2006 MINI Cooper Complaint Log

70K AND ON MY THIRD SERPENTINE BELT ,BATTERY LIGHT GOES ON AND INCREDIBLY HARD TO STEER LEFT OR RIGHT AND CAR DIES. WHEN THE BELT SHREDS OR BREAKS THE CAR DIES AND ONLY MOVES AT BELOW 5 MPH ,ONLY WARNING IS A BATTERY LIGHT ... PEOPLE BUYING THIS CAR FOR TEENS DONT ! HAD TO REPLACE TRANSMISSION AT 30 K ... IF YOU BUY THIS CAR USED WITH LOW MILEAGE GET THE TRANSMISSION CHECKED . NOTE : TRANSMISSION CHECK REQUIRES THE ENGINE TO BE PULLED OUT AND WILL COST $500.00 OIL PAN CONSTANTLY LEAKS. IF VW IS BAD BMW /MINI COOPER IS WORSE AND GETTING AWAY WITH HIGHWAY ROBBERY . SEAT BELTS ALWAYS GETTING TWISTED AND REQUIRE THE NEED TO PUL OFF ROAD TO FIX BECAUSE THEY TIGHTEN AND WON'T RELEASE TENSION. LOOK INTO DRIVER AND PASSENGER LEATHER SEATS FALLING APART ... WAITING FOR SIDE IMPACT AIR BAG TO GO OFF BECAUSE OF POOR MATERIAL AND TEXTILE USE . IF IT'S RUBBER IT ROTS OR RATS EAT IT BECAUSE THEY CAN ENTER CAR ENGINE WITHOUT ISSUE. WITH THE CLASS ACTION SUITS ,SERVICE WARNINGS,AND RECALLS IT LOOKS LIKE MINI COOPER NEEDS A HARDER MORE INTENSE INVESTIGATION . IN REGARDS TO EXACT DATES I HAVE REPAIR BILLS ,CLASS ACTION INFO. REGARDING TRANSMISSION ...WORTHLESS AS I HAVE WRONG YEAR ,ALSO CAR IS ON A CONSTANT CYCLE OF MALFUNCTION ... BRAKE LIGHTS AND HEAD LIGHTS CONSTANTLY NEED BULB REPLACEMENT . PLEASE MAKE MINI COOPER RESPONSIBLE.

POWER STEERING FAILURE WHILE DRIVING. STEERING BECAME VERY DIFFICULT. PERSISTED UNTIL CAR WAS TURNED OFF FOR SEVERAL MINUTES. HAPPENED SPORADICALLY AFTERWARD, THEN DISAPPEARED FOR A COUPLE MONTHS. ISSUE RETURNED AND NOW AFFECTS THE CAR MOST OF THE TIME WHILE DRIVING. WILL HAPPEN UPON STARTING THE CAR, OR WHILE DRIVING. *TR

MY POWER STEERING PUMP IS FAILING. VERY LOUD AND WHINY. READY TO FAIL AT ANY SECOND. *TR

THE O2 SENSOR FAILED ON MY CAR. MINI ISSUED AN EXTENDED WARRANTY ON 2006 MODELS BUT MY VIN WAS NOT INCLUDED. THIS IS RIDICULOUS THAT I HAVE THE EXACT SAME ISSUE BUT MY VIN IS NOT INCLUDED. *TR

WHEN I STARTED MY VEHICLE, 2006 MINI COOPER, THE PASSENGER AIRBAG WARNING LIGHTS CAME ON FOR NO APPARENT REASON THERE WAS NO ONE IN THE PASSENGER SEAT AT THE TIME. THERE WAS AN AUGUST, 2008 BMW RECALL ON 150,000 2002-2006 MINI COOPER'S FOR THIS SAME PASSENGER LIGHT AIRBAG ISSUE. BMW EXTENDED THE WARRANTY TO 10 YEARS ON ALL OF THESE RECAILED VEHICLES BY VIN#. I HAD THIS DIAGNOSED BY A BMW SERVICE CENTER & A FAULTY PASSENGER SENSOR PAD IN THE PASSENGER SEAT IS CAUSING THE ISSUE. THE SENSOR PAD IS ATTACHED TO THE BOTTOM OF THE PASSENGER SEAT SO BOTH ITEMS HAVE TO BE REPLACED WHICH WILL COST APPROX.$1,200. I SPOKE TO MINI USA & MY VIN# WAS NOT ON THE 2008 RECALL. I THEN ASKED MINI USA HOW DO I GET MY VIN# ON THE RECALL LIST & WAS TO TOLD TO GO TO THIS WEBSITE & FILE A COMPLAINT. AFTER YOUR INVESTIGATION, MINI USA TOLD ME THAT YOU CAN HAVE MY VEHICLE VIN# ADDED TO THE AUGUST, 2008 RECALL. MINI USA WAS ALSO UNABLE TO TELL ME IF MY PASSENGER SEAT AIRBAG WILL PROPERLY DEPLOY IN THE EVENT OF A ACCIDENT. I CONSIDER THIS AN EXTREMELY SERIOUS SAFETY ISSUE (POSSIBLE DEATH) IF THE AIRBAG DOES NOT PROPERLY DEPLOY BECAUSE OF A FAULTY PASSENGER SEAT SENSOR PAD! PLEASE HELP.....THANKS *TR

