2006 Ford Five Hundred Electrical System Problems

The contact owns a 2006 Ford Five Hundred. The contact stated while driving 50 MPH, the instrument cluster lights turned became inoperable. The contact veered to the side of the road. The contact stated that the instrument cluster lights illuminated after 5 minutes. The contact was able to continue driving. However, the failure reoccurred on four different occasions. The vehicle was taken to a local Pep Boys who was unable to duplicate the failure. The dealer and the manufacturer were not notified of the failure. The vehicle was not diagnosed or repaired. The failure mileage was approximately 60,000.

when I’m The vehicle and the temperature reaches middle temp ,the car starts to beep and all the dashboard lights go completely out and the head lights and tail lights be blinking as if they are about to go off . Even when I have the heater or a/c on they turns off and I’m a afraid that if or when I’m on the highway all my lights will just stop working on the middle of the highway at night and no one will be able to see me. And that will cause a big wreck and maybe kill myself or worst someone else. I have looked my car up to see if it has a recall but none are given. I’m afraid for the safety of my fellow drivers on the at night . And I don’t know what to do about this problem.

BATTERY JUST GOES DEAD OVER NIGHT. SIGNAL LIGHTS MELTED AND QUIT WORKING. CLUSTER PANEL JUST SHUTS OFF WHILE RUNNING AND CAN'T USE AIR, RADIO, WINDOWS, LOCKS, SEATS, ETC. CAR SHUTS OFF WHILE DRIVING DOWN THE ROAD. HAVE REPLACED ALL PARTS SUGGESTED BY CODES. STILL NO FIX. WONT SHIFT FROM FIRST GEAR AFTER CLUSTER PANEL SHUTS OFF. THERE ARE HUNDREDS OTHER COMPLAINTS. THIS IS DANGEROUS AND SHOULD BE AN ELECTRICAL RECALL. HAPPENS RUNNING DRIVING AND SITTING STILL.

CAUSE UNKNOWN- BATTERY LIGHT IS COMING ON MORE WHILE VEHICLE IS RUNNING IN ALL MODES, LOCAL AUTO STORE DETERMINED IT IS AN ELECTRICAL PROBLEM. THEY TESTED THE BATTERY, ALTERNATOR & STARTER. ALSO NOTICED THAT THERE IS A MUSTY SMELL & MANY ( IF NOT ALL) OF MY METAL PARTS ARE RUSTED.

MY 2006 FORD FIVE HUNDRED IS SURGING THERE'S NO POWER IT STUMBLES SHUTS OFF.

THIS IS A LONG ON GOING PROBLEM WITH THE ELECTRICAL PROBLEM THAT HAS BEEN GOING ON NOW FOR FIVE MONTHS. STARTED OUT HAVING THE BATTERY CLUSTER LIGHT ON & CHECK CHARGING SYSTEM. FOUND CHARGING A LITTLE LOW, HAD NEW ALTERNATOR INSTALLED. THEN WITH A WEEK, BATTERY, ENGINE LIGHT & AIRBAG LIGHT CLUSTER ARE ON, THEN THE FUN BEGAN, THEN ALL THE INSTRUMENT CLUSTER GOES OFF AND YOU HAVE NO TURN SIGNALS, NO FANS, NO RADIO, NO ELECTRIC WINDOWS, NO DOOR LOCKS AND NO BREAK LIGHTS, (BUT BREAK LIGHTS DO COME ON WHEN YOU APPLY BREAKS AND THE BACK-UP LIGHTS COME ON. THE SYSTEM CAN COME AND GO ON AND OFF WHILE MOVING AND SETTING STILL. HAVE HAD SYSTEM CHECKED AND CODED, THEY CAN NOT FIND A PROBLEM EXCEPT THAT IT IS A ELECTRIC PROBLEM, HAD ALL WIRING CHECKED, CLEANED. NO,FRAYED WIRE FOUNF AND NO DEFECTIVE COUPLING. AGAIN I GET IT A WIRE THAT IS GROUNDING AND CAUSING PROBLEM. ALL THE FUSES ARE OK AND KNOW HAVE BLOWN. THE ONLY THING I KNOW IS THIS PROBLEM WAS REPORTED TO FORD BACK IN 2006 OR 2007 AND THEY HAVE NOT PUT OUT ANY RECALL ON IT AND THERE DEALERS KNOW NOTHING ABOUT WHAT TO DO BUT THEY WILL TRY AND FIND IT AT WHERE HOURLY RATE AND IT COULD BE A HOUR OR SEVERAL HOURS TO FIND PROBLEM. AS I'VE SAID THIS IS ON GOING IT CLEAR UP AND LAST FOR A WEEK UP TO SIX WEEKS AT A TIME.

