There are 9 owner-reported electrical system complaints for the 2021 Hyundai Konain NHTSA's database. These are unverified consumer reports and may not reflect confirmed defects.
About 2 weeks ago I tried to start my car and the dash board starting flickering and glitch. Roadside assistance said all I needed was a battery. I got a battery and everything seemed fine until today. My car is starting to do the same thing. When I looked up recalls my VIN doesnt match for a recall I think my car should be under. The Battery Charge Sysytem is failing I believe. I have videos.
Over the last 2 1/2 months the car has shut off approximately 5 times while driving, without warning. Most instances have been while pulling into a parking lot, but one time (so far) it shut off while trying to back into my driveway. I'm fearful it will happen while on the freeway. I took it to the dealer, but there wasn't a fault code so they refused to look at it unless I left the car with them to drive, and wanted to charge me $45/day for a rental so I could get back & forth to work until it happened again while they were driving it.
The HVAC drainage system in my 2021 Hyundai Kona failed due to a clogged AC drain line, which led to water leaking into the cabin and mold growth. The dealer reported the drain was blocked by a spiderweb and that moisture had collected under the driver and passenger carpets. They unclogged the line, but did not inspect beneath the carpet or inside the HVAC system. Soon after, I experienced musty odors, asthma flare-ups, and headaches while driving. At-home mold tests under the passenger seat and footwell came back positive. White mold was also visibly growing under the carpet. A similar issue occurred in my fiancé’s Hyundai Elantra, also purchased from the same dealer. His AC drain was clogged and mold tested positive in the cabin, though his car had no smell. Our vehicles are stored in different environments, which rules out external environmental causes and points to a broader design flaw. There are Hyundai forums online confirming this same issue is not isolated to us. Even if spiderwebs were involved, a single web should not disable a critical drainage function and cause health risks. HVAC systems should be designed to resist common environmental factors like debris or insects. I am a cancer survivor (diagnosed in 2024) and must avoid environmental toxins like mold. Despite repeated outreach to Hyundai and the dealer, I was told no inspection or remediation would be provided beyond detailing, which is not sufficient for mold. Component that failed: AC evaporator drain tube Confirmed by dealer: Yes Manufacturer inspection: No – Hyundai declined to investigate Safety concern: Yes – mold has triggered respiratory symptoms and makes the vehicle unsafe for passengers
The contact stated that she was an insurance company claim adjuster who was calling on behalf of an insured consumer, who owned a 2021 Hyundai Kona. The contact stated that while the vehicle was parked and unoccupied, the vehicle caught on fire. The contact stated that there was no warning light illuminated before the incident. The fire department extinguished the fire and filed a report. The contact stated that the insurance company sent an inspector, who determined that the fire originated in the engine compartment. The contact stated that the entire vehicle burned and only the frame remained. There was no injury sustained. There was no police report filed. The vehicle was towed to a salvage yard, where it was totaled. The contact related the failure to NHTSA Campaign Number: 21V301000 (Engine); however, the VIN was not included. The contact did not know whether the dealer and the manufacturer were contacted. The failure mileage was approximately 23,000.
My car has approximately 14,000 miles on it and was purchased brand new. It still has 1,000 miles to go before the next servicing. Saturday I when driving approximately 40 miles an hour, the engine suddenly cut off and the car stopped in the middle of the road. I was able to start the car and drive for approximately 15 minutes before it slowed to 3mph and shut off again. I called the dealership where I purchased it and explained what happened. Initially they said they had not serviced the car in a year. I let the car sit for a day then checked all the fluids. The coolant level was fine and so was the oil. Monday, it cut off twice on my way to work. I drove to the nearest dealership and left it there. I had to rent a car as no loaners are available. It has been at the dealership for 5 days. They thought they fixed but when they test drove it, the car cut out again. Later that day, I received an email from Hyundai Blue link with an Automatic DTC Notification that a possible condition has been detected with my Engine Control System.
The contact owns a 2021 Hyundai Kona. The contact stated that while driving at various speeds, the vehicle would suddenly lost motive power and stalled. After restarting the vehicle, the vehicle operated as designed. The contact indicated that the failure had occurred on four occasions while driving. The vehicle was serviced at the local dealer, but the failure was not corrected. The manufacturer was not yet notified of the failure. The failure mileage was 21,400.
the bcw tends to go on every time the vehicle is driven on a rural two way road to town, approx. less than 20 miles. been to dealership for the problem with the bcw ,paid for diagnostic and scanned for codes ,none apparent.the dealership did minimal calibration without realalinig the sensor. the vehicle will automatically downshift causing the vehicle lurch which is totally unsafe.this began at 6000 miles.no obstructions to sensors as per dealer inspection.a brand new suv awd never been offroad ,or any collision whatsoever.reading forums leads me to believe it occures quite often to this particular vehicle.i called the local global representative and have a case number of 21601680, i thank you for your prompt response to this issue.
Driving 60mph on I-5 in May 2021. Dry roads, no wind. Vehicle suddenly surged (as if we ran over a speed bump at 60mph) despite there being no debris nor damage on the road surface. The surge felt like the ABS system triggered a single pulse, and then car completely turned off: no engine power, no radio power, no cabin lightning power, no dash lighting nor warning lights. Toggling the ignition to accessory didn't help. I had steering authority and brake authority. With no engine power, I pulled over to the side of the road. I inspected the exterior of the vehicle and there was no damage. I entered the vehicle and I was able to restart the vehicle normally. I drove it to a dealership and described the problem, they didn't know what it could be and were 30 days out on booking appointments, so I gave up.
I’ve had this car since end of September 2021. The blind spot monitor on the right side of the vehicle lights up and beeps at random times, even when there is nothing in the blind spot itself. Happens mostly while driving on the highway.
Complaints are unverified consumer reports submitted to NHTSA. A high complaint count may reflect vehicle popularity, not defect severity. Data sourced from NHTSA public records.
Data synced from NHTSA on May 4, 2026