2002 Subaru WRX Suspension Problems

REFERENCE: RECALL NO. 11V-464, NHTSA CAMPAIGN NO. 11V464000 THE CORROSION DISCOVERED IN MY SUBARU 2002 WRX IS FAR MORE EXTENSIVE THAN THAT COVERED BY THE RECALL RESULTING IN CITYSIDE SUBARU DEALERSHIP (1-761-641-1900) IDENTIFYING THE VEHICLE NOT SAFE TO DRIVE. THEIR ASSESSMENT OF THE DANGEROUS RUSTING, ROTTING AND NECESSARY REPAIRS IS QUOTED HERE (I CAN PROVIDE A FACSIMILE OF THEIR ASSESSMENT UPON YOUR REQUEST). THERE IS EXTENSIVE RUSTING AND ROTTING AS WELL AS PARTS THAT HAVE ALREADY BROKEN. THE FOLLOWING IS QUOTED FROM THE CITYSIDE SUBARU DEALERSHIP INVOICE NUMBER[XXX]' TECHNICIAN STATES: VEHICLE HAS FAILED RECALL INSPECTION OF FRONT LOWER CONTROL ARMS DUE TO RUSTING. SUBFRAME IS ALSO ROTTED AND WILL NEED TO BE REPLACED. TECHNICIAN RECOMMENDS: ADDITIONALLY UPON REPLACEMENT OF CONTROL ARMS AND SUBFRAME BOTH LEFT AND RIGHT SWAYBAR LINKS ARE BROKEN $295 FRONT KNUCKLES, WHEEL BEARINGS AND INNER AND OUTER TIE ROD ENDS ARE ROTTED AND WILL NEED TO BE REPLACED $2340 BOTH FRONT STRUTS ROTTED AND MAY NEED TO BE REPLACED IF THEY ARE NOT ABLE TO BE DETACHED AND PUT BACK TOGETHER PROPERLY $509 EACH AS REQUIRED REPLACE ROTTED LEAKING OIL PAN $416 VEHICLE IS NOT SAFE TO DRIVE' I CONSIDER MYSELF LUCKY THAT THE EXTENSIVE CORROSION AND ALREADY FAILED PARTS IN AN OTHERWISE VERY CLEAN, LOW MILEAGE CAR HAVE NOT LED TO AN ACCIDENT AND SUGGEST THAT THE RECALL NEEDS TO BE BROADER IN SCOPE. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6). *TR

DRIVING SOUTHBOUND ON I-55 FOR MORNING COMMUTE IN THE LEFTMOST LANE WHEN WITH NO DISCERNIBLE CAUSE THE CAR BEGAN TO DRIFT BACK AND FORTH ACROSS THE CENTER LANE AND LEFT LANE. THE CAR MINIMALLY RESPONDED TO ANY STEERING INPUTS. I HAD TO CRANK THE WHEEL ALMOST A TURN AND A HALF TO GET MY CAR OVER TO THE SHOULDER. FORTUNATELY, THERE WERE NO CARS NEAR ME WHEN THIS HAPPENED SO I DID NOT STRIKE ANY VEHICLES. I GOT THE CAR TOWED TO A LOCAL SHOP AND THE SERVICE PERSON QUICKLY GLANCED AROUND UNDERNEATH IT AND IMMEDIATELY NOTICED THAT THE CONTROL ARM HAD RUSTED THROUGH ON THE PASSENGER SIDE. I CAME BACK LATER THAT DAY AND THEY SHOWED ME THE CAR ON THE LIFT WHERE BOTH CONTROL ARMS WERE THOROUGHLY RUSTED AS WELL AS THE SUBFRAME. I PAID TO GET THE ONE REPAIRED BUT STILL DON'T DRIVE THE CAR AS I DON'T FEEL SAFE UNTIL THE OTHER IS TAKEN CARE OF AS WELL. *TR

THE PASSENGER SIDE LOWER CONTROL ARM ON OUR 2002 SUBARU WRX WAGON SNAPPED RENDERING THE CAR INOPERABLE. THE CAR HAS BEEN TOWED TO A MECHANIC. WHEN I LOOKED UNDER THE CAR YOU COULD SEE THE ARM WAS RUSTED THROUGH. ONCE THE CAR WAS LOADED ON THE ROLLBACK THERE WAS A VISIBLE PILE OF RUST ON THE PAVEMENT. *TT

LOWER CONTROL ARM FOR MY 2002 SUBRAU WRX RUSTED COMPLETELY AND BROKE, WHICH ALSO CAUSED THE SWAY BAR TO BE RIPPED OFF. THANKFULLY IT ONLY HAPPENED PULLING OUT OF THE DRIVEWAY AND NOT ON THE HIGHWAY. *KB

I OWNED THE CAR FOR 5K MILES AND THE FRONT WHEEL BEARINGS ARE BAD. THIS IS AN EXPENSIVE REPAIR FOR A 2 YEAR OLD CAR. I SEARCHED THE INTERNET AND FOUND THIS TO BE A COMMON PROBLEM FOR SUBARUS. THE DRIVETRAIN IS NOISY, SO IT IS HARD TO DETECT DURING NORMAL DRIVING AND CAN REALLY DAMAGE THE CAR IF NOT FOUND. *JB