2007 Toyota FJ Cruiser Complaint Log

THE PASSENGER SIDEMSEAT BELT WILL NOT RETRACT AND IS NO LONGER A FUNCTIONING SET BELT. *TR

TL* THE CONTACT OWNS A 2007 TOYOTA FJ CRUISER. THE CONTACT STATED THAT WHILE DRIVING APPROXIMATELY 35 MPH, THE INSTRUMENT PANEL LIGHTING AND GAUGES BEGAN TO FLUCTUATE ERRATICALLY AS THE VEHICLE SUDDENLY STALLED. THE CONTACT WAS ABLE TO RESTART THE VEHICLE. THE VEHICLE WAS TAKEN TO THE DEALER FOR DIAGNOSTIC TESTING WHERE THE TECHNICIAN ADVISED THAT THE ABS SYSTEM WOULD HAVE TO BE REPLACED. THE VEHICLE WAS REPAIRED BUT THE FAILURE RECURRED. IN ADDITION, THE INSTRUMENT PANEL LIGHTING WOULD NOT ILLUMINATE AND GAUGES WOULD NOT PROVIDE A READING. THE CONTACT WAS ABLE TO RESTART THE VEHICLE BUT THE BRAKES WOULD NOT RESPOND. AFTER SHUTTING THE ENGINE OFF THE VEHICLE COULD NOT BE RESTARTED. THE CONTACT INSPECTED THE VEHICLE AND DISCOVERED THAT THE BATTERY WAS MELTED. THE VEHICLE WAS TOWED TO THE DEALER FOR DIAGNOSTIC TESTING WHERE THE TECHNICIAN ADVISED THAT THE BATTERY, WIRING HARNESS, ALTERNATOR AND THE FUSE BOX WOULD HAVE TO BE REPLACED. THE VEHICLE WAS NOT REPAIRED. THE APPROXIMATE FAILURE MILEAGE WAS 75,000.

REAR DIFFERENTIAL FAILURE. THIS IS A COMMON PROBLEM IN THE EARLY YEAR MODELS OF THIS VEHICLE. STARTS WITH LOUD WHINING FROM REAR OF CAR FOLLOWED BY COMPLETE FAILURE OF GEARS INSIDE REAR DIFFERENTIAL. *TR

WHILE DRIVING MY CERTIFIED PRE-OWNED FJ AT 65MPH, I EXPERIENCE SIGNIFICANT STEERING WHEEL SHIMMY WHERE THE STEERING WHEEL OSCILLATED LEFT AND RIGHT AT LEAST15 DEGREES IN EACH DIRECTION. AS SOON AS VEHICLE SPEED DROPPED TO 64MPH, THE OSCILLATION STOPPED. THIS IS REPEATABLE. THE VEHICLE HAS STOCK WHEELS AND TIRES. *TR

TL* THE CONTACT OWNS A 2007 TOYOTA FJ CRUISER. THE CONTACT STATED THE DRIVER'S SIDE DOOR WAS RUSTED FROM THE INSIDE TO THE OUTSIDE. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURE WAS CONTACTED AND STATED THAT THE FAILURE WAS AN ISOLATED EVENT CAUSED BY ENVIRONMENTAL CONDITIONS. THE VEHICLE WAS NOT REPAIRED. THE APPROXIMATE FAILURE MILEAGE WAS 75,000.

WHEN YOU GET ABOVE 55 THE STEERING WHEEL BEGINS TO SHAKE AND ALSO WHEN BRAKING. *TR

TL* THE CONTACT OWNS A 2007 TOYOTA FJ CRUISER. THE CONTACT STATED THAT WHEN DRIVING 40 MPH AND ABOVE, HE WOULD HEAR A LOUD WHINING NOISE COMING FROM THE REAR END OF THE VEHICLE. THE VEHICLE WAS TAKEN TO A DEALER FOR DIAGNOSIS WHERE THE CONTACT WAS ADVISED THAT THE PINION GEARS AND DRIVER'S SIDE REAR WHEEL BEARING ASSEMBLY FAILED. THE VEHICLE WAS NOT REPAIRED. APPROXIMATELY TWO MONTHS PRIOR TO THE RECENT FAILURE, THE VEHICLE WAS REPAIRED FOR THE REAR PASSENGER'S SIDE WHEEL BEARING ASSEMBLY. THE MANUFACTURER WAS CONTACTED AND THEY OFFERED NO ASSISTANCE. THE FAILURE MILEAGE WAS APPROXIMATELY 135,000. THE CURRENT MILEAGE IS APPROXIMATELY 140,000. ..UPDATED 12/06/12 *BF

ONCE VEHICLE IS CRUISING ON HIGHWAY AT SPEEDS BETWEEN 55-70MPH, STEERING WHEEL SHAKES UNCONTROLLABLY. HAVE HAD THE TIRES SWAPPED, ROTATED AND BALANCED AT DIFFERENT BUSINESS AND STILL HAVE SAME ISSUE. DEALERSHIP SAYS EVERYTHING IS FINE. DID A TEST DRIVE WITH THEM AND IT SHOOK AND STILL SAID EVERYTHING WAS FINE. *TR

SINCE LATE JUNE OF 2012, MY TRD FJ CRUISER HAS HAD SERIOUS STEERING WHEEL SHAKE AT ABOUT 62 MILES AN HOUR. IT SEEMS AS THOUGH THE STEERING WHEEL VIBRATES SLIGHTLY BETWEEN 55-60 AND 65-70 BUT EXPERIENCES PEAK SHAKE AT ABOUT 62 EXACTLY. THE SHAKE IN THE STEERING IS INCREDIBLY VIGOROUS AND MAKES ME CONCERNED FOR THE SAFETY OF THE VEHICLE. I HAVE SPOKEN WITH MECHANICS AT MY LOCAL TRUCK SHOP AND THEY DO NOT KNOW WHAT THE PROBLEM COULD BE AS THE SUSPENSION IS NOT SIGNIFICANTLY RAISED AND THE WHEELS ARE IN GOOD SHAPE WITH A RECENT ALIGNMENT. THE STEERING ALSO THE STEERING LISTS TO THE RIGHT NOTICEABLY WHEN AT IT'S FULL VIBRATION SPEED (62 MPH). *TR

