2005 MINI Cooper Complaint Log

2005 MINI COOPER PASSENGER LIGHT COMES ON WITH OR WITHOUT ANY PASSENGER SITTING. HOWEVER, AFTER DRIVING FOR A WHILE GOES AWAY. WHEN THE CAR IS TURNED OFF AND STARTED AGAIN, THE PASSENGER LIGHT STAYS ON AGAIN. THIS IS NOT NORMAL. I HAVE SEEN OTHER RECALLS FOR DIFFERENT YEARS, WHY 2005 IS NOT A RECALL? *TR

2005 MINI COOPER S (BMW) POWER STEERING UNIT FAILURE - VEHICLE HAS LESS THAN 50,000 MILES. *TR

2005 MINI COOPER CONVERTIBLE AT FIRST INTERMITTENT POWER STEERING FAILURE AND NOW COMPLETE POWER STEERING FAILURE. THE FIRST TIME IT HAPPENED VERY SUDDENLY WHILE MAKING A LEFT TURN, I ALMOST RAN INTO ANOTHER CAR. NOW I AM NOT DRIVING THE CAR UNTIL I CAN AFFORD TO HAVE IT REPAIRED. *TR

THE POWER STEERING IN MY 2005 MINI COOPER HAS GONE OUT. IT STARTED FAILING INTERMITTENTLY FOR ABOUT 6 MONTHS THEN AS OF SEPTEMBER 2010 HAS FAILED COMPLETELY. IT IS EXTREMELY DIFFICULT TO STEER AND TURN THE CAR. I TOOK IT IN TO MY LOCAL MECHANIC WHEN IT WAS FAILING INTERMITTENTLY AND THEY COULD NOT RECREATE IT. NOTHING HAS BEEN CHANGED/FIXED AT THIS TIME. *TR

I OWN A 2005 MINI COOPER S 2 DOOR HARD TOP WITH CURRENTLY 90,000 MILES. JUST RECENTLY A SEMI LOUD WHIRRING SOUND STARTED FROM UNDERNEATH THE HOOD AS SOON AS THE ENGINE IS STARTED. IMMEDIATELY I CAN NOTICE THAT THE PITCH OF THE NOISE SUBTLY CHANGES WHEN YOU GO TO TURN THE STEERING WHEEL IN EITHER DIRECTION. I HAD A CERTIFIED MECHANIC LOOK AT THE CAR AND HE CONFIRMED TO ME THAT THE POWER STEERING PUMP IS FAILING. WHEN I AM DRIVING THE MINI COOPER THE STEERING WILL INTERMITTENTLY BEGIN TO GET A LITTLE HARDER TO STEER. THE PUMP IS ON THE WAY TO COMPLETE FAILURE AND HARD STEERING WILL END UP BEING THE RESULT. I HAVE BEEN RESEARCHING THIS ISSUE VIA THE WEB AND HAVE DISCOVERED THAT THE FAILING POWER STEERING UNIT IN MINI COOPERS HAS BEEN A KNOWN ISSUE WITH BMW BUT I HAVE YET TO FIND ANY INFORMATION AS TO WHAT THEY ARE DOING ABOUT IT. ASIDE FROM SPEED, STEERING A MOTOR VEHICLE IS ONE OF THE MOST IMPORTANT SAFETY CONCERNS WHEN IN OPERATION. *TR

ON SEPT. 19, 2010, MY 2005 MINI COOPER S HAD BEEN PARKED IN A GARAGE FOR ABOUT 10 HOURS. WHEN I WENT TO LEAVE, I FOUND THAT THE POWER STEERING WAS NOT WORKING AT ALL AND I HAD TO REALLY MUSCLE IT TO DRIVE IT. I'D NEVER HAD A PROBLEM WITH IT BEFORE. BECAUSE I HAD TO GET TO WHERE I WAS GOING, I DROVE IT VERY CAREFULLY. AFTER ABOUT FORTY MINUTES, I STOPPED AT A SERVICE AREA TO USE THE RESTROOM. WHEN I CAME BACK OUT AND STARTED MY CAR UP, THE POWER STEERING WAS WORKING AGAIN. SINCE THEN, I'VE HAD NO PROBLEM WITH IT. I HAD PLANNED ON MENTIONING THIS TO MY MECHANIC WHEN I GO IN TO HAVE MY BRAKES DONE IN THE NEXT WEEK. BUT THEN MY HUSBAND FORWARDED ME A NEWS STORY ABOUT THE POWER STEERING ISSUE AND I FIGURED THAT I SHOULD REPORT MINE. *TR

LOSS OF POWER STEERING AND POWER BRAKES IN A 2005 MINI COOPER CONVERTIBLE. NO WARNING AND INTERMITTENT OCCURRENCE. SOMETIMES WOULD HAPPEN WHILE DRIVING AND SOME TIMES WOULD BE IMMEDIATELY AFTER TURNING CAR ON. TOOK CAR TO MECHANIC AND HE COULD NOT FIND CAUSE. NO COMPUTER DAMAGE, NO CODES PRESENT TO INDICATE THAT ANY THING UNUSUAL HAD OCCURRED. I TRADED THE CAR IN FOR A DIFFERENT MAKER AND MODEL. *TR

TL*THE CONTACT OWNS A 2005 MINI COOPER S. THE CONTACT STATED THAT THE POWER STEERING FAILED INTERMITTENTLY. WHEN THE FAILURE OCCURRED IT BECAME EXTREMELY HARD TO TURN THE STEERING WHEEL. THE VEHICLE WAS NOT INSPECTED BY THE DEALER WHEN THE COMPLAINT WAS FILED. THE VIN WAS NOT AVAILABLE. THE FAILURE MILEAGE AND CURRENT MILEAGES WERE 15000.

