2017 Ford Focus Fuel System Problems

Received recall notice 24N07 from Ford in December 2024, stating that we should get the canister purge valve replaced if the vehicle ever displayed any of the listed symptoms. The vehicle started displaying symptoms in April 2025. Brought the vehicle to Kruse Motors, Ford Service dealership in Marshall, MN. They replaced the canister purge valve. Shortly after this, the vehicle was still displaying symptoms of running out of gas, even though the gauge said it had 3/4 tank still. Continued to drive it for a few months, but continued to get worse and the car almost died a couple of times while driving at highway speeds. This could have caused an accident because the engine was stalling while still in gear, causing the vehicle to suddenly jerk and decrease speed rapidly. Brought the vehicle back to Kruse Motors, Ford Service dealership and they found that the fuel tank was collapsing. The technician stated that this was most likely caused by the canister purge valve malfunction that was part of the recall. Because of this, they submitted a request to Ford to replace the tank and any necessary parts and labor as a result of this damage. Ford responded saying that they will not cover this as it is not part of the recall. I appealed to Ford customer service explaining that the damage was caused by the recall but they still refused to do anything about it. The dealership gave me a quote for $2600 to repair the issue. Ford has created an unsafe situation by not replacing the necessary parts caused by the malfunctioning canister purge system.

The contact owns a 2017 Ford Focus. The contact stated while driving approximately 20 MPH, while the accelerator pedal was depressed, the vehicle lost automotive power and shuddered abnormally. There was no warning light illuminated. The contact stated that the failure had occurred on several occasions. The vehicle was taken to a dealer where it was diagnosed that the there was an unknown part in the fuel tank that needed to be replaced. The vehicle was not repaired; however, the failure persisted. The manufacturer was notified of the failure. The failure mileage was approximately 90,000.

The contact owns a 2017 Ford Focus. The contact stated while driving approximately 25 MPH, the vehicle made an abnormally loud sound and lost motive power. The contact was able to pull to the side of the roadway. The contact stated that upon depressing the accelerator pedal to resume driving, the vehicle failed to exceed 10 MPH. The check engine warning light and an unknown warning light were illuminated. The contact was able to drive to the residence. An independent mechanic diagnosed the vehicle and determined that the fuel tank had failed and needed to be replaced. The contact was referred to the dealer for further diagnostic testing. The dealer was contacted for the recall repair of NHTSA Campaign Number: 18V735000 (Fuel System, Gasoline); however, no assistance was provided. The vehicle was not repaired. The manufacturer was notified of the failure. The failure mileage was approximately 55,000.

After filling up the car with gasoline, the car would not start. Once the car started, after several tries, it was shifted into drive. The car would not move, the pedals were all locked up. You could not push on the brake, gas, none of the pedals would work. The car is available to be looked at. It has been looked at by an independent mechanic who determined there was excessive vacuum in the fuel vapor management system. The check engine light is on, returning the EVAP code. My [XXX] daughter was stranded at night alone with a car that wouldn't start. This issue has happened multiple times. There is a recall in place for the 2017 ford focus that covers this exact issue, but excludes my car. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

I am the owner of a 2017 Ford Focus vehicle. Recently, I have encountered multiple occurrences of stalling while driving on the highway. In two of these instances, I was in the process of passing a semi-truck and fortunately had no other vehicle behind me, or my safety and that of others may have been put at great risk. After the first incident, the check engine light appeared and was addressed by a mechanic who believed it was likely the result of a vapor lock. The issue later reoccurred and left me stranded on the interstate in a rural location where I had to wait for several hours before being transported to a nearby hotel. The vehicle started again the following morning, and I was able to finish the trip. After conducting some research, I discovered two separate recalls (identified by the NHTSA Campaign IDs 18V735000 and 19V515000) that had been issued for cars of this model and encompassing the year of my vehicle’s construction. The malfunction, as issued by a mechanic, fit the exact specifications of the recall; that is, malfunction of the canister purge valve, causing excessive vacuum in fuel vapor management systems, that can result in an engine stall while driving and without warning. I was surprised to learn that my vehicle’s VIN was not associated with any such recall; however, I was informed by my mechanic that a software update (18s32) had occurred on June 6, 2019, possibly removing association of the recall statement with my vehicle’s VIN. I am unsure at this time of the extent of damage to the carbon canister, fuel tank, and fuel delivery module. The only issue visible from the exterior is a slight depression of the fuel tank caused by excessive vacuum. The canister purge valve was replaced on September 10, at a cost of $270.03. Due to the nature of the incident and its exact resemblance of the recall issued, I would like to seek compensation for the replacement of the defective purge valve and further inspection of the carbon canister, fuel tank, a