THE FJ CRUISER I PURCHASED IN 2007 WAS QUITE RELIABLE UNTIL RECENTLY AND IT SEEMS THAT THIS IS A SERIOUS DEFECT WITH THE MACHINED DIFFERENTIAL IN EARLY BUILDS OF THIS MODEL. TOYOTA WILL NOT TAKE RESPONSIBILITY FOR THIS DEFECTIVE DIFFERENTIAL FOR SOME REASON ALTHOUGH THERE HAVE BEEN OVER 1000 CASES SO FAR POSTED ON THE INTERNET SPECIFICALLY RELATED TO THE CARBON BRITTLELY IN THE DIFFERENTIALS THAT ARE FAILING. I HAVE INCLUDED A FEW REFERENCES BELOW: HTTP://WWW.FJCRUISERFORUMS.COM/FORUMS/PROBLEMS-DEALER-SERVICE/35767-BROKEN-REAR-DIFF-BUILD-DATE-PLEASE.HTML HTTP://WWW.FJCRUISERFORUMS.COM/FORUMS/TRANSMISSIONS-TRANSFER-CASES-TRACTION-AIDS/126060-REAR-DIFF-PROBLEM-07-A.HTML HTTP://WWW.ARFC.ORG/COMPLAINTS/2007/TOYOTA/FJ_CRUISER/ I TOOK MY CAR TO THE TOYOTA DEALER OF MARIN AND THEY ARE NOW TRYING TO CHARGE ME $2200 FOR A NEW DIFFERENTIAL, I AM REFUSING TO PAY AND I SPOKE TO TOYOTA, THEY ARE DENYING THERE IS A PROBLEM. HERE IS MY TOYOTA CASE NUMBER, [XXX] PLEASE HELP RESOLVE THIS SERIOUS ISSUE. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6). *TR

LOTS OF FRAME AND OTHER UNDERCARRIAGE RUST.

THE DRIVER FOOT REST (DEAD PEDAL) ON THIS CAR BRAKES LOOSE EASILY AND BECOMES A LOOSE OBJECT UNDER AND AROUND THE DRIVER FOOT PEDALS. I HAD MIND COME LOOSE WHILE DRIVING AND DIDN'T REALIZE IT UNTIL I ATTEMPED TO STOP MY CAR AND WAS UNABLE TO DEPRESS THE BRAKE PEDAL BECAUSE THE BROKEN FOOT REST HAD LODGED IT'S SELF UNDER THE BRAKE PEDAL AFTER BRAKING LOOSE. I ENDED UP HAVING TO SWERVE AROUND THE CAR IN FRONT OF ME ON THE HIGHWAY TO AVOID AN ACCIDENT, BEFORE STOPPING WITH THE E-BRAKE ON THE SIDE OF THE HIGHWAY. EXTREMELY DANGEROUS! *TR

TO WHOM IT MAY CONCERN, I RECENTLY BOUGHT OUT THE LEASE OF MY 20007 FJ CRUISER FROM THE HOLLYWOOD TOYOTA DEALERSHIP. I'M WRITING TO NOTIFY YOU THAT I AM EXTREMELY UNHAPPY WITH MY SERVICE AND THAT I FEEL UNSAFE IN MY TOYOTA VEHICLE. I RECENTLY HAD TO HAVE MY FJ CRUISER TOWED TO THE DEALERSHIP BECAUSE MY FRONT WHEEL NEARLY FELL OFF WHILE I WAS DRIVING. WHEN I INSPECTED THE TIRE IT WAS CLEAR THAT THE WHEEL STUDS HAD BROKEN CLEAN OFF THE BODY. THE TIRE WAS BARELY HANGING ON BY A THREAD. I'D LIKE TO NOTE THAT UPON PURCHASING THE VEHICLE, I PAID A SUBSTANTIAL AMOUNT OF EXTRA MONEY TO HAVE IT "CERTIFIED" BY THE DEALERSHIP SERVICE DEPARTMENT. IT HAS BEEN SERVICED AT THE DEALERSHIP SINCE THE CERTIFICATION AND IT HAS ONLY EVER BEEN WORKED ON BY TOYOTA DEALER SERVICE TECHNICIANS. I NEVER HEARD ABOUT ANY ISSUES WITH WHEELS OR ABOUT WHEEL DEFECTS OR RECALLS. AFTER THE WHEEL INCIDENT, THE HOLLYWOOD TOYOTA SERVICE DEPARTMENT NOTIFIED ME THAT THE WHEEL STUDS WERE DEFECTIVE AND HAD FAILED. I HAVE NEVER BEEN NOTIFIED BY TOYOTA ABOUT THIS POSSIBLE ISSUE IN MY MODEL CAR. I BELIEVE THAT IF THERE IS A KNOWN DEFECT IN A PRODUCT THAT ALL TOYOTA OWNERS SHOULD BE NOTIFIED ABOUT IT. AFTER ONLY THE HUB WITH OBVIOUSLY BROKEN STUDS WAS REPLACED THE DEALERSHIP SERVICE DEPARTMENT TOLD ME THAT THERE WAS NO GUARANTEE THAT MORE WHEEL STUDS WOULDN'T BREAK OFF MY OTHER WHEELS. IF I CANNOT BE GUARANTEED BY TOYOTA THAT THE WHEELS WILL STAY ON MY CAR WHILE I DRIVE IT THEN I HAVE TO SAY THAT I HAVE LOST ALL CONFIDENCE IN THE BRAND AND WILL NEVER PURCHASE ANOTHER PRODUCT FROM BOTH TOYOTA OR THIS DEALERSHIP EVER AGAIN. I ALSO ASKED THE SERVICE DEPARTMENT TO NOTIFY THE SALES MANAGER THAT SOLD ME THE VEHICLE SO THEY COULD FOLLOW UP WITH ME TO REASSURE ME ABOUT THE REPAIRS. THIS REQUEST WAS IGNORED. [XXX] INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6). *TR