MY 2005 MINI COOPER LOST POWERSTEERING FUNCTIONALITY DURING A SHORT INTERSTATE DRIVE (INDIANA INTERSTATE 65 FROM EXIT 64 TO EXIT 68) ON SEPTEMBER 15TH, 2010 AT 11:20AM. PARKING LOT MANEUVERING AND INTERSTATE ON-RAMP DRIVING WAS NORMAL, INTERSTATE OFF-RAMP AND SUBSEQUENT IN-TOWN DRIVING WAS WITH NO POWERSTEERING ASSIST, AND THEREFORE REQUIRED A GREAT DEAL OF FORCE TO TURN. THE POWER STEERING PUMP COOLING FAN WAS LATER DETERMINED TO HAVE COMPLETELY SEIZED, PRESUMABLY CAUSING THERMAL SHUTDOWN OF THE POWERSTEERING PUMP. MY ANALYSIS OF THE FAILURE OF THE COOLING FAN LEADS ME TO CONCLUDE THAT THE SPAL BRAND FAN USED WAS IMPROPERLY APPLIED TO THE APPLICATION. THE DESIGN AND PLACEMENT OF THE FAN INTO THE MINI CAUSES WATER AND FOREIGN MATERIAL TO POOL INTO THE BLADE HOUSING AND CAUSE CORROSION OF THE STEEL FAN MOTOR HOUSING AND EVENTUAL SEAL DAMAGE RESULTING IN MOTOR FAILURE. THIS IS OBVIOUSLY A COMMON PROBLEM WITH THESE VEHICLES: THE ONLINE MESSAGE BOARDS SHOW NUMEROUS SIMILAR FAILURES. I AM WAITING ON A NEW COOLING FAN TO ARRIVE TO FIX THE FAILURE. *TR

I JUST BOUGHT A 2005 MINI COOPER WHICH IS IN EXCELLENT CONDITION UPON BUYING. AFTER A WEEK, MY POWER STEERING WENT OUT ON A TURN THAT I COULD BARELY MAKE. I COULDN'T MAKE ANY OF THE TURNS ALL THE WAY HOME! I THOUGHT MAYBE IT'S BECAUSE THE KEY WASN'T IN THE IGNITION RIGHT. I TOOK OUT THE KEY AND RE-STARTED MY CAR. IT WORKED AND THE POWER STEERING CAME BACK ON! WELL, A COUPLE DAYS LATER THIS ISSUE HAS NOW BECOME A DANGEROUS PROBLEM. I WOULD MAKE A RIGHT TURN OFF A MAIN ROAD AND I WAS SHOCKED THAT MY CAR WOULDN'T TURN. TO MAKE THINGS EVEN WORSE, THERE WAS A SCHOOL BUS I ALMOST HIT! I HAD TO SLAM ON THE BRAKES AND TRY TO MAKE THIS IMPOSSIBLE TURN. AFTER THIS INCIDENT, THE PROBLEM HAS HAPPENED EVERY TIME I HAVE DRIVEN MY CAR. ITS BECOMING MORE FREQUENT! IT GOES OUT ALL THE TIME AND I'M NOT ABLE TO DRIVE MY CAR FOR SHORT DISTANCES. I HAVE BEEN KEEPING TRACK OF HOW MANY TIMES THIS HAS OCCURRED, I'M NOW AT 31 TIMES! MANY OF THOSE TIMES, I WAS VERY CLOSE TO HITTING MANY PEOPLE! I'M AM VERY LUCKY TO HAVE NOT BEEN IN AN ACCIDENT OR DRIVEN OFF THE ROAD!! *TR UPDATED 08/17/11*BF UPDATED 1/27/2012 *LN *TR

TL*THE CONTACT OWNS A 2005 MINI COOPER. THE CONTACT STATED THAT THE POWER ASSIST LOCKED UP AND HE LOST POWER STEERING FUNCTIONALITY. THE STEERING WHEEL WOULD BECOME EXTREMELY STIFF, MAKING IT DIFFICULT TO STEER THE VEHICLE. THE VEHICLE WAS TAKEN TO AN AUTHORIZED DEALER WHERE THE CONTACT WAS INFORMED THAT THE POWER STEERING PUMP NEEDED TO BE REPLACED. THE VEHICLE HAD NOT BEEN. THE CONTACT CALLED THE MANUFACTURER WHO OFFERED 15% OFF FOR THE REPAIR COSTS. THE CURRENT MILEAGE WAS 44,389. THE FAILURE MILEAGE WAS APPROXIMATELY 44,370.

ON SEPTEMBER 12TH I WAS MAKING MY COMMUTE HOME FROM WORK IN MY 2005 MINI COOPER S. UPON MY RETURN HOME, MY BATTERY INDICATOR LIGHT WENT ON. I PARKED AND TURNED OFF THE CAR AND THE NEXT MORNING WHEN I WENT TO RUN ERRANDS THE POWER STEERING WAS NON-EXISTENT. I HAD HE CAR TOWED TO THE BMW/MINI DEALERSHIP WHERE THEY GAVE ME A DIAGNOSIS OF A FAILING POWER STEERING PUMP AND A BAD ALTERNATOR. *TR UPDATED 09/08/11 *BF

ELECTRIC POWER STEERING PUMP & FAN FAILURE DURING LEFT TURN. SEVERAL THOUSANDS OF MINI COPPERS IN THE UK HAVE HAD SIMILAR RECALLS. IN FACT I DID FIND A RECALL FOR THE POWER STEERING PUMP FAN FOR FAULTY WIRES. I COULD FALL UNDER THE SAME RECALL, BUT BMW MINI DEALERS ARE STATING THAT IT WILL COST ME JUST FOR DIAGNOSTICS (ROUGHLY $90), THEY ALSO STATES THEY KNEW ABOUT A FILED COMPLAINT BUT SAID THEY COULDN'T EVEN LOOK AT THE FAN WITHOUT CHARGING ME. I DID FIND AFTER DAYS AND DAYS OF INTERNET SEARCHES THAT THEIR WAS A RECALL # ISSUED FOR THE FAN BUT COULD NOT LOCATE IT AGAIN. WEBSITE CITING BBC ARTICLE. WWW.NEWMINI.WORDPRESS.COM/?S=MINI+COOPER+POWER+STEERING+FAILURE. EVERYDAY I FEEL LESS AND LESS SAFE DRIVING MY MINI. THANKS. *TR

