2013 Hyundai Tucson Engine Problems

FIRSTOF ALL I WAS NEVER NOTIFIED ABOUT THE RECALLS WHICH NEED TO BE COMPLETED. WHILE I WAS DRIVING ON A HIGHWAY THE ENGINE BLEW UP AND CAR BROKE DOWN. THERE IS A HOLE IN THE ENGINE, I TOWED THE CAR TO A MECHANIC WHO TOLD ME THAT THE ISSUE WITH THE ENGINE OCCURED BECAUSE THE RECALL WAS NOT COMPLETED. I TOWED THE CAR TO HYUNDAI IN PARAMUS WHERE I BOUGHT THE CAR. THIS DEALER DOES NOT WANT TO FIX MY CAR CLAIMING I NEED TO PAY A DIAGNOSTIC FEE OF $800. I ADVISED THEM THAT I SHOULD NOT BE RESPONSIBE FOR THIS FEE AS THE ENGINE FAILED DUE TO MANUFACURER ISSUE. THEY HAVE MY CAR FOR 2 WEEKS NOW AND EVERYTIME I CALL THEY ASK FOR MONEY AND HANG UP THE PHONE. RECALLS SHOULD BE FOR FREE, ITS THE LAW.

The contact owns a 2013 Hyundai Tucson. The contact stated that while driving at an undisclosed speed, the check engine warning light illuminated, and the vehicle stalled. The vehicle was towed to an independent mechanic, who determined that the engine needed to be replaced. The vehicle was not repaired. The manufacturer was made aware of the failure and referred the contact to the NHTSA Hotline for assistance. The failure mileage was approximately 156,000.

The contact owns a 2013 Hyundai Tucson. The contact stated that the vehicle was taken to the dealer, where it was serviced under Technical Service Bulletin: 22-01-028H-1. The contact stated while driving 50 MPH the following day, the vehicle stalled. The check engine warning light was illuminated. The contact stated that the failure was scary for the contact and her minor child who was a passenger in the vehicle. The vehicle was towed to the dealer, where it was diagnosed with the knock sensor failure. The contact was informed that the knock sensor needed to be replaced. The vehicle was repaired under approval from the Manufacturer. The contact stated while driving at an undisclosed speed four days later, the failure recurred. The vehicle was towed to the dealer where it was diagnosed with engine failure. The contact was informed that the engine needed to be replaced. The contact was informed that the software update on older Hyundai vehicles was causing the engine failure. The vehicle was not repaired. The manufacturer was made aware of the failure, but no assistance was provided. The manufacturer informed the contact that the repair was not eligible for coverage under Warranty. The failure mileage was approximately 213,000.

350 miles from home the car started a knocking noise and that the engine failed. My family was in risk , i had my 2 year old son in the car and it was behind shock. No lamp no nothing. On my expenses took the car with a tow company and send it to a mechanic, he told me this cars are recalled. I got shocked again because Hyundai never send me mail or something for the KSDS update recall

With the recall in February 2023 my vehicle has a burning smell when I'm driving it which I don't feel safe in however, I have to work. Also, my vehicle will cut for now reason while driving which is so not safe as it has happened several times while on the highway. Something needs to be done or Hyundai needs to buy back my car. There have been several recalls

The automobile has 99,800 miles driven on it. While I was driving on the interstate, the engine seized up and shut off almost causing an accident and left me stranded 193 miles from home. The vehicle was inspected and there were metal shavings in the oil pan. A new engine is needed to repair this vehicle.

I was driving on the freeway and my engine started making a knowing sound. Then my car died. I pulled over to the side and couldn't even brake and I had to put the emergency brake on. Then when I tried to start my car it made a loud screeching noise from the engine so I turned it back off. I have had it checked out by a mechanic who says it's a rod bearing went out. It is common with my vehicle but my specific year hasn't been recalled but other years have been recalled for the same problem.

The contact owns a 2013 Hyundai Tucson. The contact received notification of NHTSA Campaign Number: 19V063000 (Engine and Engine Cooling). The vehicle was taken to the local dealer for a software update. The vehicle was repaired. The contact stated that while driving at an undisclosed speed, the check engine warning light illuminated. The vehicle was taken back to the same local dealer where it was diagnosed that the oil pressure sensor switch, PCM module, and electrical fan needed to be replaced. The vehicle was not repaired. The manufacturer was notified but no additional assistance was provided. The failure mileage was approximately 79,000.

Engine made some rattling noise, then smoke came from muffler while driving on a highway. The vehicle stalled and the vehicle needed to be towed. The vehicle was inoperable (unable to start the engine)..