THE INNER FENDER WELL APRON CRUSH ZONES ARE BUCKLING, CRACKING AND RIPPING UNDER NORMAL DRIVING CONDITIONS - IT APPEARS THE FRAME HAS TOO MUCH FLEX AND IS CAUSING THE WEAK SPOT IN THE INNER FENDER WELL TO BREAK. CONCERNED THAT BECAUSE THIS IS A SAFETY RELATED AREA OF THE BODY THAT THIS ISSUE MIGHT IMPACT THE STRUCTURAL INTEGRITY OF THE VEHICLE IN AN ACCIDENT, OR EVEN UNDER NORMAL OPERATING CONDITIONS. THE VEHICLE HAS BEEN TAKEN TO THE TOYOTA DEALER, AND A TOYOTA FIELD ENGINEER EXAMINED THE VEHICLE, INCLUDING TAKING NUMEROUS PICTURES. NO REPAIRS WERE OFFERED AT THAT TIME, AS THEY WERE UNSURE OF THE CAUSE OR REMEDY. *TR

MY FRAME HAS AN EXCESSIVE AMOUNT OF RUST AND I AM CONCERNED THAT IT IS GOING TO BEGIN DETERIORATING.

I BELIEVE THAT SEAT BELTS ARE ONE OF THE MOST IMPORTANT SAFETY FEATURES ON A CAR AND SHOULD LAST THE LIFE OF A CAR. I AM VERY SURPRISED THAT THE SEAT BELTS ON THIS CAR STARTED TO SHOW A FAILING TREND AT ALMOST 40000 MILES. BOTH PASSENGER AND DRIVER SIDES ARE FAILING, RETRACTING AND LOCKING-UP ISSUES. PASSENGER SIDE COMPLETELY FAILED YESTERDAY, IT IS LOCKED UP. COST TO FIX IS VERY EXPENSIVE. .MANY FJ OWNERS ARE REPORTING THE SAME PROBLEM, I ENCOURAGE THOSE WITH THE SAME ISSUE TO FILE A COMPLAINT RATHER THAN POSTING IT ON FJ CRUISER FORUM. IT SHOULD BE A RECALL ISSUE AND TOYOTA SHOULD ASSUME SUCH A RESPONSIBILITY FOR FIXING AN IMPORTANT SAFETY FEATURE. *TR

WHILE SLOWING FOR A RED LIGHT, I SLID ON A SMALL PATCH OF ICE. THE BRAKE PEDAL WENT TO THE FLOOR AND THE ABS SYSTEM RELEASED MY BRAKES. I LIFTED MY FOOT OFF THE BRAKE PEDAL AND THE ABS DISENGAGED. I REAPPLIED THE BRAKES AND STOPPED THE VEHICLE. *TR

AT 55 MPH, I APPLIED MY BRAKES AND RATHER THAN STOPPING THE VEHICLE, THE BRAKE PAD WENT ALL THE WAY TO THE FLOOR. BY PUMPING THE BRAKES REPEATEDLY AND SLOWING TO A POINT I COULD APPLY THE EMERGENCY BRAKE, I WAS ABLE TO STOP THE VEHICLE. HAD I NEEDED TO STOP QUICKLY, I WOULD NOT HAVE BEEN ABLE TO. THE MASTER CYLINDER FAILED CAUSING THE BRAKING ISSUE. I HAD THE COMPONENT REPLACED AND HAVE HAD NO BRAKING ISSUES SINCE. THE MASTER CYLINDER HAS BEEN RECALLED ON 740,000 TOYOTA VEHICLES, BUT NOT THE FJ CRUISER. ISSUES WITH BRAKING/MASTER CYLINDER HAVE BEEN REPORTING ON WWW.NHTSA.GOV FOR THE 2007 FJ CRUISER, SO THIS IS A KNOWN ISSUE. I HAVE REQUESTED THAT TOYOTA OPEN AN INVESTIGATION FOR THIS ISSUE, BUT THEY HAVE NOT. *TR

CRACKS APPEARED IN INNER FENDER ON THE FRONT DRIVER AND PASSENGER SIDES. THE CRACKS WERE PROCEEDED BY A BULGE IN THE SHEET METAL. *TR

STEERING SHAKES AT SPEEDS AT AND ABOVE 35 MPH, I HAD THE DEALER LOOK AT IT AND THEY SAY IT IS OKAY. IT HAS PRETTY MUCH BEEN THERE FOR THE PAST YEAR, I HAD A 93 LAND CRUISER WITH 253000 MILES THAT DID NOT HAVE STEERING WHEEL SHAKE LIKE THE FJ DOES. *TR

THE LEFT FOOT REST FELL OFF WHILE DRIVING AND ALMOST GOT STUCK UNDERNEATH THE BRAKE PEDAL. *TR

HEARD NOISE COMING FROM BACK OF CAR. SOUNDED LIKE IT COULD BE THE BRAKES. TOOK IT TO TOYOTA, WAS TOLD IT WAS THE REAR DIFFERENTIAL. MY HUSBAND IS A QUADRIPLEGIC AND WE HAVE A LIFT ON THE BACK OF OUR CAR. NEED IT FOR HIS SCOOTER. CAR ONLY HAD A LITTLE OVER 80,000 MILES ON IT. HAVE ALWAYS BOUGHT TOYOTA... NO ONE WILL HELP. WON'T EVEN MEET ME HALF WAY. NOT THE DEALER, NOT THE PEOPLE I WROTE TO AT TOYOTA, NO ONE. THIS IS NOT RIGHT. I HAVE EVEN GONE ONLINE AND FOUND MANY OTHERS WITH THE SAME COMPLAINT. WILL ANYONE LISTEN? IT IS IN THE SHOP RIGHT NOW AND WE ARE HAVING IT REPAIRED FOR JUST OVER $1,600 DOLLARS. *JS

