2002 Nissan Altima Fuel System Problems

The contact owns a 2002 Nissan Altima. The contact stated that the vehicle had failed the State Inspection because the VIN was included in NHTSA Campaign Number: 03V251000 (Fuel System, Gasoline). The dealer was contacted for recall completion and informed the contact that the recall was not applicable to the vehicle because the contact did not reside in the States listed in the recall. The contact stated that the vehicle registration could not be renewed due to the recall. The manufacturer was made aware of the issue, but no assistance was provided. The contact was referred to the NHTSA Hotline for assistance. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The contact had not experienced a failure.

TOOK MY CAR TO EMISSIONS AND THEY PRINTED THIS PAPER OUT OF A RECALL ON MY CAR.

FUEL PUMP LEAKING GAS VERY DANGEROUS SITUATION

FUEL PUMP LEAKED UNDER THE BACK SEAT AND SPREAD THE GAS ALL AROUND THE SEAT

THE FIRST ISSUE I HAVE ARE THE OXYGEN SENOR ARE BAD NO SPEED WHEN GETTING PASS 35 FEEL LIKE YOUR DRIVING IN 25. THE MAJOR ISSUE AND IT IS VERY UNSAFE. I WAS DRIVING DOWN THE STREET WITH MY UNDER AGE CHILDREN IN THE CAR AND WHEN THE GEARS WAS IN DRIVE IT STOP AND WENT BACKWARDS THEN I PUT IT ALL THE WAY IN PARK AND IT STOP AND TOOK OFF AND SPEED WENT TO 60 THEN BACK DOWN TO IT NORMAL SPEED. JUST THE OTHER DAY ON 2/16/15 IT WAS PLACED IN DRIVE IT AUTOMATIC WENT INTO REVERSE INSTEAD OF DRIVE BUT THE GEAR WAS IN DRIVE. *TR

I WAS DRIVING MY CAR TO WORK WHILE I WAS DRIVING TO THE I 95 HIGHWAY BY PEMBROKE RD THERE WAS A BIG METAL STUFF ON THE LANE I WAS I COULDN'T GO NOWHERE BECAUSE THE HIGHWAY WAS BUSY DIDN'T WANT TO GET INTO AN ACCIDENT THEREFORE I DROVE INTO THAT METAL STUFF AND HIT UNDER MY CAR NOW MY CAR DON'T START I DON'T HAVE NOW WAY TO GO TO WORK AND DIDN'T KNOW WHAT TO DO I CALLED TOWING TO TOWNING MY CAR I DID NOT KNOW I SHOULD POLICE ON THE FIRST PLACE THAT'S REAL SUCK THEY SHOULD HAVE PEOPLE TO CLEAN THE HIGHWAY I HAVE A PICTURE OF THE THING AND I TOOK IT ON THE HIGHWAY. *TR

DRIVER SMELLED GASOLINE AT STARTUP. WAS ONLY FAINT AT FIRST, BUT GREW STRONGER OVER THE NEXT FEW DAYS. ODOR BECAME SO OVERPOWERING THAT DRIVER HAD TO DRIVE WITH WINDOWS OPEN TO VENT FUMES. DRIVER IDENTIFIED GAS DRIPPING FROM FUEL PRESSURE REGULATOR VISIBLE ON DRIVER'S SIDE OF ENGINE. DEALER CONFIRMED FUEL PRESSURE REGULATOR LEAK, ORDERED REPLACEMENT PART, AND RETURNED VEHICLE TO OWNER STATING THAT IT'S STILL SAFE TO DRIVE. DRIVER CONCERNED OVER POSSIBLE ENGINE FIRE SINCE GAS DRIPS ONTO ENGINE WHILE IT'S RUNNING. DRIVER HAS DISCONTINUED USING VEHICLE UNTIL REPAIR IS MADE. *TR

