2006 Scion tC Body & Structure Problems

WHILE DRIVING HEARD A NOISE LIKE SOMETHING FELL AND WAS DRAGGING IN THE BACK. PULLED OFF AND NOTICED THE PLASTIC PIECE FOR MY TRUNK HAD JUST FALLEN OFF. I HADN'T BEEN USING THE TRUNK.

BRACKET THAT LIMITS DOOR OPENING GETS CAUGHT ON WINDOW TRACK THEREFORE CREATING A TEAR AND PULLING TRACK BACK , WINDOW COMES OFF THE TRACK AND IS UNABLE TO WORK PROPERLY AND IF FORCED WINDOW WILL SHATTER, DEALER SOLUTION IS ONLY TO REPLACE AUTOMOBILE DOOR SINCE APPARENTLY TRACK CAN NOT BE REPLACE ITSELF.

TL* THE CONTACT OWNS A 2006 TOYOTA SCION TC. THE CONTACT STATED THAT WHILE AT A STOP LIGHT, THERE WAS AN ABNORMAL NOISE AND THEN THE FRONT WIND DEFLECTOR FRACTURED. THE VEHICLE WAS TAKEN TO TWO WINDOW REPAIR SHOPS WHO RECOMMENDED THAT THE VEHICLE BE TAKEN TO AN AUTHORIZED DEALER FOR INSPECTION AND DIAGNOSIS. THE VEHICLE WAS TAKEN TO THE DEALER. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 73,000.

I WAS DRIVING EAST BOUND ON THE 105 FWY AND WAS KEEPING A SAVE DISTANCE GOING AT APPROXIMATELY 45 MPH SINCE TRAFFIC WAS STOP AND GO, WHEN TRAFFIC STOPPED ON FRONT OF ME. I STARTED TO APPLY THE BRAKES WITH LITTLE TO NO RESPONSE AND COULD NOT STOP IN TIME TO AVOID A COLLISION WITH THE VEHICLE ON FRONT OF ME. A FEW MINUTES BEFORE AND PRIOR TO ENTERING THE FREEWAY I HAD FELT SOMETHING SIMILAR ON THE STREET AND THOUGHT IT WASN'T AN ISSUE, HOWEVER THE BRAKES FELT AS IF THEY WERE NOT RESPONDING. THE BRAKES BEGAN TO RESPOND ONCE AGAIN AND I PROCEEDED TO CONTINUE TO DRIVE. AFTER THE ACCIDENT I THOUGHT THAT THIS MAY NOT BE AN ISOLATED INCIDENT AND THOUGHT OF REPORTING THIS INCIDENT TO MAKE SURE IT'S ADDRESSED FOR FUTURE SCION TC OWNERS. MY CAR IS NOW A TOTAL LOSS AND MY INSURANCE DIDN'T COVER IT. I'M NOW SEEKING FOR AN ALTERNATE VEHICLE SO I CAN CONTINUE MY INTERNSHIP/WORK EXPERIENCE. *TR

HATCHBACK DOOR HANDLE BROKE OFF IN MY HUSBAND'S HAND WHEN HE WAS OPENING THE HATCH. THE HANDLE IS MADE OF THIN PLASTIC AND BROKE OFF WITH NORMAL PRESSURE AND USE. *TR

I HAVE A 2006 SCION TC. THE REAR HATCH HANDLE GARNISH BROKE OFF WHILE DRIVING. IT SEEMED TO ONLY BE HELD ON BY A FEW PLASTIC CLIPS. I CANNOT OPEN MY BACK HATCH, AND AM CONCERNED FOR MY SAFETY. MULTIPLE REPORTS HAVE SHOWN THIS TO BE A SAFETY HAZARD- IN THE EVENT OF AN ACCIDENT WHERE DRIVER/PASSENGER DOORS CANNOT OPEN, I WILL NOT BE ABLE TO EXIT THE VEHICLE VIA THE BACK HATCH. ALSO STUDIES HAVE SHOWN THE HOLE CREATED BY THE MISSING PART MAY ALLOW CARBON MONOXIDE FUMES FROM THE EXHAUST TO ENTER THE VEHICLE WHILE DRIVING. I HAVE RESEARCHED THERE IS CURRENTLY A CLASS ACTION LAWSUIT IN THE WORKS AND THIS ISSUE HAS EFFECTED THOUSANDS OF PEOPLE. SCION REFUSES TO DO ANYTHING ABOUT IT. I HAVE CONTACTED THEM AND WAS INFORMED THERE IS NO RECALL AND THEY WILL DO NOTHING TO HELP WITH THE COST OF REPLACING THIS DEFECTIVE PRODUCT. *TR

