There are 6 owner-reported powertrain & transmission complaints for the 2023 Ford F-250in NHTSA's database. These are unverified consumer reports and may not reflect confirmed defects.
I was on an overpass in the left hand lane doing 40-45mpg getting ready to make a left hand turn on an expressway on ramp. I coasted for just a bit and applied the brakes gently, then a little more. The truck was not slowing down like it should have so I applied alot more brake pedal pressure and it slowed down some then it down shifted several times and the engine was roaring, I'm guessing around 3K rpms or more and pulling me forwards. I put as much pressure as I could on the brake pedal and got it down to 4-5 mph and then as it was almost at a stop, still with the motor roaring, I slammed it into park and turned the key off. The motor turned off thank goodness. I sat there for about 20 seconds or so, luckily no one was behind me, then I turned it on again and it was idling just fine. I crept through the intersection and proceeded down the on ramp at 10mph or so and pulled over. Turned it off again and called the wife and a few friends about it. It ran ok, albeit I was super cautious, to my destination 25 minutes on down the highway. Something freaked out big time in the computer. Had there been traffic or someone in front of me it would have lead to a serious crash.
Ford Has yet to update VIN Lists for 24B27 engine update.
What component or system failed or malfunctioned, and is it available for inspection upon request? The Variable Displacement Oil Pump delivers oil to the engine at low pressure/capacity during idle conditions. Routine occurrences of prolonged idle time may result in excess wear to the engine camshaft lobes and valve tappet surfaces due to reduced lubrication. Overtime, the engine may progressively run rough due to cylinder misfire. Additionally, customers may hear engine tapping noises and the Check Engine Light may illuminate. This causes delamination of the lifters and camshaft which sends metal throughout the engine causing total engine failure and this requires a completely new engine. How was your safety or the safety of others put at risk? Beyond the financial implications, A sudden breakdown on a busy road can lead to dangerous situations, putting both me and other drivers at risk. Additionally, driving a vehicle with a compromised engine can result in further damage and potentially cause accidents. Has the problem been reproduced or confirmed by a dealer or independent service center? Yes there are many forums and videos online about this issue in the 7.3 Godzilla engine produced by ford. Has the vehicle or component been inspected by the manufacturer, police, insurance representatives or others? My vehicle is currently at the dealership for repairs which they said they are unable to do so I will be taking it to another dealership next week. Were there any warning lamps, messages or other symptoms of the problem prior to the failure, and when did they first appear? In my vehicle there was no CEL but in other customers vehicles the CEL will appear if the problem is not caught soon enough.
During the 1st 20 min or so of operation the truck tries to "high idle" when in gear. This forces the operator use excessive brake pressure to keep the vehicle stopped. There have been several times my leg gets tired of holding the brake pedal down so hard the truck will creep forward unintentionally. The brakes grunt due to excessive force trying to keep the truck stopped. The dealer blows it off as normal, saying the truck is doing what its supposed to. I don't think the truck should be allowed to high idle in gear. I am afraid that I am going to accidently roll forward and hit someone. I have driven other 3/4 ton trucks and the ford 7.3 engine this is the only one that does this. I called ford and they said there is nothing to do if the dealership says the truck is operating properly.
there hasn't been an incident per say and these might not be a safety concern. however i would like to list my grievances here just so there's documentation. my radio has some type of glitch where the phone calls get static like its digital, also the mirrors don't fold in all the time when locked with the key fob, the brakes have squeaked since day 1 and the grab handle in the tailgate just slides right out when the steps are pulled out. again i don't think this really qualifies for dangerous
I had my truck inspected for this recall on October 26, 2023 and as of today they are telling me that the parts are on backorder so the recall has not been completed. Manufacturer Recall Number23S49 NHTSA Recall Number23V595 Recall StatusRecall Incomplete
Complaints are unverified consumer reports submitted to NHTSA. A high complaint count may reflect vehicle popularity, not defect severity. Data sourced from NHTSA public records.
Data synced from NHTSA on May 4, 2026