CAR WILL BE DRIVEING 55 AND COMPLETELY SHUT OFF. LOSSING EVERYTHING INCLUDING POWERSTEARING. HAVE TO PUT IN NEUTRAL N COAST TO SIDE OF THE ROAD, SOMETIMES WILL RESTART, OTHERS IT WONT. ALSO WILL START BUCKING AND SHUT OFF. I CAN BE DOING 10MPH N GO TO TURN A CORNER N IT SHUTS OFF. CAN SEEM TO RUN FINE, BE IN THE MIDDLE OF AN INTERSECTION AND THE CAR SHUT OFF AND WOULDNT RESTAR GOOD THING I CAN DRIVE AND KNEW WHAT TO DO OR I WOULD HAVE CRASHED NUMEROUS TIMES. HAVE CHANGED THE THROTTLE BODY AND ACCELERATOR, N BOTH SENSORS. DID NOT FIX PROBLEM. NOW SAYING IT'S THE PCM SHUTTING THE CAR OFF.

PULLED IN DROP OFF A DONATION AT A SECOND HAND STORE. I PUT IT IN PARK AND TURNED OFF THE VEHICLE; OPENED THE TRUNK; AND LOOKED UP STARTLED WHEN A GUY SITTING NEARBY SAID THAT MY CAR WAS SMOKING AND ON FIRE (ABOUT 10 SECONDS SINCE I SWITCHED THE CAR OFF AND GOT OUT). HE WAS ON THE RIGHT, SO I MOVED AROUND THE CAR TO THE RIGHT LOOKING TOWARDS THE ENGINE. AN EMPLOYEE OF THE STORE THAT WAS ON THE BACK, LEFT SIDE OF THE CAR POINTED TOWARDS AND SAID, 'LOOK! YOUR SIDE MIRROR IS ON FIRE!' I THEN SAW THE SMOKE BILLOWING TO THE LEFT (A STRONG AFTERNOON BREEZE WAS BLOWING NORTH). I CAME AROUND AND PEERED IN BEHIND THE ACTUAL 'MIRROR' PART; THE FIRE HAD JUST GONE OUT. LOOKING AT IT, I COULD SEE IT WAS THE SECURITY LIGHT ON THE BOTTOM SIDE OF THE MIRROR; IT WAS COMPLETELY MELTED AND FUSED TO THE MIRROR HOUSING- A BUBBLY MESS OF PLASTIC. IT SMELLED OF ACRID, MELTED PLASTIC AND BURNED ELECTRONICS. THE UNDERSIDE OF THE MIRROR HAD CAUGHT FIRE AND STARTED BURNING FOR A BIT BEFORE THE FUSE FINALLY BLEW. I AM SO GLAD MY BABY AND KINDERGARTENER WEREN'T IN THE CAR AT THIS TIME! THEY USUALLY ARE. THE LENGTH OF TIME OF TIME IT TOOK FOR THE FUSE TO FINALLY BLOW IS QUITE ALARMING! IT COULD HAVE RESULTED IN THE RAPID SPREAD OF A FIRE THAT WOULD QUICKLY OVERTAKE THE VEHICLE. WHAT IF I WAS AT A GAS STATION WHEN THIS HAPPENED WHEN THEIR HAPPENED TO BE SOME PETROL-VAPOR PRESENT. MY NEXT STOP WAS TO GET TWO PROPANE TANKS FILLED. THEY HAVE TO BLEED OFF A CERTAIN AMOUNT OF PROPANE EACH TIME WHEN FINISHED FILLING A TANK. IT ISN'T FAR FETCHED THAT THIS ELECTRICAL ISSUE WITH FAILED SAFEGUARDS COULD HAVE RESULTED IN FAR MORE INJURY THAN MY SLIGHTLY BURNED FINGERS. THIS NEEDS TO BE INVESTIGATED IMMEDIATELY BEFORE SOMETHING TERRIBLE HAPPENS TO SOMEONE. THIS IS A FANTASTIC CAR! WE LOVE IT. THIS IS PROBABLY AN EASY FIX, BUT IF IT ISN'T FIXED, MUCH WORSE COULD HAPPEN!

