2002 Mercury Mountaineer Complaint Log

JUST LEFT THE HIGHWAY AND ENDED UP AT A RED LIGHT TRAFFIC SIGNAL AND ONE THE LIGHT TURNED GREEN, I WENT TO DRIVE OFF AND A LOUD BOOM I COULD HEAR COMING FROM UNDER MY HOOD, AS I LOOKED IN MY REAR VIEW MIRROR A SEMI TRUCK STARTED HONKING ITS HORN AND SLAMMED TO MISS HITTING FROM BEHIND. I WENT TO PULL TO THE SIDE THE ROAD BUT TRUCK WAS JUMPING ALL OVER AND I HAD TO PULL IN FRONT OF CARS TURNING WHICH I SMELT A SMELL LIKE SOMETHING BURNING. *TR

MY COMPLAINT IS ON THE REAR BACK PANEL. WHEN I BOUGHT THIS CAR MY BACK PANEL CRACKED AT 76,000 MILES. OUT OF POCKET COST TO ME TO REPLACE THIS PANEL $500. NOW 2 MONTHS AGO I NOTICED A CRACK IN THAT PANEL AND DAYS LATER THE ENTIRE PANEL FLEW OFF MY CAR AS I AM DRIVING DOWN THE ROAD! I CAN ONLY IMAGINE THE SHOCK OF THE DRIVER IN THE VEHICLE BEHIND ME. FORD/MERCURY SHOULD MAN UP AND RECALL THESE. FIND A PERMANENT SOLUTION FOR AN OBVIOUS DESIGN FLAW ON THEIR PART. EVERYWHERE I GO I SEE MOUNTAINEERS AND EXPLORERS WITH CRACKED, HALF GONE OR COMPLETELY GONE REAR BACK PANELS. RIDICULOUS. *TR

TL* THE CONTACT OWNS A 2002 MERCURY MOUNTAINEER. THE CONTACT WAS DRIVING APPROXIMATELY 40 MPH ON NORMAL ROAD CONDITIONS. THERE WAS A LOUD NOISE OUTSIDE OF THE VEHICLE. THE DRIVER PULLED OVER TO THE SIDE OF THE ROAD AND INSPECTED THE VEHICLE. THE VEHICLE RESUMED OPERATION WITH CAUTION TO THE RESIDENCE. THE VEHICLE WAS TOWED TO AN INDEPENDENT MECHANIC. THE FAILURE WAS CONTRIBUTED TO THE FRONT AND REAR CONTROL ARM. THE FRONT AND REAR CONTROL ARMS WERE REPLACED. THE FAILURE MILEAGE WAS 121,000. THE VIN WAS UNAVAILABLE.

THE ISSUE WITH MY CAR THE TRANSMISSION I WAS DRIVING IT ONE THE INTERSTATE WHEN I STARTED TO HER A ROAR COMING FROM MY ENGINE AND THAT WHEN I NOTICED MY RPM WAS OFF THE CHART AND I STARTED TO GO SLOWER BY THE MINUTE AND AS I CALLED UP MY MECHANIC HE SAID IT WAS MY TRANSMISSION AND BEING FROM ANOTHER STATE AND ONLY HAVING 100 BUCKS IN THE POCKET IS NOT GOOD SO NOW IM STUCK IN A TOWN WITH NO JOB NOW NEEDING TO GET MY TRANSMISSION FIXED AND NOT HAVING A CAR TO DRIVE I CANT GET A JOB NOT HAVING A JOB MAKES ME LOSE MY CAR AND HAVING NO HOME LEFT FOR ME THAT'S JUST NOT RIGHT FORD SHOULD B THE ONES IN MY SHOES. *TR

RECENTLY, THE PCV VALVE IN MY 2002 MERCURY MOUNTAINEER HAD A LEAK (VACUUM SYSTEM LEAK). AS THE VEHICLE BEGAN TO STALL AS A RESULT OF THIS LEAK, WHILE TRAVELING 55 MPH, AND DECELERATING TOWARDS A TRAFFIC LIGHT, I LOST ALL FUNCTION OF MY BRAKES. WHEN I STEPPED HARD ON THE BRAKES, THERE WAS NO RESPONSE. HOWEVER, BECAUSE I EQUATED THIS TO POSSIBLY BEING TIED TO THE PCV VALVE, I STEPPED ON THE ACCELERATOR TO INCREASE AIRFLOW INTO THE ENGINE SO THAT I WOULD HAVE BRAKE FUNCTION. THIS GAVE ME BRAKE FUNCTION, TEMPORARILY. HOWEVER, THIS MOVE WAS VERY RISKY, AS I WAS APPROACHING CARS IN FRONT OF ME AND ACCELERATING TOWARDS THEM INSTEAD OF DECELERATING, JUST SO I COULD SLAM ON THE BRAKES AND HAVE FUNCTIONING BRAKES. THERE IS AN APPARENT LINK BETWEEN THE BRAKES AND THE VACUUM SYSTEM...WHICH POSES A DEADLY SITUATION. HAD I NOT BEEN AWARE OF VACUUM SYSTEM ISSUES AND HOW TO MITIGATE THEM, I WOULD HAVE PLOWED INTO THE STOPPED VEHICLE IN FRONT OF ME WITH NO BRAKES. THIS OCCURRED IN THE EVENING. I HAD TO USE THIS METHOD TO COMPLETE THE REMAINDER OF MY TRIP TO GET HOME, ACCELERATING EVERY TIME I NEEDED TO USE BRAKES, BECAUSE THE STALLING VEHICLE EVERY TIME HAD NO BRAKE FUNCTION. THIS CONDITION PUT ME IN A VERY BAD SITUATION, AS I ALSO HAD MY 5 YEAR OLD IN THE CAR WITH ME. THIS SYSTEM SHOULD BE RECALLED AS IT IS UNSAFE. REPLACING THE PCV VALVE CORRECTED THE PROBLEM. THERE IS ALSO NO NOTICE IN THE OPERATING MANUAL FOR THIS VEHICLE ABOUT THIS VACUUM SYSTEM PROBLEM, ESPECIALLY SINCE THE OPERATING MANUAL THAT CAME WITH THIS CAR IS FOR A PROTOTYPE SOFTWARE SYSTEM, AND DOESN'T EVEN MATCH MY VEHICLE. I HAVE COMPLAINED TO MERCURY/FORD ABOUT THIS INCORRECT MANUAL, BUT THEY DID NOT OFFER TO SEND ME A NEW ONE, AND SIMPLY TOOK THE INFORMATION AND DIDN'T EVEN RESPOND TO MY CONCERNS. *TR

