1996 Ford F-350 Brakes Problems

1/07 SQUEAK IN FRONT LEFT WHEEL, TOOK TO SEARS AS BRAKES/BEARINGS UNDER WARRANTY. ENDED UP W/ COMPLETE BRAKE JOB FRONT & REAR. PICKED UP VEHICLE, POOR PEDAL PRESSURE, NO E-BRAKE. TOOK BACK TO SEARS THEY ADJUSTED. IN APRIL HAD REAR BRAKES FAIL TO STOP VEHICLE WHILE PULLING HORSE TRAILER. ONLY FRONT BRAKES ENGAGED. TOOK BACK COULDN'T FIND A PROBLEM. TOOK TO ANOTHER SHOP THEY FOUND ONLY PADS REPLACED ON RT REAR NOT ON LEFT. THEY DID COMPLETE BRAKE JOB ON REAR (NEW DRUMS AND PADS) TOOK IN 2 WEEKS LATER STILL NOT CORRECT AND HAD VIBRATION WHEN BRAKING. ENDED UP WITH RE-SURFACE OF FRONT ROTORS AND NEW PADS. 7/29/07 PULLING HORSE TRAILER REAR ENDED VEHICLE ON 19TH AVE IN SF DUE TO REAR BRAKES NOT ENGAGING AT ALL. ONLY FRONTS ENGAGED. REAR BRAKES NOT WORKING AT ALL. *JB

DT: THE CONTACT COMPLAINED ABOUT A BRAKE PROBLEM. THE BRAKE FLUID CAUSED CORROSION ON THE BRAKE FITTINGS. ON AUGUST 7, 2003 THE FRONT BRAKES FAILED WHILE THE VEHICLE WAS GOING UP HILL. THE FORD DEALER REPLACED THE TUBING AND FITTINGS. ON MAY 24, 2004 THE REAR BRAKES FAILED WHILE HE IN A PARKING LOT. AGAIN THE FORD DEALER REPLACED THE TUBING AND FITTINGS. ON NOVEMBER 1, 2005 THE MASTER CYLINDER EXPERIENCED CORROSION AT THE BRAKE FITTINGS, CAUSING THE BRAKES TO FAIL. THERE WAS BRAKE FLUID POURING OUT OF THE FRONT DRIVER SIDE WHEEL. ANOTHER DEALERSHIP DRAINED THE BRAKE SYSTEM AND REPLACED THE LINE. THE PROBLEM HAS NOT RECURRED. *AK UPDATED 11/29/2004 - *NM

STEPPED ON BRAKE TO RELEASE THE PARKING BRAKE AND THE BRAKE PEDDLE WENT TO THE FLOOR, CAUSING ME TO HIT A POST. ON INVESTIGATION I FOUND THE BRAKE LINE TO THE REAR WHEELS ROTTED IN THE MIDDLE. ALL OTHER LINES IN THE AREA ARE LIKE NEW. I HAVE OWNED MUCH OLDER VEHICLES WITHOUT HAVING BRAKE LINE PROBLEMS. I BELIEVE THE MATERIAL IN THESE LINES ARE QUITE INFERIOR AND DANGEROUS FOR A VEHICLE. I HAD JUST BEEN TOWING MY FIFTH-WHEEL TRAILER THE DAY BEFORE. *NLM

DROVE THIS TRUCK OVER 1000 MILES THIS TRIP AND PARKED IT FOR 2 WEEKS. THEN TO TRAVEL A SHORT DISTANCE BRAKE PEDAL WENT TO THE FLOOR FIRST TIME TO APPLY BRAKES.FOUND BRAKE FLUID RUNNING OFF FRAME, AND HAD MECHANIC INSPECT FOR PROBLEM.FOUND BRAKE LINE THAT GOES TO THE REAR BRAKES WAS ROTTED THE FULL LENGTH FRONT TO REAR. ALL OTHER LINES(FUEL,ETC) IN THE SAME AREA WERE IN GOOD CONDITION.NEW LINE WAS INSTALLED.. *AK

