2004 Kia Sedona Tires & Wheels Problems

I HAVE A 2004 KIA SENDONA LX VAN AND THE WHEEL BARRINGS ARE BAD I FIXED IT ONCE ALREADY A MONTH AGO AND IT IS ALREADY BROKEN AGAIN BOTH TIMES IT COMPLETELY FELL APART IN TO LITTLE PEICES WHEN I TOOK THE WHEEL OFF.

THIS IS THE SECOND SET OF DOUGLAS TIRES I HAVE HAD TO PAY FOR EVEN THOUGH WALMART SAYS IT IS A MANUFACTURE DEFECT THEY GET HOLES IN THE SIDE OF THE TIRES THIS TIME THE WHOLE INSIDE OF MY TIRE IS GONE LOOKS LIKE ROPE HANGING OUT ME AND MY DAUGHTER COULD OF BEEN SERIOUSLY HURT OR KILLED SO I THINK THAT DOUGLAS SHOULD HAVE TO REPLACE MY TIRES ON MY KIA MINI VAN I AM SICK AND TIRED OF WALMART AND THE DOUGLAS TIRES I CANNOT AFFORD MORE TIRES HERE IS THE DOT NUMBER ON THE TIRES AND THE SIZETHEY R EXTRA TRAC [[ MTS 215/70R15 MD34 O1R 17/11 SOMETHING NEEDS TO BE DONE. *TR

ON TUESDAY, AUGUST 14, 2012, MY WIFE TOOK OUR GRANDDAUGHTER SHOPPING. AFTER DROPPING HER OFF AT HOME, MY WIFE PROCEEDED TO DRIVE ~30 MILES HOME. ON THE WAY SHE NOTED A THUMPING SOUND COMING FROM THE FRONT PASSENGER SIDE TIRE. SHE STOPPED AT A GAS STATION ABOUT HALFWAY HOME TO CALL ME AND ASK THAT I COME OUT TO CHANGE THE TIRE. AT THAT TIME SHE NOTED A BLISTER IN THE TIRE SIDEWALL. MOMENTS LATER THERE WAS A LOUD BANG AND THE TIRE BLEW OUT WHILE SITTING AT THE GAS STATION. THE FOLLOWING DAY I TOOK THE VEHICLE BACK TO THE FIRESTONE DEALER WHERE THE TIRES WHERE PURCHASED IN THE FALL OF 2010. AFTER LISTENING TO A LITANY OF EXCUSES FOR THE FAILURE, INCLUDING; SHE (MY WIFE) MUST HAVE HIT A POT HOLE, TIRES WERE UNDER INFLATED, FRONT WHEELS WERE NOT ALIGNED, TIRES HAD NOT BEEN ROTATED, FINALLY THE SALESPERSON CONCEDED THAT THE TIRE SHOULD NOT HAVE BLOWN OUT. THE BAD TIRE WAS REPLACED AT MINIMUM EXPENSE TO ME, BUT I PAID FOR MOST OF THE OTHER FRONT TIRE, IN ORDER TO HAVE TWO TIRES WITH SIMILAR WEAR ON THE FRONT OF THE VEHICLE. *TR

THE WHEEL BEARINGS DISINTEGRATED AND CAUSED THE WHOLE HUB TO COME OFF. LUCKILY WE WERE RIGHT AROUND THE CORNER FROM OUR DESTINATION AND WEREN'T GOING VERY FAST. *TR