TL* THE CONTACT OWNS A 2006 MINI COOPER. THE CONTACT STATED THAT THE AIR BAG WARNING LIGHT ILLUMINATED. THE VEHICLE WAS TAKEN TO THE LOCAL MECHANIC WHO PERFORMED A DIAGNOSTIC WHICH LOCATED A FAILURE CODE AT THE FRONT PASSENGER SEAT SENSOR. THE PASSENGER FRONT SEAT NEEDED TO BE REPLACED. THE VEHICLE WAS NOT REPAIRED. THE FAILURE MILEAGE WAS 65,000 AND THE CURRENT MILEAGE WAS 89,200.

2006 MINI COOPER S PASSENGER AIRBAG LIGHT (ABOVE REARVIEW MIRROR) IS ILLUMINATED CONSTANTLY (SEAT OCCUPIED OR NOT). LOCAL MINI COOPER DEALERSHIP SAYS THE PROBLEM IS THE SENSOR PAD, WHICH IS WOVEN INTO THE SEAT BOTTOM, AND THE WHOLE SEAT BOTTOM MUST BE REPLACED AT A COST OF $1650. DEALER SERVICE MANAGER SAYS THAT MINI USA WILL NOT HELP WITH THIS, AS THE CAR IS OUT OF WARRANTY AND HAS 100K MILES. I USED AN SRS SCAN TOOL TO CONFIRM THAT CODE 71 (SEAT OCCUPANCY SENSOR II) IS SET AND COMES RIGHT BACK AFTER CLEARING IT. QUICK SEARCH THROUGH NHTSA COMPLAINTS AND ONLINE MINI ENTHUSIAST FORUMS SHOWS THIS IS A FREQUENT PROBLEM, ESPECIALLY IN THE 2005-06 MODEL YEARS. CLEARLY A SEVERE SAFETY DEFECT WHICH MINI USA (BMW) SHOULD HAVE ADDRESSED. NO ONE CAN TELL ME IF THE PASSENGER AIRBAG WILL DEPLOY IN A CRASH OR NOT. I ALSO FIND IT INTERESTING THE WIDE RANGE OF REPAIR COSTS THAT OTHERS WHO HAVE POSTED HERE WERE QUOTED BY THEIR LOCAL MINI DEALERS (SEEMS LIKE ANYWHERE FROM $1000 - $2000). SOMETHING IS NOT RIGHT WITH THAT. *TR

POWER STEERING WENT OUT MAKING VEHICLE VERY DIFFICULT TO CONTROL. WAS TOLD BY MINI DEALER $1500 TO REPLACE. *TR

I HAD TO GO AHEAD AND HAVE THE AIR BAG SENSORS IN THE PASSENGER SEAT REPLACED LAST WEEK, BECAUSE I WILL HAVE A PASSENGER ON A TRIP TO UTAH SOON. WHEN I COMPLAINED TO ONE OF THE SERVICE PEOPLE, THAT THE PASSENGER SEAT WAS RARELY USED, HE STARTED BLOVIATING AS TO HOW HEAT CAN BREAK DOWN THE MATERIALS IN THE SENSORS. *TR

TL* THE CONTACT OWNS A 2006 MINI COOPER. THE CONTACT STATED THAT WHILE DRIVING 65 MPH, THE VEHICLE DOWNSHIFTED AND STALLED. THE CONTACT HAD TO PULL TO THE SIDE OF THE ROAD AND SHIFT INTO MANUAL MODE TO SHIFT THE GEARS UP AND DOWN. THE CONTACT ALSO STATED THAT THE BATTERY LIGHT ILLUMINATED WHILE THE VEHICLE WAS PARKED. THE CONTACT ALSO STATED THAT THE ENGINE MALFUNCTIONED DUE TO THE COOLING SYSTEM EMITTING SMOKE FROM THE ENGINE AND CORROSION ON THE ENGINE ITSELF. THE CONTACT DID NOT TAKE THE VEHICLE TO A DEALER FOR A DIAGNOSTIC TEST. THE FAILURE MILEAGE WAS 74,000.