My engine light came on. I went and had it scanned and it said it was the Canister purge valve. I see that 2017 ford focus has a recall on it and was wondering if this is connected to it.

The contact owns a 2017 Ford Focus. The contact stated that while at a complete stop, the vehicle shut off without warning. The contact replaced the canister purge valve; however, the failure persisted. Upon investigation, the contact linked the failure to NHTSA Campaign Number: 18V735000 (Fuel System. Gasoline). The vehicle was then taken to an independent mechanic and the failure was linked to the recall. The contact was informed that the fuel tank needed to be replaced and was given an estimate for the repair. The dealer and the manufacturer were notified of the failure but offered no assistance. The vehicle was not repaired. The failure mileage was approximately 98,000.

The contact owns a 2017 Ford Focus. The contact stated that while his daughter was driving at an undisclosed speed and attempting to accelerate, the vehicle lost motive power and significantly decelerated. The check engine warning light was illuminated. The vehicle was taken to an independent mechanic, who diagnosed a failure with the canister purge valve. The vehicle was not repaired. After investigating the failure, the contact related the failure to NHTSA Campaign Number: 18V735000 (Fuel System, Gasoline), but the VIN was not included. The manufacturer was notified of the failure, a case was opened, and the contact was referred to the NHTSA Hotline for assistance. The failure mileage was 58,000.

The contact owns a 2017 Ford Focus. The contact stated while operating the vehicle, the check engine warning light remained illuminated. The vehicle was taken to the local mechanic who diagnosed that the fuel system was faulty and referred the contact to the local dealer regarding a recall for the failure. The vehicle was not repaired. The local dealer and manufacturer were notified of the failure and informed the contact that the VIN was not included in NHTSA Campaign Number: 19V515000 (Fuel System, Gasoline). The contact stated that the vehicle had experienced the failure listed in the recall. The failure mileage was 58,000.

The contact owns a 2017 Ford Focus. The contact stated while driving approximately 45 MPH, the vehicle stalled and the contacted coasted the vehicle to a stop light. No warning light was illuminated. After several attempts, the contact was able to restart the vehicle, and continued driving to the destination. The contact refueled the vehicle and attempted several times to restart the vehicle. The vehicle was taken to the dealer after the check engine warning light illuminated and the contact retrieved DTC code: P1450. The dealer stated that the vehicle was inspected in 2018 under NHTSA Campaign Number: 18V735000 (Fuel System, Gasoline) without any part being replaced. The VIN was not included in the recall. The vehicle was not repaired due to the cost. The manufacturer was notified of the failure and referred the contact to the NHTSA Hotline for assistance. The failure mileage was approximately 75,000.

The contact owns a 2017 Ford Focus. The contact stated that when the vehicle was started, the check engine warning light illuminated. The vehicle was taken to an Auto Zone where a handheld diagnostic tool confirmed that the Evap canister control purge valve needed to be replaced. The vehicle was not repaired. The manufacturer was notified of the failure. The failure mileage was approximately 58,000.

The contact owns a 2017 Ford Focus. The contact stated on several occasions while the vehicle was in park(P) and being refueled, the vehicle shutoff unintendedly. Additionally, on other occasions, the vehicle failed to start. The check engine warning light was illuminated. The vehicle was taken to a dealer where the failure was not able to be diagnosed, but the contact signed an unknown document. The vehicle was taken to Jiffy Lube where it was determined that the fuel pump needed to be replaced. The vehicle was not repaired. The manufacturer was not notified of the failure. The failure mileage was approximately 62,000.