MY 2002 NISSAN ALTIMA 2.5 S VEHICLE "SHUTS OFF" SUDDENLY WHEN I AM DRIVING, LEAVING ME IN A VERY DANGEROUS SITUATION. IT HAS HAPPENED ABOUT 7 TIMES IN THE PAST 2 MONTHS. NISSAN SENT OUT A SAFETY RECALL IN EARLY 2008 REGARDING THIS ISSUE, BUT THE RECALL ONLY "REPROGRAMMED THE ELECTRONIC CONTROL MODULE". I TOOK MY VEHICLE TO AN AUTHORIZED NISSAN DEALERSHIP/SERVICE CENTER, AND THEY REFUSED TO REPROGRAM THE ECM MODULE UNTIL I PAY FOR REPLACING THE CRANKSHAFT POSITION SENSOR AND CAMSHAFT SENSOR WHICH WOULD COST ME $324. THE CURRENT RECALL FROM NISSAN DOES NOT FIX THE PROBLEM. A QUICK SEARCH ONLINE FOR THE SAME SYMPTOM REVEALS THAT MANY PEOPLE HAVE HAD THE SAME PROBLEM AND REPROGRAMMING THE ECM MODULE HASN'T CORRECTED THE PROBLEM. THE REAL PROBLEM IS WITH THE CRANKSHAFT POSITION SENSOR AND THAT NEEDS TO BE FIXED, BUT THE COST FOR FIXING IT IS BEING BORNE BY THE CONSUMER, AND NOT BY NISSAN. *TR

06/29/07 MY CAR SPUTTERED THROUGH THE INTERSECTION OF 33RD AND HIGHLAND DRIVE. I THEN PULLED INTO A BAKERY ON 3100 SOUTH AND HIGHLAND DRIVE WHEN I GOT OUT OF MY CAR I WAS OVERWHELMED BY THE SMELL OF GAS. THERE WAS A TRAIL OF GAS BEHIND MY CAR AND A LARGE PUDDLE UNDER MY CAR. AT THIS POINT I DID NOT KNOW WHAT TO DO, I WAS AFRAID TO START MY CAR SO I ASKED A GENTLEMAN AT BIG O TO COME AND LOOK AT MY CAR TO SEE IF I COULD START IT. THEY SAID THEY WOULD NOT START IT NOT KNOWING WHERE THE GAS LEAK WAS AT. I THEN CALLED THE DEALER SHIP AND THEY DID NOT SUGGEST DRIVING THE VEHICLE BUT HAVING IT TOWED DOWN TO THE DEALERSHIP. THE TOW COMPANY PICKED ME AND MY CAR UP AT ABOUT 8:50. THE GENTLEMAN TURNED ON MY CAR AND BACKED IT OUT OF THE PARKING SPOT TO PUT IT UP ON THE TOW TRUCK. THE MOMENT MY CAR WAS TURNED ON IT BEGAN TO LEAK GAS. IT LOOKED LIKE SOMEONE HAD TURNED ON A WATER FAUCET AND IT CREATED ANOTHER LARGE PUDDLE OF GAS IN THE PARKING LOT. ONCE AT THE DEALER SHIP. I EXPLAINED TO SHANE AND NICK WHAT WAS GOING ON WITH MY CAR WHEN NICK SAID, " I KNOW WHAT IS WRONG WITH IT. IT HAPPENED TO ANOTHER CAR THIS WEEK. BUT THAT ONE CAUGHT FIRE" HE TOOK MY CAR BACK INTO THE SHOP AND ABOUT 20 MINUTES LATER COME BACK OUT OF THE SHOP AND SHOWED MY GRANDFATHER AND MYSELF WHAT HAD HAPPENED. THE GAS LINE HAD "FALLEN OFF AND THE GAS WAS SOAKING INTO MY BACK SEAT." IT HAD CREATED A TAR LIKE SUBSTANCE ON THE TANK AND ON THE FOAM OF MY SEAT AND THE SEAT WAS SOAKED FROM THE GAS. I LEFT MY CAR WITH THE DEALERSHIP ALL DAY FOR THEM TO ATTEMPT TO CLEAN THE SEAT AND GET RID OF THE GAS SMELL. AROUND 6PM THAT SAME NIGHT I WENT TO PICK UP MY CAR WITH MY ROOMMATE . WE WERE ABOUT 10 FEET FROM MY CAR WHEN WE BOTH COULD STILL SMELL THE GAS. NEEDLESS TO SAY WITH THE WEATHER TURNING FROM SUMMER TO FALL AND GETTING COLDER THE GAS SMELL IS GETTING WORSE AND THE DEALERSHIP DOES NOT CARE ABOUT THE HEALTH HAZARD AND WILL NOT REPLACE MY BACK SEAT. *JB

