHEN THE TEMPERATURE DROPS. NOW I AM ABOUT TO BE OUT I DON'T KNOW HOW MUCH MONEY TO TRY TO REPAIR MY FORD WINDOWS.

TL* THE CONTACT OWNS A 2004 FORD F-150. WHILE DRIVING 30 MPH, THE SUN ROOF EXPLODED INTO PIECES. THERE WERE NO INJURIES. A DEALER WAS NOT MADE AWARE OF THE FAILURE. THE MANUFACTURER WAS NOTIFIED. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE FAILURE MILEAGE WAS APPROXIMATELY 247,000.

TL* THE CONTACT OWNS A 2004 FORD F-150. WHILE DRIVING 40 MPH, A LOUD POP SOUND EMITTED FROM THE VEHICLE. THE CONTACT NOTICED THAT THE REAR DRIVER SIDE WINDOW OPENED INDEPENDENTLY. IN ADDITION, WHILE THE VEHICLE WAS PARKED, THE FRONT AND REAR PASSENGER SIDE WINDOWS EXPERIENCED THE SAME FAILURE. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC WHERE IT WAS DIAGNOSED THAT THE WINDOW KIT FAILED. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE FAILURE MILEAGE WAS 62,000.

TL* THE CONTACT OWNS A 2004 FORD F-150. WHILE DRIVING AT APPROXIMATELY 40 MPH IN THE RAIN, WATER POURED INTO THE REAR WINDOW OF THE CAB OF THE VEHICLE. THE VEHICLE WAS TAKEN TO THE DEALER. THE TECHNICIAN REPLACED THE GASKET AROUND THE REAR WINDOW AND THE LAMP ASSEMBLY. THE VEHICLE WAS REPAIRED. THE APPROXIMATE FAILURE MILEAGE WAS 31,000. UPDATED 11/19/15*LJ

THE MIRROR(S) ARE FULL OF CORROSION AND THE DRIVERS SIDE MIRROR FELL RIGHT OFF THE CAR WHILE DRIVING. *TR

I HAVE HAD SUNROOF FIXED TWICE. KEEPS JUMPING OFF TRACK & NOW NEED TO GET IT FIXED FOR THIRD TIME. ALSO, ALL 4 POWER WINDOWS HAVE FAILED AND HAD TO BE FIXED A FEW TIMES. *TR

DRIVING DOWN MY STREET THE WINDOW JUST CRASHED DOWN! IT FELL SO FAST AND HARD THAT I HAD TO LOOK TO MY RIGHT SIDE TO SEE WHAT HIT ME! AT THAT POINT I REAR ENDED A CAR THAT SLOWED DOWN! ALL THIS IS DO TO A CHEAP PLASTIC CLIP THAT FAILED AND RELEASED THE WINDOW. *TR

THIS IS MY SECOND WINDOW REGULATOR TO BREAK. THE FIRST WAS THE REAR PASSENGER WINDOW SEVERAL MONTHS AGO. WHILE DRIVING ON EXPRESSWAY AT 60 MPH I HEARD A POP AND THEN AIR NOISE. (I SELDOM USE THE REAR WINDOWS.) THE MECHANIC HAD TO REPLACE REGULATOR AND MOTOR BECAUSE THAT WAS ALL THE DEALER HAD IN STOCK. TODAY I HAD WINDOW DOWN ABOUT AN INCH WHILE PARKED. GOT IN TRUCK AND RAISED FRONT PASSENGER WINDOW AND HEARD POP. I KNEW WHAT THE PROBLEM FROM LAST TIME AND WITH TALKING TO OTHER FORD TRUCK OWNERS. A FRIEND HAS THE SAME MODEL TRUCK AND HAS REPLACE THREE OF THE FOUR REGULATORS IN HIS FORD TRUCK. WHEN I BEGAN DRIVING THE WINDOW DROPPED. THIS TRUCK HAS NEVER BEEN DRIVEN HARD OR OFF ROAD. THERE HAS TO BE SOME FLAW IN THESE REGULATORS. I AM 66 YEARS OLD AND HAVE OWNED MANY DIFFERENT MAKES AND MODEL OF VEHICLES AND THIS SEEMS TO BE A COMMON THREAD FOR THESE FORD TRUCKS. *TR

