2025 Ram 3500 Powertrain & Transmission Problems

The contact owns a 2025 Ram 3500. The contact stated that while driving approximately 60 MPH, several unknown warning lights illuminated, and the vehicle stalled. The vehicle was towed to a dealer where it was diagnosed, and determined that several repairs were needed, and there was an issue with the battery. The dealer replaced two batteries, but the failure persisted. The vehicle was taken back to the same dealer, but the cause of the failure was not duplicated. On another occasion, while driving approximately 50 MPH and hauling a trailer, there were several unknown warning lights illuminated, and the contact heard a loud banging coming from the engine compartment before the vehicle stalled. The vehicle was towed to a different dealer, where it was diagnosed with transmission failure. The contact was informed that the transmission needed to be replaced. The vehicle was not repaired. The manufacturer was not notified of the failure. The failure mileage was approximately 9,000.

The 2025 and 2026 dually 3500 Ram trucks with the 12" AAM rear axle are having issues with the rear wheel speed sensors (different sensor for each side). They apparently fail or are not able to properly communicate to the computer. When this happens, the following are disabled: -ABS -Auto Emergency Braking -4x4 -Electronic Stability Control -Cruise Sometimes, the engine won't shut off. The gauge cluster will state it can't detect which position the transmission is in. So, you cannot shift, and you can't shut the truck off, and you can't drive. You are stuck in place with a running engine. Despite Stellantis releasing a new revision of wheel speed sensors (AB revision), they have failed in less than 2,000 miles on my truck. Many, many dually owners are experiencing these failures. I've had this problem occur over half a dozen times. It has been to the dealership to be repaired 3 times so far. After the 2nd time at the dealership, the sensors only last less than 23 miles.

The 2025 and 2026 dually 3500 Ram trucks with the 12" AAM rear axle are having issues with the rear wheel speed sensors (different sensor for each side). They apparently fail or are not able to properly communicate to the computer. When this happens, the following are disabled: -ABS -Auto Emergency Braking -4x4 -Electronic Stability Control -Cruise Sometimes, the engine won't shut off. The gauge cluster will state it can't detect which position the transmission is in. So, you cannot shift, and you can't shut the truck off, and you can't drive. You are stuck in place with a running engine. Despite Stellantis releasing a new revision of wheel speed sensors (AB revision), they have failed in less than 2,000 miles on my truck. Many, many dually owners are experiencing these failures. I've had this problem occur over half a dozen times. It has been to the dealership to be repaired 3 times so far. After the 2nd time at the dealership, the sensors only last less than 23 miles.

The 2025 and 2026 dually 3500 Ram trucks with the 12" AAM rear axle are having issues with the rear wheel speed sensors (different sensor for each side). They apparently fail or are not able to properly communicate to the computer. When this happens, the following are disabled: -ABS -Auto Emergency Braking -4x4 -Electronic Stability Control -Cruise Sometimes, the engine won't shut off. The gauge cluster will state it can't detect which position the transmission is in. So, you cannot shift, and you can't shut the truck off, and you can't drive. You are stuck in place with a running engine. Despite Stellantis releasing a new revision of wheel speed sensors (AB revision), they have failed in less than 2,000 miles on my truck. Many, many dually owners are experiencing these failures. I've had this problem occur over half a dozen times. It has been to the dealership to be repaired 3 times so far. After the 2nd time at the dealership, the sensors only last less than 23 miles.

Brand new truck (497 miles) while driving on freeway at 70 mph, truck kicked out of cruise control and threw traction control, adaptive cruise control, 4wd, check engine, and anti lock brakes disabled fault lights and codes. The vehicle will disable all these safety features for 30-50 miles, and then the faults will randomly disappear except for the check engine light. This has happened 10-12 times. This truck has had 4-5 “ram cares” case numbers, has been at the dealership for over a month combined. The faulty part supposedly is a right rear wheel speed sensor on the 12” dually axles. There is hundreds if not thousands of these trucks affected. Stellantis/ram says the sensor is has been updated, but is currently not built or for sale., there is a national backorder. We are being told to drive these trucks while ram comes up with a fix. These speed sensors affect systems that have been federally mandated since September of 2012 (anti lock brakes). They are putting customers and other drivers on the road in danger with the intermittent failure of the brakes and traction control in wet conditions.

The 2025 and 2026 dually 3500 Ram trucks with the 12" AAM rear axle are having issues with the rear wheel speed sensors (different sensor for each side). They apparently fail or are not able to properly communicate to the computer. When this happens, the following are disabled: -ABS -Auto Emergency Braking -4x4 -Electronic Stability Control -Cruise Sometimes, the engine won't shut off. The gauge cluster will state it can't detect which position the transmission is in. So, you cannot shift, and you can't shut the truck off, and you can't drive. You are stuck in place with a running engine. Despite Stellantis releasing a new revision of wheel speed sensors (AB revision), they have failed in less than 2,000 miles on my truck. Many, many dually owners are experiencing these failures. I've had this problem occur over half a dozen times. It has been to the dealership to be repaired 3 times so far. After the 2nd time at the dealership, the sensors only last less than 23 miles.