2013 Jeep Patriot Fuel System Problems

The contact owns a 2013 Jeep Patriot. The contact stated that while attempting to refuel the vehicle, the vehicle would only allow the tank to be half full before shutting off the pump. The vehicle was taken to the local dealer to be diagnosed. The contact was informed that the roll-over valve was faulty and needed to be replaced. The vehicle was repaired. The contact referenced NHTSA Campaign Number: 12V142000 (Fuel System, Gasoline) however, the VIN was not included. The manufacturer was not notified of the failure. The approximate failure mileage was 58,000.

AFTER FILLING THE VEHICLE WITH A 'FILL UP', UPON STARTING AND DRIVING, THE VEHICLE BEGAN TO START 'BUCKING' AND LOSE POWER TO ACCELERATE. I LOOKED THIS UP AND SEE MANY PEOPLE WITH THIS SAME PROBLEM THAT EITHER DO NOT FILL THEIR TANKS ALL THE WAY ANYMORE OR CORRECTED IT BY REPLACING THEIR TANK SINCE THEY SAY THIS IS A FLAW IN THE DESIGN WHEN FUEL GETS PULLED INTO A CANISTER OR CONTAINER THAT IS SUPPOSED TO PUSH OUT VAPOR BUILD UP ONLY, BUT PULLS FUEL BACK IN AND CHOKES OUT. DON'T KNOW IF I AM CORRECT ON THIS LANGUAGE SINCE ONLY GOING BY WHAT OTHER PEOPLE POST. PLEASE HAVE JEEP LOOK INTO THIS SAFETY HAZARD AND RECALL IF NECESSARY SO I DO NOT HAVE TO SPEND HUNDREDS OF DOLLARS TO REPLACE A TANK. THANK YOU.

ENGINE LURCHES AND STALLS AFTER FILLING TANK. WILL DO SO 3 OR 4 TIMES, THEN SETTLE DOWN AND RUN. DANGEROUS TRYING TO ENTER TRAFFIC. NO STALL PROBLEM BETWEEN FILLS. MANY PEOPLE HAVING SAME PROBLEM AS SHOWN HERE: HTTPS://WWW.CARGURUS.COM/CARS/DISCUSSION-T29898_DS631498

THE THROTTLE BODY. I WAS ENTERING THE HIGHWAY WENT TO ACCELERATE AND IT WOULD NOT MOVE JUST STUTTERED. A MACK TRUCK WAS SPEEDING ALONG LUCKILY THERE WAS NO ONE IN THE HIGH-SPEED LANE SO HE COULD SWERVE AROUND ME AND BEEP AT ME I HAD TO DRIVE TO THE NEXT EXIT DOING 20MPH IN THE BREAKDOWN LANE AND GET IT TO MY GARAGE WHICH WAS TWO TOWNS OVER. EVERY TIME I HAD TO STOP AT A LIGHT THEN ACCELERATE IT WOULD STUTTER AND ONLY GO TO 20MPH. THE THROTTLE LIGHT WOULD COME ON THEN GO OFF. I BROUGHT IT TO THE GARAGE AND THEY HAD TO ORDER THE PART FROM FAR AWAY BECAUSE NO PLACE CLOSE TO US HAD IT DUE TO HIGH DEMAND WHICH LEADS ME TO BELIEVE THIS IS AN ONGOING PROBLEM. I GOOGLED THE PROBLEM AND IT SEEMS WIDESPREAD I AM NOT SURE WHY A RECALL WAS NOT ISSUED PEOPLES LIVES ARE AT STAKE. I ALMOST THREW UP IN MY CAR AFTER THE MACK TRUCK PASSED ME AND I REALIZED I COULD OF BEEN KILLED. I PAID $610.37 TO GET MY CAR REPAIRED SO I AM NOT SURE IF THE EXPENSE OF THE PART IS THE ISSUE BUT AGAIN I COULD OF BEEN KILLED AS COULD OF A LOT OF OTHERS THAT I READ ABOUT.