TRUNK HANDLE TO HATCH SNAPPED OFF AS I WAS TRYING TO OPEN MY TRUNK. NOW I CAN'T ACCESS MY TRUNK. *TR

THERE IS A RATTLE NOISE COMING FROM THE REAR LEFT AREA AROUND THE HATCH. THIS PROBLEM HAS BEEN ONGOING FOR YEARS, AND JUST REALIZED MANY HAVE REPORTED THE PROBLEM TO TOYOTA ONLINE AND A FEW COMPLAINTS ON YOUR SITE. THE RATTLE OCCURS WHEN IDLE ON A STOP LIGHT, OR IDLE SOMEWHERE. THERE APPEARS TO BE SOMETHING LOOSE AS YOU CAN HEAR A LOOSE OBJECT WHEN GOING OVER A POT HOLE OR UNEVEN ROAD. THE NOISE IS A DISTRACTION AND ALMOST CAUSED ME TO HAVE SEVERAL ACCIDENTS AS I TRY TO IDENTIFY WHERE THE NOISE IS COMING FROM. THE NOISE CAN BE VERY LOUD AT TIME. PLEASE MAKE A RECALL ON THIS ISSUE SINCE THIS PROBLEM APPEARS TO BE A DEFECT ON THE WAY THE FRAMING / BODY OF THE SCION'S WAS BUILT. *TR

THE HATCH BACK TRUNK HANDLE IS VERY FLIMSY AND MADE OUT OF PLASTIC. THE TRUNK NEVER OPENS JUST BY PRESSION THE RELEASE LATCH, IT ALSO REQUIRES TO PULL ON THE FLIMSY LATCH, WHICH COULD CAUSE IT TO BREAK. I HAVE HAD TO ALREADY REPLACE IT ONCE. I HAVE SEEN MANY REPORTS HERE AND ONLINE OF THE SAME PROBLEM WITH OTHER OWNERS. *TR

THE TRUNK HANDLE ON MY BROKE OFF. SCION REFUSES TO ACCEPT RESPONSIBILITY FOR THIS DESIGN DEFECT. MY HUSBAND GLUED IT DOWN, BUT MY CONCERN IS THAT IF THE PIECE BREAKS OFF OR DETACHES IT COULD CAUSE DAMAGE TO ANOTHER VEHICLE OR INJURY. SCION REPRESENTATIVES SAID THAT IT ISN'T A DESIGN FLAW, BUT RATHER USER ERROR FROM FAILURE TO OPEN THE LATCH PROPERLY. THIS IS NOT THE CASE, AS I AM NOW EVEN MORE CAREFUL NOW THAT THE LATCH IS GLUED ON. EVEN NOW WHEN I AM OVERLY CAUTIOUS TO OPEN THE LATCH CORRECTLY, IT STILL GETS STUCK AND I'M CONCERNED IT WILL BREAK AGAIN. NOW THAT I HAVE HAD THE INCIDENT HAPPEN, I HAVE SEEN 4 OTHER SCIONS IN VARIOUS PLACES THAT HAVE THEIR HANDLE TAPED UP, MOST LIKELY DUE TO THE SAME REASON. I FIND IT HARD TO BELIEVE THAT SCION BELIEVES IT IS THE CONSUMER WHO IS AT FAULT WHEN IT IS CLEARLY A FLAW IN THE DESIGNS OF THEIR VEHICLE, AND THEY REFUSE TO CORRECT THE ISSUE UNLESS YOU HAVE DROPPED HUNDREDS OF DOLLARS WITH THEM AT THEIR DEALERSHIP FOR OIL CHANGES OR OTHER SERVICES. *TR