THE INNER FENDER WALL LINERS ARE SPLITTING ON EACH SIDE. THE FJ HAS ON 69K MILES. WE ONLY FOUND OUT ABOUT THIS PROBLEM WHEN WE TOOK THE VEHICLE INTO THE DEAL FOR NOISES WE HEARD UNDER THE HOOD. TOYOTA REFUSES REPAIRING THE PROBLEM COMPLETELY. *TR

2007 TOYOTA FJ CRUISER. PASSENGER SEAT BELT WOULD NOT RETRACT BACKWARD. THE VEHICLE WAS TAKEN TO THE TOYOTA DEALER WHO ADVISED THAT BECAUSE THE VEHICLE WAS OUTSIDE OF THE 6 YEAR/60,000 MILE WARRANTY AND NO RECALLS, THE REPAIR/REPLACEMENT OF THE PASSENGER SEAT BELT ASSEMBLY WAS AT MY EXPENSE. THE DRIVER SIDE SEAT BELT IS ALSO SHOWING SIGNS OF A WEAK RETRACT AND APPEARS THAT IT WILL ALSO REQUIRE REPLACEMENT SOON. *TR

THERE ARE TIMES WHEN MY 2007 FJ CRUISER STARTS TO SHAKE. ALSO SINCE I FIRST BOUGHT MY VEHICLE, AS I PRESSED ON THE BRAKES WHILE BEING AT A STOP LIGHT, IT WOULD JERK AND FEEL AS IF SOMEONE HAD SLIGHTLY BUMPED INTO ME FROM THE REAR OF THE VEHICLE WHEN THERE WAS CLEARLY NO ONE BEHIND MY VEHICLE. THIS HAPPENS QUITE A BIT. MY MAIN CONCERN IS THAT AS I WAS DRIVING RECENTLY I COMPRESSED THE BRAKES BEFORE ATTEMPTING A TURN AND ABSOLUTELY NO BRAKING ACTION HAPPENED. I WASN'T GOING FAST ENOUGH TO OVERTURN THE VEHICLE, BUT NONE THE LESS IT IS A VERY DANGEROUS THING FOR A VEHICLE SUCH AS THE FJ CRUISER TO MAKE TURNS AT CERTAIN SPEEDS, SO FOR THE BRAKES NOT TO WORK AT AN IMPORTANT TIME CAN CAUSE A SEVERE, IF NOT FATAL ACCIDENT. AS I MADE THE TURN EFFICIENTLY(BY MAKING A WIDER TURN), I TRIED ONCE AGAIN TO USE MY BRAKES IN WHICH THEY FELT LIKE THEY WERE TRYING TO CATCH AGAIN. AT THIS TIME I FELT UNSAFE AND FELT COMPELLED TO USE THE EMERGENCY BRAKE. I HAVE TAKEN MY VEHICLE TO GET LOOKED AT AND THEY HAVE STATED AN ISSUE WITH THE MASTER CYLINDER. I HAVE TAKEN THE TIME TO LOOK AT VARIOUS SITES AND FORUMS IN WHICH MANY PEOPLE HAVE COMPLAINTS OF THE SAME ISSUES. THIS IS A VERY DANGEROUS ISSUE FOR A VEHICLE THAT ALREADY HAS A CAUTION FOR TURNOVERS. MY VEHICLE IS A 2007 WITH UNDER 39,000 MILES ON IT. THIS SHOULD NOT BE HAPPENING TO A VEHICLE WITH MILEAGE SUCH AS THIS. PLEASE ADDRESS THIS ISSUE FOR THE CONCERN OF ALL FJ CRUISER OWNERS AND THE SAFETY OF ALL OTHER DRIVERS AROUND THIS FAULTY ACTION. THANK YOU. *KB

INFORMED VIA THE INTERNET ABOUT POSSIBLE PROBLEM, WITH AT THIS TIME UNKNOWN CAUSE, DECEMBER 2006. INNER FRONT FENDER RIPPING AND BULGING OF FENDER SUPPORT PANELS LEADING EVENTUALLY TO JAMMING OF FRONT DOORS WHILE IN THE CLOSED POSITION WHEN FRONT FENDERS DROP DOWN TO A LOWER POSITION ON FRAME BLOCKING SAME. THIS APPEARS TO BE OCCURRING TO APPROXIMATELY 20% OF THE OLDER VEHICLES WITH BUILD DATES OF 06', 07' & 08' WITH MILEAGE FROM 10,000 TO 75,000. INFORMATION GATHERED FROM FJ CRUISER FORUM VIA THE INTERNET AND WEB RESEARCH. VEHICLE HAS BEEN TAKEN TO DEALER FOR INSPECTION AND AM AWAITING A RESPONSE. DAMAGE WAS NOT DISCOVERED UNTIL 60600 MILES WHEN VEHICLE WAS BEING INSPECTED AFTER DETAILING, MILEAGE OF DAMAGE OCCURRENCE IS UNKNOWN. DEALER INSPECTED VEHICLE AND TOOK PICTURES AT THEIR LOCATION. *TR

TL* THE CONTACT OWNS A 2007 TOYOTA FJ CRUISER. THE CONTACT WAS DRIVING AND WHEN THE BRAKE PEDAL WAS ENGAGED IT WENT TO THE FLOOR AND THE CONTACT HAD TO USE THE EMERGENCY BRAKE IN ORDER TO STOP THE VEHICLE. THE CONTACT TOOK THE VEHICLE TO THE DEALER AND WAS TOLD THE MASTER BRAKE CYLINDER FAILED TO MAINTAIN PRESSURE AND THAT CAUSED THE FAILURE. THE VIN WAS UNAVAILABLE. THE FAILURE MILEAGE AND CURRENT MILEAGES WERE 83,000.