OTHER VEHICLES OF THE SAME MAKE, MODEL, AND YEAR HAVE BEEN INCLUDED FOR A SAFETY RECALL REGARDING THE BRACKETS CONNECTING THE LIFT CYLINDERS TO EACH SIDE OF THE LIFTGATE GLASS. THE ADHESIVE HAS WORKED LOOSE AND THE CYLINDER WILL NOT HOLD OPEN THE GLASS; THE GATE HAS FALLEN AND WILL CONTINUE TO DO SO, RESULTING IN GLASS BREAKAGE. *TR

FAILURE OF REAR COIL SPRING ON 2002 MERCURY MOUNTAINEER. *TR

BOTH REAR COIL SPRINGS WERE BROKEN. BOTH HAD BEEN WEAKENED DUE TO CORROSION BEFORE THEY BROKE. THIS IS A WIDELY-KNOWN ISSUE WITH THIS VEHICLE AND I HAD BEEN CHECKING FOR THIS PROBLEM EVERY COUPLE MONTHS. I LAST CHECKED IN DECEMBER OF 2008 AND NEITHER SPRING WAS BROKEN THROUGH AND NEITHER SHOWED EXTERNAL CORROSION AT THE TIME, BUT THEY MUST HAVE BEEN VERY DETERIORATED EVEN THEN. MY POINT IS THAT A VISUAL INSPECTION WITH THE WHEELS OFF DID NOT REVEAL THE PROBLEM BEFORE THE SPRINGS BROKE. ONE OF THE BROKEN SPRINGS HAS A SPLIT ALONG THE LENGTH OF THE SPRING WIRE SEVERAL INCHES LONG AND A COMPLETE FAILURE ROUGHLY PERPENDICULAR TO THE WIRE. THE OTHER DOES NOT HAVE THE SPLIT; IT IS JUST BROKEN IN SHEAR PERPENDICULAR TO THE WIRE. *TR

WHILE DRIVING MY 2002 MERCURY MOUNTAINEER I HIT A BUMP ON A SMALL BRIDGE AND MY REAR DRIVERS SIDE COILSPRING SNAPPED IN HALF. ODDLY ABOUT TEN DAYS LATER I WAS FOLLOWING A MOUNTAINEER THAT HIT A DIP IN THE ROAD AND THE SAME COILSPRING BROKE. I DO NOT KNOW THE YEAR OF THAT MOUNTAINEER THOUGH. TO REPAIR THE COILSPRING IS EXTREMELY EXPENSIVE BECAUSE IT IS DEALER ONLY 300.00 FOR THE PART AND 135.00 TO INSTALL IT. *TR

I HAD A FLAT TIRE AT THE LEFT REAR OF THE VEHICLE, WHEN CHANGING THE TIRE I NOTICED THE SPRING WAS BROKEN IN SEVERAL PIECES. I HAVE TO SEE OF THE DEALER WILL REPLACE IT UNDER WARRANTY MY VEHICLE HAS 90,000 MILES. *TR

OD LIGHT STARTING FLASHING, THEN CHECK TRANSMISSION LIGHT STARTING FLASHING, THEN 3 AND 5TH GEAR STARTED SNATCHING, TRANSMISSION WENT OUT. I HEARD ALOT OF THESE SUVS ARE HAVING PROBLEMS JUST LIKE MINE. *TR

I HAVE A 2002 MERCURY MOUNTAINEER, SAME AS THE EXPLORER. MY OD LIGHT STARTED FLASHING AND I HAD FORD SERVICE CENTER RUN THE CODE, CODE 755 SOLENOID B, I HAD THE FORD SERVICE CENTER REPLACE IT TO THE TUNE OF $698 ON MARCH 5. I GOT THE TRUCK BACK MARCH 5, 2009 AT 12PM. MARCH 6, 2009 8 AM, SAME ISSUE. I TOOK IT BACK TO THE SERVICE CENTER AND I'M TOLD I NEED A NEW TRANSMISSION. MARCH 9, 2009 I TOOK THE TRUCK TO 2 SEPARATE SHOPS, ONE OF THEM BEING A VETERAN TRANSMISSION REPAIR SHOP. SAME SOLENOID CODE 755 SOLENOID B. I TOOK IT BACK TO THE SERVICE CENTER AND AM TOLD THAT THEY WILL REPLACE AND I STILL NEED A NEW TRANSMISSION. THE TRANSMISSION REPAIR SHOP TOLD ME THAT FORD KNOWS OF THE PROBLEM AND IT IS NOT THE TRANSMISSION, THE WIRING HARNESS IS BAD WHICH CAUSES THE SOLENOID TO SHOW AS BAD AND SHOW THE CODE. SHE SAID SHE HAS HAD DEALINGS WITH THE SAME SERVICE CENTER AND EVERYTIME THEY TELL CUSTOMERS THEY NEED A NEW TRANSMISSION. THERE ARE THOUSANDS OF COMPLAINTS ONLINE FOR THE SAME EXACT ISSUE. *TR