I HEARD A WHIRRING SOUND AND A LIGHT CAME ON THE DASHBOARD. TOOK IT TO THE MINI COOPER DEALERSHIP BOB SMITH WHERE I HAD THE CAR SERVICED AND WHERE IT WAS ORIGINALLY PURCHASED. THE TECHNICIAN DID NOT PULL ANY CODES, JUST TOOK THE CAR FOR A RIDE. HE PRONOUNCED THAT THE TRANSMISSION HAD TO BE REPLACED AS IT IS A SEALED TRANSMISSION AS IT IS A "SEALED" TRANSMISSION AND THEREFORE IT COULD NOT BE REPAIRED AT A COST OF $9000! HE THEN TOOK OFF $1500 FOR A COST OF $7500! GOOGLED THIS PROBLEM TO FIND OUT THAT SO MANY MINI'S HAD THIS PROBLEM THAT A CLASS ACTION LAWSUIT HAD BEEN FILED. CONTACTED MINIUSA WHO SCOFFED AT THE PROBLEM AND OFFERED NO HELP OR RELIEF. HOPING THAT MINI WILL BE FORCED TO DEAL WITH THIS ISSUE AND THAT A RECALL WILL BE INITIATED BEFORE ANYONE IS SERIOUSLY INJURED. *TR

WHILE DRIVING THE VEHICLE, AT ANY SPEED, THE AUTOMATIC POWER TRAIN DOES NOT SHIFT GEARS PROPERLY. IT WILL SHIFT UP, AND DOWN, AND NOT ENGAGE THE PROPER GEAR. THE VEHICLE TRANSMISSION WILL "WIND-UP", THEN JUMP INTO A GEAR. AT TIMES, THE VEHICLE WILL NOT SHIFT OUT OF FIRST GEAR. *TR

DRIVING AT 55 MPH ON PARKWAY. ENGINE MADE CLUNK AND LOST POWER. PULLED CAR ONTO SHOULDER AND STARTED WITH WHITE SMOKE UNDER HOOD, PROGRESSING TO BLACK SMOKE AND FLAME. EXITED CAR AT FIRST SIGN OF SMOKE. CAR BURNED IN ENGINE COMPARTMENT, MOVED INTO CABIN. FINAL DAMAGE WAS A TOTAL. FRONT END OF CAR IS COMPLETELY BURNED. FIRE IN CABIN MELTED DASHBOARD, MOVED ACROSS AND MELTED CEILING, AND MELTED FRONT WINDSHIELD. TOOK PICTURES OF FINAL DAMAGES AT GARAGE FOLLOWING INCIDENT. *TR

WITHOUT ANY WARRANTING THE POWER STEERING WHEEL WAS HARD TO TURN. THE CAR BECAME VERY DIFFICULT TO DRIVE I JUST HAD DIAGNOSED TEST FOUR DAYS AGO ON THE CAR THE ONLY PROBLEM NOTED WAS THE THERMOSTAT. KNOW I CAN NOT DRIVE THE CAR. *TR

THE AIRBAGS LIGHT CAME ON FOR NO REASON AT ALL. DOING RESEARCH I FOUND THERE'S A LOT OF PEOPLE WITH THE SAME PROBLEM! AND APPARENTLY MINI USA IS NOT TAKING RESPONSIBILITY FOR ANY OF IT. *TR

TL* THE CONTACT OWNS A 2006 MINI COOPER. THE CONTACT WAS DRIVING 50 MPH AND LOST CONTROL OF THE VEHICLE. THE VEHICLE STARTED TO SWAY FROM SIDE TO SIDE AND CAUSED THE CONTACT TO CRASH INTO A UTILITY POLE. THE VEHICLE WAS DESTROYED AND HAD NOT BEEN INSPECTED FOR THE CAUSE OF THE FAILURE. THE CONTACT SUSTAINED SLIGHT INJURIES IN THE CRASH. THE FAILURE AND THE CURRENT MILEAGE WAS 70,000. .. UPDATED 02-07-13 *BF UPDATED 02/13/2013 *JS

2006 MINI-COOPER. CONSUMER WRITES IN REGARDS TO TRANSMISSION FAILURE. *SMD THE DEALER WAS UNABLE TO DUPLICATE THE FAILURE, BUT THEY DID STATE THE TRANSMISSION WAS IN THE PROCESS OF FAILING. THE CONSUMER STATED WHEN HE ATTEMPTED TO GET ON THE FREEWAY, THE VEHICLE WOULD NOT SHIFT INTO 2ND GEAR. THE MANUFACTURER OFFERED TO PAY 1/2 OF THE COST ON THE BILL, WHICH TOTALED $8,000. *JB

THE AIR BAG WARNING LIGHT CAME ON. WE CONTACTED THE DEALER WHERE WE PURCHASED THE CAR AND THEY SAID THERE WAS NOTHING THEY COULD DO BECAUSE IT WAS NOT UNDER WARRANTY AND THERE WAS NO RECALL. THEY HAD REPAIRED THIS PREVIOUSLY UNDER WARRANTY. WE THEN CONTACTED MINI USA AND THEY SAID OUR VIN# WAS NOT LISTED FOR A RECALL. I MENTIONED THERE ARE MINI COOPERS IN FORUMS ALL OVER THE INTERNET WITH AIRBAG LIGHT ISSUES. *TR

