2024 Toyota Camry Body & Structure Problems

The moonroof spontaneously shattered when I was driving on the freeway which sounded like a gunshot. There were no external factors such as debris from other vehicles and the temperature outside was relevantly constant at about 78F. No other cars were close to me or in front of me. For almost the entire 2 years I had my car, nothing has ever damaged the moonroof glass. I do want to note an observation that may or may not be linked to the potential safety defect: I do recall hearing strange pebble-like noises occasionally on the freeway & off the freeway at speeds of 35-65 mph. It sounds like crumbs falling down the sides/top of the car in a horizontal pattern. I observed this as early as 1 month into ownership. Upon closer inspection after stopping to inspect my vehicle, the glass shows to have shattered/blew up & outward in cube shaped pieces and the pattern of the glass appears spiderweb-like, not originating from an impact point. The fracture pattern of the remaining glass appears to match a smooth edge breakage pattern which indicates stress failure due to a spontaneous glass breakage. The dealer has denied coverage due to the technician 'finding no evidence of structural damage.' Yet, my moonroof shattered upwards and there is not evidence of an impact crater. My car is still under warranty and under 2 years old and currently is only at about 20,500 miles. The dealership quoted me 2500185 diagnostic. I will be elevating to Toyota corporate to request a closer inspection. Based on research, I discovered numerous reports of similar spontaneous sunroof failures in Toyota vehicles. The failure presents a high risk for public safety because the glass could fall into the eyes and face of the driver at highway speed. Additionally, drivers could be startled & swerve on the road at high & low speeds, on the freeway/streets. There were no warning signs/alerts. One moment I was driving to work on the quiet road & the next I heard what sounded like a gunshot.

We have purchased a used 2025 Toyota Camry from Elgin Toyota in Illinois on 2/28/2026. On Friday, March 6, 2026, at approximately 11:50 AM, my husband, [XXX] , left his place of employment (Amazon in [XXX] ). While traveling southbound on the interstate at highway speed, the rear bumper cover suddenly detached from the vehicle and flew off. He safely pulled off the interstate at approximately 12:26 PM and called me in a panic to explain what had happened. I immediately asked if he had struck any road debris or run over anything while driving. He confirmed that he had not. This occurred after the Highway XX exit in [XXX] and before any [XXX] exits on the interstate. When [XXX] was still driving, he saw in his rear view mirror a semi-truck had run over the bumper cover, making it unsafe for him to retrieve any remaining pieces from the roadway. I instructed him to return home immediately and park the vehicle safely under our carport. Following this incident, I contacted two separate body shops to obtain repair estimates. Both shops expressed significant concern and stated they had never seen a bumper cover simply detach from a vehicle under normal driving conditions—especially on a recently purchased vehicle that should have been inspected prior to sale. One body shop owner specifically advised that we contact the dealership immediately, as this type of issue should not occur if the vehicle had been properly inspected. Frankly, I am extremely concerned and alarmed by this situation. We had been in possession of the vehicle for less than one week. If this had occurred during heavy traffic or rush hour, the detached bumper could have caused a serious accident or injury to other drivers on the interstate. For documentation purposes, I do have Ring camera footage showing the 2024 Toyota Camry leaving our home on the morning of March 6, 2026, at 6:19 AM with the bumper cover intact. Additional footage may also be available from XXXin [XXX] showing [XXX] INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

The contact owns a 2024 Toyota Camry. The contact stated that the carpeting on the driver's side foot well was coming unglued on the left side, close to the brake pedal. The vehicle was taken to a local dealer to have the carpet reglued. The vehicle was repaired; however, the carpet started to detach again from the vehicle's foot well, and the contact took the vehicle back to the same dealer and was advised that it was a known issue, and there was a Technical Service Bulletin: SB-0101-24 for the repair. The vehicle was repaired but the failure reoccurred. The manufacturer was informed of the failure. The failure mileage was approximately 20,000.

I purchased a certified preowned vehicle from Fowler Toyota in [XXX] , and after complaining multiple times about my engine being too loud, a musty smell in my trunk, the attempting to clean my trunk and me pointing out rust spots in the trunk and the smell returning multiple times, and a sulfur smell that continued to get worse month after month, they finally listened to me the 3rd week of November and discovered that this car that had a previous cosmetic accident to the rear of the car before being certified, indeed had a failing catalytic converter, a misaligned trunk as well as a busted strut among other issues. There was exhaust getting into my car, causing myself, headaches, my [XXX] and [XXX] to take a nap as soon as I would pick them up from school every day for the last month that I had it before they took it in November that all of this resolved after I was given a rental. I also periodically on a weekly basis, took my pregnant daughter to her doctors appointment so she was exposed as well. My husband occasionally rode with me also among other people. After 3 1/2 months of my car being “fixed”, it was returned to me and I was told it was in perfect condition and Toyota corporate had inspected it. Approximately 10 days after picking it up, I took a long drive out on a highway with traffic lights on my way back. I started to fall asleep. I feel like I had bricks on my eyelids and it was only 3:30 in the afternoon. I almost crashed into a wall on the side. I rolled my window down and instantly felt better. I purchased a carbon monoxide monitor and after three days it registered and went off at a level of 49. I tried to take it in after calling the dealer that day, but they did not have a car for me. They only had a 4Runner that I’m not comfortable driving so I had to wait another 36 hours on a car. The next day, the carbon monoxide detector went off and registered at 315 only in a parking lot. No lights on my car are showing anything is wrong. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

I am an Uber driver and most passengers normally sitting in the rear (passenger/right side), have issues opening the door while exiting the vehicle. They generally pull the lever expecting the the door to open, but I always have to tell them to pull the lever while simultaneously pushing the door outwards (which is abnormal). This problem has been ongoing since I purchased this vehicle new in December of 2023. I reported this issue to my local Toyota dealership.

The vehicle was bought on January 6, 2024. Less than three months after driving, it was raining that day. I opened the sun visor of the sunroof and saw that the sunroof was leaking. After careful inspection, I found that the hardware of the sunroof was defective. The dealer refused to repair it or replace it for me, saying that it was a normal vehicle. I am afraid that due to quality problems, the sunroof will be blown off by the wind when driving on the highway, or rain will leak into the car, which will cause serious safety hazards. I need them to replace me with a new car.

There is a vibration sound that occurs when the brake is pressed or depressed. When driving the sound is not present. I brought it to the Smithtown Toyota dealership and they couldn’t find anything and said they heard nothing in the video I sent. After countless hours troubleshooting I traced the sound to the driver well area by the brake and gas pedal. The sound and vibration seems to be transferring from the engine area.