DRIVERS SIDE WINDOW REGULATOR WENT OUT. WAS DRIVING DOWN THE ROAD APPX 45 MPH AND THE WINDOW JUST FELL DOWN. STARTLED ME SOME BUT WAS ABLE TO KEEP CONTROL OF VEHICLE. THIS WILL BE SECOND ONE REPLACED SINCE I HAD THE VEHICLE WHICH I PURCHASED BRAND NEW. NOT ONE TO USUALLY COMPLAIN BUT APPEARS TO BE A WIDESPREAD PROBLEM FROM EARLY ON IN IT'S YEARS. THANK YOU! *TR

I WAS DOING A DAY TRIP HAULING HORSES BY MYSELF WHEN I WAS GETTING READY TO HEAD HOME WHEN I HEARD THIS TERRIBLE NOISE AND SOON WATCHED THE REAR RIGHT WINDOW DISAPPEAR AND WOULD NOT GO BACK UP. I TOOK IT INTO FORD TODAY AND WAS TOLD IT WOULD COST $300 TO FIX BUT THEY DID NOT HAVE IN STOCK AND THAT IT WAS THE REGULATOR THAT WENT OUT. I HAD THEM CHECK THE RIGHT FRONT WINDOW AS WELL AS IT WOULD GO DOWN BUT WOULD NOT GO UP USING THAT DOOR WINDOW SWITCH AND THAT THE SWITCH NEEDS REPLACED AND THAT WOULD BE $130 DOLLARS AND AGAIN PART WAS NOT IN STOCK SO COULD NOT REPLACE. SO WHEN I WENT IN TO GET MY TRUCK ALL OF A SUDDEN I FIND OUT THAT OTHER THAN THE OIL CHANGE WHICH I EXPECTED MY BILL JUST FOR THEM TO LOOK AT AND OIL CHANGE WAS OVER $190.00 AND MY WINDOWS WERE NOT FIXED YET AND NOT TOLD AHEAD OF TIME WHAT THE CHARGE MIGHT BE SO THE EXTRA $150 WAS TOTALLY NOT BUDGETS. BUT HAD TO PAY AS I NEEDED MY TRUCK TO GET HOME. I ALSO FOUND OUT THAT MY BROTHER IN LAWS TRUCK ALSO A 2004 HAD A VIN NUMBER SET THAT FORD DID REPLACE THE REGULATOR BUT NOT FOR MY VIN NUMBER. NOW THAT REALLY UPSET US A LOT ESPECIALLY FINDING OUT OTHERS HAVE HAD THE SAME PROBLEM AND THAT WE COULD HAVE ISSUES WITH THE OTHER THREE WINDOWS. FORD REALLY NEEDS TO RECALLED ALL 2004 F150 DOOR REGULATORS BEFORE SOMEONE REALLY GETS HURT AS IT IS A SAFETY ISSUE IF GLASS WAS TO BREAK IF IT HAD HAPPENED WHILE IN ROUTE. PLUS WAS NOT COVERED BY MY EXTENDED WARRANTY SO EVIDENTLY THE WARRANTY COMPANIES ARE AWARE OF THE PROBLEM IF THEY EXCLUDE IT. *TR

I STARTED UP MY TRUCK IN MY DRIVEWAY AND BEGAN TO LOWER THE DRIVER AND PASSENGER SIDE WINDOWS WHEN THE DRIVERSIDE WINDOW JUST FELL DOWN. *TR

TL* THE CONTACT OWNS A 2004 FORD F-150. THE CONTACT STATED THAT ALL FOUR WINDOWS FAILED TO OPERATE AND COULD NOT BE CLOSED. THE VEHICLE WAS TAKEN TO THE DEALER FOR DIAGNOSIS WHERE IT WAS ADVISED TO THE CONTACT THAT THE WINDOW MECHANISM NEEDED TO BE REPLACED. THE VEHICLE WAS REPAIRED AND THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 47,835. *TR UPDATED 7/15/13 *CN