SOMETIME IN LATE SUMMER OF LAST YEAR, MY CAR BEGAN TO MAKE A "HONKING" SOUND. IT SOUNDED LIKE THE CLUTCH THAT HAD ALREADY BEEN REPLACED ON BOTH OF OUR 2005 MINI COOPERS UNDER WARRANTY (ANOTHER POSSIBLE SAFETY ISSUE?) BUT THE CLUTCHING SEEMED OK. UP UNTIL THE TIME I WAS ABLE TO GET THE CAR IN TO THE SHOP TO GET LOOKED AT, I NOTICED A PUDDLE IN THE GARAGE, AND I ALSO NOTICED IT WAS GETTING HARDER TO STEER. THE SHOP DETERMINED THAT MY STEERING RACK WAS LEAKING AND NEEDED TO BE COMPLETELY REPLACED, WHICH WE DID. NOW, JUST OVER 1 YEAR LATER, THE CAR IS ALREADY EXHIBITING THE SAME BEHAVIORS EXACTLY. SOMETHING IN THE VEHICLE IS CAUSING THE RACK TO MALFUNCTION AND REQUIRE REPLACEMENT. *TR

DURING THE FIRST INCIDENT I WAS DRIVING IN TOWN, SUDDENLY THE STEERING HAD A HARD RESISTANT MAKING IT DIFFICULT TO DO A RIGHT TURN. I HAD TO MUSCLE THE WHEEL IN ORDER TO KEEP FROM VEERING INTO ONCOMING TRAFFIC. WHEN I PULLED THE VEHICLE OVER TO DO AN UNDER THE HOOD INSPECTION AND CHECK THE STEERING FLUID LEVEL, I SAW NOTHING THAT INDICATE DAMAGE. ONCE I RESTART THE VEHICLE, IT SEEM TO CORRECT ITSELF. I THOUGH WAS IT WAS MAYBE A FLUKE. LATER ON, MY WIFE INDICATED SHE HEARD A WHINING NOISE THAT CAME FROM UNDER THE HOOD, AND ASK ME TO LOOK INTO IT. AFTER LOOKING IT OVER, I ADD SOME BELT DRESSING, BECAUSE I THOUGHT COULD HAVE BEEN THE PROBLEM. IN THE MEANTIME I MADE SEVERAL CALLS TO THE MINI DEALERSHIP IN TEMPE, AZ. THE SERVICE MANAGER STATED THIS NOISE COULD BE SEVERAL INDICATORS, SUCH AS AN AGING STEERING PUMP, A MIXTURE OF NON-RECOMMENDED FLUID IN THE RESERVOIR OR THE PUMP COULD BE GOING OUT. I DISMISSED THE MIX FLUID INDICATOR, BECAUSE THE LEVELS WERE ALWAYS WITHIN RANGE AND TO MY KNOWLEDGE WAS NEVER TAMPERED WITH OR TOPPED OFF. AS SEVERAL MONTHS WENT BY, THE VEHICLE CONTINUE TO OPERATE WITHOUT INCIDENT, OTHER THAN THE WHINING NOISE, WHICH WAS HEARD WHEN THE VEHICLE WAS STARTED FOR THE FIRST TIME OF THE DAY, OR WHILE THE VEHICLE WAS RUNNING IN IDLE. RECENTLY, MY WIFE CALL ME FROM WORK AND INDICATED WHILE SHE WAS DRIVING TO WORK FOR THE 2ND TIME, THE STEERING SEEM TO LOCK AND WAS DIFFICULT TO STEER. SHE MANAGE TO DRIVE HOME WITHOUT INJURY TO HERSELF OR OTHERS. THAT SAME DAY, WHEN I LOOKED OVER THE VEHICLE FOR LEAKS, DAMAGE OR FLUID LEVELS AND THE VEHICLE STEERING AGAIN LOCKED IN PLACE. AFTER A LITTLE RESEARCH, I FOUND THIS HAS BEEN A MAJOR SAFETY ISSUE WITH THE 2004 AND 2005 MINI COOPERS, WHICH HAS BEEN ACKNOWLEDGED BY MINI OF CANADA WHO ISSUED A RECALL. ON THE FLIP SIDE, MINI CORP IN THE US AND LOCAL DEALERS DO NOT. PLEASE ADVISE WITH A REPLY. *TR

I NOTICED A STRANGE NOISE COMING FROM THE PASSENGER SIDE WHEEL AREA. TOOK THE CAR TO THE DEALER AND POWER STEERING PUMP FAILURE WAS DIAGNOSED. *TR

MINI COOPER , POWER STEERING FROZE UP AND CAME BACK WHILE DRIVING AT HIGHWAY SPEED. *TR

I STARTED MY CAR AFTER IT HAD BEEN SITTING PARKED FOR A FEW DAYS, TO FIND THAT MY POWER STEERING HAD COMPLETELY FAILED. THE CAR WAS NEXT TO IMPOSSIBLE TO DRIVE - BUT I HAD TO MOVE IT TO AVOID IT BEING TOWED. WHILE ABLE TO MANEUVER THE CAR WITH GREAT DIFFICULTY, THIS UNPREDICTABLE FAILURE COULD HAVE BEEN CATASTROPHIC HAD I BEEN DRIVING ON THE HIGHWAY, OR IN A DENSELY POPULATED AREA REQUIRING QUICK STEERING REACTIONS. THIS SEEMS TO BE AN ENDEMIC PROBLEM. SEE THIS THREAD ON THE MINI NORTH AMERICAN MOTORING DISCUSSION PAGES: HTTP://WWW.NORTHAMERICANMOTORING.COM/FORUMS/STOCK-PROBLEMS-ISSUES/74213-THE-GREAT-POWER-STEERING-PUMP-FAILURE-PROBLEMS-THREAD-22.HTML. *TR

2005 MINI COOPER POWER STEERING GOES OUT TYPICALLY WITHIN THE 1ST HOUR OF DRIVING. THE POWER STEERING FAILURE IS NOT CONSISTENT, BUT I FIND IT HAPPENS MORE OFTEN IN HOT WEATHER WHEN I HAVE THE A/C ON "AUTO" OR FULL BLAST. (???) THE A/C ALSO AFFECTS THE RADIO RECEPTION, SO PERHAPS IT DRAINS TOO MUCH POWER. AT TIMES I NEED TO PULL OFF TO THE SIDE OF THE ROAD AND DRIVE AS IF I HAVE MANUAL STEERING. I TURN OFF THE ENGINE, LET IT REST FOR 30 SECONDS THEN START IT UP AGAIN. THE POWER STEERING GOES BACK TO NORMAL. WE HAVE NOT TAKEN THE MINI IN FOR SERVICE, AS IT IS NOT CONSISTENT AND WE DO NOT LIKE THE DEALERSHIP AS THEY SEEM TO TAKE ADVANTAGE OF OUR AUTOMOTIVE IGNORANCE AND CHARGE AN ARM AND A LEG. *TR UPDATED 08/17/11*BF UPDATED 1/27/2012 *LN *TR