RAW GASOLINE FUMES SEEMS TO BE ENTERING THROUGH AIR VENTS WHILE VEHICLE IS IN OPERATION, AND FAN IS IN USE. I WAS LEAVING A CONVENIENCE STORE WHEN PATRONS IN THE PARKING LOT WAVED ME DOWN TO TELL ME THEY SMELLED FUEL FROM MY VEHICLE. I QUICKLY EXITED FROM THE LOT TO GET THE VEHICLE AWAY FROM THE STORE AND FUEL PUMPS. I DIDN'T BUY FUEL AT THAT VISIT. THE LOCAL POLICE DEPARTMENT AROUND THE CORNER HAS AN OPEN LOT, SO I HAD AN OFFICER COME OUT AND A FIREMAN RELATIVE STOP IN TO MAKE SURE THE VEHICLE WASN'T GOING TO COMBUST. LEFT THE PATRIOT SIT AND HAD AN INDEPENDENT MECHANIC CHECK IT OUT THE FOLLOWING DAY. HE DID NOT FIND ANYTHING UPON LETTING THE VEHICLE RUN AND HE TIGHTENED UP THE VENT TUBE OR FUEL FILLER NECK. THIS WAS SEVERAL MONTHS AGO. TONIGHT, WITH THE TANK AT APPROXIMATELY 1/2 FULL, I MADE THE SAME 3 MILE TRIP, USING DEFROST AND FAN, SMELLED RAW FUEL AND BY THE TIME I GOT INTO THE STORE MY THROAT AND LIPS WERE BURNING, LIGHTHEADED AND THINGS LOOKED A LITTLE HAZY. DROVE HOME WITH THE WINDOWS DOWN AND WILL APPARENTLY HAVE TO HAVE THIS ISSUE CHECKED OUT AGAIN. NOTICED THE JEEP DIDN'T SEEM TO HAVE GREAT ACCELERATION ON THE DRIVE IN. MILEAGE IS NOW MID 40K RANGE. FUEL SMELL COMING OUT IS WICKED AND TOXIC. I BOUGHT THIS VEHICLE BRAND NEW AT THE END OF 2012. LIGHT DRIVING WITH A DAILY 6MILE COMMUTE FOR WORK. THIS IS EXTREMELY HAZARDOUS ON SEVERAL LEVELS. I CAN'T IMAGINE HAVING CHILDREN AND PETS IN THE VEHICLE WHEN THIS HAPPENS. COULD THIS BE A CONTINUATION OF THE 2012 FUEL TANK PRODUCTION PROBLEM OF THE SAME MAKE AND MODEL?

TL* THE CONTACT OWNS A 2013 JEEP PATRIOT. THE CONTACT NOTICED A CHEMICAL ODOR EMITTING FROM THE VEHICLE. THE VEHICLE WAS TAKEN TO AN INDEPENDENT REPAIR SHOP. THE TECHNICIAN WAS UNABLE TO DETERMINE THE CAUSE OF THE FAILURE; HOWEVER, THE ODOR PERSISTED. THE VEHICLE WAS TAKEN TO THE DEALER FOR DIAGNOSTIC TESTING. THE TECHNICIAN DIAGNOSED THAT THE RAIL FUEL INJECTOR NEEDED TO BE REPLACED. THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURE. THE FAILURE MILEAGE WAS UNKNOWN.

THE CAR HAD 1/4 TANK OF GAS AND THE CAR STARTED ACTING LIKE IT WAS RUNNING OUT OF GAS CONSISTENTLY NEAR STALLING WHEN DRIVING. IT FELT LIKE THE CAR HAD A CLOGGED FUEL FILTER. I'VE ALSO HAD THE CAR FULLY STALL IN THE MIDDLE OF THE STREET WHILE DRIVING, ALMOST CAUSING THE CAR BEHIND ME TO REAR-END MY CAR AT LEAST ONE TIME. WHEN I TOOK THIS CAR TO A DEALERSHIP IN LOS ANGELES IN JULY, I WAS TOLD THE FUEL SENDING UNIT WAS THE PROBLEM AND THAT THEY WOULD ORDER THE PART. BECAUSE THE PART DID NOT ARRIVE WHEN SCHEDULED AND THE DATE WAS PUSHED BACK, I CALLED JEEP CORPORATE AND THEY SENT MY CONCERN TO THEIR ESCALATION DEPARTMENT. THEY ARE ANTICIPATING THE PART WILL BE AVAILABLE IN MID-OCTOBER; HOWEVER, THIS IS A SAFETY CONCERN AND JEEP HAS BEEN DRAGGING THIS OUT FOR 3 MONTHS NOW. THIS IS THE SECOND ISSUE I'VE HAD WITH THIS CAR AND THE FIRST ISSUE IS NOW RECURRING. AT THE VERY LEAST, I EXPECTED JEEP TO PROVIDE ME WITH A RENTAL CAR BECAUSE THIS IS A SAFETY ISSUE. THIS CAR WAS PURCHASED IN OREGON. *TR