PURCHASED CERTIFIED USED TOYOTA AND NEVER TRIED TO USE REAR SEAT BELTS. WHEN WE TRIED TO USE SEAT BELTS ALL THE REAR SEAT BELTS WERE NOT WORKING" WOULD NOT LATCH". *TR

NOTICED A VIBRATION IN THE BRAKE PEDAL. IT STOPPED AFTER A WHILE. TWO WEEKS LATER, VEHICLE SHUDDERED WHILE BRAKING TO A STOP AT A VERY LOW SPEED. ALL THE DASH EMERGENCY LIGHTS FOR BRAKES, ABS, VSC, LIT UP AND BRAKING ABILITY CEASED. USED EMERGENCY HAND BRAKE TO STOP. PARKED VEHICLE AND HAD TOWED TO TOYOTA DEALER PER INSTRUCTIONS IN OWNERS MANUAL. COMPUTER ANALYSIS INDICATED FAILED MASTER CYLINDER. 2007 FJ CRUISER W/55,000 MILES. $2258 COST OF NEW MASTER CYLINDER ASSEMBLY + $495 LABOR + $101 TOWING + $10 MISC + $218 TAX = $3082.19 TOTAL COST FOR PART REPLACEMENT. HAVE OLD PART IN POSSESSION. *TR

I OWN A 2007 TOYOTA FJ, IN VARIOUS OCCASIONS WHEN APPLYING MEDIUM HARD PRESSURE TO THE BRAKES, I HAVE TWO DIFFERENT BRAKE REACTIONS: 1. THE TIRES WILL LOCK AND SCREECH FOR A SHORT PERIOD OF TIME, MOMENTARILY LOOSING CONTROL, I AUTOMATICALLY LET GO OF THE BRAKE PEDAL, PUSH AGAIN TO REGAIN CONTROL AND THEN THE CAR JUST KEEPS ROLLING LIKE NO BRAKES WERE APPLIED. OR, 2. IF I HAVE TO PRESS ON THE BRAKES AND THE ROAD THE CAR HAPPENS TO BE ON IS A BIT ROUGH, WITH GRAVEL, RIDGES OR POTHOLES OR MAYBE JUST A POORLY PATCHED ASPHALT, THE CAR WILL SUDDENLY JUST ROLL, LIKE NO BRAKE HAS BEEN APPLIED, EVEN THOUGH I AM PRESSING ON THE BRAKE PEDAL, LIKE LOOSING MOST OF OR ALL BRAKING POWER. LAST EVENT HAPPENED A COUPLE OF DAYS AGO WHERE A CAR CUT ME OFF BY A TOLL PAY AREA, I PRESSED ON THE BRAKES HARD JUST AS THE CAR WAS GOING OVER A ROUGH SECTION OF THE ROAD AND IT KEPT ROLLING AS WITH NO BRAKES, AND LITERALLY JUST BY FRACTIONS OF AN INCH DID NOT HIT THE OTHER CAR. I HAVE GONE TO THE DEALER WITH THE COMPLAIN, THEY WANT ME TO PAY FOR CHECKING THE PROBLEM, BUT I AM GOING TO HAVE A TOUGH TIME REPRODUCING THE PROBLEM, EVEN THOUGH IT IS PRETTY CONSISTENT, ITS REALLY NOT SAFE TO TRY TO REPRODUCE. AS I SAID PREVIOUSLY THE STATED EVENT WAS NOT THE FIRST ONE BUT CERTAINLY THE MOST SCARY, AND HAS HAPPENED AT LEAST 4 TO 5 TIMES IN THE YEARS I'VE OWNED THE CAR. *TR

LEFT SECTION OF THE HOOD OF A 2007 TOYOTA FJ CRUISER FLEW OFF WHILE DRIVING ON THE HIGHWAY, CAUSING CARS TO SWERVE. NO WRECKS. I TOOK THE CAR TO A BODY SHOP AND THEY SAID THOSE PANEL FLY OFF ALL THE TIME BECAUSE THEY ARE NOT AFFIXED IN PLACE. NO SCREWS, GLUE, OR NAILS. NOTHING. VERY DANGEROUS. COULD HAVE KILLED FAMILIES TRAVELING ALONG THE HIGHWAY FOR SUMMER VACATIONS. *TR

NEW CAR RUSTED VERY QUICKLY. FUEL TANK STRAPS RUSTING ALSO.

SINCE I PURCHASED THE VEHICLE BRAND NEW IN 2006 IT HAS BEEN RUSTING AND AN ALARMING RATE. EVEN MY MECHANIC SAYS HE'S NEVER SEEN A NEW CAR RUST THAT QUICKLY. THE FRAME IS COVERED I RUST, I TRIED TO STOP IT BUT IT DIDN'T WORK.

2007 FJ CRUISER WITH 60,000 BLEW A HEAD GASKET. THERE IS MAJOR ENGINE DAMAGE FROM OVER HEATING. TEMP GAUGE NEVER READ THAT THE CAR WAS OVER HEATING OR THAT THERE WERE ANY ENGINE PROBLEMS. ALSO AT A RED LIGHT THE CAR SWITCHED GEARS AND A MOMENT LATER SWITCHED BACK .IT LURCHED FORWARD WITH A BIG THUMP. I WAS AT A FULL STOP WITH MY FOOT ON THE BRAKE LUCKILY! *TR

TL* THE CONTACT OWNS A 2007 TOYOTA FJ CRUSIER. THE CONTACT STATED THAT THE SEAT BELTS WOULD NOT RETRACT BACKWARD. THE VEHICLE WAS TAKEN TO THE DEALER WHO ADVISED THAT BECAUSE THE VEHICLE WAS OUTSIDE OF WARRANTY AND THERE WERE NO RECALLS, REPAIRS WOULD BE AT THE CONTACTS EXPENSE. THE MANUFACTURER CONFIRMED WHAT THE DEALER STATED AND PROVIDED NO FURTHER ASSISTANCE. THE FAILURE MILEAGE WAS 54,000.