PASSENGER AIR BAG SENSOR IS DEFECTIVE. THE PASSENGER AIR BAG OFF LIGHT, ILLUMINATES 3-4 SECONDS AFTER ENGINE START, ALONG WITH THE RED AIR BAG FAILURE LIGHT, ON THE MAIN SPEEDOMETER. THIS OCCURS, WHETHER THERE IS A PASSENGER IN THE SEAT, OR NOT, DUE TO THIS SAFETY DEFECT. MINI COOPER DEALERS, DENY THIS IS A PROBLEM, HOWEVER, I HAVE FOUND OVER 40 OTHER COMPLAINTS REGISTERED ON THIS EXACT DEFECT !!! MAJOR REPAIR COST FROM THE DEALER, TO CHANGE THE WHOLE BOTTOM SEAT CUSHION ASSEMBLY, WHICH INCLUDES THE DEFECTIVE AIR BAG SENSOR, THAT SEPARATES FROM THE SEAT CUSHION, AFTER A SHORT TIME! *JS

ON MULTIPLE OCCASIONS AT VARIOUS SPEEDS AND AT RANDOM TIMES, THE POWER STEERING ON MY 2005 MINI COOPER S WILL STOP WORKING. AFTER RESEARCHING THE ISSUE, THIS APPEARS TO BE A VERY COMMON PROBLEM THAT PLAGUES ALMOST EVERY MINI SOLD SINCE 2002. I WOULD ALSO LIKE TO REFERENCE NHTSA ACTION NUMBER :EA11005, AS IT APPLIES TO MY PARTICULAR ISSUE. *TR

INITIALLY WE WERE PARKED WITH A LARGE ADULT WHO WEIGHS ~200LBS SITTING IN THE PASSENGER SEAT, AND THE PASSENGER AIRBAG OFF LIGHTS ILLUMINATED. SHIFTING AROUND AND UNBUCKLING-REBUCKLING SEATBELT CAUSED THE LIGHTS TO GO OFF FOR A BIT. WE BEGAN TO DRIVE ANYWAY, THE TERRAIN WAS MOUNTAINOUS, AND EVENTUALLY THE LIGHTS WENT OFF. THAT NIGHT. IN THE FOLLOWING WEEKS AND MONTHS, IT WAS AN INTERMITTENT PROBLEM, SOMETIMES UPON GETTING SEATED AND STARTING TO DRIVE, OTHER TIMES ONCE WE WERE IN MOTION, VERY UNPREDICTABLE. THE PROBLEM SOMETIMES RESOLVED BY SHIFTING HIS WEIGHT OR FUSSING WITH THE SEATBELT TO GET THE LIGHTS OFF, BUT FOR THE PAST MONTH IT HAS BEEN A CONSTANT PROBLEM. *TR

DEAR SIR/MADAM, TODAY (9/29/2010) I SAW A NEWS ITEM, "(CNNMONEY.COM) -- THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION HAS OPENED AN INVESTIGATION INTO POSSIBLE POWER STEERING FAILURES IN MINI COOPER CARS" AND FELT COMPELLED TO ADD TO THE EXISTING COMPLAINS REGARDING THE DANGEROUSLY DEFECTIVE POWER STEERING ELECTROHYDRAULIC PUMP IN MY 2005 MINI COOPER S. WHILE DRIVING IN THE CITY, AVERAGE SPEED OF 25 TO 35 MPH, THE POWER ASSISTANCE PROVIDED BY THE POWER STEERING WENT DOWN TO ZERO, TOTALLY UNASSISTED, WITHOUT ANY PREVIOUS WARNING WHATSOEVER, MAKING THE STEERING OF THE VEHICLE EXTREMELY DIFFICULT, ALMOST IMPOSSIBLE, WHILE GOING AROUND A ROUNDABOUT (TRAFFIC CIRCLE) AT NO MORE THAN 25 MPH. CONSEQUENTIALLY I WAS UNABLE TO STEER FIRST RIGHT AND THE LEFT AROUND THE CIRCLE, MY PASSENGER SIDE FRONT WHEEL STRIKING THE RIGHT SIDE CURB AT THE POINT THAT I NEEDED TO TURN LEFT, DAMAGING BOTH THE WHEEL AND THE TIRE, AND POSSIBLY THE SUSPENSION (MACPHERSON STRUT). AND I ASK YOU, WHAT IF I HAD TO STEER TO AVOID A MOTHER PUSHING A BABY STROLLER, OR EVEN AN ERRANT DOG OR CAT AT THE MOMENT THE POWER STEERING ASSISTANCE DECIDED TO QUIT? WHAT IF THE FAILURE OCCURRED AT A HIGHER SPEED WHILE MERGING ON A FREEWAY? I CONSIDER BMW/MINI TO BE TOTALLY RESPONSIBLE FOR ANY DEATHS OR INJURIES AND PROPERTY DAMAGES RELATED TO THEIR NEGLIGENT FAILURE TO ENGINEER A PROPERLY WORKING POWER STEERING PUMP (AN KNOWN PROBLEM AS THE NEWER MODELS HAVE DONE AWAY WITH THE ELECTROHYDRAULIC PUMP IN FAVOR OF A TOTALLY ELECTRICAL ASSISTED STEERING). I ALSO URGE YOU TO LOOK INTO THE FAILURE RATE OF THE POWER STEERING FAN DUE TO ITS ABSURD LOCATION (UNDER THE CAR UNPROTECTED FROM THE DIRT, WATER, STONES,ETC. 5-6 INCHES FROM THE ROAD) AN AFTERTHOUGHT OF A SOLUTION THAT BMW/MINI USED TO RESOLVE THE PREVIOUSLY KNOWN TO THEM POWER STEERING PUMP FAILURE. MY CAR HAS 27,000 MILES, AND IS DEALER MAINTAINED SINCE NEW. I URGE YOU TO TAKE ACTION REGARDING THIS PROBLEM BEFORE SOMETHING MORE TRAGIC HAPPENS. THANK YOU. *TR