THE AIR BAG WARNING LIGHT CAME ON FOR THE PASSENGER SIDE SEAT. THE BMW DEALER SAID THAT THE SEAT SENSOR WAS FAULTY. *TR

TL* THE CONTACT OWNS A 2006 MINI COOPER S. THE CONTACT STATED THAT WHILE DRIVING 20 MPH, THE AIR BAG WARNING LIGHT ILLUMINATED. THE VEHICLE WAS TAKEN TO THE DEALER FOR INSPECTION WHERE THEY STATED THAT THE PASSENGER'S SEAT MAT NEEDED TO BE REPLACED. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOT NOTIFIED. THE FAILURE MILEAGE WAS 45,000.

AIR BAG SYSTEM DIAGNOSIS RETURNED FAULT CODE 71. TECH CHECK ON SRS SYSTEM FOUND PASSENGER SEAT OCCUPANCY DETECTOR FAULT. PASSENGER AIR BAG SYSTEM IS DISABLED AS A RESULT. ESTIMATED REPAIR COST IS $1200. INTERNET SEARCHES FOUND THIS IS A VERY COMMON PROBLEM WITH MINI COOPER'S AND MINI REFUSES TO COVER WHEN OUT OF WARRANTY. *TR

THE PASSENGER SEAT OCCUPANCY SENSOR HAS GONE BAD ACCORDING TO THE DIAGNOSE FROM THE DEALER. I'M TOLD THAT THIS WILL EITHER MAKE THE AIR BAG DEPLOY AT FULL FORCE OR POSSIBLY NOT AT ALL. THERE SEEMS THAT THIS IS A VERY COMMON OCCURRENCE ON BOTH BMW AND MINI'S. BMW HAS ADDRESSED THE PROBLEM, MINI HAS NOT. I HAVE A CAR WITH AN UNPREDICTABLE AIR BAG DEPLOYMENT AND THE DEALER IS TELLING ME THAT IT IS A 1000 TO MAKE THE CAR SAFE TO PUT MY FAMILY IN. THIS SEEMS LIKE DENIAL OF A PROBLEM. *TR

CAR LOST POWER AND STARTED RUNNING AND IDLING VERY ROUGH. SERVICE SHOP DISCOVERED THAT THE NYLON CAPS FOR THE HYDRAULIC LASH VALVES HAD DETERIORATED AND CRACKED AND IN SOME CASES HAD FALLEN COMPLETELY OFF HAVING A NEGATIVE AFFECT ON THE ENGINE COMPRESSION. THE ORIGINAL CAPS ARE BRIGHT YELLOW AND AFTER USE AND HEAT THEY TURN ORANGE/BROWN. INTERNET RESEARCH SHOWS SOME MINI'S HAVE STEEL LASH CAPS. SEEMS THAT A ENGINE COMPONENT SUSCEPTIBLE TO HEAT DAMAGE SHOULD NOT BE MADE OF NYLON/PLASTIC. THE CAR HAS A TOTAL OF 18 OF THESE LASH CAPS AND AT LEAST 12 ARE CLEARLY CRACKED. THERE ARE CURRENTLY NO REPLACEMENT PARTS AVAILABLE FROM MINI OR IN THE AFTERMARKET. MINI'S ONLY SOLUTION IS TO REPLACE THE ENTIRE ROCKER ARMS WHICH IS A VERY COSTLY REPAIR WHEN THE ONLY FAILURE IS SMALL NYLON CAPS. *TR

DRIVING ON THE FREEWAY WHEN I FELT THE CAR JERK FORWARD AND THEN IT FELT AS IF THE AUTOMATIC TRANSMISSION WAS SLIPPING IN AND OUT OF GEARS. MANAGED TO PULL OFF THE FREEWAY AND DRIVE TO THE LOCAL MINI DEALERSHIP, WHICH WAS LUCKILY ABOUT A MILE DOWN THE ROAD. WAS TOLD BY DEALERSHIP THE PROBLEM WAS TRANSMISSION FAILURE AND WAS QUOTED $9,000 REPAIR COST. WHEN I ASKED THE MECHANIC WHY THE TRANSMISSION HAD FAILED THIS EARLY, TOLD ME THEY HAD NO IDEA. HOWEVER, WHEN I ASKED ANOTHER EMPLOYEE HOW MANY OTHER CARS HAD THEY SEEN WITH TRANSMISSION PROBLEMS, HE RELUCTANTLY ADMITTED "QUITE A FEW". *TR

TL* THE CONTACT OWNS A 2006 MINI COOPER. THE CONTACT STATED THAT WHILE DRIVING 35 MPH, THE POWER STEERING FAILED AS THE CHECK ENGINE WARNING LIGHT ILLUMINATED. THE CONTACT WAS EXITING THE HIGHWAY WHEN THE POWER STEERING FAILED AND CAUSED AND INCREASE IN STEERING EFFORTS. THE VEHICLE WAS TAKEN TO AN AUTHORIZED DEALER FOR INSPECTION WHERE THEY ADVISED THE CONTACT THAT THE POWER STEERING PUMP NEEDED TO BE REPLACED. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOTIFIED AND ADVISED THAT THERE WERE NO RECALLS FOR THE VEHICLE AND THAT THEY WERE AWARE OF THE FAILURE THAT EXISTED WITH THE STEERING. THE FAILURE MILEAGE WAS 100,000.

