2008 Nissan Xterra Fuel System Problems

ACTION REQUESTED: 2008 NISSAN XTERRA FUEL GAUGE FAILS TO OPERATE PROPERLY AND IS SAFETY CONCERN. ISSUE: 2008 NISSAN XTERRA FUEL GAUGE READING IS ERRATIC, INACCURATE AND, AT TIMES, INOPERATIVE. WHEN FUNCTIONING, FUEL GAUGE IS INCONSISTENT. THE PROBLEM BEGAN AT APPROXIMATELY 65,000 MILES AND HAS PERSISTED. THE VEHICLE CURRENTLY HAS APPROXIMATELY 70,400 MILES. THUS FAR, NISSAN STATED THAT THE VEHICLE IS NOT PART OF A RECALL. YET, LETTER FROM NISSAN'S SENIOR MANAGER FOR TECHNICAL COMPLIANCE ACKNOWLEDGES DEFECT IN THE FUEL GAUGE SYSTEM (SEE ATTCH 3) AND A RECALL INITIATED IN MAY 2010 (ATTCH 5) AND SUBSEQUENT BULLETINS (ATTCH 4). I'VE ENCLOSED A PROOF OF OWNERSHIP THAT I'VE PROVIDED TO NISSAN (ATTCH 1) AS WELL AS A PHOTO CONTAINING THE MANUFACTURERS' DETAILS. WILL CONTINUE TO ENGAGE NISSAN AND RESPECTFULLY REQUEST YOUR ASSISTANCE IN ADDRESSING THIS SAFETY CONCERN BY ADDING THE VEHICLE TO THE RECALL AND ENABLING NISSAN TO REPLACE DEFECTIVE PART. PLEASE ADVISE IF FURTHER INFORMATION IS NEEDED OR REQUIRED.

AS I WAS TURNING LEFT ONTO A HIGHWAY AND IN THE INTERSECTION, MY VEHICLE DIED. HAD TO BE PUSHED THROUGH THE INTERSECTION WHILE TRAFFIC WAS BEING HELD BACK IN 5 LANES. THE GAS TANK REGISTERED AN EIGHTH TANK OF GAS BUT IT WAS, IN FACT, OUT OF GAS. I HAD TO HAVE THIS REPAIRED AT A REPAIR SHOP BECAUSE I WAS NOT NEAR A DEALER. I NEVER RECEIVED A RECALL NOTICE(CAMPAIGN ID# PC 042, NHTSA# 10V-075) BUT FOUND OUT LATER THERE WAS ONE ON CERTAIN VIN NUMBERS WITH MY MAKE AND MODEL VEHICLE. THE DEALER CLAIMS IT SHOULD BE COVERED BUT NISSAN SAYS THIS VIN # IS NOT COVERED. REGARDLESS, I HAD THE DESCRIBED PROBLEM WITH THE MAKE AND MODEL VEHICLE THAT HAS THIS PROBLEM AND I COULD HAVE BEEN KILLED. PERHAPS THEY NEED TO ADD MORE VIN #'S TO THEIR RECALL LIST AND GET ON THE SAME PAGE AS THEIR DEALERS. THIS WAS AN EXPENSIVE REPAIR FOR ME TO ABSORB. I WAS TO LEAVE ON A ROAD TRIP IN 2 DAYS. THANKFULLY IT HAPPENED BEFORE I WAS TRAVELING.

2008 NISSAN XTERRA. CONSUMER WRITES IN REGARDS TO VEHICLE FUEL GAUGE INACCURACY ISSUES. *SMD THE CONSUMER STATED SHE RAN OUT OF GAS ON THE HIGHWAY, EVEN THOUGH THE TANK READ A QUARTER TANK REMAINING. *JB

THE GAS GAUGE NO LONGER WORKS. I HAD IT CONNECTED TO DIAGNOSTICS AND WAS TOLD THE SENDING UNIT IS BAD(NO LONGER WORKS). *TR

