2022 Kia Soul Engine Problems

The contact owns a 2022 Kia Soul. The contact stated that while driving at an undisclosed speed, the vehicle unexpectedly lost motive power and stalled, with several unknown warning lights illuminated. The vehicle was unable to restart and needed to be towed. The contact received notification of NHTSA Campaign Number: 25V099000 (Engine and Engine Cooling). The vehicle was towed to the dealer, where it was diagnosed and it was determined that the engine had failed and needed to be replaced. The vehicle was repaired. The contact was informed by the dealer that a used engine was installed as a replacement in the vehicle. The manufacturer was made aware of the failure. The approximate failure mileage was 81,000.

Update – April 1, 2026 (NHTSA Complaint #XXX) Today, April 1, 2026, at XXX I was informed that the engine replacement will not proceed because “the 3 years or 36,000 miles have passed.” This is incorrect. My Kia Soul 2022, VIN [XXX] , currently has 44,649 miles and was purchased in 2021. Kia’s Powertrain warranty is 10 years / 100,000 miles for the original owner and covers the engine. The basic 5-year/60,000-mile warranty does not apply in this case. On February 2, 2026, the technician documented stuck oil control rings allowing oil to enter the compression area, causing excessive oil consumption. A PWA was requested for full engine replacement. I have three failed oil consumption tests (more than 1 quart per 1,000 miles) and low compression on piston 3 (145 PSI). This would be the second major engine intervention in less than one year. The dealer is proposing only a partial repair of pieces, which does not solve the root cause and represents a safety risk (engine damage, possible fire, or loss of power), as warned in the official Kia letter I received. I request that NHTSA review this unjustified denial of warranty repair and require Kia to honor the Powertrain coverage. Attached: Technician notes from February 2, 2026, the three oil consumption tests, official Kia Puerto Rico letter, full repair history, and denial communication from April 1, 2026. Thank you. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

When I drive in alloys mode the system jerky and engine makes noise or hangs and I have to turn it off and on to start it back up to drive. When I drive without alloys on it thugs sporadically as if it is going to drive backward. Per the dealer the engine oil is slugs even thought it had oil change. But this vehicle is scary, I need it but scare of driving it.

I am filing a safety complaint regarding my 2022 Kia Soul LX with approximately 97,500 miles. The vehicle has experienced sudden and excessive oil consumption despite regular maintenance and a recent oil change about 1,500 miles prior to failure. While driving in normal traffic conditions, the vehicle suddenly began running rough, lost power, and entered limp mode. Shortly after, the engine stalled while I was actively driving, creating a dangerous situation and safety concern for myself and other drivers. A mechanic inspection found diagnostic trouble codes related to camshaft timing issues and determined that the timing chain tensioner likely failed due to oil starvation. The mechanic also found internal engine damage including piston ring failure caused by abnormal oil consumption. I was advised the engine is not repairable and requires replacement. I understand there have been widespread reports, recalls, and class action litigation involving Kia engines experiencing similar oil consumption and catastrophic failure issues. However, I was informed my specific VIN is not currently included. Because this failure caused a sudden stall while driving and poses a significant safety risk, I am requesting that this complaint be investigated. I believe this defect could affect additional vehicles beyond those currently included in recalls or service campaigns. This vehicle was properly maintained and the failure occurred unexpectedly and prematurely for a modern engine. Before the stall that happened going at least 35 mph with my [XXX] daughter In the rear seat, there was no prior warning oil lights or engine lights. Causing severe safety concerns for myself and child. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

The contact owns a 2022 Kia Soul. The contact stated that the vehicle was taken to the local dealer to be repaired under NHTSA Campaign Number: 25V099000 (Engine and Engine Cooling). After retrieving the vehicle, there was an audible tinging sound coming from the vehicle. No warning lights were illuminated. The vehicle was taken back to the dealer, and the contact was informed that the tires needed to be replaced. The vehicle was taken back to the local dealer for an extensive overhaul, and it was determined that the engine needed to be replaced. The oil level was approximately ¾ of a quart low. The manufacturer was contacted, but no assistance was provided. The manufacturer suggested driving the vehicle for 1,000 miles and having an oil consumption test performed. The failure mileage was approximately 69,000.