REAR PANEL UNDER WINDOW HAS RECENTLY CRACKED, THERE ARE NOW 2 VERTICAL CRACKS RUNNING DOWN THE BACK OF THE VEHICLE. ALSO, HITCH TO REAR DOOR DOESN'T STAY UP. THIS VEHICLE HAS ALSO HAD A NEW ENGINE PUT IT AND INJECTORS HAVE POPPED OUT ON MORE THAN ONE OCCASION. THIS IS THE MOST EXPENSIVE VEHICLE I HAVE EVER PURCHASED AND IT HAS GIVEN ME MORE PROBLEMS THAN I COULD EVER EXPECT IN A VEHICLE. FORD NEEDS TO COMPENSATE FOR THIS VEHICLE. WE HAVE OWNED SEVERAL FORD'S AND HAVE NEVER SEEN ANYTHING LIKE THIS. IT IS A TRUE LEMON>>>> *TR

REAR WHEEL BEARINGS FAILING FOR A SECOND TIME. FIRST TIME WAS ON 3/15/08. *TR

TRANSMISSION SLIPS ON MY 2002 MERCURY MOUNTAINEER 6 CYLINDER AWD. THERE IS A COMMON PROBLEM WITH THIS TRANSMISSION THROUGHOUT 2002 MERCURY MOUNTAINEER OWNERS. WHY HAS THERE BEEN NO RECALL ON THIS TRANSMISSION. *TR

TL*THE CONTACT OWNS A 2002 MERCURY MOUNTAINEER. WHILE DRIVING APPROXIMATELY 50 MPH, THE CONTACT APPLIED PRESSURE TO THE BRAKES AND HEARD A GRINDING SOUND. HE THEN BEGAN TO SMELL SOMETHING BURNING AND NOTICED SMOKE UNDERNEATH THE VEHICLE. HE INSPECTED THE VEHICLE AND DID NOT NOTICE ANY LEAKING. THE FOLLOWING DAY HE NOTICED AN EXTENSIVE AMOUNT OF OIL ON THE GROUND AND THE VEHICLE WAS PULLING. THE VEHICLE WAS INSPECTED BY A MECHANIC AND THE CONTACT WAS INFORMED THAT OIL WAS COMING FROM THREE DIFFERENT PLACES AND TRAVELING TO THE REAR DIFFERENTIAL. THE DEALER AND THE MANUFACTURER HAVE NOT BEEN NOTIFIED. THE CURRENT MILEAGE WAS 118,169 AND FAILURE MILEAGE WAS 118,000.

THE TRANSMISSION IN THIS VEHICLE IS DEFECTIVE. THEIR SHOULD BE A RECALL ON THIS MODEL WHICH IS A 2002 MERCURY MOUNTAINEER. THE PROBLEM IS COSTING ALL OF FORDS CUSTOMERS ALOT OF MONEY AVERAGE COST IS 2600 DOLLARS. THEY KNOW ABOUT THIS PROBLEM AND WILL NOT HELP EVEN WITH SOME OF THE REPAIR COST. THIS IS NOT ACCEPTABLE FOR ANY COMPANY TO GET AWAY WITH. PLEASE DO SOMETHING ABOUT THIS. THANK YOU *TR

I OWN A 2002 MERCURY MOUNTAINEER 4.6L AWD. AFTER BUYING THIS CAR I HAD HEARD ABOUT HOW BIG OF A LEMON THE TRANSMISSIONS ARE, AND ON JANUARY 27TH I FOUND THIS OUT FOR MYSELF. FIRST MY CAR BEGAN SHIFTING VERY HARSHLY. THEN MY O/D OFF LIGHT BEGAN FLASHING, CHECK ENGINE LIGHT CAME ON, AND CHECK TRANSMISSION LCD CAME ON. I LOST THIRD GEAR ON THE MIDDLE OF THE HIGHWAY AND HAD TO DRIVE 9 MILES HOME GOING ONLY 25 MPH. THEN I FOUND OUT THAT IT IS GOING TO COST $2500+ TO FIX THE PROBLEM. UNFORTUNATELY I'M A SINGLE MOTHER AND FULL-TIME STUDENT, SO MY CAR IS JUST GOING TO SIT FOR A FEW MONTHS UNTIL I CAN AFFORD TO FIX IT. FORD SHOULD BE HELD ACCOUNTABLE FOR THIS PROBLEM. I HAVE HEARD FAR TOO MANY COMPLAINTS AND NO ONE HAS DONE ANYTHING ABOUT IT . *TR

AS I WAS ACCELERATING NOTHING HAPPENED. THE TRANSMISSION FAILED AND DIDN'T GO ANYWHERE AND THEN IT JERKED JUST AS A CAR WAS APPROACHING, WHICH MADE THE OTHER CAR SWERVE AND IT ALMOST GOT INTO AN ACCIDENT. *TR 2002 MERCURY MOUNTAINEERS ARE NOTORIOUS FOR BAD TRANSMISSIONS AND THEY ARE A DANGER. FORD REFUSES TO TAKE ANY RESPONSIBILITY FOR THEIR POORLY BUILT TRANSMISSIONS. *TR

JUST UNDER THE REAR WINDOW THE BACK PANEL CRACKED IN THE COLD WEATHER THE VEHICLE IS KEPT IN A GARAGE WHEN EXITING THE GARAGE INTO THE WEATHER IT JUST CRACKED JUST UNDER THE MOUNTAINEER EMBLEM ALL THE WAY DOWN THE LENGTH OF THE PANEL AND NOW THE BACK REAR WINDOW RATTLES. *TR