IN PREPARING TO TRAVEL, I WENT TO FILL UP MY GAS TANK. UPON GETTING BACK INTO MY VEHICLE AND TURNING IT ON MY GAS GAGE DROPPED TO "0" AND THE FUEL LIGHT AND CHECK ENGINE LIGHT WENT ON , INDICATING THAT THE TANK WAS EMPTY, AND WHO KNOWS WHAT ELSE WAS WRONG. I CONTACTED NISSAN AND WAS ISSUED A CASE NUMBER, AND MADE AN APPOINTMENT WITH THE NISSAN DEALERSHIP NEAR MY HOME. ON 10/1/14, I BROUGHT MY VEHICLE IN, DESCRIBED INCIDENT TO SERVICE CLERK. THEY EXPLAINED THAT THEY THOUGHT IT WAS THE FUEL SENDER FLOAT AND WOULD DO A DIAGNOSTIC TEST. THEY CONFIRMED THAT WAS INDEED THE ISSUE. I WAS CHARGED FOR THE DIAGNOSTIC TESTING AND QUOTED OVER $400 TO REPLACE THE PART. SINCE I HAD NO CHOICE, I PAID FOR THE TESTING, BUT DID NOT HAVE THE PART REPLACED. OVER A MONTH LATER, I'M STILL DEALING WITH THIS ISSUE. I FOUND THAT THE USDOT HAD ISSUE A RECALL IN 2010 FOR 2006 -2008 NISSAN XTERRA'S. MY VEHICLE IS A 2008 MODEL, PURCHASED IN OCTOBER 2007. *TR

TL* THE CONTACT OWNS A 2008 NISSAN XTERRA. THE FUEL GAUGE DISPLAYED THAT THE FUEL TANK WAS EMPTY WHEN THERE WAS FUEL PRESENT IN THE TANK. THE DEALER DIAGNOSED THAT THE FUEL TANK SHELLS MALFUNCTIONED AND NEEDED TO BE REPLACED. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE. THE FAILURE MILEAGE WAS UNAVAILABLE.

I RECEIVED A WARRANTY NOTIFICATION LETTER AROUND 2011 , STATING THAT NISSAN WAS PROVIDING THE HIGHEST LEVELS OF PRODUCT QUALITY AND CUSTOMER SATISFACTION. THIS LETTER STATED THAT NISSAN WAS EXTENDING THE WARRANTY FOR THE FUEL SENDING SENSOR THAT CAN MALFUNCTION AND INCORRECTLY GIVE A WRONG READING ON THE FUEL LEVEL. THEY WHERE EXTENDING THE NEW VEHICLE LIMITED WARRANTY FOR 36 MONTHS/ 36,000 MILES TO 72 MONTHS 72,000 MILES. SO I PUT THE STICKER AND LETTER IN MY WARRANTY BOOKLET. I CALLED THE NISSAN DEALERSHIP AND GAVE THEM MY VIN NUMBER AND THEY STATED THAT MY VEHICLE WAS NOT PART OF THE "CAMPAIGN RECALL" AND YOU DONT NEED TO DO ANYTHING FURTHER. SO IT IS NOW 2014, 3 YEARS LATER AND WHAT HAPPENS ........ THE FUEL SENDING SENSOR IS BROKEN, I SPOKE TO THE DEALER AGAIN ON 2-17-2014, AND AGAIN THEY STATED TO ME THAT MY VIN NUMBER WAS NOT PART OF THE CAMPAIGN RECALL AND WHEN I SHOWED THEM MY LETTER , THEY STATED TO ME THAT YES IT WAS UNDER WARRANTY AT THE TIME OF RECEIVING THE LETTER.....BUT THEY SAID TO ME IN 2011 THAT NO NEED IF YOU DONT HAVE A PROBLEM YOUR VEHICLE DOESNT NEED TO HAVE THIS REPLACED ....... SO I GOT TOLD WRONG TWICE ONCE WHEN YOU GET THE LETTER UNLESS IT IS BROKEN THEN THEY WONT FIX IT.....AND NOW THAT IT IS BROKEN MY VIN NUMBER IS NOT PART OF THE "CAMPAIGN RECALL" SAD THAT NISSAN DOES THIS .....THEY SHOULD HONOR THIS RECALL FOR ALL VIN NUMBERS THAT SHOW THIS PROBLEM. I BOUGHT THIS VEHICLE NEW FROM THE DEALER AND WILL NOT GIVE OUT 600.00 FOR THEM TO REPLACE AN 80.00 PART. I WISH MORE PEOPLE COMPLAIN SO THIS GOES TO RECALL. WITHOUT FIXING THIS YOU CANNOT PASS INSPECTION FOR YOUR CAR. AT THE TIME OF RECEIVING THE LETTER THEY SHOULD HAVE FIXED IT BUT IT WASNT BROKEN. 3 YEARS LATER THEY WONT FIX IT MY VIN IS NOT PART OF CAMPAIGN RECALL????? *TR