Urgent Escalation – Case CAS-XXX – Kia Soul 2022 VIN [XXX] – Excessive Oil Consumption Confirmed in 3 Tests – Partial Repair Unacceptable After Multiple Failures and Second Engine Intervention in Less Than six months INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

The contact's daughter owns a 2022 Kia Soul. The contact stated that while her daughter was driving 40 MPH, the engine froze for two minutes. The oil light was illuminated. The contact stated that the vehicle was undriveable. The vehicle was towed to the local dealer, and the failure was associated with NHTSA Campaign Number: 25V099000 (Engine and Engine Cooling); but the recall repair was declined because maintenance receipts were not available. The vehicle was towed to another local dealer, Friendship Kia, where the vehicle was diagnosed with a bent camshaft and spark plugs failure. The spark plugs were replaced. The manufacturer was contacted, but no assistance was provided. The failure mileage was approximately 90,000.

Vehicle is only 4 years old. Engine light came on. I used my Fixd code reader to diagnose. It mentioned several sensors which I replace cam shaft sensor. Intake sensor. Crank shay sensor. All were replaced, engine light came back on after each replacement. I took it to dealership for service and diagnosis. They indicated engine replacement due to timing being out of line; sheared king pin. Vehicle has been serviced regularly. Never anticipated having to replace an engine on a four year old vehicle. Still making payments and now $9,000 repair is Absurd! Additionally, these symptoms are consistent with similar symptoms listed in other kia soul recalls. This is my second Kia but probably will be my last if the manufacturer does not rectify this problem. Codes: P0017, P000B, P0068, P0014

The contact owns a 2022 Kia Soul. The contact stated that the vehicle stalled while idling on several occasions. Additionally, the check engine warning light was illuminated. The contact scanned the vehicle with a vehicle scanner, and the DTC: P1C28 was retrieved, which the contact related to NHTSA Campaign Number: 23V531000 (Power Train); however, the model year was not included in the recall. The contact later became aware that the VIN was included in NHTSA Campaign Number: 25V099000 (Engine and Engine Cooling), and the vehicle was taken to the dealer for the recall repair. The dealer diagnosed that the engine oil pump needed to be replaced, and the contact was informed that the repair was not covered under the recall. The contact stated that the oil pump failure might also be related to the oil piston rings failure described in the recall. The manufacturer was notified of the failure but declined to cover the cost of the repair. The vehicle was not yet repaired. The failure mileage was approximately 62,000.

Safety recall letter dated 4/4/25 states the piston rings may have been manufactured incorrectly causing oil consumption resulting in loss of drive power and/or fire. Kia performed two 1000 mile oil level checks which indicated it was 2 quarts low both times!!! I have asked for a written document stating they are not going to fix the problem and why (because he did not have all his oil change records ) but they will not send one not will they answer my emails or phone calls!

The contact owns a 2022 Kia Soul. The contact stated while driving at an undisclosed speed, the vehicle briefly jerked and jolted before returning to normal functionality. The check engine warning light was illuminated. The vehicle was not taken to the dealer or an independent mechanic. The vehicle was not repaired. The manufacturer was not notified of the failure. The failure mileage was 50,000. The VIN was not available.

I was driving back from Cleveland Oh to Columbus oh, the car started to slow down on its own , the engine light came on,and the car started to shake, and back firing. I made back home took care of to a certified mechanic shop for diagnostics. I just got an oil changed two days before this happened the mechanic noticed there was no oil in my car, it Was in my piston rings. They told me there was a recall on my year Kia for the piston . I called Kia, they said they couldn’t find a recall for my car. If there was a recall sc336 for Kia souls and seltos. I asked if the dealer could honor the recall on my vehicle they said no because the recall didn’t include my vin number

