2011 Jeep Patriot Fuel System Problems

The contact owns a 2011 Jeep Patriot. The contact stated that while driving at an undisclosed speed, the vehicle stalled. While refueling, the fuel tank failed to allow all with fuel. The contact had to restart the vehicle and add more fuel several times. There were no warning lights illuminated. The contact called the local dealer where a service appointment was scheduled. The vehicle was not diagnosed or repaired. The vehicle was taken to an independent mechanic who informed the contact that the failure was due to a faulty rollover valve and the fuel tank needed to be replaced. The manufacturer was contacted but provided no assistance. The approximate failure mileage was 115,000.

WHEN FUELING AT A GAS STATION AND THE VEHICLE IS OFF I CAN ONLY PUT ROUGHLY 25 CENTS OF FUEL IN AT A TIME.

WHEN FILLING THE FUEL TANK TO NORMAL FULL LEVEL, THE VEHICLE WILL STALL AND RUN AT VERY LOW RAM. THIS ONLY HAPPENS RIGHT AFTER FILLING THE TANK TO FULL AND STARTING TO ACCELERATE AT A NORMAL RATE. AFTER DOING RESEARCH, THIS SEEMS TO BE A VERY COMMON ISSUE ACROSS MANY JEEP VEHICLES.

Filled gas tank and restarted Jeep. Pulled away from gas station into traffic and the jeep sputtered and died. Restarted and spit and sputtered and died again. After several tries and waiting, car started. Idled roughly for a few minutes then cleared up. No problems or indication of any problems until had to get gas again. Another incident while filling gas tank, pump continuously cut off and had to pump extremely slow to fill tank. Again, sputter and spat after starting. At times as the gas is going in it sounds like a gulping sound after I stop pumping gas. These problems happen every time have to get gas. It is dangerous and very frustrating. This has been going on way too long. I took it to the shop and the mechanic says the roll over valve inside the gas tank is stuck and I must have a new gas tank installed at $1500. I would welcome you to inspect this vehicle. There have been no warning lamps, signals, messages, or other indicator of a problem with the vehicle.

JEEP STALLS AFTER REFUELING. ANYTIME YOU FULLY FILL THE TANK THIS IS AN ISSUE. WAS VERY STARTLING THE FIRST COUPLE OF TIMES IT HAPPENED. I NOW EXPECT THIS TO HAPPEN, BUT FOR OTHER PEOPLE IT COULD BE AN EXTREME HAZARD. IT HAPPENS WITH THE VEHICLE STATIONARY OR IN MOTION. SUBSIDES AFTER SECOND OR THIRD RESTART...OR IF YOU LET IT SIT WITH THE GAS CAP OPEN FOR A MINUTE OR SO, THESE SEEMS TO HELP.

THE PROBLEM I AM HAVING IS WITH THE ROLLOVER VALVE WHICH IS LOCATED IN THE GAS TANK. WHEN I PUT FUEL IN, IT ACTS LIKE IT IS FULL, EVEN THOUGH THE GAS GAUGE IS TELLING ME THAT I HAVE TANK OF GAS. IT WILL ONLY TAKE THE GAS IF I PUT IN GALLON AT A TIME. THEN WHEN I START TO DRIVE IT, IT WANTS TO STALL, AND I HAVE TO GIVE IT THE GAS AND THEN IT RUNS. I HAVE DONE RESEARCH ONLINE AND THIS IS A PROBLEM IN ALL JEEPS. IF I AM IN AN ACCIDENT THE ROLLOVER VALVE COULD REMAIN OPEN INSTEAD OF CLOSING. THE VALVE IS STICKING AND UNRELIABLE. THIS VALVE DOES IT EVERY TIME YOU PUT GAS IN IT.

5 OR SO MINUTES AFTER FILLING UP MY CAR IT COMPLETELY SHUT OFF WHILE I WAS IN THE MIDDLE OF MAKING A LEFT HAND TURN IN THE RIGHT LANE I WAS ALMOST HIT RIGHT ON. THIS MAKES THE 5TH TIME THIS HAS HAPPEN.

CAR SHUTS OFF QND STOPS WITHOUT WARNING EVERYTIME AFTER FILLING TANK WITH FUEL... VERY DANGEROUS ON HIGHWAY...