TRANSMISSION HAS BEEN REPAIRED 3 TIMES. THE LAST WAS JAN 2009 WHEN IT WAS COMPLETELY REBUILT. *TR

2002 MERCURY MOUNTAINEER 4.6L V8 AWD 100,000MILES! VARIOUS TRANSMISSION PROBLEMS O/D LIGHT FLASHING ONE DAY CAUSING TRANSMISSION NOT TO SHIFT CORRECTLY. TEN MINUTES LATER START THE VEHICLE AND LIGHT NOT ON AND TRANSMISSION SHIFTS FINE. HAPPENS ON SEVERAL OCCASIONS. TRANSMISSION BEGAN TO SLIP. TAKE TO MECHANIC FLUID LEVEL AND FILTER ARE FINE. HOOK UP TO COMPUTER AND SAYS VARIOUS INTERNAL PROBLEMS. TORQUE CONVERTER ALSO BEGAN WHINING AND MAKING NOISE WHICH PROBABLY MEANS ITS COMING APART INSIDE. ESTIMATED FIX BETWEEN 1800.00-2800.00! SEVERAL WITH SIMILAR VEHICLES HAVE REPORTED SAME PROBLEMS! ALSO HAS WHEEL BEARING ISSUES! *TR

O/D LIGHT BLINKS AND TRANSMISSION SHIFTS HARD OR MISSES SHIFTS. FEELS LIKE TRANNY MIGHT BE ABOUT TO GO... STARTED ABOUT A YEAR AGO BUT WENT AWAY AFTER CHANGING TRANNY FLUID. NOW IT IS BACK, ISSUE IS WORSE, AND SEEMS LIKE IT IS HERE TO STAY. *TR

THE TRANSMISSION KEEPS SLIPPING CAUSING THE CAR TO STALL AND STUTTER IN TRAFFIC HAD TO HAVE IT REBUILT IN 2008 COSTING $3600.00, THE DIFFERENTIALS CAUSING PROBLEMS ON FRONT AND REAR WITH THE CAR WHEELS SPINNING AND STICKING AT TIMES, THE TIRES (ALL FOUR) BALLING OUT FROM THE INSIDE OUT HAVING TO REPLACE THEM EVERY THREE TO FOUR MONTHS, THE POWER LOCKS, RADIO, INTERIOR LIGHTS ALL WORK WHEN THEY WANT TO LIKE ITS A SHORTAGE. *TR

REAR TAILGATE LATCH BRAKES ACROSS THIS IS A KNOW ISSUE WITH ALL FORD EXPLORERS AND MERCURY MOUNTAINEERS. IT'S OBVIOUSLY A BAD DESIGN FROM FORD MOTOR CO. FORD NEEDS TO RECALL THIS AND IT'S THEIR DESIGN AND IT ALSO CAN REPRESENT AN INJURY TO SOMEONE IF A PIECE WAS TO FALL OFF AND HIT ANOTHER CAR. *TR

THE TRANSMISSION ON MY 2002 MERCURY MOUNTAINEER. THE O/D LIGHT IS FLASHING, AND SEEMS TRANS IS SLIPPING EVEN WORSE. I HAVE HAD IT TO THE DEALERSHIP MANY TIMES SINCE I BOUGHT IT NEW, AND THEY NEVER COULD FIND THE PROBLEM. NOW IT HAS BEEN OUT OF WARRANTY FOR QUIET SOME TIME AND HAS BECAME A HUGE PROBLEM. I LOOKED ON THE INTERNET AND NOTICED A TON OF COMPLAINTS ON THIS EXACT ISSUE AND WAS HOPING IT WOULD BE GROUND FOR A RECALL. *TR

ON DEC. 19, 2008, THE O/D LIGHT BEGAN TO FLASH AND THEN ON DEC.26TH THE SERVICE ENGINE SOON LIGHT CAME ON. AS I WAS DRIVING THE CAR BEGAN TO REV UP WHEN I WAS NOT MASHING THE GAS. I HAVE NOT DRIVEN IT SINCE. I CALLED THE FORD DEALERSHIP AND WAS TOLD TO DO A DIAGNOSTIC TEST ON IT, IT WOULD COST $98 PER ISSUE. I SEARCHED THE ISSUE ONLINE AND FOUND THAT MANY PEOPLE HAVE COMPLAINED ABOUT THIS AND HAVE PAID THOUSANDS OF DOLLARS TO HAVE IT FIXED. I WOULD LIKE TO KNOW IF THIS IS A RECALLABLE ISSUE DUE TO THE ABOUT OF COMPLAINTS? I JUST SPENT $300 HAVING THE DOOR AJAR SENSOR FIXED, SOMETHING THAT OTHERS HAVE ALSO COMPLAINED ABOUT. *TR

WHEN APPROACHING MY VEHICLE (2002 MERCURY MOUNTAINEER) FROM BEHIND, I NOTICED A CRACK IN THE CENTER OF THE LIFTGATE PANEL, BEGINNING AT THE BOTTOM OF THE WINDOW AND EXTENDING TO THE HANDLE. I RESEARCHED THIS ON THE INTERNET AND FOUND THAT IT IS A PROBLEM WHICH HAS OCCURRED IN FORD-MANUFACTURED SUVS, INCLUDING THE MOUNTAINEER AND EXPLORER. I CALLED THE SERVICE MANAGER OF THE DEALERSHIP WHERE I PURCHASED THE VEHICLE. HE WAS FAMILIAR WITH THE PROBLEM AND STATED THAT THE PANEL WILL NEED TO BE REPLACED. SINCE THERE IS NO RECALL ISSUED, THERE WAS NOTHING HE COULD DO. I THEN CALLED FORD CUSTOMER SERVICE AND SPOKE TO A PERSON WHO TOLD ME THAT FORD COULD NOT PROVIDE ASSISTANCE SINCE MY VEHICLE WAS OUT OF WARRANTY. SINCE THIS IS AN OBVIOUS DEFECT IN THE PRODUCT, I BELIEVE THAT FORD SHOULD ISSUE A RECALL AND COVER THE REPAIR COST. FORD SHOULD STAND BEHIND THE QUALITY OF ITS VEHICLES AND IF THERE IS A PROBLEM, THEN IT SHOULD PROVIDE THE CUSTOMER WITH A SATISFACTORY REMEDY. *TR