Originally, my CE light came on the first week of July 2025 and threw a Historical P0011 code for my intake Camshaft Variable Timing Solenoid. Light went off, and I took it to my local KIA dealership within a couple of days for a diag. They didn't catch a code, but said that sometimes the P0011 code will throw if there is any oil build-up, so they just recommended a 60k mile maintenance about 9k miles early and that it "should clear the code" with a flush. I couldn't afford a $1400 total service so I took it to a service shop nearby for an engine flush and an oil change on 08/08/25. The service shop also got a code for my variable Timing Solenoid and they cleared it after service. After one drive cycle, the CE light came back on, and this time threw a pending code for a Cylinder 2 misfire. The employee at the Auto Parts store said that Cylinder 2 could have a faulty coil and suggested a replacement, which we did. After another drive cycle, the CE light came on once again and threw a code(of unknown status) for a Cylinder 2 and 4 misfire. They advised us that due to the misfires after an oil change, that the Solenoid sounded like the problem afterall. I replaced my Solenoid, and not only did my CE light come on again, but I also experienced misfire, along with white smoke from my exhaust and rough idle. I got one last diag on 08/09/25 and they were able to do a scan, where they found oil had reached my spark plugs, and had noted the walls of my pistons were worn from the pistons knocking the walls. We also noticed that we burned through the entirety of the oil added to my vehicle during my oil change. With all of that information, the mechanic advised me that his best opinion without looking at my internal motor that my Piston Rings are likely worn, causing my misfires, oil consumption, burnt oil, and oil rising past the Piston Rings. We discussed the current recall on 2022 Kia Souls due to faulty Piston Rings and that it could coincide

My [XXX] daughter was a passenger in a vehicle involved in a crash in which the vehicle struck a tree and a fire was present. She was unable to exit the vehicle and did not receive medical attention in time. Public records indicate the vehicle had an open federal safety recall at the time, listed as incomplete. I am submitting this information for awareness and review. I am not making any conclusions regarding causation. However, I believe it is important that incidents involving vehicle fires and open recalls are documented and evaluated to help protect other families. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

My kia soul had no warning lights until last week when it shut down completely while pulling into an intersection, I have just purchased it 6 months ago. The engine light came on along with the oil lamp, battery light and master warning light. The car shut down and after a few minutes came back on. It has been doing this randomly for a week now so its barely been driven. It had a p000a code so I took it to a kia dealership for repairs after having it checked elsewhere and being told it needs a new engine. The repairs they quoted me at are over 4k and included the intake cam and intake and exhaust cam phasers. There is not much of a guarantee that this could not happen again if I spend it. I was told its unsafe to drive so its parked and may have to be defaulted on. I've seen others with similar issues while researching.

The contact owns a 2022 Kia Soul. The contact received notification of NHTSA Campaign Number: 25V099000 (Engine and Engine Cooling). The contact stated that there was an abnormally loud sound coming from the engine while driving at various speeds and while the engine was idling. The check engine warning light was illuminated. The vehicle was taken to the local dealer to be repaired under the recall. The dealer informed the contact that the failure appeared to be related to the oil pressure throughout the engine. Additionally, the dealer informed the contact that the recall test could not be performed because the vehicle had failed to start; however, the contact stated that the vehicle was operable at the time it was taken to the dealer. The dealer informed the contact that the engine needed to be replaced out the out-of-pocket. The contact related the engine replacement to the recall. The vehicle was not repaired. The manufacturer was made aware of the failure, but no assistance was provided. The failure mileage was approximately 77,800.

Took my 2022 soul in for the ring recall. The kia dealership in myrtle beach denied warranty due to sludge. That my complaint. I thought if ring leaks it creates sludge.

The contact owns a 2022 Kia Soul. The contact stated while driving 30 MPH, the vehicle inadvertently lost motive power. The contact was able to pull over to the shoulder of the roadway and observed smoke coming from the engine compartment. The contact stated that the vehicle failed to restart. No warning lights were illuminated. The vehicle was towed to the dealer, who determined that the engine had seized but was unable to diagnose the vehicle. The vehicle was not repaired. After investigating the failure, the contact related the failure to NHTSA Campaign Number: 25V099000 (Engine and Engine Cooling); but the VIN was not included. The manufacturer was notified of the failure, a case was opened, and the contact was referred to the NHTSA Hotline for assistance. The failure mileage was 70,000.

Car is burning oil and check engine light came on. It shakes and stalls when coming to a stop.

-Piston oil rings,oil burn -potential fire or wreck risk -oil usage confirmed -no -engine noise Manufacturers are accepting 1 qt burn per 1,000 miles. This is beyond excessive and should be repaired or replaced.