DOOR FROZE SHUT AND EVER SINCE MANUALLY OPENING THE MESSAGE CENTER STATES DRIVER DOOR AJAR AND PASSENGER DOOR AJAR AND THEY ARE NOT. BUT I CAN'T RESET DRIVER CONTROLS UNTIL DOORS SHOW CLOSED. HAVE RUN CODE IN MY CAR AND ONLY CODE IS P0193 FUEL RAIL PRESSURE SENSOR. NO CODES FOR DOORS.

TL* THE CONTACT OWNS A 2006 FORD FIVE HUNDRED. THE CONTACT STATED THAT THE REAR DRIVER SIDE TAIL LIGHT FAILED TO ILLUMINATE. WHEN THE VEHICLE WAS PLACED IN REVERSE, THE REVERSE LIGHTS FAILED TO ILLUMINATE. IN ADDITION, THE CONTROL PANEL AND DRIVER SIDE BLINKERS FAILED TO ILLUMINATE. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC WHERE IT WAS DIAGNOSED THAT THE ALTERNATOR FAILED AND NEEDED TO BE REPLACED. THE VEHICLE WAS REPAIRED; HOWEVER, THE FAILURES RECURRED. THE MANUFACTURER WAS NOT MADE AWARE OF THE FAILURES. THE APPROXIMATE FAILURE MILEAGE WAS 150,000.

I WASING A WERE THERE WAS A RECALL ON MY CARE UNTELL SOMEONE TOLD ME. *TR

CLUSTER CONSTANTLY GIVES OUT, THERE IS A RECALL IN PLACE FOR THE 2005 VERSION WHICH HAS THE SAME ISSUE BUT NOT THE 2006. THE CLUSTER HAS BEEN REPLACED TWICE ALREADY, EVERYTHING SUDDENLY STOPS WORKING HAVE RECEIVED NUMEROUS TICKETS AT THIS POINT FOR GOING OVER THE SPEED LIMIT BECAUSE OF THIS ISSUE ALL CLUSTER GAUGES STOP WORKING THERE IS NO WAY TO NO HOW FAST YOU ARE GOING. *TR

WHEN I FIRST START MY CAR ITS SLOW TO GIVE POWER, OFTEN WHEN I DRIVE IT ON THE STREET IT'LL JUST LOSE COMPLETE POWER AND DIE DOWN. THEN I HAVE TO RESTART ITFOR IT TO TEMPORARILY GO AWAY THEN IT HAPPENS AGAIN. *TR

DURING NORMAL DRIVING VEHICLE DASH LIGHTS WENT COMPLETELY OUT AND THEN BEGAN TO FLICKER WHILE BOTH GAUGES SPEEDO AND TACH WENT LEFT TO RIGHT ON AND OFF REPEATEDLY CAUSING A LOSS OF POWER ON VEHICLE RENDERING VEHICLE UNSAFE TO DRIVE AND ALMOST CAUSING COLLISION.. BROUGHT TO FORD DEALER REPLACED ALTERNATOR AND PROBLEM STILL EXISTS AFTER 500 DOLLAR EXPENSE. *TR

CPSC: I1390188A. 2006 FORD FIVE HUNDRED. CONSUMER STATED THE LEFT FRONT HEAD LIGHT CAUGHT ON FIRE SPONTANEOUSLY WHILE HAVING BEEN PARKED FOR 30 MINUTES IN THE GARAGE AND ENGINE WAS OFF. *LN THE FIRE DESTROYED THE LEFT FRONT ENGINE AREA. THE VEHICLE WAS TOTALED BY THE INSURANCE COMPANY.