WHEN FILLING THE GAS TANK FULL, THE ENGINE STALLS AND HESITATES FOR ABOUT 30 SECONDS AFTER FIRST STARTING THE ENGINE BACK UP AFTER THE FILLING OF THE TANK. IT CAUSES MY ENGINE TO COMPLETELY STOP WORKING AND I HAVE TO TURN THE KEY OFF AND RESTART THE ENGINE. I HAVE STALLED OUT IN TRAFFIC CAUSING THE CHANCE FOR AN ACCIDENT. THIS HAPPENS AS I TURN THE CAR BACK ON AND BEGIN DRIVING RIGHT AFTER FILLING THE TANK FULL OF GAS.

VEHICLE WILL SHUT OFF UNEXPECTEDLY AFTER RUNNING FOR LONG PERIODS OF TIME. LOSS OF POWER STEERING. THISE WOULD HAPPEN AT ANY SPEED.

WHILE DRIVING THE VEHICLE JUST DIES FOR NO REASON. AFTER A WHILE IT STARTS BACK UP WITH THE EXCEPTION OF ONE TIME I HAD TO HAVE IT TOWED TO A MECHANIC. A COUPLE DAYS AGO IT STALLED WHILE ON THE FWY WITH MY 3 YR OLD SON ALMOST RESULTING IN DISASTER. I BOUGHT THIS VEHICLE ABOUT 6 MONTHS.

WHILE TRAVELING APPROXIMATELY 3 HRS AT HIGHWAY SPEED, WITH THE CRUISE CONTROL ON AND IN 108 DEGREE WEATHER, THE MOTOR SHUT DOWN. IF FELT AS IF THE VEHICLE RAN OUT OF FUEL. NO LIGHTS, NO WARNINGS, AND OVER 1/4 TANK OF FUEL. AFTER STOPPING ON THE SHOULDER THE MOTOR WOULD TURN OVER, BUT NOT START, MADE ME THINK THAT THE FUEL PUMP WAS BAD. 5 MINUTES LATER IT STARTED, BUT WHEN THE THROTTLE WAS PRESSED IT DIED AGAIN. ANOTHER 15 MINUTES OF SITTING THE VEHICLE STARTED, BUT FELT "SLUGGISH". I STARTED MOVING SLOWLY DOWN THE SHOULDER, AND THE VEHICLE BEGAN TO RESPOND NORMALLY, AND FINISHED THE LAST HOUR OF THE DRIVE WITHOUT INCIDENT. *TR

I WAS DRIVING IN WAUSAU, MY JEEP STOPPED, I ACCELERATED-NOTHING. I HAD CARS BEHIND ME HONKING AND THE ONE DIRECTLY BEHIND ME WAS COMING UP FAST, I STEERED TO THE RIGHT AND MANAGED TO MAKE IT INTO A SNOWBANK. I TURNED MY CAR OFF, RESTARTED IT. SAT FOR ABOUT 10 MINS WITH HAZARDS ON AND WAS ABLE TO DRIVE BACK HOME TO EAU CLAIRE. IN FEBRUARY I REPLACED MY TRANSMISSION. MY TRANSMISSION NEVER WENT OUT. MY VEHICLE WOULD JUST GET STUCK IN REVERSE, I'D HAVE TO PUT IN DRIVE, BACK TO REVERSE, THEN TO DRIVE AGAIN TO GO. IN ADDITION I HAD TWO MORE EPISODES, ONE WITH MY TWELVE YEAR OLD IN THE VEHICLE WITH ME WHERE IT JUST STOPPED ACCELERATING. SO I HAVE A NEW TRANSMISSION IN. I HAVE ALSO FILED A SEPARATE COMPLAINT REGARDING TREAD WEAR ON NOW TIRES, BUT IT'S A FEW WEEKS LATER AND SOMETHING STILL ISN'T RIGHT. I'M NOT GETTING STUCK IN REVERSE ANYMORE, IT'S ONLY BEEN A MONTH, BUT I HAVEN'T HAD THE JEEP STOP, BUT IT FEEL LIKE THE (EXCUSE MY LACK OF MECHANICAL [XXX]) FUEL ISN'T GETTING TO WEAR IT NEEDS TO GO FAST ENOUGH BECAUSE SOMETIMES IT DOESN'T ACCELERATE (IT'S BEEN OVER 30 DEGREES ALL WEEK, IT'S NOT DUE TO NOT HAVING THE CAR WARM UP). THEN WHEN IT DOES CHOOSE TO ACCELERATE IT "JUMPS" TO IT. OVERALL IT'S JUST NOISY. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6). *TR