FUEL FILL PIPE CONNECT TO BODY HAS RUSTED ON NISSAN ALTIMA WITH 47K MILES (2002). I BELIEVE THERE IS A RECALL ON ANOTHER NISSAN PRODUCT FOR THE SAME ISSUE. THIS CURRENTLY IS CAUSING CAR TO FAIL EMISSIONS, HOWEVER I WOULD BELIEVE IT IS A SAFETY RISK AS WELL. THIS CAR IS CURRENTLY EARLY PRODUCTION OF REDESIGED ALTIMA, COULD POTENTIALLY BE PART OF FIRST IDENTIFICATION OF ISSUE. IN TRYING TO ORDER THE PART DEALER HAS INDICATED THERE IS A BACKLOG FOR THE PART. WOULD INDICATE THEY ARE HAVING HIGH DEMAND IN RESOLVING THIS ISSUE. *NM

CAR FAILED 2 TIMES WHILE DRIVING ON THE HIGHWAY AND FAILED TO ALLOW ENGINE TO RUN OVER 900 RPM'S. PART REPLACED WAS THROTTLE BODY CHAMBER ASSEMBLY. *JB

HAVE A SLOPING DRIVEWAY - WHEN CAR IS PARKED WITH A FULL TANK OF GASOLINE, UNDER CERTAIN CONDITIONS (USUALLY WARM DAYS), GASOLINE DRIPS OUT OF CAR IN THE AREA AROUND THE REAR OF THE FUEL TANK. HAVE HAD THE CAR INTO DEALER MULTIPLE TIMES, THEY HAVE BEEN UNABLE TO RECREATE PROBLEM. THE PROBLEM IS INTERMITTENT, BUT UNLESS SOLUTION IS FOUND I'M SURE IT WILL RECUR - I WOULD RATE THIS A SIGNIFICANT SAFETY HAZARD.*JB

GAS DOOR DID NOT LATCH CLOSED. HAD REPAIRED ON 3/9/06. NOW I HAVE NOTICED SEVERAL 2002 NISSAN ALTIMAS WITH THE SAME PROBLEM. I CONTACTED NISSAN NORTH AMERICA ON 7/7/06 AND WAS TOLD THAT THIS DEFECT WAS NOT IN RECALL STATUS, AND I COULD THEREFORE NOT BE ISSUE A REFUND FOR THE REPAIR. I BEGAN COLLECTING PLATE NUMBERS OF ALTIMAS WITH THE SAME PROBLEM, I'M AT NUMBER SEVEN SO FAR. I BELIEVE THAT THE GAS DOOR NOT CLOSING COULD BE A SAFETY ISSUE AND SHOULD BE RECALLED. THIS DEFECT IS NOT EXCLUSIVE TO MY CAR. *NM

I HAD BEEN SMELLING GAS FUMES INSIDE THE CAR AND OUTSIDE FOR 2 MONTHS. I BROUGHT MY CAR TO THE NISSAN DEALER I BOUGHT IT FROM AND THEY FIXED THE PROBLEM FOR $160.00. ON MY SERVICE RECEIPT IT SAID THEY FOUND GROSS EVAP LEAK: FUEL TANK SEAL NOT SEALING: REPLACED FUEL SENDER SEAL. I QUESTIONED WHY WOULD A 3 YEAR OLD CAR START LEAKING GAS FROM THE TOP OF THE GAS TANK AND THEY SAID "IT'S JUST NORMAL WEAR AND TEAR." I CAN UNDERSTAND WEAR AND TEAR ON TIRES AND BRAKES BUT GIVE ME A BREAK, THE ONLY THING I DO TO A GAS TANK IS FILL IT WITH GAS! MY CAR IS ONLY 3 YEARS OLD WITH 46,000 MILES AND THEY SAID THAT THE WORK WAS NOT COVERED UNDER WARRANTY. I EVEN SPENT $900.00 FOR AN EXTENDED WARRANTY. MY FIANCE IS A SMOKER AND I WAS WORRIED FOR HIS SAFETY IN THE CAR SO I TOLD HIM NOT TO SMOKE IN THE CAR FOR FEARS OF SOMETHING HAPPENING IF THE FUMES WOULD IGNITE SOMEHOW. I COMPLAINED TO THE SERVICE MANAGER AND GOT NOWHERE. THEY TOLD ME TO CALL NISSAN'S CUSTOMER SERVICE NUMBER AND STILL AFTER AT LEAST 5 CALLS THEY WILL DO NOTHING. I SWEAR THEY ARE JUST THERE TO "HEAR" COMPLAINTS AND WORK YOU DOWN UNTIL YOU JUST FORGET ABOUT IT. I WILL NOT GIVE UP. ALSO, THE CLEAR COAT ON MY PAINT IS STARTING TO CHIP ON THE FRONT BUMPER AND PLASTIC GRILL> GUESS WHAT THEY SAID? NOT COVERED UNDER WARRANTY. I AN FED UP WITH NISSAN AND WILL TAKE ADVANTAGE OF EVERY OPPORTUNITY TO SWAY PEOPLE AWAY FROM BUYING ANY NISSAN OR INFINITI. *JB

