2008 Subaru Outback Air Bags & Restraints Problems

The dash pad in the 2005 to 2009 Subaru Legacy and Outback models have a very common problem of deteriorating to where they become sticky and then sections start cracking and falling off. My concern is that this is happening in the area of the passenger air bag. There is a portion of the dash bad which says SRS AIRBAG imprinted in the pad material and mines actually about to fall off. If the air bag should deploy from a serious enough collision, these loose pieces will be one projectiles and could easily cause injury esp to someone eye. I reached out to SOA but they offered no help. The claim number was 250530-0001813. Subaru did extend the warranty on this a few years back but they have since expired. The missing piece in the image is towards the bottom but the area directly over the airbag is severely cracked.

The contact owns a 2008 Subaru Outback. The contact stated while driving approximately 30 MPH, the passenger’s side air bag sensor light remained illuminated. The contact stated that the air bag warning light was also flashing. The failure became constant. The contact had not taken the vehicle to a local dealer. The vehicle was not repaired. The contact's husband had inspected the air bag sensor under the front passenger’s seat and determined that the sensor was functioning. The contact stated that her husband replaced the air bag sensor in the front passenger’s seat sun visor. The vehicle was repaired. The manufacturer had been informed of the failure. The failure mileage was approximately 128,000.

Airbag dashboard warning light stayed on while driving on 1/31/2022 and 2/1/2022. Dealer (Autofair Subaru in Haverhill Massachusetts) confirmed there was a problem in the overhead console. Researching the problem, I came across https://www.subaruoutback.org/threads/2006-obw-airbag-light-on-my-fix.42574/ which identified a loose component on the printed circuit board caused by a crack in the solder. Cold weather seems to exacerbate the crack and cause the component to fail intermittently. Many have reported this problem with their Subaru and have made repairs by touching up the solder. Subaru states that the collision system may not function when this condition causes the Airbag Warning Light to remain on.

2008 SUBARU OUTBACK. CONSUMER WRITES IN REGARDS TO AIRBAG SAFETY RECALL. *LD THE CONSUMER STATED THERE WERE DIFFICULTIES SCHEDULING THE RECALL REPAIR. *JS

[2008 SUBARU OUTBACK WITH 82,000 MILES, TAKADA AIRBAG REPLACEMENT JULY 2020]. AIRBAG WARNING LIGHT (RED) ILLUMINATED ON THE DASHBOARD INSTRUMENT PANEL AS SOON AS THE CAR IS TURNED ON AND REMAINS ON AS LONG AS THE ENGINE IS RUNNING WHETHER MOVING OR STATIONARY. THIS IS NOTIFYING THE DRIVER THAT THE AIRBAG SYSTEM IS INOPERABLE AS STATED BY MULTIPLE MECHANICS, SUBARU MECHANICS AND SUBARU SERVICE MANAGERS OVER DOZENS OF BLOGS AND EVEN THE SUBARU WEBSITE. OVERHEAD CONSOLE (IN MAP LIGHT GROUP) SHOWS PROPER NOTIFICATION OF SEATBELT NEED AND AIRBAG ACTIVATION WHEN WEIGHT IS EXERTED ON PASSENGER SEAT SURFACE, BUT WITH THE AIRBAG RED WARNING LIGHT LIT ON THE DASHBOARD, THE PASSENGER, AND POSSIBLY DRIVER AIRBAG, IS TOTALLY INOPERATIVE. THIS IS A SERIOUS SAFETY ISSUE AND NEGLECT BY SUBARU IN ADDRESSING THIS SAFETY PROBLEM IS OF IMMEDIATE CONCERN. HUNDREDS OF SUBARU OWNERS, MANY NOT DIRECTLY REPORTING TO NHTSA, HAVE COMPLAINED ABOUT THIS SERIOUS SAFETY ISSUE, BUT NOTHING HAS BEEN DONE.