MY 2006 SCION TC REAR TRUNK HANDLE BROKE OFF. IT IS A COMMON PROBLEM. I HAD TAPE HOLDING IT ON FOR A YEAR OR SO, AND GLUED IT MYSELF. I DID NOT RECEIVE ANY RECALL NOTICE OTHERWISE I WOULD HAVE FIXED IT. IT IS NOT JUST THE HANDLE TO GET IN TO THE TRUNK. THIS IS A 18 INCH BY 6 INCH PIECE OF MY CAR HANGING BY A WIRE. I JUST CALLED SCION AND THEY SAID THAT IS WAS NOT A RECALL BUT A WARRANTY EXTENSION THAT EXPIRED 7 YEARS FROM THE DATE OF CAR BEING SOLD OR MARCH 2014. HOPEFULLY IT STAYS ON AND DOESN'T FLY OFF ON THE FREEWAY AND CAUSE AN ACCIDENT, BECAUSE THEN WILL NOT BE ABLE TO HAVE ACCESS TO MY SPARE TIRE OR GET INTO MY TRUNK. THIS SHOULD BE A RECALL WITH NO EXPIRATION DATE. *TR

MY 2006 SCION TC TRUNK LATCH WAS HARD TO OPEN. THEN ONE DAY THE WHOLE ASSEMBLY FELL OFF. IN CHECKING WITH NHTSA IT WAS REVEALED THAT THERE ARE SEVERAL COMPLAINTS OF THIS ISSUE. HOW DO WE GET A RE-CALL?? *TR

I PURCHASED MY TC IN SEPTEMBER OF 2010... I NOTICE AFTERWARDS THAT IT RATTLES IN THE BACK,LOUD WHILE GOING DOWN THE ROAD... AND IT IS SO ANNOYING. I'VE TRIED EVERYTHING TO GET IT TO STOP. ALSO, SITTING STILL WITH THE CAR NOT IN NEUTRAL IT MAKES THIS LOUD RATTLE ON THE LEFT SIDE CLOSE TO THE GAS TANK.. WHAT THE HECK??? *TR

I HAVE A 2006 TOYOTA SCION TC AND THE REAR HATCH HANDLE HAS COMPLETELY COME OFF FOR THE 4TH TIME IN 5 YEARS. THE FIRST TIME IT WAS COVERED UNDER WARRANTY, THE 2ND AND 3RD TIME IT WAS COVERED BY THE DEALERSHIP AS A COURTESY BUT, AS THE CAR IS OUT OF WARRANTY, THEY WANT TO CHANGE ME $260. JUDGING BY WHAT I HAVE READ, THERE IS CERTAINLY A PROBLEM IN THE DESIGN TO EXPECT TWO CLIPS TO HOLD A PIECE OF PLASTIC THAT IS DIRECTLY IN FRONT OF THE LATCH THAT OPENS THE TRUNK. THERE IS A TSB IN JANUARY THIS YEAR THAT COVERS THE BACK DOOR HANDLE GARNISH THAT IS LOOSE OR BROKEN, BUT MY DEALERSHIP SAYS THAT IS NOT THE SAME. FOR ME TO SPEND MONEY ON AN OBVIOUS TOYOTA MANUFACTURING PROBLEM THAT WILL OCCUR AGAIN IS RIDICULOUS. I HAVE IT TAPED ON WITH DUCT TAPE THAT IS REALLY A NICE COLOR. HOW DO I GET SATISFACTION FROM TOYOTA? IS THERE A TSB THAT I CAN'T FIND? *TR

I OWN A 2006 SCION TC. WHEN I GRABBED THE HANDLE TO RAISE THE TRUNK THE ENTIRE REAR HANDLE RIPPED COMPLETELY OFF THE CAR. UPON RESEARCH I SEE THAT THIS A COMPLETELY COMMON ISSUE. WHEN I CALLED THE DEALER THEY CLAIMED THIS WAS ENTIRELY MY RESPONSIBILITY TO REPLACE. HOWEVER CLEARLY THIS IS MALFUNCTION IN THE DESIGN OF THE VEHICLE. *TR