75,000 MILE TIRES COMING APART AFTER 23,844 MILES ! AFTER VISITING RELATIVES IN STUART FLA ON OUR WAY HOME ON I-95 HEADING SOUTH TO POMPANO BEACH AT 70MPH OUR VAN STARTED TO VIBRATE VICIOUSLY IN THE REAR,I PULLED OFF THE HIGHWAY TO CHECK THE TIRES,I THOUGHT ONE OF THE REAR WHEELS CAME LOOSE I JUST HAD IT IN AT THE POMPANO BEACH PEPBOYS FOR A TIRE ROTATION AND FRONTEND ALIGNMENT,AFTER CHECKING ALL THE WHEEL NUTS ON THE REAR AND FRONT WHEELS I FOUND NONE TO BE LOOSE. I DID NOT HAVE A FLASHLIGHT TO INSPECT THE TIRES WITH US,I HAD TO WAIT TILL WE ARRIVED HOME SO I COULD SEE WHAT HAD HAPPENED TO THE TIRES,I HAD TO KEEP THE SPEED DOWN TO 55 MPH BECAUSE OF THE BAD VIBRATION TO MAKE IT HOME THIS WAS AT 9PM SUNDAY NIGHT. MONDAY MORNING I INSPECTED THE TIRES,I FOUND THE TIRES TO HAVE CRACKS ALL AROUND BOTH SIDES OF THE TIRES WHERE THE TREAD COMES TOGETHER WITH THE SIDEWALL. THE LEFT REAR TIRE IS THE WORST,THE TREAD HAS A BULGE THE SIZE OF A FOOTBALL NEXT TO THE SIDEWALL. I FELL THAT ALL OF THE TIRES ON MY VAN NOT TO BE SAFE TIRES AND I DON'T TRUST THEM. *TR

BRIDGESTONE INSIGNIA SE200 SIZE P215/70R15 65K MILE TIRES SET OF 4 PURCHASED. MAY 2009 WITH 77,567 MILES ON VEHICLE. DATE ON TIRE IS 2108 SO THEY APPEAR TO HAVE BEEN A YEAR OLD WHEN INSTALLED AT COYOTE TIRE SHOP IN GLENDALE AZ. DRIVING IN 80 DEGREE WEATHER 70MPH IN A KIA SEDONA WITH 2 ADULTS AND ONE 6YR OLD CHILD INSIDE. TREAD SEPARATED FROM TIRE. WAS ABLE TO PULL TO SIDE OF ROAD. AIR NEVER ESCAPED FROM TIRE. STILL HAS 32LBS IN IT COLD. TIRE TREAD DESTROYED REAR BUMPER OF VEHICLE UPON SEPARATION. NO PRIOR HANDLING OR VIBRATIONS OCCURRED. ODOMETER READ 104235 AT TIME OF INCIDENT SO THE TIRE ONLY HAD 26,668 MILES ON IT. DOT NUMBER: Y7M3 MODEL YEAR 2004 MAKE KIA MODEL SEDONA EX VEHICLE IDENTIFICATION NUMBER: N/A TIRES WERE AFTERMARKET. *TR

TL*THE CONTACT OWNS A 2004 KIA SEDONA. WHILE DRIVING APPROXIMATELY 65 MPH, THE CONTACT HEARD A LOUD CRACKING NOISE. A FEW MOMENTS LATER, HE HEARD A LOUD EXPLOSION. THE CONTACT PULLED OVER AND NOTICED THAT THERE WAS A HOLE IN THE REAR PASSENGER SIDE HUB AND THE BEARING WAS MISSING. THE VEHICLE WAS TOWED TO AN AUTHORIZED DEALER WHERE THE CONTACT WAS INFORMED THAT THE VEHICLE WAS NOT INCLUDED IN RECALL 05V232000 (WHEELS). THE VEHICLE HAD NOT BEEN REPAIRED. THE CURRENT AND FAILURE MILEAGES WERE APPROXIMATELY 97,000.

VEHICLE: 2004 KIA SEDONA AT 47K MILES ROARING NOISE COMING FROM REAR-END. NOTIFIED KIA SINCE THERE WAS A RECALL ON CERTAIN 2004 MODELS BUT THEY SAID MY VEHICLE WAS NOT PART OF THE RECALL...GO FIGURE. I HAD MY LOCAL AUTO REPAIR SHOP REPLACE BOTH INNER AND OUTER WHEEL BEARINGS ON THE REAR AXLE. THEY SHOWED ME THE OLD BEARINGS WHICH WERE RUSTY AND HAD PITS. IT APPEARS THAT ALL 2004 MODELS SHOULD HAVE BEEN INCLUDED IN THIS RECALL. *TR