The vehicle has an engine oil leak at the oil pan gasket. This was previously recalled by Hyundai (19V063000) as potentially causing a sudden loss of power or rapid slowing of the vehicle during operation. The Hyundai dealership addressed that recall by placing RTV on the gasket. It appeared to fix the issue for a few months to a year. Then I noticed the vehicle was dripping oil and that it appeared to be coming from the oil pan gasket. The "fix" that Hyundai previously performed has stopped working resulting in the same safety issue as identified in the prior recall. My wife took the vehicle to a Hyundai dealership today and where they confirmed that it was leaking from the oil pan and quoted $396 to fix it. My wife was told that they would not remediate the safety issue since they already performed work for that recall and it had been a year. I feel this is a serious issue - that the work they did to resolve a safety recall has failed and they are unwilling to fix it. I wonder if the work to my vehicle was done correctly compared to others (did the remediation call for RTV to be used?), or if Hyundai did not take the correct approach to remediate the issue (should it have been a new, thicker gasket instead of the RTV?). In either case, the fix has failed and resulted in the same deficient safety condition stated in the prior recall.

The contact owns a 2013 Hyundai Tucson. The contact stated that after her husband made a right turn at a low rate of speed, the engine ceased without warning. The vehicle failed to restart after multiple attempts. Due to the failure, her husband had the vehicle towed to an independent mechanic where it was diagnosed with engine failure. The manufacturer had been notified and informed her that there were no recalls on the vehicle; they offered no further assistance. The vehicle had yet to be repaired and remained in the possession of the mechanic. The failure mileage was 121,600.

My engine failed without any check engine lights prior. Started making a REALLY loud flapping noise when accelerating and would get worse the higher the RPM and the higher MPH. Even while coasting the noise was still prominent. It started around 12pm on 12/11/2021 and at 1:07pm (approximately 1 hour later) on the same day, it officially failed. The noise had started and gradually got worse while I was on the highway going approximately 65-70mph. I had stopped and pulled over shortly after it had started and made some calls to some certified Hyundai dealers to try and see what to do. I had made an appointment for first thing on Tuesday morning, 12/14/2021. I told them I would drop it off as soon as possible because I was sure it was going to blow. Tuesday appointment was the earliest appointment available at ANY Hyundai dealer within an acceptable/safe range. After I had made the calls, I proceeded to try and make it home. I was about 35-40 miles to home and my engine got EXTREMELY loud and not running properly. I was approximately 10 minutes from the dealership I bought my car from and I decided, if I made it there that I would leave the car there and not drive it home because I did not feel safe. About 45-60 seconds after the noise got so loud I couldn’t hear the radio. I was trying to find a safe spot to pull over but apparently didn’t make the decision in time because at 65-70mph (cruise control set at 67mph) my engine made a crash/boom sound then every light on my car’s dash lit up and car longer was functioning. I got pulled off to the curb immediately and shut the car off. Approx 5/2021, check engine came on, code read all cylinders were misfiring, spark pugs were changed because no engine failure was detected. My KDS recall serviced 11/27/2021, approximately 78,000-79,000 miles. Shop never mentioned and concerns with my car while it was there. Engine failed just over 80,000 miles.

The contact owns a 2013 Hyundai Tucson. The contact stated that the catalytic converter was stolen, and the vehicle was towed to an independent mechanic for repair. The vehicle remained in its possession for a month before being returned to the contact. While the contact was driving home from the mechanic shop at an unknown speed, the engine shut off without warning. The contact initially towed the vehicle back to the independent mechanic who then informed her of NHTSA Campaign Number: 19V063000 (Engine and Engine Cooling). The contact then had the vehicle towed to a dealer where a diagnostic test was performed, and it was determined that the vehicle experienced engine failure. The results were sent to the manufacturer who informed the dealer that the failure was not a result of the recall and that they would only cover half the cost of a new engine. The contact called the manufacturer directly and was given the same information. A case was filed. The vehicle had yet to be repaired and remained in the possession of the dealer. The failure mileage was approximately 150,000.

The whole engine shut down as I was going 70 mph on an interstate. At that time both the oil light and battery light came on. Once I pulled over, I could smell burning wires and a haze of smoke started coming in through the front air vents. The SUV was towed first to my mechanic then to the Hyundai service center who said this was a recall defect and they would look into it. At the time of the failure, I was out of cell tower range, but able to make a 911 call from the side of the 4 lane interstate. I was able to put on my hazard lights. I received a ride home from a state trooper. The car had regular oil changes, tire rotations, and normal inspections. Nothing out of the ordinary; no concerns about the engine. No warning lights came on prior to the shut down. It was 100% out of the blue. The Hyundai service center has now informed me the 2013 Hyundai Tucson has an “open campaign” recall on it (#966). They have extended coverage to repair/replace any engine under150,000 miles. My Tucson has 125,197 miles on it, but because I did not see their recall flyer in the mail, this service center is refusing to cover the expense of replacing the engine. Instead, they are asking me to foot the bill to the tune of $12,000.00. This is not an expired recall and a know issue by Hyundai.