CAR WOULD NOT START. EXTREMELY STRONG GASOLINE ODOR IN CAR. LARGE PUDDLE OF GASOLINE UNDER CAR. GAS LINE CAME OFF GAS TANK. FITTING HAD VIBRATED LOOSE. REPLACED FITTING AND RECONNECTED GAS LINE. LUCKILY NO FIRE AND THE CAR WAS NOT MOVING AT THE TIME. FRIENDS WITH SAME YEAR AND MODEL CAR EXPERIENCED THE SAME PROBLEM WHILE DRIVING.

MAJOR GAS LEAKS. *AK

NHTSA 03V251000 AT EXTREMELY COLD TEMPERATURES MOISTURE IN THE FUEL TANK COULD FREEZE AND FORM ICE CRYSTALS. THESE ICE CRYSTALS MAY OBSTRUCT THE SUCTION OPENING OF THE FUEL PUMP. CONSUMER RECEIVED THIS RECALL LETTER IN NOVEMBER 2003. DEALERSHIP STILL DOES NOT HAVE THE PARTS AVAILABLE TO CONDUCT RECALL REPAIRS. *AK

THE CONSUMER RECEIVED A RECALL NOTICE (NHTSA 03-V-251-000) FOR THE REPLACEMENT OF THE FUEL TANK, HOWEVER THE DEALER DID NOT HAVE THE PARTS AVAILABLE TO REPAIR THE RECALL. *NM

"PURE" GAS SMELL IN EXHAUST....VEHICLE FAILS TO RESTARTS AFTER BEING DRIVEN SHORT DISTANCES , TURNE OFF, AND RE-STARTED. HAS HAPPENED SINCE I HAVE PURCHASED THE VEHICLE....DEALERSHIP/REPAIR NEVER FINDS ANY PROBLEMS. THIS IS THE 5TH TIME IT HAS HAPPENED OVER A YEAR. CAR WILL NOT RE-START, UNLESS I WAIT 2-4 HOURS & TRY AGAIN. DEALERSHIP/SERVICE SAID MAY HAVE SOMETHING TO DO WITH WHERE I PURCHASE FUEL....BUT I FILL UP AT SEVERAL PLACES THROUGH OUT THE WEEK...SO I KNOW THAT'S NOT THE PROBLEM.*AK

THE FIRST INCIDENT WAS ON DECEMBER 3, 2002 WHEN MY CAR ENGINE CEASED TO FUNCTION ON THE INTERSTATE AT 70MPH. THERE WAS NO WARNING AND THE ENGINE LIGHT DID NOT COME ON. VEHICLE WAS TOWED TO THE DEALERSHIP AND THE COMPUTER WAS REPLACED. ON JANUARY 15, 2003, AGAIN ON THE INTERSTATE, THE VEHICLE EXPERIENCED THE SAME PROBLEM. IT CEASED FUNCTION AND THE ENGINE LIGHT DIDN'T COME ON. THE VEHICLE WAS AGAIN TOWED AND THIS TIME THE PROBLEM HAS BEEN DIAGNOSED AS A MALFUNCTION WITH FUEL PUMP. THE FUEL PUMP AND GAS TANK ARE SCHEDULED TO BE REPLACED AND PIECES OF METAL WERE FOUND IN THE GAS TANK.