THE SEAT SENSOR IS FAULTY. IT READS THAT SOMEONE UNDER 30LBS IS IN IT (DISABLING THE AIRBAG) THE DASH LIGHT VERIFIES IT IS OFF. THIS PROBLEM IS INTERMITTENT TO THIS DAY. SO IF A CRASH OCCURS THE SENSOR WON'T READ CORRECTLY IF ANYONE IS IN THE SEAT OR NOT, THE AIRBAG MAY NOT DEPLOY AND IF IT DOES WILL DO SO POSSIBLY WITH TOO MUCH FORCE. *TR

WAS DRIVING ON HIGHWAY AT APP. 60 MPH, DOWNSHIFTED TO PASS AND EML LIGHT CAME ON AND POWER TO CAR WAS GREATLY REDUCED. FOUND OUT IT WAS A BROKEN CRANKSHAFT VIBRATION DAMPENER. NOTIFIED DEALER AND WAS TOLD THAT THERE WAS NO WARRANTY OR RECALL ON THIS ISSUE. QUITE EXPENSIVE TO REPAIR ALSO. CONTACTED MINI OF USA AND WAS TOLD THAT IT HAD TO BE DIAGNOSED BY A MINI DEALER FOR ANY POSSIBLE ASSISTANCE, BUT WAS NOT GUARANTEED THAT ASSISTANCE WOULD BE PROVIDED. *TR

TL* THE CONTACT OWNS A 2006 MINI COOPER S. THE CONTACT STATED THAT THE FRONT PASSENGER'S AIR BAG WARNING LIGHT ON THE REARVIEW MIRROR WAS ILLUMINATED. THE VEHICLE WAS TAKEN TO THE DEALER WHERE THE TECHNICIAN DIAGNOSED THAT THE SEAT PAD SENSOR NEEDED TO BE REPLACED. NO REPAIRS WERE PERFORMED TO THE VEHICLE. THE MANUFACTURE WAS MADE AWARE OF THE FAILURE. THE FAILURE MILEAGE WAS 54,000 AND THE CURRENT MILE WAS 67,000.

PASSENGER SEAT AIR BAG SENSOR WARNING LIGHT IS LIGHTING UP. THIS HAS BEEN DIAGNOSED AS A RESULT OF A DEFECTIVE PASSENGER SEAT AIR BAG SENSOR. THERE WAS NO INCIDENT THAT CAUSED THIS. IT JUST WENT BAD. THIS APPEARS TO BE A KNOWN ISSUE FOR MIN AND BMW BUT THEY ARE NOT TAKING RESPONSIBILITY TO REPLACE THE SENSOR WHICH RUNS ANYWHERE FROM $900 TO $1600 TO BE REPAIRED. THIS AUTOMOBILE HAS BEEN VERY WELL MAINTAINED HAS LESS THAN 60K MILES AND IS A ONE OWNER. THERE WAS NO REASON FOR THIS TO HAVE GONE BAD OTHER THAN THE PART MUST BE OF POOR QUALITY OR DESIGN. THIS IS A SAFETY ISSUE AND MINI USA SHOULD STEP UP AND RESOLVE THIS FOR THEIR CUSTOMERS. *TR

THE PASSENGER SEAT OCCUPANCY SENSOR IS WEAK AND PRONE TO FAILURE. MINI DOES NOT COVER REPLACEMENT AND CHARGES $1200-$2000 TO REPLACE THE PART LEADING MANY OWNERS, INCLUDING MYSELF TO DRIVE THE CAR IN AN UNSAFE CONDITION (LOW SPEED OR NON DEPLOYING AIRBAGS). *TR

I WAS SLOWING DOWN TO MAKE A LEFT HAND TURN AND ALL OF THE SUDDEN THE POWER STEERING WENT OUT ON IT. BEING A FRONT WHEEL DRIVE CAR MADE IT EXTREMELY DIFFICULT TO TURN. HAD SOMEONE WITH LESS ARM STRENGTH BEEN IN THE DRIVER'S SEAT THEY COULD HAVE HIT ONCOMING TRAFFIC HEAD ON AND KILLED SOMEONE. *TR