I HAVE A 2006 TOYOTA SCION TC AND THE REAR HATCH BACK HANDLE JUST COMPLETELY CAME OFF. THE CAR HAS CLOSE TO 45000 MILES ON IT. I NEVER USE FORCE TO OPEN THE HATCH BACK, NEVER HAD ANY ISSUE WITH IT AT ALL. THEN LAST WEEK I SIMPLY WENT TO OPEN THE HATCH AND OFF CAME THE ENTIRE PANEL WITH THE HANDLE. IT WAS CRAZY I HAVE PICTURES OF IT JUST HANGING BY THE WIRES FOR THE BACK LIGHTS. I TOOK TO DEALERSHIP THEY DENIED TO FIX EVEN WITH MY PLATINUM WARRANTY PACKAGE. I AM VERY UPSET I FEEL THIS IS NOT MY PROBLEM. THE MANAGER AT THE DEALER EVEN SAID HE SEES THIS ALL THE TIME. I HAVE READ ON PLENTY OF WEBSITES THAT PEOPLE ARE HAVING SAME PROBLEM. PEOPLE HONK AT ME WHEN I DRIVE TO LET ME KNOW IT'S HANGING. RIGHT AFTER IT HAPPENED I GOT HONKED AT ON THE FREEWAY AND IT'S DISTRACTING TO MYSELF AND OTHERS. I REALLY WANT THIS TO BE RECALLED FOR MYSELF AND OTHERS. *TR

DRIVING DOWN THE HIGHWAY AT 65MPH, THE SUNROOF SHATTERED WITHOUT ANYTHING HITTING IT. SUNROOF COVER WAS CLOSED PREVENTING GLASS FROM COMING INTO THE CABIN AND PREVENTING POSSIBLE INJURY. AFTER SPEAKING WITH SCION THEY ARE UNWILLING TO COVER REPAIR COSTS SIGHTING THAT IT COULD HAVE BEEN DEBRIS FROM THE ROAD. CLEARLY, I HAVE NO PROOF EXCEPT FOR THE NUMEROUS OTHER CLAIMS THROUGH NHTSA. REGARDLESS, THEY HAVE BEEN LESS THAN HELPFUL IN RECTIFYING THE SITUATIONS AND SOLVING THE ISSUE. *TR

IN EARLY FEBRUARY 2009 MY DRIVER'S SIDE DOOR DID NOT OPEN ALL THE WAY. I THOUGHT THAT IT JUST WAS STICKING AND GAVE IT A HARDER PUSH. IT THEN STARTED WORKING FINE. A COUPLE OF WEEKS LATER I WENT TO THE DRIVE THROUGH AT THE BANK AND LOWERED THE WINDOW. WHEN I WENT TO PUT IT UP IT ONLY WENT UP HALF WAY. IT WAS TWO MONTHS OUT OF WARRANTY. I TOOK IT TO THE DEALER THEY TOLD ME THAT THE WAY THE HINGE AND WINDOW MECHANISM ARE DESIGNED I NEEDED A COMPLETELY NEW DOOR, THAT THE OLD ONE COULD NOT BE FIXED. I FOUND OUT THIS IS A DESIGN DEFECT WITH THE CAR WHICH DEALERS WERE NOTIFIED OF IN 2007, BUT WERE NOT REQUIRED TO NOTIFY VEHICLE OWNERS. THE REPAIR WAS GOING TO COST ME AROUND $2400. JUST FOUND A FRIEND WHO WAS ABLE TO FIX IT IN AN HOUR AND A HALF. THERE IS A MODIFICATION AVAILABLE IF YOU KNOW ABOUT THE PROBLEM AND ASK. MODIFICATION REALLY NEEDS TO BE DONE BEFORE THE PROBLEM OCCURS, OR AT LEAST BEFORE YOU USE THE WINDOW AFTER THE DOOR STICKS, BUT IF YOU ARE UNAWARE OF THE DESIGN PROBLEM, THE INITIAL STICKING OF THE DOOR SEEMS LIKE A MINOR NEXT TIME THE CAR IS SERVICE HAVE IT LUBED TYPE ISSUE. *TR UPDATED 09/01/09. *LJ