I WAS TRAVEL AT A SPEED OF 70 MPH, WHEN MY VEHICLE LOST POWER IMMEDIATELY DOWN TO 15 MPH. THE ENGINE DID NOT SHUT OFF, BUT I COULD NOT ACCELERATE ABOVE 15 MPH. I WAS ABLE TO PULL TO THE RIGHT BECAUSE THE TRAFFIC FLOW WAS SPACED SO I COULD SAFELY PULL OVER. THERE WAS NO WARNING THAT THIS MALFUNCTION WAS GOING TO HAPPEN. THE VEHICLE WAS SAID TO GONE INTO "LIMP MODE". THE ELECTRONIC BELT WAS REPLACED THAT APPARENTLY CONTROLS THE VEHICLE FUNCTION AT A COST OF $3400.00. *TR

POWER STEERING INTERMITTENTLY TURNED ON AND OFF DURING THE NORMAL OPERATION OF THE CAR THREE TIMES SINCE PURCHASE TEN MONTHS AGO. THE ACTUAL FAILURE OF THE POWER STEERING PUMP OCCURRED ON 8/16/2010 WHEN THE RELAY WITHIN THE UNIT FAILED AND WOULD NOT TURN THE PUMP OFF EVEN WHEN THE CARS ENGINE WAS OFF. THE RESULT WAS A DRAINED BATTERY AND THE CAR WAS UNABLE TO BE JUMP STARTED BECAUSE THE POWER STEERING PUMP TURNED ON AND CONTINUED TO DRAIN POWER AS SOON AS IT WAS CONNECTED TO POWER EVEN WITH THE ENGINE OFF AND THE KEY OUT OF THE IGNITION. THIS IS VERY DANGEROUS AS THE STEERING WHEEL IS NEARLY IMPOSSIBLE TO TURN WHEN THE PUMP SHUTS DOWN AND ALL THREE OCCURRENCES WERE WHEN TRAVELING AT HIGHWAY SPEEDS IN EXCESS OF 55 MPH. ALSO WHEN THE CAR IS OFF THE COOLING FAN IS ALSO OFF AND THE PUMP HEATS UP TO THE POINT WHERE THERE IS A VERY REAL RISK OF ENGINE FIRE. THE CAR WAS TOWED TO A MECHANIC TO HAVE THE POWER STEERING PUMP AND THE COOLING FAN REPLACED. THE WORK IS NOT YET COMPLETED BUT THE ESTIMATED COST IS 1,700 USD. THIS APPEARS TO BE A RECURRING PROBLEM WITH MINI COOPERS AS THE NUMBER OF FORUMS DEVOTED TO AND PERSONS REPORTING THIS ISSUE ON THE FORUMS ARE ASTOUNDING. *TR

PULLED INTO A BOOKSTORE CAME BACK 30MIN LATER, TRIED TO PULL OUT OF THE PARKING LOT AND THERE WAS NO POWER STEERING. MY WIFE ISN'T QUITE STRONG ENOUGH - SO I HAD TO DRIVE IT THE REST OF THE WAY HOME. VERY SUDDEN AND WITHOUT WARNING, COULD HAVE BEEN MUCH WORSE. POWER STEERING PUMP FAILURE. *TR

INTERMITTENT FAILURE OF POWER STEERING BEGINNING AT APPROXIMATELY 48,000 MILES, WITH INCREASING FREQUENCY AND DURATION UNTIL COMPLETE FAILURE OF POWER STEERING AT APPROXIMATELY 55,000 MILES, DESPITE FULL POWER STEERING FLUID RESERVOIR AT ALL TIMES. MINI DEALER ADVISES NEW POWER STEERING PUMP REQUIRED. *TR

THE POWER STEERING ON MY 2005 MINI COOPER S BEGAN MALFUNCTIONING ON 8-9-2010. WHILE GOING LEFT ON A MIXMASTER, THE POWER STEERING FAILED AND I THOUGHT I WAS GOING TO HIT THE SIDE OF THE BRIDGE AND PERHAPS DRIVE OFF OF THE SIDE OF THE BRIDGE. THE PASSENGER IN MY CAR HELPED ME STEER (WITH FORCE) TO THE LEFT AND DRIVE TO THE STRAIGHTAWAY. THE POWER STEERING IS INTERMITTENT, WORKING FIVE PERCENT OF THE TIME. MY CAR WAS SERVICED IN JUNE OF 2010 DUE TO A PROBLEM WITH THE TENSION BELT, WHICH CAUSED THE CAR TO HAVE A BURNING SMELL AND NO AIR CONDITIONING. THE "SERVICE ENGINE" LIGHT IS ON TEN PERCENT OF THE TIME AND THE "CHECK TIRE PRESSURE" LIGHT IS ON OFTEN, THOUGH I NO LONGER HAVE RUN-FLAT TIRES. MY CAR IS DIFFICULT TO DRIVE DUE TO THE LACK OF POWER STEERING. AT THE TIME OF THE FIRST INCIDENT, MY CAR HAD APPROXIMATELY 75,000 MILES. *TR

TL* THE CONTACT OWNS A 2005 MINI COOPER. THE CONTACT WAS DRIVING 55 MPH WHEN THE POWER STEERING FAILED WITHOUT WARNING. THE STEERING WHEEL BECAME INCREASINGLY TIGHT WHEN THE FAILURE OCCURRED. THE CONTACT REPLACED THE POWER STEERING PUMP HIMSELF. THE MANUFACTURER WAS NOT CONTACTED. THE VIN WAS NOT AVAILABLE. THE FAILURE MILEAGE WAS 88,000 AND THE CURRENT MILEAGE WAS 113,000.

