There are 2 owner-reported suspension complaints for the 2025 Tesla Model 3in NHTSA's database. These are unverified consumer reports and may not reflect confirmed defects.
I am reporting a safety issue involving my 2025 Tesla Model 3 Performance. My steering wheel began shaking while driving, and the vehicle felt unstable, especially at speed. I brought the vehicle to Tesla Service in Las Vegas. Their inspection found that the outer tie rod nut on the passenger front side was loose, which created steering play and caused the steering wheel shake (documented in Tesla invoice #XXX). A loose tie rod nut is a serious steering safety defect that can result in loss of steering control. Tesla performed a four-wheel alignment and tightened the components but stated the issue is “maintenance” and not covered under warranty, despite the vehicle having only 12,890 miles. Tesla also stated the steering rack had “no issues,” but they did not perform any repair on the steering system beyond tightening the loose tie rod nut and charging me for alignment. They also did not explain how a nearly new vehicle could develop a loose steering component. A loose outer tie rod nut should never occur on a new car unless there is a defect or improper assembly from the factory. This poses a significant safety hazard, especially at highway speeds. Tesla did not treat this as a steering safety defect and only attributed it to alignment. They declined warranty coverage and did not fully address the root cause. I am filing this complaint because steering components should not loosen on a 2025 model vehicle, and the situation could have resulted in loss of control or an accident. I want NHTSA to be aware in case this issue appears in other vehicles of the same model year.
The vehicle has loud creaking and groaning noises when turning the wheel at low speed or at a standstill, I’ve taken it to a Tesla service center where they claimed that this is just a characteristic of the vehicle yet I myself and a mechanic and understand that the fundamentals of suspension are the same regardless of what type of vehicle it may be and know that this is actually a known issue with Teslas especially with Model 3s. My vehicle is at 10,683 miles and still within the warranty, on Friday, September 26 at 8 AM. I dropped off my vehicle for repairs later that day at around 1645 or as known as 4:45 PM. I was messaged saying that my vehicle is ready for pick up as I read the service notes, I saw that they did not do any repair on my suspension. This is concerning to me because this is a safety issue and I highly believe that the vehicle needs to be repaired. The service center is located in Santa Clarita, California.
Complaints are unverified consumer reports submitted to NHTSA. A high complaint count may reflect vehicle popularity, not defect severity. Data sourced from NHTSA public records.
Data synced from NHTSA on May 4, 2026