TL*THE CONTACT OWNS A 2002 MERCURY MOUNTAINEER. THE CONTACT STATED THAT THE WIRING HARNESS IN THE DOOR WAS EXPOSED. THE VEHICLE HAD NOT BEEN INSPECTED OR REPAIRED. THE CONTACT CALLED THE MANUFACTURER WHO OFFERED NO ASSISTANCE. THE FAILURE MILEAGE WAS APPROXIMATELY 90,000 AND THE CURRENT MILEAGE WAS APPROXIMATELY 170,000. UPDATED 01/26/11*LJ THE CONSUMER STATED THE WINDOWS WOULD NOT GO UP OR DOWN. UPDATED 03/25/11

EXPERIENCING TRANSMISSION ISSUES AT 75K MILES. TOOK IT TO SHOP WHO REPORTED THESE TRANSMISSIONS ARE NOTORIOUSLY BAD, REPLACING SOME AT 60K MILES AND MOST BY 100K. MINE NEEDS TO BE REPLACED AT A COST OF $2500. PROBLEM IS USE OF ALUMINUM WITHIN METAL AND FAST WEAR. FORD SHOULD BE HELD ACCOUNTABLE FOR MAKING POOR QUALITY PRODUCTS. TRANSMISSIONS SHOULD HAVE A MUCH GREATER LIFE THAN 75K MILES. PROBLEMS NOTICED - SLIPPING OUT OF GEAR WHILE DRIVING, NOT ENGAGING GEAR WHEN SELECTED, NOT SHIFTING INTO HIGHER GEAR (OVERREVVING),, CLUNKING SHIFTS. DANGER ARISES WHEN YOU SELECT GEAR, ACCELERATE AND NOTHING HAPPENS AND SUDDENLY IT POPS INTO GEAR WHICH CAUSES VEHICLE TO LUNGE FORWARD. *TR

TRANSMISSION PROBLEM. LESS THAN 80,000 MILES ON VEHICLE. MAINTENANCE KEPT UP TO DATE. I STARTED THE CAR AND BEGAN TO DRIVE AWAY WHEN SUDDENLY IT WOULD NOT PICK UP SPEED AND IT KEPT JERKING. IT WAS NOT DRIVEABLE AT ESPECIALLY ON A HIGHWAY. EVERYWHERE I WENT TOLD ME IT WAS THE TRANSMISSION. IT COST ME OVER $2,000.00 FOR ANOTHER TRANSMISSION. I AM SHOCKED TO SEE SO MANY OTHERS WITH TRANSMISSION PROBLEMS. I HAD NO PROBLEMS AT ALL WITH THIS VEHICLE UNTIL THIS HAPPENED. I FIND IT STRANGE THAT I NEVER HAD ANY OTHER MAINTENANCE PROBLEMS WITH THIS CAR AND SUDDENLY I LOSE A TRANSMISSION. IT SOUNDS LIKE A RECALL WAS DUE TO MYSELF AS WELL AS THOUSANDS OF OTHERS WITH THIS SAME MAKE AND MODEL. I WAS READY TO MAKE MERCURY MY MAIN CHOICE OF VEHICLE BUT AFTER THIS, I DON'T THINK SO. I WOULD LOVE TO BE INCLUDED IN A CLASS ACTION SUIT.

2002 MERCURY MOUNTAINEER TRANSMISSION FAILURE! COMMON PROBLEM AND SHOULD BE A FACTORY RECALL. THOUSANDS TO REPAIR!!!!! *TR

I BOUGHT THIS MOUNTAINEER IN EARLY 2007 WITH 62,000 MILES ON IT. FROM THE START IT SHIFTED VERY ROUGH. IT HAS PROGRESSIVELY WORSENED UNTIL THIS WEEK WHEN MY WIFE WAS DRIVING IT WOULD NOT SHIFT OUT OF SECOND GEAR AT ALL AND WAS NEARLY BROADSIDED WITH FOUR CHILDREN IN THE VEHICLE BECAUSE SHE COULD NOT MOVE. TOOK IT TO A REPAIR SHOP AND WAS INFORMED THAT I NEEDED TO HAVE THE TRANSMISSION FIXED. FROM OTHER COMMENTS I HAVE READ THIS SEEMS TO BE A FAIRLY COMMON PROBLEM WITH THIS VEHICLE. ALSO HAD TO HAVE THE REAR DIFFERENTIAL REPLACED AT AROUND 75,000 MILES WHICH SEEMS FAIRLY RIDICULOUS, AND A BEARING HAS GONE OUT TWICE ON THE SAME WHEEL. THIS VEHICLE DOESN'T SEEM TO BE BUILT TO LAST. *TR

TL*THE CONTACT OWNS A 2002 MERCURY MOUNTAINEER. WHEN THE CONTACT OPENED THE LIFTGATE, THE GLASS SHATTERED ON HER HAND. THE BRACKETS CAUSED THE LIFT CYLINDERS TO DETACH FROM THE GLASS AND SHATTER. PRIOR TO THE FAILURE, THE CONTACT HEARD A RATTLING SOUND. THE VEHICLE WAS PREVIOUSLY REPAIRED ACCORDING TO FORD RECALL NUMBER 04S20 AND NHTSA CAMPAIGN ID NUMBER 01I010000 (VISIBILITY:GLASS, SIDE/REAR). THE FAILURE MILEAGE WAS UNKNOWN BECAUSE THE INSTRUMENT PANEL CONSTANTLY DISPLAYS AN ERROR MESSAGE STATING THAT THE REAR LIFTGATE IS AJAR DUE TO THE FAILURE.