ON JAN.7TH AROUND 10:00PM MY SON AND HIS COUSIN AND HER BOY FRIEND WAS GOING TO THE STORE FOR SNACKS. THE ROAD WAS COVERED WITH SNOW AND HE HAD THE FJ CRUISER IN 4-WHEEL DRIVE. THE FJ CRUISER SLID OFF THE ROAD AND FLIPPED OVER INTO THE RIVER. THE VEHICLE HAS SEVERAL AIR BAGS IN IT AND NOT ONE OF THEM DEPLOYED. THANK GOD, THEY WERE NOT HURT, ALTHOUGH THEY DID GO TO THE HOSPITAL. NEED LESS TO SAY THE FJ CRUISER WAS TOTALED. NO ONE OF THE AIR BAGS WENT OFF. *TR

TL *THE CONTACT OWNS A 2007 TOYOTA FJ CRUISER. THE CONTACT STATED THAT WHILE DRIVING APPROXIMATELY 35 MPH IN THE SNOW, THE CONTACT LOST CONTROL OF THE VEHICLE WHICH WENT INTO A DITCH, HITTING SEVERAL TREES. NONE OF THE AIR BAGS IN THE VEHICLE DEPLOYED. THE VEHICLE WAS CURRENTLY BEING REPAIRED. THE FAILURE AND CURRENT MILEAGES WERE 60,000.

1. I WAS DRIVING HOME FROM WORK AND WAS ON THE HIGHWAY. THE CARS IN FRONT OF ME CAME TO AN ABRUPT STOP, CAUSING ME TO SLAM MY BREAKS WHILE I WAS DOING 40-ISH. 2. THIS CAUSED THE CAR TO BAKE STUMBLE AS THE BREAKS SLOWED THE CAR, THEN CAME LOSE CAUSING THE CAR TO LUNGE FORWARD, THEN MOMENTARILY BRAKE, THEN LOSE BRAKING AGAIN. THIS CAUSED ME TO ALMOST SLAM IN TO THE CAR IN FRONT OF ME. 3. I HAVE NOT TAKEN CORRECTIVE ACTION AS THIS SHOULD ADDRESSED BY TOYOTA AS THERE ARE MANY MANY PEOPLE DESCRIBING THE SAME ISSUE. *TR

2007 FJ CRUISER ENGINE BAY BODY RIPS, NOTICED AT APPROXIMATELY 75K. NO OFF ROADING SINCE PURCHASED USED DECEMBER 2007 WITH 32K ALREADY CLOCKED. RIPS ARE SYMMETRICAL ON BOTH SIDES OF THE ENGINE BAY INNER FENDER APRON. *TR

SEVERE RUST ISSUES. ENTIRE REAR DIFFERENTIAL REQUIRED REPLACEMENT. ALL POWER STEERING AND AUTOMATIC TRANSMISSION LINES NEEDED REPLACEMENT, FUEL LINES ARE NEXT FUEL TANK STRAPS RUSTED AND BROKE OFF, TANK FELL DOWN. BRAKE PAD PINS REQUIRED CUTTING OFF. PROTECTION PLATES RUSTED OFF. EXHAUST SYSTEM COMPONENTS REQUIRED REPLACEMENT DUE TO RUST. ENTIRE FRAME AND ENGINE COMPARTMENT COVERED IN RUST. ALL THESE ITEMS HAVE CAUSED MULTIPLE SAFETY ISSUES. MULTIPLE STRAPS AND CONNECTIONS FOR VARIOUS COMPONENTS ARE NO LONGER USABLE DUE TO RUST.

TL*THE CONTACT OWNS A 2007 TOYOTA FJ CRUISER. WHEN THE VEHICLE STOPPED THE ANTI LOCK AND TRACTION CONTROL LIGHTS BEGAN ILLUMINATING ON THE DASHBOARD. WHILE EXAMINING THE VEHICLE HE NOTICED THAT THE FRONT DRIVERS SIDE WHEEL SPEED SENSOR WAS BROKEN. HE ATTEMPTED TO TAKE THE VEHICLE TO AN AUTHORIZED DEALER BUT THE VEHICLE WOULD NOT ACCELERATE BECAUSE THE WHEELS WERE LOCKED. WHILE TOWING THE VEHICLE A LOUD POPPING NOISE WAS HEARD AND ALL OF THE WHEELS EXCEPT THE FRONT DRIVERS SIDE WHEELS BEGAN TO TURN. THE VEHICLE WAS TOWED TO AN AUTHORIZED DEALER WHERE THEY WERE UNABLE TO DIAGNOSE THE FAILURE. THE SPEED SENSOR WIRE WAS REPLACED. THE FAILURE MILEAGE WAS 24,000 AND THE CURRENT MILEAGE WAS 26,000. UPDATED 02/02/11 *CN

AFTER A "PANIC STOP" IN MY 2007 TOYOTA FJ CRUISER, THE BRAKE MASTER CYLINDER FAILED. WHEN AT A STOP LIGHT, THE BRAKES WILL SLOWLY FADE UNTIL THE PEDAL IS ON THE FLOOR AND THE TRUCK WILL ROLL FORWARD. THIS IS NOT COVERED UNDER WARRANTY AND I WILL HAVE TO PAY TO REPLACE IT. THIS IS HAS OCCURRED WITH OTHER PEOPLE AND IS DOCUMENTED ON FJCRUISERFORUMS.COM. *TR