IN SEPTEMBER 2012 THE AUTOMATIC TRANSMISSION BEGAN SLIPPING. I HAD IT CHECKED OUT AND WAS TOLD THAT THE TRANSMISSION WAS FINE AND THAT MINI SAYS IT NEVER NEEDS TO BE SERVICED OR HAVE THE FLUID CHANGED. OVER THE NEXT SEVERAL MONTHS IT GOT WORSE AND I WAS FINALLY TOLD THAT THE TRANSMISSION NEEDS TO BE REPLACED. FORTUNATELY I NEVER HAD AN ACCIDENT OR ANY OTHER SERIOUS CONSEQUENCE AS A RESULT OF THE FAILING TRANSMISSION. THIS CAR HAS BEEN TRADED IN BECAUSE THE TRANSMISSION WOULD COST $10,000.00 TO REPLACE. *TR

TL* THE CONTACT OWNS A 2006 MINI COOPER. THE CONTACT STATED THAT THE FRONT PASSENGER'S SEAT WAS OCCUPIED WHEN THE AIR BAG DEACTIVATED WARNING MESSAGE DISPLAYED. THE CONTACT STATED THAT THE DEALER REPLACED THE SEAT MAT SENSOR BUT THE REPAIR DID NOT REMEDY THE ISSUE. THE CONTACT TOOK THE VEHICLE BACK TO THE DEALER FOR A DIAGNOSTIC TEST, WHICH CONFIRMED THAT THERE WAS A DEFECT IN THE SEAT MAT SENSOR. THE DEALER DID NOT REPLACE THE SEAT MAT SENSOR. THE FAILURE MILEAGE WAS 45,000.

PASSENGER SEAT AIRBAG SENSOR FAILED AND THE AIRBAG LIGHT STAYS ON AND THE AIRBAGS IN THE FRONT SEAT PASSENGER AND DRIVER MAY BE DEACTIVATED AND NOT WORK IN A CRASH. MINI IS AWARE OF THIS PROBLEM HAS CHOSE TO IGNORE IT. IT IS A GREAT SAFETY HAZARD. MY WIFE HAS REFUSED TO RIDE IN THE CAR OR LET ANYONE ELSE RIDE IN IT. *TR

MY MINI COOPER S 2006 HAS BEEN RANDOMLY BANGING INTO GEAR AND WAS DIAGNOSED BY NORTHWEST MINI AS NEEDING A TRANSMISSION REPLACEMENT FOR $8361.00 (BEFORE TAX). PROBLEM CAUSES CAR TO LOOSE ACCELERATION AND POWER. *TR

THERE IS A" LINE" CRACK IN THE WINDSHIELD STARTING IN THE MIDDLE OF THE WINDOW AND BEGINNING @ 4 INCHES FROM THE TOP OF THE WINDOW AND EXTENDING LEFT TOWARD THE DRIVER SIDE OF THE WINDSHIELD.. NO HEAD, OR ICE HAIL OR BODY HIT THE WINDOW, TO CAUSE THE BREAK.. *TR

MINI COOPER TRANSMISSION FAIL. THE CAR DOES NOT GO BETWEEN 20 TO 50 MPH. IT HAS NO POWER AND THAT CAN BE DANGERS WHEN I AM GETTING INTO THE HIGHWAY AND CARS ARE GOING AT A HIGH SPEED. ON TOP OF IT MY CAR STALLED IN THE MIDDLE OF RUSH HOUR. LUCKY I GOT IT STARTED AND WAS ABLE TO MAKE IT HOME. SEEMS LIKE EVERYONE IS HAVING THIS PROBLEM THE CAR NEED TO BE RECALL AND GET IT FAXED BECAUSE SOMEONE CAN DIE. *TR

TL* THE CONTACT OWNS A 2006 MINI COOPER. THE CONTACT STATED THAT WHILE DRIVING AT VARIOUS SPEEDS, THE PASSENGER'S SIDE AIR BAG LIGHT ILLUMINATED. THE VEHICLE WAS TAKEN TO A DEALER FOR DIAGNOSIS AND THE CONTACT WAS INFORMED THAT THE FRONT PASSENGER'S SIDE SEAT COVER WOULD NEED TO BE REPLACED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE VEHICLE HAD NOT BEEN REPAIRED. THE FAILURE AND CURRENT MILEAGE WAS 43,160.