THE AIRBAG WARNING LIGHT STAYS ON EVEN WHEN THERE ISN'T A PASSENGER IN THE PASSENGER SEAT. THE LIGHT INDICATES THE AIRBAG IS OFF. THE LIGHT ALSO STAYS ON IF THERE IS A PASSENGER IN THE SEAT. I AM NOT SURE IF THE AIRBAG WOULD WORK IN THE EVENT OF AN ACCIDENT. THE DEALER INDICATED I NEEDED A NEW SEAT AT MY COST. TO ME THIS IS A MANUFACTURER'S DEFECT THAT BMW SHOULD FIX. *TR

TL* THE CONTACT OWNS A 2005 MINI COOPER. THE CONTACT STATED THAT WHEN DRIVING AT LOW SPEEDS AND ATTEMPTING A TURN, THE STEERING WOULD BECOME INCREASINGLY RESISTANT. THE FAILURE WOULD ONLY OCCUR WHEN TURNING AND ONCE THE TURN WAS COMPLETE, THE STEERING WOULD RETURN TO NORMAL. THE VEHICLE WAS INSPECTED BY THE DEALER AND THEY ADVISED THAT THE STEERING PUMP MAY BE THE CAUSE OF THE FAILURE. THE VEHICLE WAS NOT REPAIRED. THE FAILURE AND CURRENT MILEAGE WAS APPROXIMATELY 76,000.

TL* THE CONTACT OWNS A 2005 MINI COOPER. WHILE DRIVING AT 35 MPH, THE POWER STEERING FAILED AND THE STEERING WHEEL BECAME EXTREMELY DIFFICULT TO TURN. THE CONTACT SHUT OFF THE ENGINE AND WHEN RESTARTING, THE POWER STEERING ASSIST DID NOT RESET ITSELF. THE CONTACT WAS ABLE TO DRIVE THE VEHICLE TO HER RESIDENCE HAVING TO UTILIZE EXTREME BODILY FORCE TO MANEUVER THE STEERING WHEEL. THE DEALER WAS CONTACTED AND THEY ADVISED HAVING THE POWER STEERING PUMP REPLACED. THE POWER STEERING PUMP WAS REPLACED AT THE CONTACT'S EXPENSE. THE FAILURE AND CURRENT MILEAGES WERE 56,500. THE VIN WAS UNAVAILABLE

2005 MINI COPPER CAUGHT ON FIRE. THE FIRE RESULTED IN A TOTAL LOSS OF THE AUTOMOBILE. *TR

ON 2005 MINI COOPER S WITH 13,000 MILES THE PASSENGER AIRBAG WARNING LIGHT CAME ON. MINI DIAGNOSED REASON AS FAILURE OF THE SENSOR IN THE PASSENGER SEAT, WHICH WOULD REQUIRE $1100 REPAIR. MINI WILL NOT FIX BECAUSE CAR IS OUT OF WARRANTY. MINI DID NOT STATE WHETHER THE AIRBAG WILL OR WILL NOT FUNCTION. PASSENGER SEAT HAS RARELY BEEN USED. MINI DENIES RESPONSIBILITY. *TR

TL* THE CONTACT OWNS A 2005 MINI COOPER S. THE CONTACT STATED THE VEHICLE WOULD NOT START. SHE CONTACTED ROADSIDE ASSISTANCE WHICH JUMP-STARTED THE VEHICLE. THE VEHICLE RESUMED NORMAL OPERATION. THE FAILURE RECURRED THE NEXT DAY AND SHE WAS ABLE TO HAVE THE VEHICLE JUMP-STARTED A SECOND TIME. THE DEALER REMOVED THE BATTERY AND THERE WAS EXCESSIVE WATER SURROUNDING THE BATTERY BOX. THE VEHICLE RESUMED NORMAL OPERATION FOR A WHILE UNTIL THE FAILURE RECURRED. THE VEHICLE WAS TOWED TO THE DEALER WHERE THE CONTACT WAS INFORMED THAT THE BATTERY WAS ENTIRELY ENCASED IN WATER AND EXHIBITED CORROSION. IN ADDITION, THE DEALER ADVISED THAT THE BST CABLES AND FUSE ASSEMBLY WOULD NEED TO BE REPLACED. THE DEALER WAS UNABLE TO PROVIDE AN EXPLANATION FOR THE EXCESSIVE WATER IN THE BATTERY. THE CONTACT WAS CONCERNED THAT IF THE VEHICLE WAS REPAIRED, THE FAILURE WOULD ONLY CONTINUE TO RECUR. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WOULD NOT PROVIDE ANY ASSISTANCE. THE CURRENT AND FAILURE MILEAGES WERE 28,326.

TL*THE CONTACT OWNS A 2005 MINI COOPER. THE CONTACT STATED WHILE DRIVING VARIOUS SPEEDS, THERE WAS A LOSS OF POWER STEERING. THE CONTACT WAS ABLE TO CONTINUE DRIVING. THE VEHICLE WAS TAKEN TO BOTH THE DEALER AND INDEPENDENT MECHANIC AND THEY INFORMED THE CONTACT THAT THE ELECTRIC POWER STEERING PUMP WOULD NEED TO BE REPLACED. THE VEHICLE WAS NOT REPAIRED. THE FAILURE MILEAGE WAS 56,000. THE VIN WAS UNAVAILABLE. UPDATED 2/23/11 *CN

I HAVE A 2005 MINI COOPER. THE AIRBAG SENSOR IN THE PASSENGER SEAT FAILED AROUND 66,000 MILES. I WAS TOLD THAT THE PASSENGER SEAT AIRBAG AND BOTH DOOR SENSORS HAD TO BE REPLACED ALONG WITH THE BATTERY CABLE AT A COST OF $4000.00. SOUNDS AS IF BMW STILL HAS REAL ELECTRICAL PROBLEMS IN THEIR CARS AND ARE STICKING IT TO CONSUMERS TO FIX IT INSTEAD OF FIXING THESE PROBLEMS THEMSELVES. THE CAR HAS NEVER BEEN INVOLVED IN ANY ACCIDENT. *TR

TRANSAXLE ON THE MINI COOPER FAILED. UNIT CONTAINS SEALED BEARINGS (SO I'M TOLD), THAT ARE NOT SERVICEABLE. THEREFORE, I HAD TO BUY A COMPLETE NEW UNIT AT A COST OF $3,000 ()INCLUDED $900 LABOR). I UNDERSTAND THIS IS NOT AN UNCOMMON FAILURE FOR MINIS, AND THAT MINI AND BMW ARE REFUSING TO WORK WITH CONSUMERS TO ADDRESS THIS PROBLEM. HOWEVER, THEY HAVE APPARENTLY CHANGED THE DESIGN, RECOGNIZING THE POOR DESIGN OF THE ORIGINAL UNIT. *TR