I OWN TWO 2007 TOYOTA FJ CRUISERS, AND BOTH OF THE WINDSHIELDS HAVE CRACKED. I'VE LOOKED UP ON SEVERAL FORUMS, BLOGS, ETC..., IN REGARDS TO THIS PROBLEM AND IT SEEM THAT MANY OTHER TOYOTA FJ CRUISER OWNERS ARE EXPERIENCING THE SAME PROBLEM. I BELIEVE THE DESIGN AND THE QUALITY OF THE WINDSHIELDS THEY INSTALLED ON THESE VEHICLES ARE SUB STANDARD AND HINDER THE SAFETY OF THESE VEHICLES IN AN ACCIDENTAL ROLLOVER. TOYOTA FAILS TO ACKNOWLEDGE THIS PROBLEM AND BLAMES ROAD DEBRIS FOR THIS PROBLEM. I WOULD LIKE FOR AN INVESTIGATION TO BE OPEN SO THE CAN DETERMINE THE INTEGRITY OF THE WINDSHIELD, AND HOPEFULLY A RECALL WILL BE ORDERED TO REPLACE THESE DEFECTIVE WINDSHIELDS. *TR

THIS IS A TOYOTA ECM COMPUTER ELECTRICAL MALFUNCTION. I WAS WAITING IN MY 2007 TOYOTA FJ CRUISER AT A TRAFFIC STOP FOR THE LIGHT TO CHANGE FROM RED TO GREEN. AT THIS TIME, I FELT A HARD "BUMP" AS IF ANOTHER CAR HAD REAR-ENDED MY FJ. THERE WAS THIS REAL HARD "THUMP." THE FJ HAD SHIFTED GEARS ON ITS OWN WHILE AT A COMPLETE STOP. EITHER THE TRANSFER CASE DIFFERENTIAL AND/OR THE ELECTRICAL REAR DIFFERENTIAL LOCKED UP. BOTH MY HANDS WERE ON THE STEERING WHEEL AND MY RIGHT FOOT WAS ON THE BRAKE AT THE TIME. THERE IS NO DRIVER'S SIDE FLOOR MAT. THE FJ GOT A STRONG GRIP ON THE ROAD AND IT LURCHED FORWARD. THERE WAS A LOT OF EXTRA POWER AND A LOT MORE TRACTION THAN IN THE NORMAL "D" MODE FOR DRIVING ON DRY PAVEMENT. INSTINCTIVELY, I PRESSED DOWN HARDER ON THE BRAKE IN ORDER TO KEEP THE FJ FROM MOVING INTO THE INTERSECTION. TWO SECONDS LATER, THERE WAS ANOTHER "THUMP" AND THE FJ SHIFTED BACK INTO THE NORMAL ROAD GEAR "D." I BELIEVE WHAT HAPPENED IS THAT THE ECM COMPUTER SENT A MALFUNCTIONING SIGNAL AND LOCKED UP ONE OR BOTH OF THE DIFFERENTIALS. THIS HAPPENED WITH AN AUTOMATIC TRANSMISSION ON DRY PAVEMENT AND STOP WHEN THERE WAS NO DRIVER COMMAND TO SHIFT GEARS. THE SENSATION I FELT IS SIMILAR TO USING MY FJ FOR OFF-ROAD DRIVING AND SHIFTING INTO 4WD "LOW," BUT THIS WAS MUCH MORE SEVERE. MY CONCERN IS THAT THE ECM COMPUTER MIGHT MALFUNCTION HIGHWAY SPEEDS OF 70 MPH. IT COULD SEND A SIMILAR COMMAND TO LOCK UP EITHER THE TRANSFER CASE DIFFERENTIAL OR ELECTRIC REAR DIFFERENTIAL. IF THIS HAPPENS, THE FJ BECOMES A 5,000 LB. FLYING MISSILE, BASICALLY OUT OF CONTROL. I WOULD NOT BE ABLE TO STEER THE FJ OR TO NAVIGATE TURNS PROPERLY. IT WOULD BECOME A DANGER NOT ONLY TO MYSELF, BUT TO ALL OTHER CARS IN THE IMMEDIATE VICINITY. THIS IS THE FIRST TIME IT HAPPENED. SOMETHING IS DANGEROUSLY WRONG WITH TOYOTA'S ECM COMPUTER SYSTEM IN THE FJ CRUISER. *TR

SUMMARY: THE PRIMARY SAFETY SYSTEM (BRAKES) IN MY 2007 TOYOTA FJ CRUISER FAILED TWICE. THE LOCAL TOYOTA DEALERSHIP UTILIZING TOYOTA NATIONAL RESOURCES WERE UNABLE TO ISOLATE THE PROBLEM. THE SOLUTION WAS TO COMPLETELY REPLACE BRAKE SYSTEM AND CHARGE IT TO ME. THE LACK OF AVAILABILITY OF PARTS NATIONALLY (BACKORDER) RESULTED IN A COMPLETELY UNREASONABLE REPAIR TIMEFRAME. THE VEHICLE WAS OUT OF SERVICE FOR 49 DAYS AND COST $2503.99 TO REPAIR. OCTOBER 1, 2010 DRIVING IN TRAFFIC DEPRESS BRAKE. THE PEDAL GOES COMPLETELY TO FLOOR BOARD. NO INDICATION OF PROBLEMS VIA INTERIOR WARNING LIGHTS. OCTOBER 6, 2010 PROBLEM DETERMINED TO BE BRAKE MASTER CYLINDER. PART ORDERED (47025-35111 CYLINDER SUB-ASSEMBLY) THROUGH INTERNET SITE OF LAKELAND TOYOTA IN FLORIDA. THE COST OF THE PART IS $981.37 AND THE PART IS ON BACKORDER. ESTIMATED DELIVER IS 10/26/10. OCTOBER 26, 2010 PART ARRIVES AND IS INSTALLED. MULTIPLE WARNING LIGHTS ARE INDICATED ON INTERIOR DISPLAY. NOVEMBER 1, 2010 TOYOTA DEALERSHIP DETERMINES THE NEW MASTER CYLINDER ASSEMBLIES COMPUTER IS DEFECTIVE. NOVEMBER 4, 2010 TOYOTA DEALERSHIP REPLACES NEW MASTER CYLINDER COMPUTER WITH MY OLD COMPUTER. THE RESULT IS THE WARNING LIGHTS TURNING OFF AND INDICATES THE PROBLEM HAS BEEN FIXED. THE MECHANIC TAKE THE VEHICLE ON A TEST DRIVE ACTIVATES THE ANTILOCK BRAKES WHICH RESULTS IN AN UNEXPECTED LOSS OF VEHICLE CONTROL. THE SERVICE MANAGER REFUSES TO RETURN THE VEHICLE CLAIMING IT IS UNSAFE TO DRIVE. NO WARNING LIGHTS ARE INDICATED ON THE VEHICLE. NOVEMBER 10, 2010 TOYOTA DEALERSHIP DETERMINED THAT THE MASTER CYLINDER WITHIN THE NEW MASTER CYLINDER ASSEMBLIES IS FAULTY. BRAKE SOLENOID COMPONENTS ARE ALSO DETERMINED TO BE FAULTY AND A CONTRIBUTING FACTOR IN THE LOSS OF VEHICLE CONTROL. TOYOTA RECOMMENDS THAT COMPLETE BRAKE ASSEMBLY (47050-35072 $1823.87) BE REPLACED. THIS IS VIRTUALLY THE ENTIRE BRAKE SYSTEM OF THE VEHICLE. THIS ASSEMBLY IS ON BACKORDER AS WELL. NOVEMBER 18, 2010 VEHICLE REPAIRED AND RETURNED. *TR

