2007 Toyota FJ Cruiser Complaint Log

WHEN APPLYING MY BRAKES ON SEVERAL OCCASIONS MY BRAKES WOULD FAIL TO ENGAGE AND STOP THE CAR. IT OCCURS WHEN I COME TO A STOP UNDER NORMAL BRAKING AND ONE TIRE HITS A BUMP SUCH AS A MAN HOLE COVER. NO MATTER WHAT I DO THE BRAKES DO NOT ENGAGE AND THE CAR CONTINUES TO ROLL FORWARD. ANTI LOCK DOES NOT ENGAGE WHEN THIS OCCURS IT IS AS IF THE BRAKE PEDAL IS DEAD. ALSO, THE OPPOSITE EXTREME OCCURRED YESTERDAY WHEN APPLIED MY BRAKES WITH NORMAL PRESSURE AND THE VEHICLE BRAKED VERY QUICKLY AND UNEXPECTEDLY HARD. EVERYTHING FLEW FORWARD IN THE VEHICLE. I BELIEVE THESE TWO ISSUES ARE COMMON TO TOYOTA FJ CRUISER OWNERS AND ARE DANGEROUS LIFE SAFETY ISSUES. *TR

TL*THE CONTACT OWNS A 2007 TOYOTA FJ CRUISER. OCCASIONALLY WHEN THE CONTACT ATTEMPTED TO ACCELERATE AT VARIOUS SPEEDS, HE NOTICED THAT THE ACCELERATOR PEDAL BECAME STUCK TO THE FLOOR CAUSING THE VEHICLE TO ACCELERATE. IN ORDER TO STOP THE VEHICLE THE CONTACT HAD TO APPLY EXTREME BRAKING PRESSURE. THE VEHICLE HAS NOT BEEN DIAGNOSED BY THE DEALERSHIP AND THERE WERE NO PRIOR WARNINGS. THE CURRENT AND FAILURE MILEAGES WERE 31000.

TL* THE CONTACT OWNS A 2007 TOYOTA FJ CRUISER. THE CONTACT STATED THAT THE PASSENGER SIDE SEAT BELT WOULD NOT RETRACT. THE DEALER DID NOT OFFER ANY ASSISTANCE DUE TO THE MILEAGE ON THE VEHICLE. THE MANUFACTURER WAS NOT NOTIFIED. NO REPAIRS WERE PERFORMED. THE CURRENT MILEAGE WAS 77,000. THE APPROXIMATE FAILURE MILEAGE WAS 45,000. THE VIN WAS UNAVAILABLE.

2007 FJ CRUISER HAS A CRACK ON THE INNER FENDER, ALSO REFERRED TO AS AN ENGINE BAY BODY RIP. THIS VEHICLE HAS NOT BEEN IN AN ACCIDENT. THE CRACK WAS NOTICED AT AROUND 39,500 MILES, BUT MAY HAVE BEEN THERE EARLIER. NO CORRECTIVE PARTS HAVE BEEN INSTALLED. *TR

VEHICLE: 2007 TOYOTA FJ CRUISER, 4WD AUTOMATIC. 1. EVENTS: ABS SYSTEM FAILURE CAUSED BY UNEVEN ROAD SURFACE (POTHOLE, STEP DOWN, BUMPY ROAD) CAUSING A SINGLE WHEEL TO MOMENTARILY LOSE TRACTION DURING BRAKING. 2. THE ABS SYSTEM ENGAGES (BRAKE PEDAL CANNOT BE FURTHER DEPRESSED, PULSATING / CLICKING NOISE HEARD) TO STABILIZE THE ERRANT WHEEL, BUT DOES NOT PROCEED WITH STOPPING THE VEHICLE AFTERWARDS, NO MATTER HOW HARD THE DRIVER CONTINUES TO PRESS THE BRAKE PEDAL. THE ONLY WORKAROUND IS FOR THE DRIVER TO KNOW TO RELEASE THE BRAKE PEDAL AND RE-APPLY IT. 3. TOYOTA INSISTS THAT THIS IS NORMAL FOR THE ABS SYSTEM DESIGN AND THAT THERE IS NO FIX FOR THE PROBLEM APART FROM APPLYING THE WORKAROUND. I BELIEVE OTHERWISE SINCE I HAVE CONTACTED ONE OTHER FJ CRUISER OWNER WHO HAD THE SAME PROBLEM, AND HAD HIS MASTER CYLINDER / ACTUATOR REPLACED BY TOYOTA UNDER WARRANTY, AND THIS CORRECTED THE PROBLEM, ALTHOUGH AT AN EXPENSE OF ABOUT $2,000 TO THE DEALERSHIP. I FAXED A DESCRIPTION OF THIS COMPLAINT TO RIGHT TOYOTA IN SCOTTSDALE ON JUNE 11, 2009, VISITED THE DEALERSHIP AS MY ODOMETER ROLLED OVER TO 36,000 MILES AN HOUR AFTER SENDING THE FAX, AND REGISTERED A CASE NUMBER WITH TOYOTA CUSTOMER ASSISTANCE CENTER ON JUNE 12, 2009 DESCRIBING THE ISSUE AND HOW THE DEALER EXPLAINED THAT THE PROBLEM COULD NOT BE FIXED. I HAVE EXPERIENCED THIS ISSUE FOUR TIMES IN THE LAST TWO YEARS. THE MOST RECENT OCCURRENCE WAS ON JUNE 6, 2009, WHERE I WAS BRAKING FOR A RED LIGHT, THE VEHICLE ROLLED OVER A 3 INCH STEP DOWN IN THE PAVEMENT, AND SUDDENLY I HAD NO BRAKES, WHICH CAUSED ME TO ROLL 20 FEET BEYOND MY INTENDED STOPPING POINT, INTO THE INTERSECTION. LUCKILY THERE WAS NOTHING IN FRONT OF ME. RELEASING AND RE-APPLYING THE BRAKE FINALLY STOPPED THE VEHICLE, BUT NOT UNTIL IT WAS POTENTIALLY TOO LATE. *TR