THE TIMING BELT FAILED PREMATURELY. IT HAD BEEN REPLACED AT 70K MILES AND FAILED AT 140K MILES ON THE SECOND BELT WHICH ONLY HAD 70K MILES ON IT VERSUS THE MANUFACTURE RECOMMENDED 100K MILES REPLACEMENT INTERVAL. THIS HAPPENED DURING HIGHWAY TRAVEL AND THE VEHICLE IMMEDIATELY LOST ALL POWER AND ONLY HAD 5 SECONDS TO FIND A SAFE PLACE TO PULL OFF THE HIGHWAY. ADDITIONALLY, THE VEHICLE HAS AN AIRBAG RECALL FOR THE SECOND TIME, CITING DEATH DUE TO METAL PROJECTILE AND I AM HAVING A VERY HARD TIME HAVING THAT REPLACED AS THE CAR IS NOW BEING DRIVEN IN CANADA AND SUBARU DEALERS IN CANADA WON'T HONOR THE REQUIRED RECALL.

STICKY, MELTING DASHBOARD, SHINY AND REFLECTIVE IN DIRECT SUNLIGHT CREATING VISIBILITY PROBLEMS, UNSURE HOW IT WILL REACT IF PASSENGER AIRBAG MUST BE DEPLOYED THRU DETERIORATING DASHBOARD, AFFECTING RESALE VALUE. DASHBOARD LITERALLY COMES OFF ON HANDS OR WIPING RAGS, POSSIBLE RELEASE OF CHEMICALS INTO INTERIOR? SUBARU WILL ONLY ADDRESS 1/3 OF THE DEFECT REPAIR COST. TOTAL AVERAGE COST FOR REPLACEMENT IS APPROX $1500-1600.00, ACTUAL DASHBOARD ITSELF RETAILS FOR $502.50 FROM DEALERS AND IS APARENTLY AVAILABLE WITHIN A FEW DAYS WHEN ORDERED. SUBARU GAVE CREDIT FOR $500.00, ALMOST COVERING THE COST OF THE DASHBOARD / COVER ONLY*** APPROX. $1000 .00 IN LABOR MUST BE PAID BY CUSTOMER. CAR IS IN OTHERWISE IMMACULENT CONDITION. THIS IS A DEFECT AFFECTING SAFETY, AND IS A KNOWN PROBLEM WITH SUBARU EFFECTING ALL OF THIS MODEL AND SIMILAR MODELS WITH HIGH SUN EXPOSURE. IT IS ALSO CROSS MANUFACTURER AFFECTED, IE; TOYOTA, NISSAN, ETC. THEY HAVE TAKEN THE ROLE OF RECALL AND REPLACE. SUBARU HAS NOT TO DATE. SUBARU IS AWARE THAT THIS IS A SERIOUS PROBLEM YET REFUSES TO ACCEPT FULL RESPONSIBILITY FOR.

I BOUGHT MY CAR IN 2016 THERE WAS A RECALL ON AIRBAGS, THEY FIXED IT BEFORE I BOUGHT IT, BUT MY AIRBAG LIGHT HAS BEEN GOING ON AND OFF FOR OVER A YEAR NOW, I HAD MY MECHANIC RESET IT , BUT IT COMES BACK ON, IS IT UNDER WARRANTY STILL OR NOT ?

AFTER PASSENGER AIR BAG REPLACEMENT AIRBAG LIGHT WOULD COME ON INTERMITTENTLY. NOW AIRBAG LIGHT STAYS ON. ALSO FOUND MOISTURE FROM A/C BEING ON UNDER THE DASHBOARD AFTER PASSENGER AIR BAG WAS REPLACED. AIRBAG LIGHT STAYS ON ALL THE TIME UNTIL CAR IS TURNED OFF. MOISTURE FROM A/C IS WHEN A/C IS ON ANYTIME.