I OWN A 2004 FORD F150 4-DOOR P/U. OVER THE PAST SEVERAL YEARS THREE OF THE FOUR WINDOW IN MY FORD F150 HAVE FALLIN AT DIFFERENT TIMES ( WINDOW REGULATOR ). FORD REFUSED TO PAY FOR THE REPAIR AND I WAS TOLD THEY KNOW ABOUT THE PROBLEM, HOWEVER, WERE NOT GOING TO ISSUE A RECALL. THIS WEEK MY 4TH WINDOW REGULATOR BROKE CAUSING THE WINDOW TO FALL AGAIN WHILE IN A SHOPPING CENTER PARKING LOT. I ADVISED FORD THIS WAS UNSAFE AND HOW CAN ANYONE SECURE A VEHICLE WITH FAULTY WINDOW REGULATORS. SOMEONE COULD LOSE CONTROL OF THEIR VEHICLE IF THIS OCCURS DURING DRIVING AND THIS ISSUE SHOULD BE ADDRESSED. *TR

THE 3RD OUT OF 4 DOOR WINDOWS FELL INTO THE DRIVER'S FRONT DOOR - REGULATOR ASSEMBLY. LOUD BANG BEFORE THEY FELL. SCARED ME - THOUGHT SOMEONE HAD THROWN A LARGE ROCK AT MY VEHICLE. THIS IS THE 3RD TO FAIL WITHIN 8 MONTHS (LAST 2 ON THE SAME DAY IN JULY 2012). REPAIR COST WAS $245.00. THERE IS STILL NO RECALL ON THESE REGULATOR ASSEMBLIES, ALTHOUGH HUNDREDS, IF NOT THOUSANDS, HAVE HAD THE SAME PROBLEM. I CONTACTED FORD FOR REIMBURSEMENT, AND RECEIVED NO RESPONSE. *TR

GOT INTO VEHICLE, STARTED, AND IMMEDIATELY LOUD POPPING SOUNDS CAME FROM UNDER THE ENGINE, AND WORSE WHEN PUT INTO REVERSE. LUCKILY HAD 2 HOBBY MECHANICS, THAT I WORK WITH, COME TAKE A LOOK. THEY IMMEDIATELY DETERMINED THAT ONE OF MY SPARK PLUGS HAD BACKED-OUT. THEY TOOK THE COVER OFF AND DETERMINED IT WAS THE 1ST SPARK PLUG, AND LUCKILY THE THREADS WERE IN GOOD SHAPE. PUT SPARK PLUG BACK IN, AND VEHICLE STARTED FINE AFTER THAT. I TRAVEL 45 MILES ONE WAY TO/FROM WORK. IF THIS HAPPENS AGAIN, COULD LEAVE ME STRANDED. 2ND LUCK, NO REPAIR COST. I CAN ONLY IMAGINE WHAT THE DEALER WOULD HAVE CHARGED. IN ADDITION, 2 WEEKS LATER, I HAD THE 3RD (2 PREVIOUS WERE IN FRONT RIGHT & REAR DRIVER WINDOW) OUT OF 4 DOOR WINDOWS FALL INTO THE DOOR. THIS TIME IT WAS THE DRIVER'S FRONT DOOR - REGULATOR ASSEMBLY. LOUD BANG BEFORE THEY FELL. SCARED ME - THOUGHT SOMEONE HAD THROWN A LARGE ROCK AT MY VEHICLE. THIS IS THE 3RD TO FAIL WITHIN 8 MONTHS (LAST 2 ON THE SAME DAY IN JULY 2012). TOTAL REPAIR COST ON WINDOWS WAS $900.00. THERE IS STILL NO RECALL ON THE SPARK PLUG PROBLEM, AND THE REGULATOR ASSEMBLY PROBLEMS, ALTHOUGH HUNDREDS, IF NOT THOUSANDS, HAVE HAD THE SAME PROBLEM. I CONTACTED FORD FOR COMPLAINT & REIMBURSEMENT, AND RECEIVED NO RESPONSE. IT'S VERY OBVIOUS, IT'S TIME TO DO SOMETHING ABOUT THIS! *TR