2007 TOYOTA FJ CRUISER HAS ISSUES WITH THE TIRE PRESSURE. *NJ THE CONSUMER STATED HER INSURANCE COMPANY MADE HER AWARE OF A RECALL REGARDING THE TIRES ON THE VEHICLE. THE CONSUMER STATED HER HUSBAND HAD TO KEEP PUTTING AIR IN THE TIRES. THE VEHICLE HAS DUNLOP TIRES WHICH WAS RECALLED. THE DEALER INFORMED THE CONSUMER THE VEHICLE IDENTIFICATION NUMBER WAS NOT INVOLVED IN THE RECALL. *JB

ANOTHER FENDER BULGE ISSUE. THE BULGE STARTED AT 30K MILES. I'M AT 90K MILES NOW AND THE PASSENGER SIDE BULGE HAS NOW BECOME A TEAR. THE DRIVERS SIDE HAS ALSO BECOME A TEAR. I BELIEVE THIS ISSUE IS VERY COMMON ON THE FJ CRUISERS BUILT IN 2007. THIS ISSUE WAS ATTENDED TO ON THE NEWER MODELS. THE CRUMPLE ZONES IS WHERE THESE TEARS APPEAR AND I AM VERY CONCERNED FOR THE SAFETY OF MYSELF AND MY PASSENGERS. MY VEHICLE IS NOT THE FIRST THIS HAS HAPPENED TO AND IT WILL NOT BE THE LAST UNTIL TOYOTA RECOGNIZES THIS AS AN EPIC FAILURE ON THEIR PART. I CANNOT UNDERSTAND HOW A VEHICLE THAT HAS 90K MILES STILL HAS THE STOCK BATTERY AND BRAKE PADS BUT HAS TWO MAJOR TEARS IN THE BODY! *TR

MY 2007 FJ CRUISER'S BRAKES FAIL OCCASIONALLY WHILE BRAKING ON A BUMPY ROAD SURFACE. WHEN THIS HAPPENS, THE FIRST INSTINCT IS TO PRESS THE BRAKE PEDDLE HARDER TO THE FLOOR BUT THE VEHICLE CONTINUES MOVING FORWARD AT THE SAME SPEED OF TRAVEL PRIOR TO THE APPLICATION OF THE BRAKE. I HAVE TRIED PUMPING THE BRAKE WHEN THIS HAPPENS BUT IF THE ROAD SURFACE CONTINUES TO BE UNEVEN THE PROBLEM PERSISTS. I HAVE HAD A FEW CLOSE CALLS BUT LUCKILY HAVE NOT HAD AN ACCIDENT YET. *TR

TL* THE CONTACT OWNS A 2007 TOYOTA FJ CRUISER. THE CONTACT STATED THAT HE NOTICED ON TWO OCCASIONS, THE VEHICLE BEGAN TO SUDDENLY ACCELERATE TO ALMOST 90 MPH. WHEN HE INSPECTED THE VEHICLE, HE SAW THAT THE FLOOR MATS SLID UP AND WERE PUSHING AGAINST THE GAS PEDAL. THE FLOOR MATS WERE NOT PROPERLY HOOKED TO PREVENT THE ACCELERATION. HE HAS NOT CONTACTED THE DEALER OR THE MANUFACTURER TO-DATE. THE VEHICLE HAD NOT BEEN REPAIRED TO-DATE. THE CURRENT MILEAGE WAS 29,939. THE FAILURE MILEAGE WAS APPROXIMATELY 22,000. UPDATED 03/01/10. *LJ UPDATED 06/11/10