2008 SUBARU OUTBACK. CONSUMER WRITES IN REGARDS TO PASSENGER SIDE AIRBAG RECALL. CONSUMER STATES THAT VEHICLE WAS TOTALED AND WOULD LIKE FOR THEIR CONTACT INFORMATION TO BE REMOVED FROM DATABASE. *LD *JS

AIRBAG WARNING LIGHT SYSTEM IS ON INTERMITTENTLY, ESPECIALLY FOLLOWING COLD WEATHER. KEYWORDS: "SUBARU CODE 26 AIRBAG". IT IS CLEAR THAT THIS PROBLEM IS PERSISTENT AND OTHER SUBARU OWNERS REPORT THE SAME PROBLEM. THERE APPEARS TO BE A PROBLEM WITH INADEQUATE SOLDERING OF THE ELECTRONICS ON THE PRINTED CIRCUIT BOARD (PCB) RELATED TO THE AIRBAG WARNING LIGHT DISPLAY. IT IS UNCLEAR WHETHER THIS DEFECT IMPAIRS THE ABILITY OF AN AIRBAG TO DEPLOY IN THE EVENT OF AN ACCIDENT. IT CAN PRESENT ITSELF WHEN THE VEHICLE IS MOVING OR STATIONARY. MANY WEB-BASED ACCOUNTS OF THE PROBLEM HAVE REPORTED THAT CHANGES IN VEHICLE TEMPERATURE DUE TO WEATHER (PARTICULARLY ON COLD DAYS) MAY BE RELATED TO THE SOLDERING JOINT TO MALFUNCTION. IT IS NOT CLEAR TO ME WHETHER A PASSENGER IS IN DANGER IF THIS LIGHT IS ON OR IF IT IS A FAULTY SIGNAL THAT I CAN IGNORE. I WANT CLARITY REGARDING SAFETY.

TAKATA AIR BAG RELATED. WE REPLACED THE RECALLED PASSENGER TAKATA AIRBAG A WHILE AGO, AND AT THE SAME TIME PAID $297.95 TO THE DEALER TO FIX THE ISSUE (ERROR CODE 26) RELATED TO THE AIRBAG FAILURE INDICATOR WARNING LIGHT COMES. NOW WE ARE HAVING THE SAME PROBLEM AGAIN WITH THE AIRBAG FAILURE INDICATOR WARNING LIGHT, IT IS TURNED ON. SUBARU SHOULD BE PAYING FOR REPAIRING THIS RE-OCCURING PROBLEM WITH THE WARNING LIGHT AND REIMBURSING US FOR THE $297.95 WE PAID THE FIRST TIME TO FIX IT, SINCE SO MANY PEOPLE HAVE BEEN COMPLAINING ABOUT THIS PROBLEM.

"TAKATA RECALL" I UNDERSTAND THAT I MAY BE DRIVING A CAR WITH THESE AIRBAGS AND THAT THEY MAY CAUSE SERIOUS DAMAGE OR DEATH IN CASE OF AN ACCIDENT. NOTHING HAS YET HAPPENED, BUT IN THE CASE OF AN ACCIDENT THERE COULD BE SOMETHING SERIOUS.

TAKATA RECALL-- SUBARU "REPAIR" OF DEFECTIVE AIRBAGS DANGEROUS. WARNING LIGHT ILLUMINATES REGULARLY. SUBARU REFUSES TO FIX. ----NOTE SUBARU ALSO REFUSED TO REPAIR LONG REPORTED ISSUES WITH BRAKES, AIR BAG, WINDSHIELD. THEY SOUGHT $$THOUSANDS OF DOLLARS IN REPAIR BILLINGS. ALL THREE OF THESE LATER SUBJECT OF RECALLS. SUBARU REPORTED OIL CONSUMPTION DUE TO GASKET LEAKAGE, CONCERN FOR CAT CONVERTER AS POTENTIAL REPAIR BILLING. THIS APPEARS TO BE A FOURTH POTENTIAL SUBJECT OF RECALL NOW. ----- WHAT MORE HAS TO BE DEFECTIVE ON ONE CAR BEFORE ENTIRE CAR RECALLED?!

TAKATA RECALL. REPORTING MY CAR IS ON THE RECALL LIST. I WAS INFORMED WITH A LETTER FROM SUBARU MY CAR HAS THIS DEFECT. I AM MAKING AN APPOINTNENT TO HAVE IT REPLACED ASAP. IT HAS NOT DEPLOYED YET.