I HAD THE FRONT WHEEL BEARINGS AND HUBS REPLACED AT 65,000 MILES ON MY 2004 KIA SEDONA UNDER WARRANTY DUE TO PLAY IN THE HUB. LAST MONTH DURING A BRAKE INSPECTION I WAS INFORMED THAT THEY ARE BAD AGAIN THE VEHICLE NOW HAS 106,000 MILES. THIS IS A POTENTIAL HAZARD AS WHEN THEY FAIL COMPLETELY THE WHEEL WILL FALL OFF POTENTIALLY CAUSING A SERIOUS ACCIDENT. I BELIEVE THIS TO BE A DESIGN FLAW SINCE THIS ONLY VEHICLE I HAVE OWNED IN 30 YEARS THAT NEEDED BEARINGS REPLACED EVEN ONCE MUCH LESS TWICE IN 100,000 MILES. JUST TO LET YOU KNOW THE REAR BEARING WERE REPLACED TWICE ALREADY UNDER WARRANTY ONE TIME UNDER A RECALL AND ANOTHER TIME AS A RESULT OF ANOTHER BRAKE INSPECTION. *TR

TL*THE CONTACT OWNS A 2004 KIA SEDONA. WHILE DRIVING APPROXIMATELY 45 MPH SHE HEARD A ROARING NOISE COMING FROM THE WHEELS. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC WHERE SHE WAS INFORMED SHE NEEDED NEW WHEEL BEARINGS ON ALL FOUR WHEELS. THE MANUFACTURER WAS NOTIFIED AND SHE WAS INFORMED HER VEHICLE WAS NOT INCLUDED IN THE RECALL ASSOCIATED WITH NHTSA CAMPAIGN ID NUMBER 05V232000, WHEELS. THE VEHICLE WAS NOT REPAIRED. THE FAILURE MILEAGE WAS 78,000 AND THE CURRENT MILEAGE WAS 90,000.

DRIVING ON 8/9/09, CAR STARTED SHAKING, GOING ABOUT 70 MPH. PULLED TO RIGHT LANE SLOWING DOWN, GOT OFF EXIT RAMP AND ABOUT 30 FEET DOWN LEFT FRONT TIRE BLEW OUT. TREAD HAD SEPARATED FROM TIRE AND ONCE GOT TO SAFE PLACE TO CHANGE TIRE, MY FRONT QUARTER PANEL AND LEFT FRONT HEADLIGHT WERE DAMAGED. *TR

TL*THE CONTACT OWNS A 2004 KIA SEDONA. WHILE DRIVING BETWEEN 45-55 MPH, THE CONTACT NOTICED A LOUD ROARING NOISE AND VIBRATION IN THE VEHICLE. SHE PULLED THE VEHICLE OVER AND CALLED THE MECHANIC. THE MECHANIC ADVISED HER TO CHECK THE LUGS TO SEE IF THE WHEELS WERE ON TIGHT. SHE DROVE TO THE NEXT TOWN AND STOPPED AT A REPAIR SHOP. THE MECHANIC DROVE AROUND THE BLOCK AND STATED THAT THE WHEEL BEARING APPEARED TO BE DEFECTIVE. THE DEALER STATED THAT HER VIN WAS NOT INCLUDED IN NHTSA CAMPAIGN ID NUMBER 05V232000 (WHEELS). THE CURRENT AND FAILURE MILEAGES WERE APPROXIMATELY 77,000.

TL*THE CONTACT OWNS A 2004 KIA SEDONA. WHILE DRIVING 60 MPH, THE CONTACT HEARD A LOUD THUMPING SOUND. AFTER SHE INSPECTED THE VEHICLE, SHE NOTICED THE WHEEL AND TIRE DETACHED. THE VEHICLE WAS TOWED TO THE DEALER HOWEVER; THEY WERE UNABLE TO DIAGNOSE THE FAILURE. AS OF MARCH 25, 2008, THE DEALER HAD NOT REPAIRED THE VEHICLE. THE CURRENT MILEAGE WAS 83,000 AND FAILURE MILEAGE WAS 82,000.