THE REAR DOOR LATCH BROKE OFF IN MY HAND. THE WHOLE MECHANISM NEEDS TO BE RECALLED. SCION CLAIMS THAT THE OWNER'S MANUAL ADVISES NOT TO LET THE MECHANISM BEAR ANY WEIGHT. THIS IS ERRONEOUS, AS THE OWNER'S MANUAL TELLS YOU TO LIFT AFTER PUSHING THE BUTTON. THIS LIFTING OVER TIME CAUSES WEAR OF THE TINY PLASTIC PIECES THAT ARE BEARING THE WEIGHT OF THE ENTIRE REAR/HATCH BACK DOOR. AFTER HAVING THIS PROBLEM I HAVE BEEN LOOKING AT OTHER VEHICLES ON THE ROAD, AND NOT MANY HAVE THIS KIND OF FAULTY DESIGN. THE SAFETY ISSUE IS TWO-FOLD: NUMBER ONE, THE LIGHT ON TOP OF THIS MECHANISM IS THE BRAKE LIGHT. IT JUST FALLS OFF OVER TIME. ONCE IT IS BROKEN, THERE IS NO WAY TO HOLD IT IN PLACE AND IT BLOCKS THE LICENSE PLATE AND ALSO COULD FALL OFF ENTIRELY AND DAMAGE ANOTHER VEHICLE. NEEDLESS TO SAY I COULD NOT BELIEVE THAT THIS WAS DESIGNED INTO THE VEHICLE. I AM CONVINCED THAT NUMEROUS OTHER PEOPLE HAVE HAD THIS PROBLEM AS BOTH THE DEALERSHIP AND THE SCION HELP LINE ADMITTED THAT THIS HAPPENS FREQUENTLY. THEY ALL SEEM TO BE IN COLLUSION ABOUT IT BEING A DESIGN DEFECT EVEN THOUGH THEY ADMIT THERE IS A PROBLEM WITH THE WEIGHT BEARING ASPECT OF THE TRUNK LATCH. I WAS TO OPEN IT BY TOUCHING THE BUTTON AND THEN LIFTING FROM THE BOTTOM OF THE TRUNK. WHEN DOING THIS IT IS IMPOSSIBLE TO OPEN THE DOOR AS THE LATCH NEEDS TO BE PUSHED AT THE SAME TIME IT IS LIFTED UPWARD. OTHERWISE THE LATCH JUST STAYS LOCKED. I FIND THIS WHOLE SITUATION PROBLEMATIC AS I PURCHASED A SCION BECAUSE OF TOYOTA'S SOLID REPUTATION OF STANDING BY THEIR VEHICLES. AS MAY VEHICLE IS PAST ITS WARRANTY THIS DEFECT IS NOT COVERED. I WAS TOLD THAT AS ONE TIME GESTURE THEY WOULD FIX THE PROBLEM IF I PAID FOR IT AND THEN APPLIED FOR REIMBURSEMENT. I LIVE FROM PAYCHECK TO PAYCHECK AND DO NOT HAVE THE MONEY TO FIX THE DANGLING DOOR LATCH. AFTER SPEAKING WITH SCION OVER SEVERAL DAYS THEY AGREED TO COVER THE REPAIR IF THE DEALERSHIP WOULD BILL SCION FOR THE COST. THE ISSUE IS THAT IT WILL HAPPEN AGAIN. *TR

MY 2006 TOYOTA SCION TC HAS THIS VERY FLIMSY HATCH BACK TRUNK HANDLE(PLASTIC) THAT BROKE. I HAVE SEEN MANY SAME PROBLEM ON THE SAME MODEL TC ON THE ROAD. SO THIS IS DEFINITELY A DESIGN PROBLEM AND TOYOTA SHOULD FIX THIS. LOOKING AT HOW THIS SYSTEM WAS PUT TOGETHER, I CAN TELL WHY THIS PIECE IS NOT LASTING. *TR