AIRBAG WARNING LIGHT INDICATES SYSTEM IS EITHER OFF OR INOPERATIVE - IT DOES NOT MATTER IF SOMEONE IS SITTING ON THE PASSENGER SEAT OR NOT. THE AIRBAG LIGHT IS ALWAYS ON. AFTER REVIEWING NUMEROUS COMPLAINTS ON MINI FORUMS, IT APPEARS THAT THE PROBLEM IS COMMON AND DUE TO A DEFECTIVE SENSOR UNDER THE SEAT COVER. SINCE I RARELY CARRY PASSENGERS, THIS CONDITION IS DEFINITELY NOT DUE TO WEAR AND TEAR. AS IT STANDS, I HAVE NO WAY TO ASCERTAIN IF THE AIR BAG WILL DEPLOY IN AN ACCIDENT SITUATION. THIS COULD CAUSE SERIOUS INJURY TO ANYONE RIDING IN THE PASSENGER SEAT OR EVEN THE DRIVER. A LOW MILEAGE VEHICLE OR EVEN AN OLDER VEHICLE SHOULD NOT HAVE THIS TYPE OF SAFETY ISSUE. MINI CUSTOMER SUPPORT OFFERED NO HELP DUE TO CAR BEING OUT OF WARRANTY. INDEPENDENT SHOP IS DOING THE REPAIR FOR $1210.00 DUE TO LACK OF CONFIDENCE IN MINI. *TR

TL* THE CONTACT OWNS A 2006 MINI COOPER S. THE CONTACT WAS TRAVELING 40 MPH WHEN THE AIR BAG WARNING LIGHT ILLUMINATED. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC WHO DIAGNOSED THAT THE AIR BAG SENSOR NEEDED TO BE REPLACED. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE. THE VEHICLE WAS NOT REPAIRED. THE FAILURE AND CURRENT MILEAGES WAS 42,000. UPDATED 08/29/12*LJ UPDATED 08/29/12

THE PASSENGER AIRBAG WARNING LIGHT INDICATES THERE IS A PROBLEM WITH THE PASSENGER AIRBAG SYSTEM. THE LIGHT ILLUMINATES CONTINUOUSLY WHETHER A PASSENGER IS IN THE SEAT OR NOT INDICATING THAT THE AIRBAG IS TURNED OFF FOR THE PASSENGER. MINI COOPER DENIES ANY PROBLEM WITH THEIR SAFETY AIRBAG SYSTEM, YET THERE ARE MANY PEOPLE COMPLAINING ABOUT HAVING THE SAME ISSUES. THE PROBLEM OCCURRED SHORTLY AFTER THE WARRANTY RAN OUT. *TR

38,000 MILES: AIR BAG WARNING LIGHT FOR PASSENGER SIDE SEAT STAYS ILLUMINATED. AIR BAG WARNING LIGHT REMAINS ON AFTER VEHICLE HAS STARTED AND DOES NOT TURN OFF. 54,900 MILES: AISIN AUTOMATIC TRANSMISSION - AUTOMATIC TRANSMISSION FAILED THEREBY MAKING THE CAR INOPERABLE. THE CAR SHOWED SIGNS OF GEAR CHANGE SLIPPING BETWEEN 2ND AND 3RD GEARS. TRANSMISSION DIAGNOSIS, CATASTROPHIC FAILURE OF MANUAL VALVE BODY AND INTERNAL GEARS. REQUIRED A COMPLETE TRANSMISSION REBUILD. *JS

THE SRS DETECTOR MAT FOR TURNING OFF THE AIRBAGS IN THE EVENT OF AN UNDERWEIGHT OCCUPANT IS EASILY BROKEN. WHEN BROKEN, SENSORS DISABLE THE AIRBAGS. THIS PART IS EXTREMELY EXPENSIVE TO REPLACE AND I CAN NOT AFFORD IT ON A FIXED INCOME ($1600). THIS IS A SAFETY ISSUE AND SHOULD BE A RECALL. THE MAT HAS ISSUES: 1) VERY PRONE TO FAILURE AND 2) INTEGRATED INTO THE SEAT CUSHION SO IT CAN NOT BE REPLACED ITSELF, IT MUST HAVE THE SEAT CUSHION REPLACED ALSO. MY MODEL IS A SPECIAL EDITION AND THERE ARE NO PARTS IN THE USA. 11 IN GERMANY AT A VERY HIGH PRICE. *TR

PASSENGER SEAT OCCUPANCY SENSOR IS DEFECTIVE. THE PASSENGER SEAT AIR BAG LIGHT ILLUMINATES AFTER ENGINE START ALONG WITH THE RED AIR BAG FAILURE WARNING LIGHT. DOESN'T MATTER IF SEAT OCCUPIED OR NOT. THIS IS A SAFETY HAZARD DUE TO DISABLING AIR BAG. MINI DEALERS DENY THIS IS A MANUFACTURING DEFECT OR DESIGN PROBLEM YET THERE ARE OVER 40 COMPLAINTS ON THIS FORUM. REPAIR COSTS ARE SUBSTANTIAL TO REPLACE BOTTOM SEAT CUSHION. A MODIFICATION KIT OR RETROFIT TO REPLACE DEFECTIVE SEAT MAT IS NEEDED. *TR