WHEELS ON TOYOTA 2007 FJ CRUISER, THE PAINT ON WHEELS STARTED BUBBLING, I THEN EXPERIENCED AIR PRESSURE LOSS IN ALL 5 TIRES INCLUDING SPARE TIRE. I HAVE TO CONSTANTLY CHECK TIRE PRESSURE AS ALL WHEELS CONTINUALLY LEAK AIR. CAUSING DIFFERENT AIR PRESSURE IN TIRES. THIS IS A FACTORY DEFECT AND COULD CAUSE LOSS OF CONTROL AT ANY GIVEN TIME. *TR

WHILE TRAVELING IN THE FAR RIGHT HAND LANE, IN A WORK ZONE AT DESIGNATED SPEEDS AS CONTROLLED BY ROAD WORKERS. THE VEHICLE IN FRONT OF ME APPLIED BRAKES CAUSING ME TO DUE THE SAME. MY BRAKES INITIALLY GRABBED MOMENTARILY AND THEN RELEASED UNEXPECTEDLY, WHILE I WAS STILL APPLYING THE BRAKES. I JAMMED ON THE BRAKES THE TIRES LOCKED UP AND NOSE DIVED VIOLENTLY.....BARELY AVOIDING AN ACCIDENT. OBVIOUS SIGNIFICANT BRAKE SYSTEM FAILURE. *TR

TL* THE CONTACT OWNS A 2007 TOYOTA FJ CRUISER. THE VEHICLE WAS BEING REPAIRED AT THE DEALER FOR AN UNRELATED FAILURE WHEN THE CONTACT WAS ADVISED THAT THE FRONT INTERIOR FENDERS WAS FRACTURED. THE VEHICLE WAS NOT REPAIRED. THERE WERE NO PRIOR WARNINGS OF THE FAILURE. THE CURRENT AND FAILURE MILEAGES WERE 49,000.

2007 TOYOTA FJ CRUISER. I HAVE THIS SUV SINCE SEP., 2007. THE ONLY PROBLEM I HAVE WITH THIS SUV IS THE ABS BRAKE SYSTEM, WHICH DOESN'T WORK RIGHT. WHEN COMING TO A STOP, IF THERE IS A METAL MANHOLE COVER OR A POT HOLE WHEN I APPLY BRAKE, THE ABS ACTIVATES AND STAYS ACTIVE (NO BRAKE AT ALL) LONG AFTER I HAVE CROSSED THE HOLE CAUSING THE SUV TO ROLL MUCH FURTHER THAN I WOULD HAVE WITHOUT ABS. I LOST BRAKE COMPLETELY DURING THIS PROCESS, AND I ALMOST HIT THE CAR IN FRONT OF ME ON THAT DAY. I HAD TO RELEASE AND RE-APPLY BRAKE TO GET THE BRAKE WORK AGAIN. BUT THIS ISN'T THE WAY HOW ABS WORKS. THERE ARE MANY OTHER FJ OWNERS HAVING THE SAME PROBLEM. *TR

BODY TEARS IN THE INSIDE FRONT FENDER WALL OF 2007 TOYOTA FJ CRUISER. THE TEARS WERE DISCOVERED AT 23K MILES AFTER READING ABOUT THE PROBLEM WITH PRE-01/07 VEHICLES ONLINE. THE MANUFACTURER CLAIMS THAT THESE TEARS ONLY HAPPEN IF THE VEHICLE IS SUBJECT TO A SEVERE IMPACT OF 9G OR ABOVE. I'VE DRIVEN EVERY MILE ON THIS VEHICLE, IT HAS NEVER HAD ANY SORT OF HARD IMPACT AT ALL. THE DEALER ALSO SUGGESTED THAT THE ADD-ON FRONT BUMPER CAUSED THE DAMAGE. THE BUMPER, SOLD AND INSTALLED BY THE TOYOTA DEALER, IS AFTERMARKET, BUT 27% OF USERS REPORTING THIS PROBLEM ONLINE ARE 100% FACTORY. I DON'T KNOW WHEN THE DAMAGE OCCURRED, BUT THE VEHICLE HAS NOT BEEN HIT "JUMPED" OR OTHERWISE ROUGHLY TREATED. THE CRACKS ARE AT SOME BODY FILLER BETWEEN TWO PANELS, AND I SUSPECT ARE THE RESULT OF MATERIAL FATIGUE. MANUFACTURER CLAIMS THAT I MUST HAVE SOMEHOW DAMAGED THE VEHICLE AND THEY ARE NOT RESPONSIBLE. *TR