There are 3 owner-reported body & structure complaints for the 2020 Mercedes-Benz C-Classin NHTSA's database. These are unverified consumer reports and may not reflect confirmed defects.
The contact owns a 2020 Mercedes-Benz C300. The contact stated that a section of the roof near the top of the windshield, between the sunroof, had detached and flown off the vehicle while driving 30 MPH in bumper-to-bumper traffic. The driver was able to grab the portion of the rubber gasket and pulled it into the vehicle through the driver’s side front window. The roof was in three pieces. The contact turned on the hazard lights and was able to pull over safely to the side of the roadway. There were no warning lights illuminated. The contact was concerned about the failure potentially causing a road hazard under different circumstances. The vehicle was taken to an independent mechanic the next day who declined to service the vehicle and informed the contact it was an issue for the manufacturer. The contact went to a body shop and was informed that the failure was caused by a design flaw. The contact called the local dealer, who initially did not respond. The contact called the dealer again, who requested photos. The vehicle was taken to the local dealer, who declined the repair the vehicle and escalated the issue. The vehicle was not diagnosed or repaired. The manufacturer was contacted regarding the failure and opened a case, but no decision had been made regarding the repair coverage. The failure mileage was approximately 28,722.
On Tuesday, June 24th, 2025, the glass panel located between the windshield and sunroof on my 2020 Mercedes-Benz C43 AMG unexpectedly detached and flew off while driving. This posed a serious safety risk to me and others on the road. There were no prior warning lights, messages, or symptoms before the failure occurred. This appears to have resulted from heat stress weakening the bonding that secures the panel to the vehicle—an issue consistent with NHTSA Recall 23V854000. That recall covers my exact year, make, and model, yet my specific VIN has not been included for reasons unknown, despite experiencing the exact same failure described in the recall notice. The issue was confirmed by Mercedes-Benz of Boston, where my vehicle is currently located. The failed component is available for inspection upon request. The dealer quoted me approximately $2,200 for repairs but declined to cover the cost under warranty since my VIN is not part of the active recall. I have opened a case with Mercedes-Benz Corporate to request full or partial reimbursement, and I am reporting this to NHTSA so that my VIN may be considered for inclusion in the recall.
Roof panel is peeling and rattling loose. I’m afraid it will come off like the other C-300s that were recalled for their roof panel flying off.
Complaints are unverified consumer reports submitted to NHTSA. A high complaint count may reflect vehicle popularity, not defect severity. Data sourced from NHTSA public records.
Data synced from NHTSA on Apr 25, 2026