2020 Subaru Forester Engine Problems

While driving my 2020 Subaru Forester at approximately 15 mph, the engine unexpectedly shut off, resulting in an immediate loss of propulsion (vehicle stall while in motion). This created a safety risk because the vehicle was in traffic and could have been struck from behind or lost the ability to accelerate out of danger. No crash occurred and there were no injuries. There were no warning lamps, warning messages, check engine light, or limp mode before, during, or after the stall event. The vehicle later experienced catastrophic engine failure, also without any warning indicators. The vehicle has been inspected by an authorized Subaru dealership. The dealership confirmed the failure and diagnosed crankshaft bearing failure on cylinder 3, and recommended short block replacement along with related engine component replacement (including cam phasers and gaskets/seals). The engine/vehicle remains available for inspection upon request. Manufacturer has been notified through Subaru of America Customer Advocacy. Subaru has offered partial goodwill assistance but has declined further escalation or full remedy. Note: I have video of this showing no engine lights however unable to upload it below. Can send via email if required. Thank you. [XXX] INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

my Subaru suddenly had numerous warning lights go on. Took it to the dealer and they said it was due to a recalled part: thermo control valve. They replaced it for free but said my head gaskets needed to be replaced after checking my oil for $4000 plus. I believe the recalled part caused the head gasket issue and shouldn’t have to pay also the mileage is only 66k

Subaru Forester engine stalls at an intersection due to auto start stop feature of subaru to save fuel, except that this is the second time when engine is idling it lowers the revs and then it stalls when trying to auto start engine; first time the dealer said is battery issue, I replaced the battery at my cost, and this is the second time. It is dangerous because there are oncoming traffic and I have only a split second to turn on my flashing lights. This is a brand new battery install on 9/2024.

"Check Engine" light along with "Eye Sight" appeared suddenly on Nov. 22, 2024. All safety systems along with cruise control became inoperable. Took car to Subaru dealer and it was confirmed to be the catalytic converter. My VIN is covered under extended warranty, but I was never notified of this. Plus, now repairs are of an emergency nature. Also, I do a lot of driving including on the NJ Turnpike, I-95, etc., and while I am awaiting car to be repaired, I have no safety features to rely on--which was one of the reasons I bought a Subaru. They will not pay for a courtesy car loan. Another issue is the Thermo Control Valve. I was notified that I have an extended warranty for this, but part has to FAIL before Subaru will make repairs. Once again this becomes an emergency repair situation instead of a proactive one.

Upon exiting freeway, all lights on car came on including brake light. When placed in park, the engine would rev. If placed in drive, car would drive without gas given. Car towed to Subaru dealership and diagnosed with thermo control valve defect which seems to be a known widespread issue. Thankfully I was located close to a Subaru dealership however if not, this could cause others to be stranded. Given this widespread issue, a recall should occur to fix this issue.

The contact owns a 2020 Subaru Forester. The contact stated while driving 70 MPH, the vehicle failed to accelerate and then stalled. The driver was able to pull over safely. There were no warning lights illuminated. The vehicle was towed to an independent mechanic, who determined that the failure was due to the thermal control valve and produced DTC codes: P2682 and P26A. The mechanic replaced the cooling gasket and coolant control valve and added coolant. The local dealer was contacted, but the vehicle was not diagnosed or repaired. The manufacturer was contacted and assisted with the repair. The approximate failure mileage was 52,395.

P2682 Engine overheating and engine gauge flashing red due to a recall related to the engine coolant bypass valve. The vehicle stopped and required a tow for $417 to the nearest Subaru dealership to repair. After towing to the dealership they charged 31% of parts to labor and would not eliminate or discount the invoice.

The contact owns a 2020 Subaru Forester. The contact stated while driving at 60 MPH, a deer jumped in the roadway causing damage to the front driver-side engine compartment. No air bags had deployed. The contact had managed to pull onto the side of the road. The contact stated she and the front passenger exited the vehicle safely when shortly afterward a fire started in the front driver-side engine compartment. No injury was sustained. A police report was filed but was unavailable. The local dealer was not contacted, and the vehicle was not diagnosed or repaired. The vehicle was towed to a tow lot where it was then taken by the insurance company. The contact stated the insurance company had the vehicle in their possession for an investigation. The origin of the fire was unknown. The manufacturer was made aware of the failure. The failure mileage was approximately 23,000.

DEFECTIVE THERMOSTATIC CONTROL VALVE- This part NEEDS to be recalled. Manufacturer has extended the warranty on the part, so it was free to replace. Otherwise, it's a $1600 part. I'm thankful they covered the price, but upset that this KNOWN issue is preventable and they've been letting people continue to be put in danger for four years now?! Incident 1) I was driving 45 mph on a busy street when the car bucked & All engine lights turned on (not helpful to pinpoint a problem) EyeSight turned off (when I needed it most.) The car was worse than dead. I was desperate to get to the shoulder, so I slammed on the emergency lights. Horrified, I realized turning the wheel did almost nothing. I had to lean on the steering wheel to get to the shoulder. When I applied gas it would choppily accelerate, so instead i let the car coast. Since i had no gas, i was stuck in the middle of a side road. I put it in park and turned it off. Someone started walking up from the bad neighborhood, wanted me to get out so he could push the car. I said no, but It took a few minutes to talk him into leaving through the glass of my window. But, this time when i started it up the dash warning lights were off Incident 2) between Oct& Nov 2024 Intermittently all the dash lights turned on, no cruise control or Eyesight. Resolved on its own. No engine trouble acompanied these. Incident 3) Nov 5th, 2024. I started my car, warmed it up, and drove for about 3 minute's when all the dashlights lit up, Eyesight failed, and the whole engine acted like it was on choppy seas. This was at night in a rural area and I was barely able to guide the car to the right shoulder because the accelerator was not working at all. Ended up slashing up my tire and ruining my rim on the shoulder of the road since the car was barely maneuverable. I could have been killed or in an accident - where is the recall on this part?? Mileage at total failure : 46,434

I was driving to work and many of my warning lights suddenly came on. This includes my check engine light, my lane assist light, my auto collision braking, my eye sight disabled and my cool engine light keeps going on and off. My cabin heating also isn’t working. There is no reason for this happening other than my thermo control valve failing.

