2007 MINI Cooper Engine Problems

[XXX]. Mini Cooper 2007-2013: Recalls and TSB. My car is part of a recall under MINI Recall for Timing Chains. I understand now it was settled as part of a class action lawsuit that extended the warranty. I always take my car to a dealer and now after mileage they told me that they want me to pay out of my pocket. My car is a 2007 S. My mileage is 105,000K miles. The recall notice is for the year of my car and they are saying my car is too old and the mileage. This recall is for the year of my car so I am not understanding. Upon inspection by the dealer, it and needs to be replaced and cost $4,100.00. I don't have that kind of money. . My name is [XXX], [XXX]., [XXX], [XXX]. Phone #[XXX]. The dealership is Mini Cooper 1660 E.Spring Street, Long Beach Ca 90806. I never received this recall notice and knew of this only because I took my car to the dealer for something else related for the 3rd time.

VACUUM PUMP AND WATER PUMP NEED TO BE REPLACE

TL* THE CONTACT OWNS A 2007 MINI COOPER. THE CONTACT STATED WHILE AT A STANDSTILL, THE VEHICLE BEGAN TO EMIT SMOKE FROM THE ENGINE COMPARTMENT. THE CONTACT STATED CHECK ENGINE WARNING LIGHT WAS ILLUMINATED. THE VEHICLE WAS TAKEN TO LOCAL DEALER SCHOMP MINI (1001 PLUM VALLEY LN, HIGHLANDS RANCH, CO 80129 (303) 872-5752) WHERE IT WAS DIAGNOSED THAT THE THERMAL HOUSING NEEDED TO BE REPLACED. UPON INVESTIGATION, THE CONTACT ASSOCIATED THE FAILURE WITH NHTSA CAMPAIGN NUMBER: 18V248000 (ENGINE AND ENGINE COOLING) HOWEVER THE VIN WAS NOT INCLUDED. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER HAD NOT BEEN INFORMED OF FAILURE. THE FAILURE MILEAGE WAS APPROXIMATELY 138,867.

THE TURBOCHARGER HAD TO BE REPLACED, NEW TURBO GOT HOT AND MELTED THE VALVE COVER. THEN THE TURBOCHARGER CAUGHT FIRE WHILE IN MOTION IN A RURAL NEIGHBORHOOD. ALL WITHIN 6 MONTHS.

MY VEHICLE IS CURRENTLY @ BRAMAN BMW WPB (5612423210) FOR A TIMING CHAIN PROBLEM WHICH WAS UNDER RECALL. THE SERVICE ADVISOR CALLED ME AND NOTIFIED ME THAT THE TIMING CHAIN BROKE INSIDE THE ENGINE & COMPLETELY DESTROYED THE MOTOR. TE TIMING CHAIN JOB ALONE ESTIMATE IS $3800, BUT THEYVE NOTIFIED ME THAT THE ENGINE IS UNREPAIRABLE & MUST BE REPLACED! THEY ALSO FAILED TO ACKNOWLEDGE THAT THIS HAPPEN WHILST DRIVING ON AN INTERSTATE, ALMOST CAUSING A HUGE ACCIDENT!! PLEASE HELP!! MINI APPARENTLY CARES MORE ABOUT MONEY THAN LIVES!!

TL* THE CONTACT OWNS A 2007 MINI COOPER S. THE CONTACT STATED THAT THERE WAS A CATASTROPHIC ENGINE FAILURE WITHOUT WARNING. THE VEHICLE WAS UNABLE TO BE DRIVEN AND WAS TOWED TO BRAMAN MINI OF PALM BEACH (2815 OKEECHOBEE BLVD, WEST PALM BEACH, FL 33409, (561) 257-4774). THE DEALER INDICATED THAT THE MANUFACTURER SERVICE CAMPAIGN WAS ONLY TO ADDRESS REPLACING THE TIMING CHAIN AND THAT THE REPLACEMENT OF THE ENGINE ASSEMBLY WAS NOT INCLUDED IN THE MANUFACTURER'S GUIDELINES OF THE SERVICE CAMPAIGN. THE VEHICLE WAS NOT REPAIRED. THE CONTACT WAS WAITING FOR A RESPONSE FROM THE MANUFACTURER TO DETERMINE IF THEY COULD APPROVE THE DEALER REPLACING THE TIMING CHAIN AND THE ENGINE ASSEMBLY. THE FAILURE MILEAGE WAS NOT AVAILABLE.