WE TOOK OR 2004 SEDONDA EX. TO WESTON PONTIAC FOR A RECALL ON THE THROTTLE CABLE, MY WIFE ALSO SHOWED THEM THE LETTER FOR THE RECALL ON THE ALLOY WHEELS ASKED FOR THEM TO CHECK REAR BEARINGS FOR MOISTURE IN FEAR OF A CRASH. AFTER 3 HRS SHE WAS SENT HOME SAID IT WAS GOOD AND THEY WOULD ORDER PARTS. SOMETHING DIDN'T SEEM RIGHT SO I HAD HER TAKE IT TO BE CHECKED BY OTHER TECH. HIS FINDINGS WAS MOISTURE AND WAS CORRODED WITH RUST. LATER WHEN I WAS TALKING TO KIA'S CAC THEY GOT WESTON PONTIAC ON THE PHONE THE SHOP SAID THEY NEVER HAD TIME TO CHECK REAR BEARINGS WE WERE LUCKY THAT NO ONE WAS INJURED OR DEATHS WE HAVE GOTTEN A RUN AROUND FROM THEM LIES AND ONLY FIXING 1/2 THE PROBLEM. SAYING OUR PARTS ARE IN AND THEY DID NOT EVEN HAVE THEM JUST THAT KIA HAS CALLED AND WANTED TO GET THEM OFF THEIR BACKS. WE WERE ALSO TOLD TO KEEP CHECKING FOR MOISTURE IN THE BEARINGS AND JUST BRING IT WHEN WE DO. ITS LIKE SAYING DRIVE WITH YOUR EYES CLOSED YOU NEVER KNOW WHEN YOU MAY CRASH, AS THE RECALL SAYS I DON'T LIKE THAT ODDS WITH MY WIFE & GRANDCHILDREN LIVES AT HAND. KIA( KARRIE) IS WHO I SPOKE TO & GAVE ME THIS # K1016279 TO REFER TO MY COMPLAINT SAID WELL YOUR VAN IS FIXED AND NO ONE GOT HURT I DON'T SEE WHAT YOUR PROBLEM IS. THE LIE TO MY WIFE SAYING OR VAN WAS OK WHEN NEVER CHECK AND WAS NOT THE RISK THEY PUT MY LOVED ONES IN WITH NO CONCERN FOR THEIR LIVES AND THAT THEY NEVER FIXED IT THEY PUT A BANDAID ON IT JUST TO GET US AND THIS RECALL OFF THEM. I KNOW THE RECALL WAS NOT ON THE RENTAL BUT IT WAS NOT SAFE TO BE OUT ON THE ROAD THE TIRES WERE BOLD AND WAS OUT OF ALIGNMENT THAT IT PULLED SO HARD TO THE RIGHT. THE ONLY THING THEY COULD SAY WAS NO ONE TOLD US. SO THEY PUT US FROM ONE DANGER RIGHT INTO ANOTHER. PLEASE SOMETHING NEEDS TO BE DONE TO STOP THEM HOW MANY OTHERS HAVE THEY SENT OFF SAYING THEIR VEHICLE IS OK AND NOT. THANK-YOU FOR YOUR TIME AND CONCERN IN THIS MATER ALBERT SMITH . *JB

DT: 2004 KIA SEDONA. NHTSA RECALL 05V232000 CONCERNING REAR WHEEL BEARING WAS ISSUED. THE VEHICLE WAS TAKEN TO THE DEALERSHIP AND PARTS WERE ORDERED FOR THE VEHICLE ON JULY 7, 2005. THE CONSUMER WAS STILL WAITING ON THESE PARTS TO BECOME AVAILABLE. THE CONSUMER CONTACTED THE DEALERSHIP AT LEAST THREE TIMES AND ALL THREE TIMES THEY COULD NOT TELL THE CONSUMER WHEN THE PARTS WOULD BE IN. *AK *MR