The contact owns a 2017 Ford Focus. The contact stated that while taking the vehicle to an independent mechanic for an oil change, the mechanic discovered fuel in the oil. The dealer was alerted of the failure and the vehicle was towed to the dealer. A test was performed on the vehicle and the contact was instructed to drive the vehicle for 700 miles to test the fuel system. The contact's father then tested the vehicle after 700 miles and confirmed that a fuel odor was coming from the vehicle. The manufacturer was notified of the failure. The vehicle was taken back to the dealer and remained in the dealer's possession. The approximate failure mileage was 85,000.

The contact owns a 2017 Ford Focus. The contact stated while driving at approximately 50 MPH, the vehicle was sputtering and almost stalled. The contact stated that the check engine warning light was illuminated. The contact stated that the failure was intermittent but had become a recurring failure. The contact had taken the vehicle to an independent mechanic who diagnosed the vehicle and determined that the canister purge valve needed to be replaced. The vehicle was not repaired. The manufacturer was informed of the failure. The contact had researched online and related the failure to NHTSA Campaign Number: 19V515000 (Fuel System, Gasoline). The failure mileage was approximately 50,000.

The contact owns a 2017 Ford Focus. The contact stated that after her daughter refueled the vehicle at the gas station, the vehicle failed to start. The contact stated that the vehicle started after several attempts. The contact stated that the vehicle was experiencing rough idling. Additionally, the contact stated that while her daughter was making a right turn and merging onto a ramp, the vehicle stalled inadvertently in the middle of the road. The contact's daughter was unable to pull to the side of the roadway. The contact stated that her daughter was able to restart the vehicle after several attempts. The contact's daughter then pulled to the side of the road. The contact stated that her daughter was able to drive to the residence. The vehicle was taken to the dealer, where it was diagnosed that the purge valve had failed and needed to be replaced. The vehicle was not repaired. The contact related the failure to NHTSA Campaign Number: 19V515000 (Fuel System, Gasoline). The manufacturer was notified of the failure and informed the contact that the VIN was not included. The manufacturer referred the contact to the NHTSA Hotline for assistance. The failure mileage was unknown.

This year make and models have an recall #19v51500 due to this recall their is a canister purge valve need to be replace. so i buy a vehicle and its has a problem with purge valve and the Ford company refuse it to fix this issue under the recall.

The contact owns a 2017 Ford Focus. The contact stated when the vehicle was started, the check engine warning light illuminated. The vehicle was taken to a dealer where it was diagnosed that the purge valve needed to be replaced. The vehicle was not repaired. The manufacturer was not made aware of the failure. The failure mileage was 44,500.

The contact owns a 2019 Ford Focus. The contact stated that while starting the vehicle, the RPMS were significantly high. The check engine warning light was illuminated. The vehicle was taken to the dealer, who informed the contact that the vehicle was operating as designed. The contact stated that the failure recurred while driving, and while at a complete stop, the check engine warning light illuminated. The contact stated that the RPMs would exceed 1,500 and would then drop to 600-700. The contact stated that the vehicle lost motive power temporarily while driving on one occasion. The vehicle was not diagnosed nor repaired. The contact related the failure to NHTSA Campaign Number: 19V515000 (Fuel System, Gasoline) however, the VIN was not included. The manufacturer was not notified of the failure. The failure mileage was approximately 17,000.

The contact owns a 2017 Ford Focus. The contact stated that the check engine warning light was intermittently illuminated. The contact stated that while driving at an undisclosed speed, the vehicle hesitated and started to shake with the RPM increasing. The vehicle was taken to an AutoZone to be diagnosed. The mechanic retrieved DTC: P0456 (EVAP leak). Additionally, the contact stated that the 02 sensor was replaced; however, the failure recurred. The vehicle was not repaired. Neither the dealer nor the manufacturer was notified of the failure. The failure mileage was approximately 91,000.

I took my vehicle to have the recall repaired they did not fix all the issues with the recall as soon as I picked it up it broke down again. They are now charging me for a diagnostic test that I did not ask for they told me the problem they think it is which is covered by the recall but now they refuse to work on my car. The service manager is rude and unprofessional cussing at me and my husband on the phone. Now I'm stuck with a car that doesn't work and they are refusing to replace parts that are covered under the recall.