2009 MINI Cooper Air Bags & Restraints Problems

The seatbelt and air bag warning light for the passenger front seat stays on.

The contact owns a 2009 Mini Cooper. The contact stated that while driving at an undisclosed speed, the seat belt warning light illuminated even though there was no passenger seated in the passenger’s seat. The contact stated that the warning light remained illuminated with the passenger’s seat occupied and the seat belt properly fastened. The vehicle was taken to an independent mechanic, but was not diagnosed or repaired. The dealer was not contacted. The vehicle was not diagnosed or repaired. The manufacturer was made aware of the failure and referred the contact to the NHTSA Hotline for further assistance. The failure mileage was approximately 92,000.

The passenger occupancy seat sensor is defective (as reported by many other owners of this vehicle model). The sensor is very costly to replace in terms of parts ($1,500) and labor ($1,500) and MINI does not sell the sensor separately as it is embedded in the seat foam. The defective sensor does not recognize a passenger sitting in the passenger seat and deactivates the passenger airbag which is an essential, lifesaving device fitted to a small vehicle. When involved in a major vehicle collision, without a working airbag, the risk of fatality drastically increases. The sensor is also responsible for NOT deploying the airbag if a passenger under 100lbs is sitting in the seat ie. a child. Again, this is a massive safety concern especially due to other owners resorting to a cheap aftermarket bypass module which will always deploy the airbag. This solution could seriously injure or cause fatalities for passengers under 100lbs. Other MINI models with the same electronic occupancy sensor problems have had recalls issued by the NHTSA and has not issued recalls for vehicles with the same issue consistently. It is the NHTSA's responsibility to hold the manufacturer accountable for ALL vehicle models with similar defects impacting the safe and consistent operation of life preservation devices such as airbags especially when repair costs for these defective devices are cost prohibitive for vehicle owners to replace.

Passenger Seat Occupancy Sensor fails There's a warning light for passenger airbag off , and also the airbag light on the dash panel never goes away ,even when a passenger is sitting on it. Is a common thing on minis , the dealer charges $100 to reset it within obd tool

The contact owns a 2009 Mini Cooper. The contact stated while driving approximately 30 MPH, the passenger occupant sensor light illuminated. The contact had taken the vehicle to a local dealer, where it was diagnosed and determined that the mat switch needed to be replaced. The vehicle was not repaired. The contact was advised by the dealer that there was a recall for the mat switch however, neither the VIN nor the vehicle was included. The manufacturer was informed of the failure. The failure mileage was approximately 22,000.

TL* THE CONTACT OWNS A 2009 MINI COOPER. THE CONTACT STATED WHILE DRIVING AT VARIOUS SPEEDS, THE AIR BAG AND THE SEAT BELT WARNING LIGHTS ILLUMINATED. THE VEHICLE WAS NOT TAKEN TO A LOCAL DEALER OR INDEPENDENT MECHANIC TO BE DIAGNOSED. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER HAD NOT BEEN INFORMED OF THE FAILURE. THE FAILURE MILEAGE WAS APPROXIMATELY 156,000.

PASSENGER SIDE AIR BAG NOT ACTIVATED WHEN SIT IS OCCUPIED. AIRBAG WARNING LIGHT ON ALL TIMES.

PASSENGER AIRBAG 'OFF' WARNING LIGHT STAYS ON AT ALL TIMES EVEN WHEN SOMEONE IS SITTING IN THE SEAT.

TL* THE CONTACT OWNS A 2009 MINI COOPER. THE CONTACT STATED THAT THE PASSENGER SEAT OCCUPANT WARNING LIGHT ILLUMINATED INTERMITTENTLY. THE CONTACT TOOK THE VEHICLE TO AN INDEPENDENT MECHANIC WHO DIAGNOSED THE VEHICLE WITH A DEFECTIVE OC3 SEAT OCCUPANCY MAT. MINI OF STEVENS CREEK LOCATED AT (4201 STEVENS CREEK BLVD, SANTA CLARA, CA 95051) WAS NOTIFIED OF THE FAILURE AND REFERRED THE CONTACT TO THE MANUFACTURER. THE MANUFACTURER WAS CONTACTED AND NOTIFIED OF THE FAILURE. THERE WAS NO ASSISTANCE PROVIDED. THE VEHICLE WAS NOT REPAIRED. THE FAILURE MILEAGE WAS 95,000.

MY PASSENGER SIDE AIRBAG LIGHT STAYS ON CONSTANTLY, EVEN IF SOMEONE IS SITTING THERE

PASSENGERS OC3 SEAT OCCUPANCY MAT FAILED CAUSING THE PASSENGER SIDE AIR BAG TO BE DEACTIVATED. MINI HAD EXTENDED THE WARRANTY ON THIS FOR 10 YEARS AND 120,000 MILES. MY MINI WAS LESS THAN 10 YEARS OLD BUT DID HAVE 130,000 MILES ON 4/3/2019 WHEN I TOOK IT INTO THE DEALER. MINI HAS REFUSED TO REPLACE THIS DEFECTED PART EVEN THOUGHT THEY KNOW IT WAS DEFECTIVE BECAUSE THEY EXTENDED THE WARRANTY. THEY ALSO KNOW THAT ON PREVIOUS YEARS MODELS THEY WERE FORCED TO RECALL THIS PART AS I ALSO OWN A 2006 MINI THAT WENT BAD AND IT TOOK OVER A YEAR BEFORE THEY FINALLY DID A RECALL. MINI DOES NOT HAVE A WORKABLE CUSTOMER RELATIONS SYSTEM THAT ALLOWS THE CUSTOMER TO APPEAL THIS SAFETY DEFECT REPLACEMENT REJECTION. THE BOTTOM LINE IS THAT MINI KNOW THEY HAVE A DEFECTIVE SAFETY SENSOR AND HAVE A HISTORY OF THIS BEING A BAD PART BUT ARE UNWILLING TO DO THE RIGHT THING AND REPLACE IT. THEY INSTEAD WANT THE CUSTOMER TO SPEND OVER $1,000 DOLLARS TO REPLACE IT FOR THEIR OWN SAFETY. THIS IS A BAD COMPANY DYNAMIC AND SHOWS NO CORPORATE RESPONSIBILITY.