The Thermo Control Valve is faulty and renders the vehicle non-operative. There have been numerous instances in Subaru Foresters in the same make and year.

The Thermal Control Valve failed on my car and it’s only 3 years old. This is a common issue and is widely known within the forums. Subaru should recall these valves as they are failing prematurely.

I was at a red light when the engine shut off and the check engine and several other warning lights came on. After multiple tries I was finally able to restart the vehicle and drive it off the road. After taking it to the dealership the confirmed issue is the Thermal Control Valve. The dealership is requesting about $1600 to replace the faulty part.

I stopped at a red light. The car's auto shutoff feature turned the car off for the fuel savings. When the light turned green and I went to go, the car tried to start and failed. I had to put it in park and start the car manually.

On Sunday, [XXX] we were traveling in our 2020 Subaru Forester on a trip from Minnesota to Florida for a vacation. Not long into cross country trip we found ourselves stranded on the side of the highway uncertain about the ability of our vehicle to continue to due to a defective Thermo Control Valve failure. About 200 miles into our trip, while driving at highway speeds south of Rochester, MN the dashboard lit up. The check engine light was on, and other safety features were lit up on the dash as disabled (Eye-sight technology, lane assist, automatic vehicle collision braking). The heat would not work after this incident. We checked the owners manual, and then drove to an Auto-parts store to have a scan done to determine the error code. The code "P26A3 - Engine coolant bypass valve A Range/Performance" was indicated. In checking online we discovered that a Thermo Control Valve replacement was needed ASAP and to continue driving the vehicle could risk severe engine damage. Since it was a Sunday, and we were essentially stranded if we couldn't use the vehicle. We continued on, stopping and checking the engine periodically for overheating. We were able to get an appointment at Lou Fusz Subaru in St. Peters, MO on Monday afternoon and they replaced the Thermo Control Valve at a cost of $1,961.51. We were told that this wasn't under warranty due to the mileage on the vehicle (76,358 miles). In researching this issue online, we found that the Thermo Control Valve failure to be a common issue and certain year/model vehicles and Subaru should have recalled this part a long time ago (in our opinion). INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

My thermo value went bad on my 2020 Forrester with no symptoms or warning causing me to become stranded in the middle of an extremely busy road. This is seemingly known problem and I'm unsure why Subaru has not been more proactive with this knowledge, not allowing others to end up in the same dangerous situation I was left in. Also, even after having the thermo value replaced, I have no way of knowing if any permanent damage was caused to my engine.

Started engine after parking and check engine light came on, eyesight disabled, and flashing “s”. Stopped driving and took vehicle to dealer. Diagnosed as thermo control unit. Told they didn’t have a loaner and was safe to drive for a few days. Has no heat and engine would not warm up. No safety systems. Retained 3 days later to dealer when loaner was available. Repaired under powertrain warranty.

The contact owns a 2020 Subaru Forester. The contact stated while driving 75 MPH, the Forward Collision Avoidance Automatic Emergency Braking system activated and applied the brakes. The contact was able to pull to the shoulder of the roadway, where he smelled a burnt smell in the interior of the vehicle. The vehicle returned to normal functionality, but the failure became a regular occurrence. The check engine and brake warning lights were illuminated. The vehicle was taken to the dealer, who diagnosed a failure with the throttle body. The vehicle was repaired, but the failure reoccurred. The manufacturer was notified of the failure, and a case was opened. The failure mileage was 35,600.

Check engine light came on, low temp light stays on, Eyesight disabled, lane departure, emergency breaking, etc have all been disabled due to the issue. I took it to the local autobody shop and they found code p0128 | Coolant Thermostat Issue. This has caused all safety features to become disabled as mentioned above. I was told by the local shop that I need to go to the dealership. I have not brought it to the dealership yet however, after looking online I found that this is a common issue with this make and model vehicle however, nothing has been done by Subaru to recall the component. I am going to bring the car to a dealership however, I'm upset that Subaru hasn't acted on the information that they have a faulty component in this vehicle. I am very concerned with cost of repairs since I am being forced to go to the dealer.

The thermo control valve malfunctioned causing the check engine light to come on which shut down all the safety features in the vehicle including the front eye sight camera, blind spot warning, the rear automatic braking, lane departure warning, adaptive cruise control, and lane keeping assistance. The check engine computer readout diagnostic trouble code was P26A5 "Engine Coolant Bypass Valve "A" Position Sensor Circuit Range/Performance". The vehicle was taken to a Subaru dealer who found the thermo valve performance was out of spec. This vehicle has not been recalled although the manufacturer replaced the part in 2021 vehicles acknowledging the valve was faulty. Because of the mileage on my vehicle, it was not covered under the warranty although many have been replaced under the manufacturer's warranty due to the failure of this valve under the 60,000 mile warranty. I believe this should be a recall item for others who experience this issue.