SERVICE ENGINE SOON LIGHT CAME ON WHILE DRIVING ON RESIDENTIAL STREETS. HAD CODE CHECKED. CODE LISTED AS P0462. CLEARED CODE THEN RESTARTED CAR. UPON STARTING CAR NONE OF THE GAUGES WORKED ONLY THE TACHOMETER AND SPEEDOMETER WORKED. FUEL, TEMPERATURE, OIL, ODOMETER, TRIP ODOMETER AND ALL WARNING LIGHTS TO INCLUDE TURN SIGNAL INDICATORS DID NOT WORK. UPON DRIVING GAUGES WOULD REGAIN POWER, BUT THE FUEL GAUGE DID NOT FUNCTION PROPERLY. TOOK VEHICLE TO DEALER. SEEMS THAT MY VIN WAS NOT INCLUDED IN THE RECALL # 10V075000, EVEN THOUGH THE EXACT RECALL REPAIR WAS DONE TO MY CAR TO FIX THIS ISSUE. WHILE THE FUEL GAUGE NOW WORKS, NONE OF MY OTHER GAUGES WORK. I WAS TOLD THE COMBO METER THAT CONTROLS MY CLUSTER OF GAUGES WOULD NEED TO BE REPLACED. THERE WERE NO ISSUES WITH MY VEHICLE UNTIL THE SERVICE ENGINE SOON LIGHT CAME ON. MY VEHICLE SHOULD HAVE BEEN INCLUDED IN THE RECALL STATED ABOVE, AND I FIND IT HIGHLY SUSPECT THAT ALL OF MY GAUGES GO OUT AT THE EXACT SAME TIME, BUT ACCORDING TO NISSAN THESE ARE TWO SEPARATE UNRELATED ISSUES. I HAVE HAD TO PAY $488 TO REPAIR WHAT SHOULD HAVE BEEN COVERED UNDER THE RECALL, AND NOW NEED TO PAY AN ADDITIONAL $590 TO REPAIR MY GAUGES. MY VEHICLE SHOULD HAVE BEEN INCLUDED IN THE RECALL FOR OTHER 08 NISSAN XTERRAS. *TR

I AM DRIVE IN HWY MY LIGHT FUEL ON WHEN I SURE WE HAVE GAS MANY TIMES HAPPEN AFTER. *TR

FUEL SENDING UNIT FAILURE HIGH LEVEL SENSOR HIGH CURRENT. *TR

FUEL SENSOR ON MY 2008 NISSAN XTERRA IS BROKEN. I HAVE NO WAY OF KNOWING HOW MUCH GAS IS IN MY TANK. IT HAS OCCURRED OVER THE PAST FEW MONTHS. SOMETIMES THE TANK WILL READ EMPTY OR OTHER VALUE. THE DEALER WILL NOT REPAIR UNDER A WARRANTY, EVEN THOUGH THE CAR IS LESS THAN 3 YEARS OLD! I AM PAYING OUT OF POCKET TO REPAIR THE VEHICLE AT THE DEALER. *TR

OUR NISSAN XTERRA WAS RECALLED FOR THE FUEL GAUGE DEFECT IN MARCH 2010. IT IS NOW NOVEMBER 2010 AND NEITHER THE DEALER NOR NISSAN USA HAVE BEEN RESPONSIVE TO OUR RESPONSE TO THEIR RECALL. WE HAVE CONTACTED THE DEALER THREE TIMES, AND NISSAN USA ONCE WITHOUT ANY RESULTS. *TR

THE GAS GAUGE READS ABOUT 1/8 OF A TANK AND MY TRUCK RUNS OUT OF GAS BEFORE THE LOW FUEL LIGHT COMES ON. THEY FIXED THE PROBLEM EACH TIME BUT THEN A FEW WEEKS LATER I ENDED UP HAVING THE SAME PROBLEM, THE DIAGNOSIS WAS THE FUEL SENDING UNIT THEY REPLACED THAT AND THEY ALSO REPLACED THE FUEL PUMP ON THE LAST 2 OCCASIONS. I HAVE HAD THIS PROBLEM 3 TIMES SINCE 06/13/08 THE MOST RECENT TIME WAS ON 07/23/08. *TR