THE POWER STEERING PUMP IN MY 2005 MINI COOPER S CONVERTIBLE INTERMITTENTLY STOPS WORKING 1 TO 5 TIMES PER WEEK. THERE DOES NOT APPEAR TO BE ANY PATTERN TO IT, IT HAS HAPPENED AT COLD START, AFTER WARM START, HOT/COLD/WET/DRY WEATHER, LEVEL/SLOPED PARKING, WHILE DRIVING & STATIONARY, ETC. I'VE LEARNED TO LIVE WITH IT AS AN ANNOYANCE, UNTIL I RECENTLY HAD A VERY FRIGHTENING FAILURE THAT VERY NEARLY HAD *FATAL* CONSEQUENCES. I WAS DRIVING ROUGHLY 25 MPH, THE POSTED SPEED LIMIT, IN A RESIDENTIAL AREA, WHEN A YOUNG CHILD (I ESTIMATE 4-5 YEARS OLD) RAN INTO THE STREET FROM BETWEEN TWO PARKED CARS 5 OR 6 CAR LENGTHS IN FRONT OF ME. I SLAMMED ON THE BRAKES (ABS FULLY ENGAGED) AND ATTEMPTED TO SWERVE INTO THE ONCOMING [EMPTY] LANE AT AVOID... BUT MY STEERING PUMP WAS OUT AND I COULD NOT ALTER MY COURSE SUFFICIENTLY. I CAME TO A STOP WITH THE CHILD BARELY THREE FEET OFF MY FRONT BUMPER! SO NO DAMAGE OR INJURY, BUT... THIS FAILURE COULD EASILY HAVE BEEN MUCH, MUCH WORSE! *TR

BOTH MY PASSENGER AIRBAG WARNING LIGHT AND AIRBAG WARNING LAMP IN THE INSTRUMENT PANEL IS ILLUMINATED DEACTIVATING AIRBAG DEPLOYMENT WHEN AN ADULT IS SITTING IN THE PASSENGER SEAT AND REMAINS ON WHEN PASSENGER SEAT IS VACANT WHILE DRIVING. THERE IS ALSO 2 TECHNICAL SERVICE BULLETINS (TSB) I'M AWARE OF RELATING TO THIS MALFUNCTION: TSB: SI M-65-02-06 AIRBAG WARNING ILLUMINATED, FC55 FOR VEHICLES PRODUCED FROM AUGUST 31, 2005 - APRIL 25, 2006. NHTSA 10026024 (MY VEHICLE WAS PRODUCED IN AUGUST 2005 AS INDICATED ON MY DRIVER DOOR PANEL). TSB: 720106 AIRBAG WARNING LAMP FOR OC3 SEAT MAT FAULT, AIRBAG WARNING LAMP ILLUMINATES TOGETHER WITH THE PASSENGER AIRBAG STATUS LAMP. NHTSA 10019981. I SPOKE WITH 2 SERVICE MANAGERS AT MINI INDICATING FAULTY DETECTION MAT, PARTS WERE IN STOCK AND WILL NOT BE COVERED UNDER WARRANTY FOR REPAIR OR REPLACEMENT ESTIMATED AT APPROXIMATELY $1000.00. MY ONLY RECOURSE IS TO REPAIR IT, FEELING UNCOMFORTABLE DRIVING MY VEHICLE OR TRANSPORTING PASSENGERS IN THE EVENT THE AIRBAGS WILL NOT DEPLOY. IN ADDITION, BMW OF NORTH AMERICA, LLC EXTENDED THE WARRANTY ON PASSENGER AIRBAG DETECTION MATS TO 10 YRS/UNLIMITED MILEAGE FOR SPECIFIC BMW MODELS RANGING FROM MY04 THROUGH MY06, WHO OWNS MINI OF NORTH AMERICA. I'VE READ SEVERAL FORUMS RELATING TO THIS ISSUE, ONE OF WHICH STATES MINI DID EXTEND THE WARRANTY ON MODELS PRIOR TO MY05, BUT PROBLEM HASN'T BEEN RESOLVED IN MODEL YEARS THEREAFTER AS MENTIONED IN MY COMPLAINT AND OTHER NHTSA BULLETINS. I CONTACTED MINI OF NORTH AMERICA WITH NO POSITIVE RESPONSE. *TR

2005 MINI COOPER S WITH 42K MILES. DRIVER SIDE DOOR FAILS TO OPEN FROM THE INSIDE. I CAN ONLY EXIT THE CAR BY USING THE OUTSIDE DOOR HANDLE WHICH REQUIRES OPENING THE WINDOW. IF AN EMERGENCY OCCURS WHICH REQUIRES RAPID EXIT FROM THE CAR AND THERE WAS A FAILURE OF THE ELECTRICAL SYSTEM I WOULD NOT BE ABLE TO EXIT VEHICLE. 42K MILES IS FAIRLY LOW AND THE CAR HAS NOT BEEN ABUSED. MINI COOPER CLAIMS THIS IS 'NORMAL' WEAR. IT IS NOT 'NORMAL' WEAR AND IS INDEED A MANUFACTURERS DEFECT WHICH APPARENTLY HAPPENS TO MANY MINI COOPERS. *TR

MY POWER STEERING COMPLETELY WENT OUT IN MY 2005 MINI COOPER WHILE COMING AROUND A TURN ON A BUSY HIGHWAY IN A MAJOR CITY. I WAS AWAY FROM HOME AND SCARED TO DEATH. AFTER DOING A LITTLE RESEARCH THIS APPEARS TO BE A COMMON PROBLEM WITH MINI MODELS 01-06. THIS PART NEEDS TO BE RECALLED ASAP BEFORE SOMEONE IS KILLED. CURRENTLY I AM FIGHTING WITH THE MINI CUSTOMER RELATIONS DEPARTMENT BECAUSE MY "CASEWORKER" IS ALSO MYSTERIOUSLY UNAVAILABLE AND THEY WILL NOT LET ME SPEAK TO ANYONE ELSE BECAUSE MY "CASEWORKER" HAS ALL THE DETAILS ABOUT THE CAR'S DEFECT EVENTHOUGH THEY WORK OUT OF A CALL CENTER AND ALL THE NOTES ARE UPLOADED IN THE COMPUTER AND VISIBLE FOR ALL "CASEWORKERS". *TR