TL* THE CONTACT OWNS A 2002 MERCURY MOUNTAINEER. WHILE DRIVING APPROXIMATELY 50 MPH WITH THE FRONT DRIVER SEAT HEATING SYSTEM ACTIVATED, AND THEN THERE WAS AN UNEXPECTED EXCESSIVE HIGH VOLTAGE OF HEAT PENETRATION THROUGH THE BOTTOM OF THE SEAT. THE DRIVER SMELLED A STRONG BURNING ODOR OF RUBBER IN THE FOAM SEAT CUSHION. THE DRIVER PULLED OVER TO THE SIDE OF THE ROAD. AFTER WAITING TWENTY-FIVE MINUTES FOR THE SEATING AREA TO COOL DOWN, HE WAS ABLE TO RESUME NORMAL VEHICLE OPERATION. THERE WAS NO PERSONAL INJURIES SUSTAINED. THE VEHICLE WAS TAKEN TO AN AUTHORIZED DEALER FOR INSPECTION. THE FAILURE WAS CONTRIBUTED TO A SHORT CIRCUIT IN THE HEATED SEAT SYSTEM. THE TECHNICIAN RECOMMENDED NOT TO ACTIVATE THE HEATED SEAT SYSTEM. THE VEHICLE HAS NOT BEEN REPAIRED FOR THE MALFUNCTION. THE FAILURE MILEAGE WAS 50,00. THE CURRENT MILEAGE WAS 89,000.

I OWN A 2002 MERCURY MOUNTAINEER. THE TAILGATE DEVELOPED A CRACK BETWEEN THE EMBLEM AND THE REAR GLASS LIFT. SINCE THIS CRACK HAS DEVELOPED, THE DOOR AJAR LIGHT HAS STAYED ON CONSISTENTLY, CAUSING THE INTERIOR LIGHT TO STAY ON, DRAINING THE BATTERY, WHICH HAD TO BE REPLACED. I HAVE NOTICED THE SAME CRACK IN ALMOST EVERY FORD EXPLORER THAT I SEE. I HAVE NOT YET ATTEMPTED A REPAIR BECAUSE I DON'T FEEL I SHOULD HAVE TO PAY OUT OF POCKET FOR AN OBVIOUS MANUFACTURING DEFECT. *TR

WHILE DRIVING ON THE HIGHWAY THE FRONT LEFT ORIGINAL MANUFACTURES RIM HAD A CATASTROPHIC FAILURE. THE RIM IN QUESTION AFTER INVESTIGATING IT HAD A FRACTURE THAT WAS PERPENDICULAR TO THE ROTATION OF THE RIM WHICH RESULTED IN THE LOSS OF AIR PRESSURE CAUSING A SECONDARY FAILURE BY THE RIM FRACTURING IN THE CIRCUMFERENCE CAUSING THE RIM ITSELF TO SEPARATE INTO TWO PIECES. *TR

TL*THE CONTACT OWNS A 2002 MERCURY MOUNTAINEER. THE CONTACT STATED THAT THE GEARS FAILED AND WOULD NOT SHIFT FROM THE PARK POSITION INTERMITTENTLY. THE VEHICLE HAD NOT BEEN INSPECTED OR REPAIRED. THE CONTACT BELIEVED THE COLUMN SHIFT TO BE THE CAUSE OF THE FAILURE. THE FAILURE MILEAGE WAS APPROXIMATELY 90,000. THE VIN WAS UNAVAILABLE. UPDATED 01/26/118LJ UPDATED 02/11/11

ADD TO YOUR LIST OF COMPLAINTS OF SPARK PLUG EJECTION FROM THE ALUMINUM HEAD. THIS IS A FORD MOTOR COMPANY DESIGN FLAW THAT THEY REFUSE TO RESOLVE. TOTAL PARTS AND LABOR TO FIX = $3,372.50. *TR

TL*THE CONTACT OWNS A 2002 MERCURY MOUNTAINEER. WHEN THE CONTACT ATTEMPTED TO CLOSE THE REAR HATCH WINDOW, IT SUDDENLY EXPLODED. SHE NOTICED THAT THE REAR DRIVER'S SIDE WINDOW HATCH HAD FALLEN OFF OF THE VEHICLE. THE VEHICLE WAS TAKEN TO A LOCAL MECHANIC AND THE CONTACT WAS INFORMED THAT THE REAR LIFT GATE NEEDED TO BE REPLACED. THE VEHICLE HAS NOT BEEN DIAGNOSED BY THE DEALER. THE CONTACT DID NOT NOTICE ANY DIFFERENCES BEFOREHAND. THE CURRENT AND FAILURE MILEAGES WERE 79,332. UPDATED 11/07/08 *BF THE CONSUMER LEARNED OF RECALL #04V442000 BUT WAS INFORMED HER VEHICLE WAS NOT INCLUDED IN THE RECALL.. THE CONSUMER WAS TOLD THE RECALL WAS RELATED TO THE FAILURE OF THE REAR WINDOW BRACKETS BUT ALSO BECAUSE OF WHERE THE VEHICLE WAS MANUFACTURED. UPDATED 11/07/08. *JB

TL*THE CONTACT OWNS A 2002 MERCURY MOUNTAINEER. WHILE DRIVING 10 MPH, THE FRONT END OF THE CONTACT'S VEHICLE WAS STRUCK BY ANOTHER VEHICLE TRAVELING 70 MPH. NONE OF THE AIR BAGS DEPLOYED. THE VEHICLE HAS NOT BEEN DIAGNOSED BY THE DEALER. THE CONTACT DID NOT NOTICE ANY DIFFERENCES BEFOREHAND. A POLICE REPORT AND PICTURES ARE AVAILABLE. THE CURRENT AND FAILURE MILEAGES WERE 101,200.