TL* THE CONTACT OWNS A 2006 FORD FIVE HUNDRED. THE CONTACT STATED THAT THE AIR CONDITIONING UNIT FAILED AND WAS BLOWING HOT AIR. THE VEHICLE WAS TAKEN TO A LOCAL MECHANIC FOR INSPECTION. THE MECHANIC DRAINED THE AIR CONDITIONING SYSTEM HOWEVER, THE FAILURE WAS NOT CORRECTED. THE MECHANIC ADVISED THE CONTACT THAT THE AIR CONDITIONING SYSTEM NEEDED TO BE REPLACED. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE. THE FAILURE AND CURRENT MILEAGE WAS 94,000. THE VIN WAS NOT AVAILABLE.

I HAD BEEN HAVING TROUBLE WITH MY VEHICLE REVVING WHEN DRIVING ON THE HIGH WAY. I RECEIVED A NOTICE FROM FORD THAT AS A PART OF A CUSTOMER PROGRAM IF MY CAR WAS HAVING TROUBLE THEY WOULD CLEAN AND REPROGRAM. IN JANUARY OF 2013, MY LOCAL FORD DEALERSHIP CLEANED AND REPROGRAMMED THE THROTTLE BODY. OCTOBER OF 2014 I WAS DRIVING DOWN THE INTERSTATE AND MY CAR DIED. I WAS ABLE TO SAFELY GET THE CAR TO THE SIDE OF THE ROAD. LET IT SIT, IT STARTED AND I WAS ABLE TO DRIVE HOME APPROXIMATELY 25 MILES WITH THE CAR DYING A COUPLE MORE TIMES ALONG THE WAY. I TOOK THE CAR TO GET LOOKED AT AND WAS ADVISED THAT MY ELECTRONIC THROTTLE BODY WAS BAD AND NEEDED TO BE REPLACED. I CONTACTED FORD WHO WAS OF NO ASSISTANCE. I CONTACTED MY LOCAL FORD DEALERSHIP WHO SAID SORRY, WE CAN FIX IT BUT IT WILL BE AT MY COST. I CHOSE TO TAKE MY CAR TO AN INDEPENDENT MECHANIC WHO REPLACED THE ELECTRONIC THROTTLE BODY. I HAVE MADE MORE THAN ONE ATTEMPT FOR FORD TO ACKNOWLEDGE THAT THE CLEANING DIDN'T REPAIR THE PROBLEM WITH NO SUCCESS. *TR

TL* THE CONTACT OWNS A 2006 FORD FIVE HUNDRED. THE CONTACT STATED THAT THE GAUGES FAILED TO FUNCTION AND OFTEN FLUCTUATED. THE VEHICLE WAS TAKEN TO THE DEALER WHERE IT WAS FOUND THAT THE INSTRUMENT CLUSTER NEEDED TO BE REPLACED. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS CONTACTED ABOUT THE FAILURE. THE FAILURE MILEAGE WAS APPROXIMATELY 90,000. ...UPDATED 11-18-13 *BF

THE AIRBAG WARNING LIGHT COMES ON AND THEN THE ENTIRE GAUGE CLUSTER (I AM TALKING ABOUT THE SPEEDOMETER, THE TEMPERATURE GAUGE, THE GAS GAUGE, AND THE TACHOMETER) SHUTS OFF COMPLETELY AND COMES BACK ON RANDOMLY. TEN DAYS AFTER INITIAL INCIDENT THE AIRBAG WARNING LIGHT CAME ON AND THEN THE GAUGE CLUSTER SHUT OFF COMPLETELY AND STAYED OFF. THE SPEEDOMETER IS THE MOST IMPORTANT PART. I HAVE SEEN SEVERAL ARTICLES ONLINE ABOUT THE SAME TOPIC, AND THE BELIEF IS THAT IT IS DUE TO FAULTY SOLDERING ON THE BACK OF THE UNIT. *TR

THE CAR LUNGES FORWARD OR BACKWARDS WHEN SHIFTING GEARS ALSO LUNGES WHEN COMING TO A STOP VERY VIOLENTLY. I DRIVE WITH PLENTY OF SPACE IN FONT OF ME SO I HAVEN'T HIT ANYTHING I'M SURPRISED NO ONE ELSE HAS EITHER. *TR