2016 Lincoln MKC Powertrain & Transmission Problems

At 85,000 miles I was experiencing a grinding noise coming from my front end when making sharp turns to left or right. Took car to my mechanic immediately for diagnosis. They found the motor mounts and rear differential is binding and close to failure. My mechanic contacted FOMOCO to see about a replacement for the rear differential and was told that there were not any available due to a REDESIGN of the product. He was asked to check back in two weeks! Two weeks w/o my transportation! I replaced the motor mounts, (85Kmi?) After researching on line, several ford & lincoln sites the problems I am experiencing are not unique or infrequent on Lincolns and ford Edges. It would seem to me that these problems are frequent enough to have the manufacturer ininitiate a recall on these products! My mechanic also works on our Sherriff department vehicles and their Ford Edge units are experiencing same problems. I would hope these problems will initiate an investigation into this matter!

Was at the Drive-thru ordering speaker and the car would not shift out of park and could not manually be shifted into neutral so the car could be moved. Drive-thru ordering window was blocked for 16 hyrs. Had to have the car towed with dolly. Vehicle was inspected by independent mechanic and found that the bushing was damaged.

When driving you could smell fumes, it would jerk, and kick in and out of gear and would have no heat. Coolant was always low with no visible leaks to the mechanic.

A gasket failed which allowed coolant to leak into the engine. Due to lack of coolant, two of the cylinder heads cracked and warping of the engine block occurred. No coolant in the engine could result in a engine seizure or fire which poses an extreme risk to one's safety. The check engine light came almost immediately before the cylinders started to misfire. 11/25/2023. The vehicle and components have been inspected by the dealers service department and the warranty inspector. The car needs a full engine replacement which only half is covered under the warranty. I am out of pocket the other half. See link regarding a current lawsuit the describes EXACTLY what happened to my vehicle: [XXX] . INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

The contact owns a 2016 Lincoln MKC. The contact stated that while driving at an undisclosed speed, there was smoke entering the cabin through the vents. The check engine warning light was illuminated. The vehicle was towed to the local dealer, where it was diagnosed and determined that the catalytic converter needed to be replaced. The vehicle was repaired, but the failure recurred. The contact stated that the vehicle failed to exceed 40 MPH. The vehicle was taken back to the dealer, where it was diagnosed that an unknown brake part had melted, and the electrical system was damaged. The contact stated that the failure was related to NHTSA Campaign Number: 23V378000 (Engine). The manufacturer was not contacted. The failure mileage was approximately 82,000.

The contact owns a 2016 Lincoln MKC. The contact stated that she started the vehicle and when she shifted the gear shifter into drive, the gear shifted into neutral instead. The contact stated that she noticed that the park mode light was displayed. The contact turned off and restarted the vehicle and was able to drive the vehicle to her destination. The contact stated when leaving her destination, the gear shifter would not shift into any gear and was inoperable. The contact stated that the failure had occurred several times. The vehicle was towed to the dealer and diagnosed with a failed cable shifter bushing. The contact was informed that the cable shifter bushing needed to be replaced. The vehicle was not repaired. The manufacturer was made aware of the failure and advised the contact to report the failure to the NHTSA Hotline. The failure mileage was approximately 117,524.

In 2019 I bought a used 2016 Lincoln MKC Reserve 2.0 Ecoboost Engine w 34K miles. In 4 years I've driven 11,400K miles. A few weeks ago my vehicle would not start. I had a tow to a Ford Retailer because the Service Tech at a Lincoln Retailer informed me they were backed up having 10 vehicles waiting to replace failed Ecoboost engines all with coolant leaks most likely I would need the same. After the $400 diagnostics I was told that I needed a new engine! Unlike the Lincoln Tech, Fords would not discuss anything about all the news, recalls or TSBs on Failed Ecoboost Engines. My Powertrain Warranty had recently expired well under mileage I would be responsible to pay. My MKCs decline happened suddenly and rapidly went downhill. First I noticed it was loud at start up which was odd and was running very rough. I checked underside and the rear to see if something was hanging and noticed a bluish gray smoke come out of exhaust for under a minute then then all symptoms cleared. Next for the 1st time a Check Engine Light came on which indicated a Misfire in Cylinder 4. Finally I had no heat in the cabin yet the engine was starting to overheat this time the Check Engine Light was blinking rapidly while driving at night in the freezing cold with my young daughter with me. It was very dangerous with supercold tempuratures being Winter in the NorthEast with icy roads. I started to smell a chemical burning odor. I have never experienced an overheating engine before in my life. I was scared and panicking not wanting to risk my engine blowing up or catching fire especially with my young child. I had no choice but to put all the windows down and pull over on the side of the road which had no sidewalks. The hood was very hot to touch. Next I am under the hood with a flashlight to check the fluids when I first became aware of the Coolant Reservoir was near empty, which explained the lack of heat and overheating. I owe $10k and it will cost $10k to replace Fords FAULTY Engine.

2016 LINCOLN MKC parked on driveway for over 24 hours, when my father was outside gardening he noticed smoke and flames coming from under the hood, the Fire Department was called who out the fire out and stated it was "totaled". Fire Department conducted their own investigation to determine the cause of the fire. The report returned indicating the "Engine" was the origin of the fire. Thank the lord my father was outside or our garage and house could have burnt down with all of us in it. THIS IS A HUGE SAFETY ISSUE!! I opened two claims with CarMax MaxCare Warranty which were denied. I have one case open with Ford Motor Company which is still pending. Car is currently at autoshop undergoing another diagnosis of the the orgin of fire for my CarMax MaxCare Warranty.

The contact owns a 2016 Lincoln MKC. The contact stated while driving at an undisclosed speed, the vehicle shuddered and lost motive power. The vehicle returned to normal functionality, but the failure became a regular occurrence. The check engine warning light was illuminated. The vehicle was taken to the dealer, who diagnosed a failure with the torque converter. The vehicle was repaired, but the failure reoccurred. The vehicle was taken back to the dealer, who then diagnosed a general failure with the transmission. The vehicle was repaired, but the failure reoccurred. After investigating the failure, the contact related it to Customer Satisfaction Program: 20N07. The manufacturer was notified of the failure but provided no assistance. The failure mileage was 58,000.

WHEN VEHICLE IS SLOWED (EVEN SLIGHTLY) BY DEACCELERATING OR SPED UP BY ACCELERATING THE SHIFTING SUDDENING AND HARSHLY GRABS AND LURCHES EFFECTING VEHICLE STABILITY. THE IMPACT IS VERY PRONOUNCED AND AUDIBLY LOUD AT HIGHWAY SPEEDS. THE VEHICLE HAS ALSO LUNGED FORWARD AS SHIFTING OCCURS WHEN BRAKING JUST PRIOR TO COMING TO A FULL STOP. THIS HAS HAPPENED ON MULTIPLE DATES.

WHEN ACCELERATING FROM A COAST THE VEHICLE JERKS AND BANGS INTO GEAR. AT TIMES IT FEELS LIKE THE VEHICLE WAS HIT FROM BEHIND. THIS HAPPENS ANYTIME WHETHER ON A CITY STREET OR HIGHWAY IN TRAFFIC CONDITIONS. FORD FIELD SERVICE ENGINEER WAS ABLE TO DUPLICATE THIS CONCERN BUT SAID IT WAS WITHIN THE PARAMETER OF THE VEHICLE BECAUSE IT HAPPENS AT LOW SPEED. I FIND THIS A NOT ACCEPTABLE ANSWER FOR A FAULTY TRANSMISSION.