2023 Jeep Gladiator Fuel System Problems

Gas overflows when filling at gas station It has happened over 5 times. Nozzle is on the lowest setting Have been to the dealership twice to have it inspected I have video of it happening twice. The tank is usually 1/4 tank when filling. Safety hazard.

Cut off on me while driving. Loss power in middle of street almost cause me to hit another vehicle. Took it to repair under warranty they took almost 2 months to repair. Did some research and apparently this is a common issue on these trucks ans it is still not a recall about it. Dealership replaced same fuel injection pump it had. So basically it will happen again sometime soon. My vehicle only has 17k miles.

My check engine light came on and I was told it set a code for a flash update . Dealership did the update and told me if the light came back on it was the fuel pump . Light came back on and I took it back immediately to dealership . They said perfectly safe to drive , it’s the fuel pump . My jeep truck only has 22,000 miles on it . Three days later I was driving home and the vehicle engine light was turned off by the dealership a second time and the fuel pump went out while I was driving with no light warning or nothing and my truck came to a sudden stop in the midst of me driving . Traffic was behind me and beside me . I was nearly missed . Jeep evidently has known of this same massively reported issues with previous models from 2020-2022 models. This is a huge issue driving and the vehicle just came to a sudden stop Locked down the shifter . Could not move the shifter without assistance to even put the truck in neutral to move it out out of the middle of traffic. Luckily the towing company knew how take the key and strap it into neural to move it . I pray Jeep Manufacturers are held accountable for not having this already become a safety recall . I seen many reports of this exact issue for their models since 2020 on Jeep Group Facebook community complaints for the Jeep Gladiator trucks after I experienced this possible death threat . Woe to the consumer whose lives could be at stake.

Every time I fill up with gas it splashes up and over quite a bit. I have tried many different ways to get it to stop splashing. Slowed down the flow, changed positions of the tube. Slowed down the flow to try and not let it splash up towards the end of the fill. As soon as it gets close, it splashes over, on my fender, and about a 1 foot gas spot on the ground every time. I have not been to the dealer yet, I have decided to report this online, to see if anyone else has, and I feel this is a safety and hazard issue to the environment.

I have 2 Jeep gladiators and both are gasoline powered. The problem is the fuel nozzle cannot go fully into the receptacle to add gas. This causes the fuel nozzle to not sense when to click/stop the fuel coming from the gas station pump when the tank and filler hose of the Jeep are full. The result is that gasoline splashes out of the refueling receptacle and then both onto me and also down the side of the bed of the Gladiator on the drivers side where the fuel refill receptacle is located. I put a camera borescope into the fill nozzle and this obstruction can be seen in the attachment.

Every single time I try to fill my gas tank, at any gas station, the gas pours out and shoots up fast out of the tank fill hole. I have even slowed down filling, and when I hear it getting close coming up the pipe, I let of the pump handle and it will still come up and splash out. I have 3100 miles on it, and it has done it every single time. I have to wipe gas off my fender and it splashes enough to run down on the ground every time. I think this is an immediate safety and environmental issue.