MAJOR SAFETY CONCERN: 2002 MERCURY MOUNTAINEER AWD, PURCHASED WITH AROUND 79000 MILES, IN 2007. A FEW DAYS AFTER PURCHASE STARTED SHIFTING REALLY HARD INTO 3RD GEAR, CALLED DEALER AND HE SAID TO HAVE TRANSMISSION FLUID CHANGED, CHANGED THAT COST 100.00. SEEMED TO HELP SOME, NOW AT 100,000 MILES OR SO CAR WILL NOT GO OVER 30MPH. DRIVING VEHICLE IN BUSY TRAFFIC AND CAR ONLY GOING UP TO 30 IN A SERIOUS HAZARD. FORD NEEDS TO BE HELD ACCOUNTABLE FOR THIS. TOO MANY 2002 ARE HAVING EXACT SAME PROBLEM. CAR JERKS INTO REVERSE, O/D FLASHES, CHECK TRANSMISSION LIGHT COMES ON , HARD JERKS AND SHUDDERS INTO 3RD GEAR....COME ON HOW MANY MORE PEOPLE HAVE TO GIVE UP HARD EARNED MONEY TO FIX FORDS MISTAKES??? IN PROCESS OF TRYING TO FIND A TRANSMISSION SHOP TO TAKE THIS HEAP OF JUNK TO. *TR

I WENT TO SHIFT MY CAR INTO REVERSE AND THE STICK SHIFT LOCATED NEXT TO STEERING WHEEL CAME OFF IN MY HAND, WENT TO DEALER AND THE PART WAS $800.00 FOR THE WHOLE STEERING COLUMN, THE PART THAT BROKE WAS A SMALL PIECE HOLDING THE STICK, BUT DEALER SAID IT HAD TO REPLACE ALL OF IT. SINCE I COULD NOT AFFORD THAT AMOUNT I SEARCHED FOR A USED PART AND EVERYONE SAID IT WAS VERY COMMON ON THESE CARS AND I FINALLY FOUND ONE FOR $200.00 BUT HAVE NOT HAD IT INSTALLED DUE TO COSTS. AND TO ADD TO MY PROBLEMS I WAS DRIVING ON THE FREEWAY AND THE OD LIGHT STARTS TO FLICKER AND AFTER NUMEROUS CALLS AND RESEARCHING THE PROBLEM WAS TOLD THAT IT IS THE TRANSMISSION AND WOULD PROBABLY NEED TO REPAIR/REPLACE AND THAT IT IS A COMMON PROBLEM WITH THESE CARS. *TR

I HAD NOTICED THE STANCE OF THE VEHICLE HAD CHANGE AND DURING A ROUTINE NEW YORK STATE INSPECTION IT WAS DETERMINED THAT THE REAR SPRINGS ON MY 2002 MERCURY MOUNTAINEER HAD BROKEN. THE REAR SPRING DEFECT ALSO CAUSE THE REAR SHOCKS TO PREMATURELY WEAR OUT AND NEED REPLACEMENT. THE SPRINGS WERE CRACKED ENTIRELY IN HALF. IT APPEARS AS IF THERE WERE A DEFECT RELATING TO THE METALLURGICAL PROPERTIES OF THE METAL USED OR POSSIBLY A DEFECT IN THE MANUFACTURE OF THE SPRINGS. AT NO TIME WAS THIS VEHICLE DRIVEN OFF ROAD OR USED TO TOW ANYTHING. THE VEHICLE SIMPLY WAS USED BY MY WIFE TO DRIVE BACK AND FORTH TO WORK( 20 MILE ROUND TRIP ON THE HIGHWAY) THE CAR WAS OUT OF WARRANTY BY ABOUT 2 YEARS AND HAD ABOUT 50,000 MILES ON IT. A FORD REPRESENTATIVE TOLD ME TO TAKE IT TO THE DEALER FOR THEM TO INSPECT IT, THERE CONCLUSION WAS THE SAME. TWO REAR BROKEN SPRINGS, AS WELL AS 2 REAR SHOCKS THAT REQUIRED REPLACEMENT . THEIR COST ....OVER $1000.00. THERE IS NO WAY THIS ITEM SHOULD BREAK...GOD FORBID IT HAPPENS ON THE HIGHWAY AT A HIGH SPEED, .... A SPRING BREAK AT HIGHWAY SPEED WOULD CAUSE THE VEHICLE TO BECOME EXTREMELY UNSTABLE AND POSSIBLY CAUSE A HIGH SPEED CRASH. SPRINGS ACTUALLY SUPPORT THE WEIGHT OF THE VEHICLE AND WHEN THERE BROKEN.....THERE IS A SUDDEN AND UNFORESEEN UNSETTLING OF THE VEHICLE.....WHICH IN MY OPINION IS A MAJOR SAFETY ISSUE. I BROUGHT THIS TO THE ATTENTION OF FORD VIA THEIR 800 TELEPHONE # - (800-392-3673)...THEIR RESPONSE WAS..."WE ARE UNDER NO LEGAL RESPONSIBILITY TO FIX THIS PROBLEM. THE CAR IS OUT OF WARRANTY AND IT WAS MY RESPONSIBILITY TO FIX THE CAR....." I BELIEVE FORD HAS A RESPONSIBILITY, NOT ONLY ME, BUT TO ALL IT'S CUSTOMERS WHO OWN THIS VEHICLE OR ITS COUSIN THE FORD EXPLORER. I EXPECTED MORE FROM A LARGE COMPANY SUCH AS FORD. I'M SURE THEY HAVE A PROTOCOL TO DOCUMENT THIS INCIDENT, BUT I WONDER IF THEY JUST SWEPT THIS INCIDENT UNDER THE FORD CARPET. I FEEL I HAVE A RESPONSIBILITY TO LET OTHERS KNOW...THIS IS WHY I MADE THIS COMPLAINT. *TR