I have Only 113186 miles on my Tucson.I started hearing a engine knock while driving the vehicle and then the vehicle started stalling out.The next day I took it to my mechanic.He tested everything then he drained my oil and found metal shavings from the rod bearing and told me the engine was no good.I changed the oil at regular intervals.I found out they have a recall on the 2017-2018 Tucson's with bad bearing issues.The engine is the same as mine the 2.0

Was driving on the highway at 74 mph when the engine started knocking and smelled of smoke, no other warning symptoms and all routine maintenance have been performed timely, in fact on-time pul change was performed the day before. I safely exited the highway and when I came to a complete stop at the end of the off ramp the oil, engine _ battery light came on and engine died. I checked the oil - it was clean and full. Had to get towed to a shop. They said the rod in the 4th cylinder is the culprit and requires a new engine ($7,500). I've called the Hyundai dealer and am waiting to hear back. Cars mileage is 139k and otherwise in excellent condition.

Was driving at 70mph on the highway when the failure occurred. The engine began making a very loud knocking noise and I was thankfully able to safely pull over before the car completely shut down. No check engine or oil lamps turned on and there were no signs that the engine was failing. It just all of a sudden started knocking while driving on the highway and I was lucky to get to the side of the road without causing an accident or being stuck in the middle of the highway with a broken engine. Checked the oil and found metal shavings on the dipstick so I called a tow truck to have the vehicle towed to the dealership that last serviced it. The dealership initially kept telling me it was upper engine noise until I pushed them to actually tell me which part failed. They then finally admitted that it was one of the engine bearings. This failure was also 2 months after that same dealership had pulled the oil pan off and replaced the gasket and oil pressure sensor for an active recall. This seems to be a VERY common problem for this 2.4theta engine from Hyundai. Hyundai is refusing to warranty the engine and wants $9600 to replace the engine that failed and left me stranded on the highway 2hrs away from home. The vehicle has now been at the same dealership for over 2 months while I fight with Hyundai's warranty and customer service dept who keep denying my claim that the engine is defective and should be warrantied. While my car has been at this same dealership they have preformed another NEW active recall for programming the knock sensor to sense bearing failures on these engines. THIS NEW RECALL WORK WAS DONE WITHOUT MY CONSENT AND I DID NOT SIGN OFF ON THEM PREFORMING THIS WORK BECAUSE THE ENGINE HAS ALREADY HAD A BEARING FAILURE!!!

What component or system failed or malfunctioned, and is it available for inspection upon request? Engine failure while operating vehicle How was your safety or the safety of others put at risk? My wife, 2 children and myself were on a busy interstate and immediately lost all power from the engine, unable to accelerate. Had to navigate other vehicles to reach the shoulder where we were stranded for at least an hour. Has the problem been reproduced or confirmed by a dealer or independent service center? The independent service center immediately cited well known issues with this specific 2.4L engine and recommended we go to the dealer. Awaiting the dealers feedback at this time. Has the vehicle or component been inspected by the manufacturer, police, insurance representatives or others? Not at this time Were there any warning lamps, messages or other symptoms of the problem prior to the failure, and when did they first appear? No; the vehicle was well maintained. The oil/fluid levels were appropriate before the start of the trip. No warning lamps or the like were present prior to the incident. No symptoms evident prior to the incident.

The contact owns a 2013 Hyundai Tucson. The contact stated that the vehicle engine failed. When driving with the cruise control set at 70 mph, the engine emitted a loud knocking sound and the vehicle decelerated. The vehicle powered off and the vehicle rolled onto the road shoulder. The contact was able to open the hood and smoke emitted from under the hood and emitted an engine oil burnt odor. The vehicle was not towed to a dealer or mechanic to have a diagnostic performed. The vehicle was not repaired. The manufacturer was not contacted. The failure mileage was 65,000.

My 81 year old Mother was driving the vehicle when it just stopped on her on a busy intersection and a tow company and police had to be called. The tow company tried to jump the car and it did not work. The mechanic said that the engine is shot and it only has 124k miles and has been well taken care of and all recalls have been addressed. This is a hazardous and dangerous issue that could have ended badly. I contacted the Hyundai dealer that did my recall to check it and they do not have any appointments until 09-15-2021 which is 3 weeks away. I do not understand how a vehicle that has regular maintenance has the engine just go with no prior warning.