TIMING CHAIN TENSIONER BROKE AND MESSED UP THE ENGINE

THERE WAS A RECALL FOR THE TIMING CHAIN, SO I HAD IT REPLACED IN THE RECALL PROGRAM THAT WAS OFFERED THROUGH MINI COOPER. LESS THEN 2 YEARS LATER, MY TIMING CHAIN BROKE AGAIN, AND HAS DAMAGED THE MOTOR OF MY CAR. IT WOULD NOT START

TIMING CHAIN MAKING LOUD NOISE WHEN STARTED

MINI COOPER S - NUMEROUS ISSUES FOUND HAVING PURCHASED A USED 2007 MINI COOPER S FROM A SMALL DEALER IN TALLAHASSEE, FLORIDA, WE DID OUR RESEARCH UP-FRONT WITH A 'CARFAX REPORT' WHICH SHOWED NO ISSUES, WE ALSO DID A VIN DATABASE SEARCH FOR RECALLS AND FOUND NO OPEN RECALLS AND ASSUMED THAT IT WAS SAFE TO PURCHASE WHICH WE DID FOR JUST OVER $5,000. NOW THAT WE ARE NEARING A YEAR INTO OUR 4-YEAR PAYMENT PLAN, ON JANUARY 17, 2016, MY WIFE WAS DRIVING NORTH ON I-75 IN GEORGIA AND AT APPROX. MILE MARKER 211, THE ENGINE SEIZED AND SHE REQUIRED A TOW OFF THE INTERSTATE. LUCKILY, THERE WAS NO ACCIDENT OR INJURY- BUT IT SEEMS THAT WOULD HAVE HELPED OUR CASE' UPON ATTEMPTING REPAIRS, WE FIND NUMEROUS ISSUES WITH THE ENGINE (2007 R56/N16 4 CYLINDER TURBOCHARGED) INCLUDING TIMING CHAIN, WATER PUMP, VACUUM PUMP, ETC' BELOW ARE PHOTOS OF REMOVED PARTS FROM THE ENGINE ' THE VACUUM PUMP SEIZED AND BENT THE METAL COMPONENTS ' SINCE THIS IS CONNECTED TO THE 'EXHAUST CAMSHAFT', WHEN IT SEIZED IT SEIZED THE EXHAUST CAMSHAFT ' ON THE OPPOSITE END OF THIS CAMSHAFT IS A SPROCKET WHICH CONNECTS THE TIMING CHAIN (ANOTHER KNOWN ISSUE WITH THIS VEHICLE) ' THE BOLT AND SPROCKET DROPPED INTO THE ENGINE AND TIMING CHAIN AREA, CREATING A CATASTROPHIC FAILURE WHICH IT APPEARS WE ARE GOING TO BE 'LEFT HOLDING THE BAG' FOR

On 2014 a Class Action Lawsuit was filed against BMW OF NORTH AMERICA for claims regarding MINI COOPER models. Answering your questions as follows: -The failing component was the timing chain tensioner -Yes, engine stalled at any speed -No, dealer did not acknowledge the real problem -No, dealer did not told me about the Class Action Lawsuit, did not advice me of any preventive repair or to install a new timing chain tensioner, when the component failed dealer told me that the problem was a jumping timing chain ; the same excuse as in the lawsuit. -There was only an engine light, not any other warning light There were two repairs, the first for $ 2,629.10 on 6/18/2016 the second for $ 3,354.93 on 1/13/2017 dealer had a two years parts and labor warranty that didn't honor and in 2016 the lawsuit was active and not of my knowledge. My question is: if the production numbers engraved on the timing chain tensioner cylinder face match or are part of the production batch from the factory for which the class action lawsuit took place ? Numbers top line: 7565868 80-02 Lower line: IV/ IS GERMANY 3 1 0 This is looks like half cero All components (parts) and the vehicle are available for inspection. Once engine is out of timing pistons will hit the valves (interference engine), in my engine broke at least one valve seat, pieces fell into combustion chamber getting stuck between pistons and cylinder walls scratching these, result lost of compression, engine die. Engine was beyond any repair, and still was charged for. Lawsuit for vehicles manufactured goes to April 2007 mine was February 2007 Neither the MINI COOPER dealer or BMW North America corporate offices paid any attention to my complaint.

THIS CAR HAS BEEN A CONSISTENT USER OF OIL. IT USES A QUART AT ABOUT 500 MILES. THIS ENGINE HAS A REPUTATION FOR PROBLEMS ON MINI COOPER S MODELS AND THE PEUGEOT MODELS WITH THAT SAME ENGINE. I'VE HEARD THAT LATER MODELS DON'T BURN OIL. I'D LIKE TO KNOW WHY BMW HAS NOT RECALLED THEM. FIRST THE TIMING CHAIN, COOLING SYSTEM AND HIGH PRESSURE FUEL PUMP., THEY PAID FOR THE TIMING CHAIN AND THE FUEL PUMP.

WE ARE A SECOND OWNER OF THIS MINI COOPER HAD IT ABOUT A YEAR. TURN THE CAR ON AND HEAR A RATTLE IN MOTOR. WORSE WHEN IT'S COLD. TOOK IT IN TO BE CHECKED IT THE TIMING TENSIONER. APPARENTLY THERE HAS BEEN AN ISSUE WITH THIS FOR SOMETIME. REPAIR COST IS AROUND $2000. CAR ONLY HAS 76,000 MILES THIS PART SHOULD BE PROVIDED UNDER WARRANTY. BUT WHEN IT BREAKS IT AFFECTS THE MOTOR AS WELL BECAUSE IT IS METAL IT TEARS THE MOTOR UP. MAKING A 10 DOLLAR PART COST THOUSANDS OF DOLLARS FOR REPAIR. I DON'T FEEL LIKE I AM LIABLE FOR THE EXPENSE THAT MINI KNEW WAS A PROBLEM AND NEVER RECALLED.