ON A RAINY DAY, REAR BRAKE LINING GRABBED ACTUATING THE ABS SYSTEM. AS I HAVE FOUND, THIS PROBLEM IS DISCUSSED IN FORD TSB 9805A24A. THE BRAKE PEDAL FELL AS ADDITIONAL PRESSURE WAS NEEDED TO STOP. DESCRIBED AS "NORMAL" IN SPECIAL SERVICE MESSAGE 03731. (A NICE WAY TO DESCRIBE A PROBLEM THAT YOU DO NOT WANT TO FIX.) THE ABS BRAKES STOPPED PUMPING. THE SYSTEM THEN APPEARED AS THOUGH NO BRAKES WERE APPLIED. THE TRUCK WAS NOT SLOWING DOWN. EITHER THE BACK BRAKES AND POSSIBLY THE FRONT WERE NOT FUNCTIONING AT ALL, OR ALL 4 WHEEL WERE LOCKED UP AND THE TRUCK WAS SLIDING. (TIRES WERE ALL IN GOOD CONDITION.) I WAS FORCED TO PUT THE TRUCK INTO A DITCH IN ORDER TO AVOID THE VEHICLE IN FRONT OF ME. LATER TESTING ON A WET SURFACE REVEALED THAT I WOULD HAVE BEEN BETTER OFF TO PUMP THE BRAKES, SOMETHING THAT MANUFACTURERS OF ABS SYSTEMS ADVISE YOU NOT TO DO. AS I UNDERSTAND FROM READING INFORMATION BY OTHERS WHO HAVE HAD THE SAME PROBLEM, THE VACUUM SUPPLY ON THE SYSTEM IS NOT SUFFICIENT TO HANDLE REPEATED OPERATION BY THE ABS SYSTEM. I STILL AM NOT SURE WHAT THE CONDITION OF THE WHEELS WERE AT THE POINT WHEN I HAD TO LEAVE THE ROAD, WHETHER THE FRONT WERE ROLLING, OR LOCKED AND WHETHER THE BACK WERE ROLLING OR LOCKED. *AK

POWER BRAKE VACUUM PUMP FAILED, RESULTING IN LOSS OF POWER BRAKES. THE DEALER HAS BEEN NOTIFIED. *AK

WHILE DRIVING AT 55 MPH AND WITHOUT PRIOR WARNING THE FRONT BRAKE ROTORS CRACKED. FORD REFUSES TO ADMIT THAT THEY HAVE A PROBLEM WITH BRAKE ROTORS. *AKL

ABS BRAKES MAKE NOISE AND FEEL LIKE THEY ARE DRAGGING.

THE RIGHT AND LEFT FRONT BRAKE ROTORS CRACKED IN HALF TO THE HUB IN WHICH COULD CAUSE LOSS VEHICLE CONTROL. DEALER CANNOT DETERMINE PROBLEM. *AK

ROTORS ARE CAUSING VEHICLE TO SHAKE AND BECOME UNSAFE. HAS SPENT OVER $100.00 BECAUSE OF BAD MATERIAL ON BRAKES. *AK

NO SUMMARY( DOT NUMBER: TIRE SIZE: 235-85R16 )

BRAKE SYSTEM FAILURE.

WARPING OF REAR BRAKE DRUMS, APPEAR TO BE OUT OF ROUND.*AK

ABS: PUMPED BRAKES WHILE COMING TO STOP, REARENDED/LOCKED UP, PROBLEM HAS OCCURRED SIX TIMES SINCE PURCHASE, REPAIRED 2 TIMES, NO ACCIDENT.*AK

ANTILOCK BRAKES FAILED, CAUSING LEFT REAR BRAKE TO LOCK UP.

VEHICLE VIBRATES WHEN APPLYING BRAKES, DRIVER ALMOST LOST VEHICLE CONTROL. *AK

POOR ABS BRAKE PERFORMANCE, THE ABS LIGHT STAYS ON AT ALL TIMES. THE WHEELS LOCK UP AND EXTENDED STOPPING IS EXPERIENCED. *AK

WHILE TRAVELING NORMAL HIGHWAY SPEEDS, DUAL WHEEL BRAKES OVERHEAT, CAUSING REAR WHEELS TO DRAG, BRAKES FADE WHEN HOT, DRIVER HAS HAD TO PUT VEHICLE IN REVERSE AND BACK TO RELEASE BRAKES, DRUMS AND SHOES HAVE BEEN REPLACED 2 TIMES, VEHICLE HAS BEEN IN SHOP FIVE TIMES, THIS IS AN INTERMITTENT PROBLEM. *SLC

THE LEFT REAR WHEEL LOCKS UP IN A NORMAL BRAKING SITUATION. THE DEALER HAS WORKED ON THIS (7) TIMES. THE SYSTEM HAS ABS. *AK

MOTORHOME ELDORADO 29 1/2 FT. 12000 GVW, ABS FAILURE: PEDAL GOES TO WITHIN AN INCH OF FLOOR, CAN'T PUMP BRAKE, BRAKE ACTION SEEMS INADEQUATE IN STOPPING ON DRY PAVEMENT OR GRAVEL, ONLY REAR WHEELS STOP VEHICLE, NOT ENOUGH BRAKE PRESSURE DURING PANIC STOP. *AK