2002 MERCURY MOUNTAINEER. THE TRANSMISSION WENT OUT AT 66000 MILE AND 1 MONTH AFTER EXTENDED WARRANTY. CALLED FORD COSTUMER ASSISTANCE CENTER AND THE PERSON SAID SHE HAS NEVER HEARD OF THIS PROBLEM. WENT ON-LINE (EDMUNDS.COM, CARSURVEY.ORG, ETC. AND SAW ONE AFTER ANOTHER COMPLAINTS ABOUT EXACT SAME PROBLEM. THE CHECK TRANSMISSION WARNING LIGHT FIRST WENT ON AT 59000 MILE (STILL UNDER WARRANTY). BUT I READ THE MANUAL FIRST BEFORE TAKING IT TO DEALER. THE MANUAL STATED SUV WAS UP FOR FLASHING THE TRANSMISSION FLUID AT 60000 MILES. FLUSHED THE FLUID AND WARNING LIGHT WENT AWAY. SIX MONTHS LATER TRANSMISSION WARNING LIGHT IS BACK (WARRANTY HAS JUST EXPIRED). FOUND OUT THERE IS A RECALL ON THE SAME TRANSMISSION ON THE EXPLORER BUT THE MOUNTAINEER (WHICH IS SAME TRUCK WITH DIFFERENT BRANDING) DOES NOT. SO WHY IS THIS THE CASE? LUCKILY FOR ME I WAS NOT IN THE FREEWAY WENT THE TRANSMISSION WENT OUT. *TR

I HAVE AN 2002 MERCURY MOUNTAINEER HAD THE TRANSMISSION REBUILT 6 MONTHS AGO BEEN BACK TO THE TRANSMISSION SHOP 7 TIMES ...THREE TIMES FOR A SYNLAN PACK??OR SO THAT'S WHAT HE (THE MECHANIC) HAS TOLD ME . *TR

TL*THE CONTACT OWNS A 2002 MERCURY MOUNTAINEER. WHILE THE VEHICLE WAS PARKED, THE WINDOW LIFTGATE SHATTERED WHEN IT WAS CLOSED. THE DEALER STATED THAT THE VEHICLE HAD PREVIOUSLY BEEN REPAIRED UNDER NHTSA CAMPAIGN ID NUMBERS 04V442000 (STRUCTURE:BODY: HATCHBACK/LIFTGATE:HINGE AND ATTACHMENTS), 01I010000 (VISIBILITY: GLASS, SIDE/REAR), AND 07E104000 (VISIBILITY:GLASS, SIDE/REAR); THEREFORE, THE CONTACT WOULD BE RESPONSIBLE FOR THE REPAIR COST. UPDATED 09/15/08 *BF UPDATED 09/17/08. *JB

TRANSMISSION FAILED AT AROUND 100,000 MILES. HAD TRANSMISSION REBUILT IN JULY 2007. NOW TRANSMISSION IS FAILING AGAIN THIS JULY 2008. I'VE HAD MANY SHIFTING PROBLEMS WITH THE TRANSMISSION AND NOW THERE ARE TIMES IT WON'T SHIFT AT ALL. *TR

COMPLAINT IN DETAIL FOR, MERCURY MOUNTAINEER : JULY 24, 2007 I PURCHASED A 'AS IS WARRANTY' 2002 MERCURY MOUNTAINEER FROM TOYOTA OF SCION IN CONCORD, NC. THIS CAR WAS ADVERTISED ON THEIR WEBSITE FOR $11,995 AND REPORTED MILEAGE OF 51,972. SUBSEQUENT TO MY PURCHASE BELOW IS AN OUTLINE OF MY EXPERIENCE WITH THE VEHICLE: I REVIEWED THE CAR-FACTS VERY METICULOUSLY, AND ARRIVED AT THE FINDINGS NOTED BELOW WITH REGARD TO THE REPORTED MILEAGE: 1.11/20/2004 SOURCE: NC MOTOR VEHICLE DEPT. INDIAN TRAIL NC TITLE # 771444062507118 MILEAGE WAS REPORTED AT 48,000. 2.12/15/2005 SOURCE: NEW YORK MOTOR VEHICLE DEPT., HICKSVILLE, NY MILEAGE WAS REPORTED AT 39,412 WHICH SIGNIFY A DECREASE OF -8,588. 3.9/7/2006 SOURCE: NC MOTOR VEHICLE DEPT. INDIAN TRAIL, NC, MILEAGE WAS REPORTED AT 45,200 WHICH SIGNIFY AN INCREASE OF +5,788. 4.AS MENTIONED ABOVE ON 7/24/08 I PURCHASED THE VEHICLE WITH REPORTED MILEAGE OF 51, 972 WHICH SIGNIFY AN INCREASE OF +6772. *TR

TL*THE CONTACT OWNS A 2002 MERCURY MOUNTAINEER. WHILE THE CONTACT WAS UNDERNEATH THE HOOD DETAILING HER VEHICLE, THE HOOD CAME DOWN ON HER WITHOUT WARNING. SHE WAS NOT INJURED. THE CONTACT CALLED THE MANUFACTURER TO REPORT THE FAILURE AND WAS INFORMED THAT THERE WAS NO RECALL. SHE WAS ADVISED TO REPORT THE FAILURE TO NHTSA. THE FAILURE MILEAGE WAS 58,500.