2003 Subaru Outback Tires & Wheels Problems

PRIMEWELL TIRES DEVELOPED WAVE AND INTENSE ROAD NOISE EVEN AT 50% TREAD.. HAVE BEEN BALANCED/ALIGNED REGULARLY

2003 SUBARU OUTBACK IMPREZA WAS ON THE OHIO TURNPIKE WHEN THE REAR LUG NUTS BROKE CAUSING THE TIRE TO COME OFF OF THE VEHICLE. *KB THE CONSUMER STATED THE TIRES HAD BEEN ROTATED 1 WEEK PRIOR. OHIO TRAFFIC CRASH REPORT# 10-0773-90. *JB

TL*- THE CONTACT STATED THAT A COMPANY VEHICLE, A 2003 SUBARU OUTBACK , HAS THE SAME PROBLEM THAT WAS MENTIONED IN RECALL CAMPAIGN # 02V235000. ON 02/10/07 WHILE DRIVING 55 MPH UNDER GOOD ROAD CONDITIONS THE RIGHT REAR TIRE CAME OFF THE VEHICLE. THE CONTACT STATED THAT THERE WAS NO NOTICE OF THE WHEEL HAVING ANY PROBLEMS. THE CONTACT STATED THAT THE RECALL STATED THAT THE WHEELS MAY HAVE AN OFF-CENTER DIAMETER. HE CHANGED THE TIRE, AND DROVE THE VEHICLE ABOUT 30 MILES. THE CURRENT MILEAGE WAS 111500.*AK

1. EVENTS LEADING TO FAILURE: NO ABNORMAL EVENTS PRIOR TO FAILURE (NO TIRE VISUAL INDICATIONS, NO SOUNDS, NORMAL STEERING AND SUSPENSION BEHAVIOR, NO TIRE IMPACTS). TIRE PRESSURE CHECKED MONTHLY AND TIRES ROTATED REGULARLY (~ EVERY 8,000 MI). 2. FAILURE AND ITS CONSEQUENCES: A SINGLE OEM TIRE (BRIDGESTONE POTENZA P225/60R16 E92QZ) WITH 43,700 MILES LOST ALL PRESSURE DUE TO FAILURE OF SIDEWALL, WITH SEPARATION APPARENT AROUND ENTIRE CIRCUMFERENCE OF TIRE. FAILURE OCCURRED WHILE PARKED ON LEVEL PARKING LOT SURFACE AFTER DRIVING 10 MINUTES AT MODERATE SPEED. 3. WHAT WAS DONE TO CORRECT THE FAILURE; I.E, PARTS REPAIRED OR REPLACED (AND IF OLD PART IS AVAILABLE): INTEND TO REPLACE TIRE SHORTLY. OLD TIRE IS AVAILABLE. PHOTOS AVAILABLE. *NM

TWO ORIGINAL EQUIPMENT BRIDGESTONE POTENZA TIRES ON OUR SUBARU 2003 OUTBACK FAILED AT 9,800 AND 11,700 MILES OF USE, WITHIN THREE MONTHS OF EACH OTHER. BOTH STARTED AS SLOW LEAKS FOR ABOUT A WEEK,WHICH WE MONITORED AND FILLED. THEN SUDDENLY A BIG WHITE CIRCULAR SPLIT APPEARED IN THE SIDEWALL ABOUT AN INCH AWAY FROM THE TREAD, AND TIRES WERE DEAD FLAT AND RUINED. FIRST TIRE WAS DRIVER-SIDE REAR; SECOND WAS PASSENGER-SIDE FRONT. WHEN BROUGHT TO FIRESTONE DEALER FOR WARRANTY FULFILLMENT FOR FIRST TIRE, WE WERE TOLD IT WAS OUR FAULT (?!) AND WE HAD TO PAY FOR REPLACEMENT. CAN'T WAIT TO HEAR EXPLANATION FOR SECOND INCIDENT...BUT NOT SURE I WANT ANOTHER OF THESE ON MY CAR. LOCAL SUBARU DEALER SAYS THIS IS FIRST HE'S HEARD ABOUT THESE TIRES, BUT I SEE THREE OTHER COMPLAINTS ON NHTSA WEBSITE SPECIFIC TO SUBARUS AMONG THE 92 "GENERAL" AND 37 "SIDEWALL" POTENZA COMPLAINTS. TIRE IS P225/60 R1697H. NEVER SAW ANYTHING LIKE THIS IN MY 30 YEARS OF DRIVING.*AK

WHEEL WELLS OF SUBARU OUTBACK PACK UP WITH ICE WHILE DRIVING IN HIGH MOISTURE CONTENT SNOW AND SLUSH, CAUSING TIRES TO RUB ON ICE IN WHEEL WELLS WHILE DRIVING, IMPEDING TURNING RADIUS AND ABS SYTEM.*AK

WHILE DRIVING IN A MIDDLE LANE ON I-270, I SUDENLY BECAME AWARE OF A BUMPING NOISE. I PULLED OVER TO THE RIGHT SHOULDER THROUGH SEVERAL LANES OF TRAFFIC. WHEN I CHECKED THE TIRES, I SAW THAT THE SIDEWALL OF MY PASSENGER SIDE REAR TIRE HAD BECOME COMPLETELY DISATTACHED FROM THE TREAD. THE TIRE WAS ORIGINAL EQUIPMENT ON MY 2003 SUBARU OUTBACK. A FIRESTONE DEALER INSPECTED THE TIRE IN DETAIL, BUT COULD FIND NO PUNCTURE OR OTHER CAUSE OF TIRE FAILURE BESIDES SPONTANEOUS DISINTEGRATION. FIRESTONE WANTED $56 TO REPLACE IT UNDER WARRANTY, AFTER TREADWEAR MEASUREMENT, EVEN THOUGH TIRE HAD ONLY 6800 MILES ON IT.*AK

WHILE DRIVING AT 50 MPH RIGHT REAR TIRE BLEW OUT. ORINGINAL TIRES ON VEHICLE. *AK