THE AIRBAG LIGHT IS ON AND THE PASSENGER SEAT AIRBAG DETECTION LIGHT SAYS OFF EVEN WHEN AN ADULT IS SITTING IN THE SEAT. I TOOK THE CAR IN AND THE AIRBAG CODE READ WAS A 71 INDICATING THAT THE OC3 MAT IN THE PASSENGER SEAT IS FAULTING. THE DEALERSHIP IS TELLING ME THAT THE AIRBAG MAY OR MAY NOT WORK EVEN IF A PASSENGER IS IN THE SEAT. I WAS TOLD BY THE DEALERSHIP THAT IT WOULD COST UP TO 3000.00 FOR MY CAR TO REPLACE THE OC3 MAT!!! NO SAFETY RECALL WARRANTY AVAILABLE FOR THIS MODEL YEAR AS THERE IS ON OTHERS! *TR

2005 MINI COOPER CONVERTIBLE DOES NOT TURN OFF EVEN AFTER KEY IS REMOVED. SAFETY ISSUE POTENTIAL WITH THEIR DRIVE-BY-WIRE IGNITION? DEALER SAID IT IS CAUSED BY WIRE HARNESS AND/OR REAR TAIL LIGHT CONNECTION. CAR MAY BE UNSAFE? *TR

I WAS ON MY REGULAR COMMUTE THROUGH CITY STREETS. AFTER ABOUT 10 MILES OF DRIVING I WAS GOING ABOUT 40MPH ON A FAIRLY STRAIGHT ROAD. ON THE NEXT LIGHT CURVE I NOTICED THE WHEEL WAS MORE DIFFICULT TO TURN. I SLOWED DOWN TO TURN INTO A SIDE ROAD AND THAT'S WHEN I REALIZED THE POWER STEERING MUST HAVE BEEN OUT. I CHECKED THE RESERVOIR AND IT WAS FULL. I CALLED THE DEALER AND THEY SAID THEY WERE AWARE OF MANY COMPLAINTS OF POWER STEERING GOING OUT. THEY ALSO MENTIONED THAT THERE IS NO RECALL FOR THE POWER STEERING. DEALER NOTIFIED ME THERE WOULD BE A $100 CHARGE FOR DIAGNOSTICS. IF ITS FOUND TO BE THE POWER STEERING FAN IT WOULD COST $300 PLUS LABOR. IF IT'S THE PUMP IT WOULD BE $800 PLUS LABOR. WARRANTY EXPIRED 5 MONTHS AGO. APPARENTLY MINI DOES NOT WANT TO HAVE TO PAY TO FIX A PROBLEM THAT NUMEROUS MINI OWNERS ARE HAVING. THIS IS A SAFETY ISSUE! HAVING THE POWER STEERING GO OUT MID-DRIVE CAN EASILY CAUSE AN ACCIDENT! *TR

UNEXPECTED AND PERMANENT POWER STEERING FAILURE. *KB

TL* THE CONTACT OWNS A 2005 MINI COOPER. THE CONTACT STATED THAT WHILE DRIVING APPROXIMATELY 45 MPH, THE FRONT PASSENGER AIR BAG OFF INDICATOR ILLUMINATED WITH AN OCCUPANT POSITIONED IN THE SEAT. IN ADDITION, THE FAILURE WOULD OCCUR EVEN WHEN AN OCCUPANT WAS NOT PRESENT IN THE FRONT SEAT. THE ILLUMINATION NO LONGER CONTINUED WHEN THE ENGINE WAS TURNED OFF. THE VEHICLE WAS TAKEN TO AN AUTHORIZED DEALER, WHO STATED THE PASSENGER SEAT MAT SENSOR WOULD NEED TO BE REPLACED. THE VEHICLE HAD NOT BEEN REPAIRED. THE MANUFACTURER WAS NOTIFIED OF THE PROBLEM. THE APPROXIMATE FAILURE MILEAGE WAS 25,000.

I OWN A 05 MINI COOPER S THAT HAS POWER STEERING PROBLEMS..THE STEERING WENT OUT WHEN DRIVING 75MPH..SINCE THEN THE POWER STEERING MOTOR WILL NOT SHUT OFF ON ITS OWN AND THE BATTERY MUST BE DISCONNECTED WHICH IS ANOTHER ISSUE ALTOGETHER...I AM NOT ABLE TO DRIVE THIS VEHICLE AS IT IS NOT SAFE...IT STARTED AS AN INTEMITTENT PROBLEM AND NOW IS A CONSTANT PROBLEM...I ONLY OWN THIS VEHICLE AS WAS HOPING MINI WOULD STEP UP AND TAKE CARE OF THIS... *TT

POWER STEERING ASSIST FAILS REPEATEDLY. SOLUTION HAS BEEN TO STOP CAR AND RESTARTED ENGINE; SEEMS TO RESET PUMP ELECTRONICS. THIS INTERMITTENT POWER STEERING FAILURE HAS HAPPENED DOZENS OF TIMES IN THE 3 YEARS WE'VE OWNED THE CAR AND CAN BE VERY DANGEROUS IF DRIVER IS NOT AWARE OF THE CHANGE IN STEERING ABILITY. WE'RE GOING TO HAVE TO REPLACE THE PUMP I BELIEVE AND WITH ALL THE OTHER COMPLAINTS ABOUT THIS PROBLEM I FEEL MINI/BMW SHOULD VIEW THIS AS A MANUFACTURER DEFECT AND COVER UNDER WARRANTY -- IT IS CLEARLY A DANGEROUS PART AND POOR DESIGN. *TR

ELECTRIC FAN THAT COOLS THE POWER STEERING PUMP ON OUR 2005 MINI COOPER FAILED. OUR MECHANIC SAYS HAD WE DRIVEN VERY FAR, OUR POWER STEERING PUMP WOULD HAVE FAILED. HE TELLS US THIS IS A COMMON PROBLEM WITH MINIS, AND A FULL 50% OF HIS MINI CUSTOMERS HAVE EXPERIENCE FAN FAILURE, PUMP FAILURE, OR BOTH. *TR