ENGINE, THERMOSTAT, GASKET, RADIATOR, COOLANT TUBE, AND BATTERY WENT OUT ON THE V AT THE SAME TIME. IT WAS RUNNING ROUGH AND JUST STOP RUNNING.

MY 2007 MINI COOPER STARTED TO OVERHEAT, DISPLAYING BOTH THE YELLOW AND RED INDICATION LIGHT SIMULTANEOUSLY. I STOPPED, LOOKED AT THE MANUAL AND IT SUGGESTED THAT I TURN THE CAR OFF AND LET IT COOL OFF. I LET MY MINI "COOL DOWN" AND WHEN I WENT TO START MY CAR IT WOULD NOT START UP. MY CAR IMMEDIATELY SHUT OFF, I CALLED MINI COOPER WHICH IS 75 MILES AWAY AND GOT MY CAR TOWED. I WAS TOLD MY ENGINE NEEDS REPLACEMENT FOR 11K. MY MINI WAS CHECKED LESS THAN ONE MONTH AGO AND I RECEIVED NO WARNING THAT MY ENGINE WAS FAILING. MY 2007 MINI ONLY HAS 83,000 FAR FROM THE EXPECTED OVER 100,000 LIFE EXPECTANCY. I WAS TOLD MY ENGINE FAILED DUE TO LOW COMPRESSION AND THE REPLACEMENT OF A THERMOSTAT; A THERMOSTAT THAT HAVEN'T BEEN IN STOCK FOR MONTHS. AFTER GOOGLING THIS ISSUE, I FOUND HUNDREDS OF COMPLAINTS FOR THE SAME ISSUE. BMW REFUSE TO RECALL THE THERMOSTAT OR ENGINE, AND IT'S AN OUTRAGE. TO MAKE MATTERS WORST, A FAIR CONDITION, RUNNING 2007 MINI W/83,000 MILES AND PACKAGES VALUE IS LESS THAN 5K, A CLEAR SIGN OF THE WORTH OF A MINI. SUPER SAD CUSTOMER.

ENGINE WAS RUNNING EXTREMELY ROUGH AND VERY LOUD ENGINE NOISE RATTLE. TOOK THE CAR TO MINI COOPER SERVICE DEPARTMENT IN JACKSONVILLE FOR DIAGNOSTIC THEY NEED TO REPLACE THE TIMING CHAIN, THEY WANT TO CHARGE ME OVER 2,800. WHEN MY UNDERSTANDING THIS ISSUE WAS ADDRESSED BY A RECALL TO BE REPAIR WITHOUT CHARGE.

WHEN I START MY CAR WHILE PARKED IN MY GARAGE FROM COLD THERE IS A EXTREMELY LOUD RATTLE KNOCK NOISE IN THE ENGINE. I WAIT FOR IT TO WARM UP THEN I DRIVE IT THERE IS STILL A LOUD ENGINE NOISE THAT IT MAKE IT SOUND LIKE IF IT IS A DIESEL ENGINE. AND AFTERWARDS THE ENGINE STALLS AND IT LOOSES RPM WHEN I AM DRIVING ON THE HIGHWAY OR STREET MAKING IT HAZARDOUS AND DANGEROUS BECAUSE THE ENGINE CHOKES AND WANTS TO DIE OUT ON THE ROAD WHILE I AM DRIVING IT.

WHEN I START MY CAR WHILE PARKED IN MY GARAGE FROM COLD THERE IS A EXTREMELY LOUD RATTLE KNOCK NOISE IN THE ENGINE. EVEN IF I WAIT FOR IT TO WARM UP WHILE I AM DRIVING THERE IS STILL A LOUD ENGINE NOISE THAT IT MAKE IT SHOULD LIKE IF IT IS A DIESEL ENGINE. AND AFTERWARDS THE ENGINE STALLS DRIVING ON THE HIGHWAY AND IT LOOSES ITS RPM WHILE DRIVING MAKING IT HAZARDOUS AND DANGEROUS BECAUSE IT APPEARS TO DIE OUT ON THE ROAD WHILE I AM DRIVING IT.

OIL FEED LINE LEAKING ON TURBO

TIMING CHAIN REPLACED AT 32K, JUST FAILED AGAIN AT 92K WITH MOBIL ONE OIL AND FILTER CHANGES EVERY 5K MILES. CHAIN JUMPED IN GARAGE DURING SHUT DOWN OF ENGINE. WOULD NOT RESTART. I CHECKED SPARK, FUSES FOR PRIMARY FUEL PUMP AND MADE A JUDGEMENT THAT IT WAS A FAILURE OF THE HIGH PRESSURE FUEL PUMP AND TOWED IT TO THE DEALER FOR WARRANTY REPLACEMENT. GOT THE CALL THE TIMING CHAIN JUMPED A LINK AND I WOULD NEED A REPLACEMENT AGAIN. CAN'T BELIEVE IT . THIRD CHAIN WITH GOOD LUBRICATION MAINTENANCE IN UNDER 92K.