SRS warning light on. Intermittent at first. Passenger seat occupancy light on and off intermittently, occupied or not. SRS code reader indicates the problem is the passenger seat occupancy sensor. Mini dealer states the repair is not covered under warrantee. I fear for the safety of my front seat passenger if airbag does not deploy and/or the safety of a smaller child if it does deploy.

AIRBAG PASSENGER LIGHT STAYS ON WHEN A PASSENGER IS IN THE SEAT AND ALSO STAYS ON WHEN IS NOBODY IN THE PASSENGER SEAT . AND THE PASSENGER LIGHT TURNS ON IN THE RPM GAGE (IN THE RPM GAGE )

PASSENGER AIRBAG LIGHT STAYS ON AND IT IS DEACTIVATED WHEN I AM DRIVING. THIS APPEARS TO BE A KNOWN PROBLEM WITH NO RECALL IN EFFECT. I AM SEEKING BYPASS OPTIONS ONLINE TO BUY TO ALWAYS KEEP THE AIRBAG ON REGARDLESS OF HAVING A PASSENGER SITTING THERE. STILL VERY UNSAFE IF A KID SITS IN THAT SEAT. THIS NEEDS TO BE RECALLED

PASSENGER AIRBAG OFF LIGHT ON WHEN PASSENGER (OVER 25LBS) IS SITTING IN PASSENGER SEAT. AS IS THE SEAT BELT WARNING LIGHT IN SPEEDOMETER GAUGE. ALSO SRS RED WARNING LIGHT SHOWS ON TACHOMETER GAUGE. THESE WARNING INDICATORS ARE "ON" REGARDLESS OF WHETHER VEHICAL IS IDLE (NOT MOVING) OR WHEN AT SPEED( IN MOTION)

AIR BAG LIGHT CAME ON AND DOES NOT TURN OFF

MY PASSENGER SIDE AIRBAG LIGHT STAYS ON CONSTANTLY, EVEN IF SOMEONE IS SITTING THERE

I WAS DRIVING DOWN HWY 16 (A STRAIGHT A WAY 2 LANE HWY) TOWARDS WOODLAND WHEN THE DISPLAY SHOWED WHAT APPEARED TO BE THE WATER ICON AND I NOTICED WHITE SMOKE FROM UNDER MY HOOD, SO I PULLED OVER AND SAT THERE THINKING MAYBE MY CAR WAS OVERHEATING. A TRUCK COMING BEHIND ME WENT BY HONKING THEIR HORN AND I LOOKED IN REVIEW MIRROR AND NOTICED DARK SMOKE COMING FROM BEHIND MY CAR.. I THEN PROCEED TO GET OUT OF MY VEHICLE AND COULDNT GET THE DRIVERS DOOR OPEN A GENTLEMAN CAME UP TO MY VEHICLE TOLD ME TO GET OUT BUT I TOLD HIM THE DOOR WOULDNT OPEN, HE OPENED THE DOOR AND WAS SAYING GET OUT AND AWAY THE CARS GOING TO BLOW UP, THAT WAS MY FIRST ACKNOWLEDGMENT THAT THE VEHICLE WAS ON FIRE. THE POLICE AND FIRE DEPT WAS NOTIFIED AND CAME OUT TO WHERE THE VEHICLE WAS AT AND PROCEED TO EXTINQUISH THE VEHICLE. I HAD TO GET THE CAR TOWED BY TRIPLE A OFF A FRIENDS OF MINES TOW PACKAGE THAT SHE HAS. IM CONTACTING THE FIRE DEPT AND POLICE TODAY ON GETTING SOME PAPERWORK RELATED TO THIS TODAY SO ALL I HAVE TO SHOW IS PICS.

I RECENTLY PURCHASED A 2009 MINI COOPER AND THE AIRBAG AND SEATBELT WARNING LIGHTS COME ON WHENEVER I GET IN THE CAR. THE LIGHT CAME ON RECENTLY WHEN I STARTED THE CAR AND IT NOW OCCURS EVERY TIME I TURN THE MOTOR ON. I'VE BEEN ONLINE RESEARCHING THE PROBLEM AND DISCOVERED THAT THIS MAY MEAN THAT THE AIRBAGS WILL NOT DEPLOY IF I HAVE AN ACCIDENT. THIS APPEARS TO BE A PROBLEM FACING A NUMBER OF MINI COOPER OWNERS AND BMW HAS NOT RESOLVED THIS PROBLEM AFTER MANY COMPLAINTS.

TL* THE CONTACT OWNS A 2009 MINI COOPER. THE CONTACT STATED THAT THE AIR BAG WARNING INDICATOR ILLUMINATED. THE SOUTH SHORE MINI COOPER WAS CONTACTED AND DIAGNOSED THE AIR BAG SENSOR MAT WAS DEFECTIVE AND NEEDED TO BE REPLACED. THE MANUFACTURERS WAS NOT NOTIFIED OF THE FAILURE. THE FAILURE MILEAGE WAS APPROXIMATELY 17,000....UPDATED 10/23/17 *BF UPDATED 10/24/2017*JS