ISSUES WITH AIRBAG LIGHT IN 2006 MINI COOPER S, WHEN SOMEONE IS IN THE SEAT IF THEY ARE NOT SITTING JUST THE RIGHT WAY THE LIGHT WILL GO ON, WARNING US THE AIRBAG IS DEACTIVATED, SOMETIMES THE AIRBAG LIGHT WILL GO ON FOR THE PASSENGER SEAT WITH NOBODY IN THE SEAT. SOMETIMES THE SEATBELT WARNING LIGHT WILL COME ON WITH NO ONE IN THE SEAT AS WELL. MOVING THE SEAT WILL SOMETIMES CORRECT THE ISSUE. COMPLAINTS TO MINI AND DEALER WERE ON DEAF EARS. [XXX] I COPIED AND PASTED THE COMPLAINT, BUT MY PROBLEM IS EXACTLY THE SAME. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6). *TR

THE PASSENGER SIDE AIR BAG SENSOR WARNING LIGHTS STAY ON ALL THE TIME THAT IGNITION IS ON, EVEN WHEN NO ONE IS IN THE SEAT. YOU CAN SIT IN THE SEAT AND THE LIGHT STAYS ON. MY CONCERN IS WHETHER OR NOT THE AIR BAG WILL STILL FUNCTION. *TR

PER MY RESEARCH, THIS A RECURRING PROBLEM WITH THE 2006 MINI COOPERS. NUMEROUS BULLETIN BOARDS HAVE THE SAME QUESTIONS FOR A SAFETY CONCERN IF THE AIRBAG WILL DEPLOY FOR THE PASSENGER SEAT. TOOK CAR TO DEALER FOR DIAGNOSTICS AND THEY GAVE US A REPAIR PRICE OF $1200.00 TO REPLACE THE LOWER SEAT FOR THE OCCUPANCY PAD IS DEFECTIVE WHICH CAUSES THE LIGHT TO COME ON FOR THE PASSENGER BAG AND ALSO THE MAIN LIGHT IN THE DASH. NOT SURE IF BMW CARES ABOUT SAFETY OF THE PEOPLE WHO HAVE PURCHASED THEIR VEHICLES BUT IT IS A BIT CALLOUS ON THEIR PART FOR NOT DOING A RECALL ON THE 2006 MINI COOPER SEAT SENSOR. I HAVE SEEN A REGULAR BMW VEHICLE THAT HAS A SIMILAR PROBLEM HAVE A RECALL FOR A BAD SEAT SENSOR. I AM CONCERNED FOR ANY PERSON WHO RIDES IN THE PASSENGER SEAT IF AN ACCIDENT WERE TO HAPPEN THAT THE AIRBAG WILL NOT DEPLOY CAUSING GREAT BODILY HARM. *TR

OVER THE COURSE OF THE PAST SIX MONTHS THE SRS LIGHT WAS INTERMITTENTLY COMING ON. IN THE PAST FEW WEEKS IT FINALLY CAME ON AND STAYED ON. I TOOK TO THE LOCAL BMW/MINI DEALER AND THEY ASSESSED IT FOR $167.00. THEN I WAS TOLD IT WAS A PASSENGER SEAT SENSOR ISSUE AND THE COST OF THE PART AND LABOR WOULD BE APPROXIMATELY $1100. I DID SOME RESEARCH ON THE MATTER AND REALIZED THAT DOZENS IF NOT HUNDREDS OF MINI-OWNERS HAVE HAD THE SAME PROBLEMS WITH THE SENSORS, SEATS AND LIGHTS DATING BACK TO 2003+. SEEMS TO ME THAT IF IT'S BEEN AN ISSUE THAT THEIR SO CALLED ENGINEERING DEPARTMENT MIGHT RESOLVE THE PROBLEMS WITHOUT COSTING OWNERS THIS KIND OF MONEY. I THINK ITS A RIP JOB BY THE DEALERS AND A FAILURE OF THE ENGINEERS AT MINI TO RESOLVE THE PROBLEM. COST FOR SUCH A REPAIR SHOULD BE ON THEM. I WILL MAKE SURE TO REPORT TO ANYONE THAT WILL LISTEN TO STAY AWAY FROM THE PURCHASE OF THESE CARS DUE TO THE POTENTIAL FOR FUTURE PROBLEMS. *TR

UNFASTENED SEAT BELT WARNING LIGHT STAYS ON AND AIRBAG OFF INDICATOR STAYS LIT AT ALL TIMES, WITH OR WITHOUT A PASSENGER RIDING IN THE SEAT NO MATTER THE WEIGHT OF THE PASSENGER. UNFASTENED SEAT BELT WARNING BELL/DING DOES NOT CHIME. *TR

CAR WAS PARKED IN DRIVEWAY WITH HAND BRAKE ENGAGED. 5 MINUTES LATER, THE CAR ROLLED DOWN DRIVEWAY AND HIT A DITCH. REAR SUSPENSION WAS DAMAGED. THE HAND BRAKE WAS STILL ENGAGED. *TR