ORIGINAL SOLDERING IN OVERHEAD CENTER CONSOLE WHERE PASSENGER AIRBAG ON/OFF LIGHT IS LOCATED WAS LOOSE CAUSING THE AIRBAG LIGHT ON THE DASH TO TURN ON. IT SEEMS TO BE A WIDESPREAD ISSUE WITH THIS GENERATION OF SUBARU OUTBACK. WITH THE AIRBAG LIGHT ILLUMINATED ON THE DASH THE AIRBAGS MAY NOT GO OFF IN AN ACCIDENT CAUSING A MAJOR SAFETY CONCERN.

TL* TAKATA RECALL. THE CONTACT OWNS A 2008 SUBARU OUTBACK. THE CONTACT RECEIVED NOTIFICATION OF NHTSA CAMPAIGN NUMBER: 15V323000 (AIR BAGS); HOWEVER, THE PART TO DO THE REPAIR WAS UNAVAILABLE. THE CONTACT STATED THAT THE MANUFACTURER EXCEEDED A REASONABLE AMOUNT OF TIME FOR THE RECALL REPAIR. THE CONTACT MADE AN APPOINTMENT WITH A DEALER, BUT THERE WERE NO PARTS AVAILABLE WHEN THE CONTACT ARRIVED. THE MANUFACTURER WAS NOT MADE AWARE OF THE ISSUE. THE CONTACT HAD NOT EXPERIENCED A FAILURE. PARTS DISTRIBUTION DISCONNECT.

LETTER FROM CONSUMER REGARDING ISSUES WITH HIS 2008 SUBARU OUTBACK DUE TO A RECALL; SEEKING ASSISTANCE IN GETTING HIS VEHICLE CORRECTED BY JANUARY 31, 2017. *SMD THE CONSUMER REFERENCED RECALL # 15V323000. *JB

AIR BAG: THE "OVHD CONSOLE PASS ON OFF INDICATOR" HAD TO BE REPLACED. SEAT BELTS: THE FRONT DRIVER SIDE SEAT BELT DOES NOT RETRACT RELIABLY. IT HAS BROKEN THE LEFT FRONT DOOR SWITCH TWICE. WINDSHIELD WIPERS: THE WIPER BLADE TRANSMISSION UNIT HAD TO BE REPLACED.

"TAKATA RECALL" MY VEHICLE WAS TOWED TO "SUBARU OF PLANO" IN PLANO, TX. FOR AN OIL LEAK, WAS THERE FOR 3 WEEKS WHILE I WENT BACK AND FORTH WITH MY INSURANCE COMPANY. ON THE SECOND TO LAST DAY I LEARNED OF THE AIR BAG RECALL AND CALLED TO INFORM MY SERVICE ADVISOR OF THIS SINCE AT THIS POINT I WAS UNAWARE OF THE RECALL. GOT A CALL FROM HIM THE NEXT MORNING STATING THAT ALL OF THE REPAIRS HAD BE COMPLETED AND MY CAR WAS READY...? (SOUNDED FISHY TO ME..) ANYHOW, I NOTED THAT THE VEHICLE WAS ONLY DRIVEN 2 MILES IN THE THREE WEEKS IT WAS AT THE DEALERSHIP. NEEDLESS TO SAY I MADE IT A WHOLE 4 MILES BEFORE THE CAR STARTED TO DIE AND TURN OFF IN THE MIDDLE OF THE ROAD... TOOK THE CAR TO A NEAR BY SERVICE CENTER AND FOUND THAT THE DEALERSHIP PUT 2 TIMES THE AMOUNT OF OIL IN THE CAR THAT IT IS SUPPOSED TO HAVE WHICH IS CONCERNING BUT WHAT I'M REALLY CONCERNED WITH IS THE SHORT AMOUNT OF TIME IT TOOK TO INSTALL THE NEW AIRBAG, SINCE THE RECALL DEPARTMENT I ORIGINALLY SPOKE WITH STATED THAT THE PARTS WHERE STILL ON A NATIONAL BACK ORDER?