There are 3 owner-reported engine complaints for the 2025 Hyundai Santa Fein NHTSA's database. These are unverified consumer reports and may not reflect confirmed defects.
Traveling in a 55 zone on Rt 27 and my vehicle lost power and said pull over and charge vehicle with engine on. I did this once and the battery went up to half way charge then I could start to drive again. Less than a half a mile up the road climbing a good size hill by the town’s salt shed—the same issue occurred. I had to pull over again and allow battery to recharge. This is not a complete hybrid, it has a gas engine not sure why the hybrid and gas are not syncing up. Many users on the internet have reported the same issue that I have experienced. Someone needs to investigate this before major injury occurs.
Immediately following routine maintenance performed at an authorized Hyundai dealership, my 2025 Hyundai Hybrid Santa Fe Calligraphy experienced a complete loss of engine oil, which resulted in the engine shutting down while driving on a highway. While traveling at highway speed with my minor daughter, the oil pressure and engine warning lights illuminated, followed by multiple error messages. The vehicle rapidly lost power, and I struggled to safely maneuver it onto the shoulder while high-speed traffic was passing. This created an immediate and life-threatening safety situation, with a real risk of being struck by other vehicles. We were stranded on the roadside for over three hours awaiting a tow, exposed to ongoing traffic danger. The dealership later advised that the incident was caused by a faulty Hyundai-supplied part, not driver error, misuse, or lack of maintenance. The vehicle had only approximately 4,000 miles at the time of failure. A sudden engine shutdown due to oil loss at highway speeds presents a severe risk of collision, injury, or death, especially when it occurs without warning. Given that a Hyundai component is implicated, I am concerned this may represent a broader safety defect affecting other vehicles. This incident caused extreme distress and endangered both myself and my child. I am submitting this complaint so that NHTSA may evaluate whether this issue warrants regulatory review or further investigation.
Yesterday while I was driving I almost was hit by another car in an intersection. My car did not respond fast enough, the engine did not have any stregth. I found today after I took it for service that it needs a replacement of the oil pump. My car is new it only has 4 months of usage and this type of repairs is done in vehicles with a high mileage. This is very uncommon.
Complaints are unverified consumer reports submitted to NHTSA. A high complaint count may reflect vehicle popularity, not defect severity. Data sourced from NHTSA public records.
Data synced from NHTSA on Apr 25, 2026