TL* THE CONTACT OWNS A 2004 FORD F-150. THE CONTACT WAS DRIVING APPROXIMATELY 50 MPH WHEN THE FRONT PASSENGER'S SIDE WINDOW GLASS RELEASED ABRUPTLY INSIDE OF THE DOOR PANEL WITH A LOUD THUMPING NOISE. THE CONTACT WAS ABLE TO CONTINUE DRIVING. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE MANUFACTURER WAS NOTIFIED OF THE PROBLEM. THE APPROXIMATE FAILURE MILEAGE WAS 141,000.

I WAS DRIVING MY 2004 FORD F150 SUPERCAB DOWN THE STREET IN MY NEIGHBORHOOD ON MY WAY TO WORK. I ROLLED UP THE POWER WINDOWS AND HEARD A WEIRD SOUND FROM THE PASSENGER DOOR. I DECIDED TO ROLL IT BACK DOWN TO SEE WHAT WAS GOING ON. AS SOON AS I PRESSED THE DOWN BUTTON, THE WINDOW JUST FELL RIGHT INTO THE DOOR. IT WAS A LITTLE FRIGHTENING AND COULD SEE HOW IT COULD CAUSE A WRECK IF IT HAPPENED ON THE INTERSTATE. WHEN I GOT TO WORK, I GOT OUT TO CHECK IT OUT. I COULD STILL HEAR THE MOTOR WORKING, BUT I COULD HEAR PIECES OF GLASS AND KNEW THE WINDOW SHATTERED. *TR

DRIVING ON THE FREEWAY A LOUD BANG AND THE DRIVER SIDE WINDOW FALLS INTO THE DOOR AND WILL NOT ROLL BACK UP. REAR DRIVER SIDE WINDOW FELL INTO THE DOOR THREE MONTHS AGO WHILE PARKED IN FRONT OF OUR HOUSE. APPARENTLY THE WINDOW REGULATOR FAILS AND THE WINDOWS FALL INSIDE THE DOOR. UPON SEARCHING THE INTERNET THERE ARE HUNDREDS OF PEOPLE THAT HAVE EXPERIENCED THIS SAME PROBLEM WITH THE FORD F150 WINDOW REGULATORS. FORD IS CHARGING BETWEEN $250 - $500 TO FIX THE REGULATORS PER WINDOW. SOME PEOPLE HAVE HAD TO FIX THE SAME WINDOW MORE THAN ONCE. *TR

TWO WEEKS PRIOR TO NOW I HAD TO REPLACE THE WHOLE TRACK ASSEMBLY FOR THE WINDOW ON THE DRIVER'S SIDE. DRIVING DOWN THE HIGHWAY, THE WINDOW JUST FELL INTO THE DOOR PANEL. THIS COULD OF RESULTED IN A SERIOUS ACCIDENT BECAUSE OF THE WINDOW JUST FALLING! TWO DAYS AGO, THE SAME THING HAPPENED TO THE PASSENGER SIDE WINDOW. THE WINDOWS GOING DOWN WHEN YOU ARE NOT EXPECTING IT IS SCARY. THESE WINDOWS UNEXPECTEDLY GOING DOWN CAN RESULT IN AN ACCIDENT. I FEEL THAT THERE IS AN ENGINEERING DEFECT IN THESE WINDOW SYSTEMS. I HAVE BOTH ORIGINAL FORD PARTS THAT CAME OUT OF THE DOOR PANELS. I CALLED FORD, BUT THEY TOLD ME THEY CAN NOT DO ANYTHING ABOUT THIS. *TR

WAS DRIVING DOWN THE ROAD AT APPROXIMATELY 55 MPH AND THE LEFT DRIVER'S SIDE WINDOW CAME CRASHING DOWN. I THOUGHT A ROCK WAS COMING THROUGH THE WINDOW AND ALMOST WENT OFF THE ROAD. *TR