DT: CONTACT STATED RECEIVED A RECALL FROM KIA ON 06/13/2005 CONCERNING HUB CAPS. TOOK VEHICLE TO DEALER FOR RECALL REPAIRS ON 8-8-05 AND THEY HAD NO PARTS TO FIX IT. HE RECEIVED THE RECALL LETTER ON 6-13-05. THE DEALER AND MANUFACTURER TOLD HIM TO CONTACT SOMEONE IN KOREA TO GET THE PARTS IN.*AK THE CONSUMER STATED THE RECALL HAS SINCE BEEN TAKEN CARE OF. 11/15/05. *JB

DT: THERE IS A PROBLEM WITH HEAVY CORROSION ON THE FRONT WHEELS. THE CONTACT NOTICED THE PROBLEM IN AUGUST 2005, BUT IT HAD BEEN GOING ON BEFORE THEN. HE HAD TAKEN IT TO THE DEALER TO HAVE TWO RECALL REPAIRS PERFORMED. THE RECALLS WERE FOR THE REAR WHEELS AND THROTTLE CABLE. THE RECALLS WERE ESC-051 AND SC-049. THE CONTACT ASKED THE DEALERSHIP TO LOOK AT THE FRONT WHEELS ALSO. HE TOLD HIM THAT ANY VEHICLE WOULD HAVE THAT SAME PROBLEM. THE REPAIRS HAVE YET TO BE DONE. *AK UPDATED 11/29/05. *JB

DT: CONTACT RECEIVED A RECALL LETTER AROUND 6-15-05 CONCERNING ALLOY WHEELS. THE CONSUMER CALLED THE DEALER, AND THEY TOLD HER THE BEST THEY COULD DO WAS PUT HER ON A WAITING LIST. THEY COULD NOT TELL HER A SPECIFIC TIME WHEN SHE MIGHT BE CALLED BACK. THERE WERE MORE THAN 30 PEOPLE AT DEALER WITH SIMILAR PROBLEMS. . SHE CONTACTED THE DEALER THE VERY SAME DAY SHE RECEIVED THE LETTER. THE LAST TIME SHE CALLED,(ON JULY 12,05, SHE TOLD THEM TO PUT HER ON THE LIST. THEY DID RECOMMEND ANOTHER KIA DEALER FURTHER AWAY. SHE DID NOT WANT TO GO FURTHER AWAY DUE TO THE SAFETY ISSUE INVOLVED.*AK *JB

DT: CONSUMER RECEIVED A RECALL LETTER AROUND JUNE 13, 2005. SHE CONTACTED THE LOCAL DEALERSHIP, AND WAS TOLD THE PARTS WERE NOT IN. SHE CALLED BACK TODAY AND THE PARTS STILL WERE NOT AVAILABLE. SHE CALLED KIA, AND THEY TOLD HER TO CALL BACK AND HAVE THE VEHICLE INSPECTED UNTIL THE PARTS WERE AVAILABLE. SHE HAS TO CALL BACK AGAIN TO ARRANGE FOR THAT. *AK

DT: CONTACT STATES RECEIVED A RECALL LETTER DATED 6-13 05 FRO KIA. ON 6-28-05 TOOK VEHICLE TO DEALER FOR INSPECTION . THEY SAID THEY WOULD NEED TO ORDER THE PARTS. HE KEPT CALLING EACH WEEK, AND THEY TOLD HIM THEYE WERE STILL WAITING FOR THE PARTS. WHEN THE CONSUMER CALLED THE 800 CUSTOMER SERVICE NUMBER FOR KIA THEY TELL HIM THE PARTS WERE ON BACKORDER FROM KOREA. ON 8-10-05 THEY TOLD HIM TO TAKE VEHICLE BACK TO THE DEALER, HAVE THEM LOOK AT IT, AND IF THEY FEEL THAT VEHICLE WAS UNSAFE THEY WILL GOVE HIM A RENTAL/LOANER CAR TO DRIVE.*AK