2007 TOYOTA FJ CRUISER. I'VE HAD ACCELERATION ISSUES WITH MY TOYOTA FJ CRUISER, AS MENTIONED IN THE CURRENT RECALLED MODELS. WHILE ATTEMPTING TO COME TO A STOP, THE ENGINE REVS AND "ACCELERATES" AT AN UNCONTROLLABLE LEVEL THROWING THE CAR OUT OF CONTROL. THIS HAS HAPPENED A MINIMUM OF 3 TIME ALREADY AND POSSIBLY MORE THAT I WROTE OFF AS OTHER ISSUES. 2 OF THE 3 TIMES I TURNED SHARPLY TO THE RIGHT AND OFF THE ROAD WITHOUT HITTING ANYONE OR ANYTHING, APPLYING THE BRAKE UNTIL THE ENGINE SLOWED DOWN AND I COULD COME TO A FULL STOP. I CALLED TOYOTA, (MAY 2009) AND THEY THOUGHT IT MIGHT BE A COMPUTER ISSUES AFFECTING ACCELERATION, OF COURSE THIS WAS BEFORE THE WIDESPREAD RECALL. THESE ISSUES WERE NOT DUE TO FLOOR MATS OR STICKY ACCELERATORS. I UNDERSTAND THAT MY CAR, 2007 FJ, IS NOT PART OF THE RECALL, BUT HAS THE SAME ISSUES AS THE RECALLED MODELS. *TR

DRIVER SIDE INNER FENDER APRON STARTED BULGING IN THE AREA OF THE CRUMPLE ZONE. THE VEHICLE HAS NOT BEEN IN THE ACCIDENT OR ANYTHING SIMILAR THAT WOULD SEEM TO LEAD TO THE FAILURE. I AM VERY CONCERNED WITH THE SAFETY OF THE VEHICLE NOW SINCE THE CRUMPLE ZONE IS AFFECTED. *TR

THE PAINT HAS BEEN DRAMATICALLY CHIPPING OFF OF MY 2007 FJ CRUISER. THIS WAS BROUGHT TO THE DEALERSHIPS AND TOYOTA REGIONAL MANAGERS ATTENTION IMMEDIATELY AND IT HAS BEEN OVER A YEAR AND A HALF OF UNRETURNED PHONE CALLS, MISSED APPOINTMENTS AND BEING DISMISSED. *TR

THE INNER FENDER WALL OF MY FJ CRUISER IS BENDING AND BASED ON OTHERS WITH THIS ISSUE IT WILL SOON CRACK, THE INNER FENDER WALL WILL MOVE AND IMPEDE THE MOVEMENT OF THE DOORS. THIS IS A DESIGN DEFECT AND TOYOTA SHOULD ISSUE A RECALL. *TR

MY 2007 TOYOTA FJ CRUISER HAS UNEVEN WEAR ON THE EDGE OF THE TIRES AT 40,000 MILES. THE ORIGINAL COMPLAINT THAT BROUGHT ME TO THE DEALERSHIP WAS A VIBRATION IN THE STEERING WHEEL AT 65MPH. I WAS INFORMED THAT THERE IS A RECALL (CAMPAIGN ID # 06V235000) BUT MY VEHICLE DOES NOT HAVE THE ASSIGNED FOR THE RECALL. IT CERTAINLY SOUNDS LIKE MY VEHICLE IS EXPERIENCING SIMILAR ISSUES. I NOTICED THE VIBRATION APPROXIMATELY 3-4 MONTHS AGO. *TR

I WENT ON A TRIP WITH MY TOYOTA FJ CRUISER. PRIOR TO THE TRIP, I NOTED THAT THERE WAS NOTHING WRONG WITH MY VEHICLE. DURING THE TRIP, I LOOKED IN THE ENGINE COMPARTMENT AND OBSERVED THE INNER LEFT FENDER HAD A SLIGHT BULGE AND CRACK. THE VEHICLE WAS NOT INVOLVED IN ANY COLLISION, NOR ANY OTHER TYPE OF EVENT. JUST NORMAL ROAD DRIVING. *TR

THE INNER FENDER WELLS ON MY 2007 TOYOTA FJ CRUISER ARE BULGING ON BOTH THE DRIVERS SIDE AND PASSENGER SIDE. DEFINITELY SEEMS TO BE A DEFECT IN DESIGN DUE TO POSSIBLE INABILITY OF VEHICLE TO HANDLE THE FLEXING, ETC. IT IS NOW AFFECTING MY DOORS AND BASIC ALIGNMENT OF VEHICLE. GAPS ARE FORMING WHERE THERE SHOULDN'T BE GAPS, ETC. I JUST GOT MY TIRES BALANCED AND ALIGNED AND THE TIRES ARE WEARING FUNNY JUST 2 MONTHS AFTER HAVING WORK DONE ESPECIALLY ON THE DRIVERS SIDE WHERE THE LARGER BULGE IS. THE BULGE IS NOTICEABLY GETTING LARGER WITH TIME AND WILL EVENTUALLY CRACK. I HAVE FRIENDS THAT HAVE THE SAME PROBLEM, STARTED WITH BULGES AND NOW THEIR INNER FENDER WELLS ARE CRACKED. TOYOTA WILL NOT ADMIT TO HAVING KNOWLEDGE OF THIS PROBLEM AND YET EVERY YEAR THE VEHICLE HAS BEEN PUT INTO PRODUCTION THE INNER FENDER WELLS HAVE BEEN IMPROVED AND REINFORCED...BUT EVEN THOSE ARE NOW FAILING AND BULGING. TOYOTA IS AWARE OF THIS AND BLAMING IT ON OFFROAD USE OR AFTERMARKET PARTS....BUT ITS HAPPENING ACROSS THE BOARD ON ALL OR MOST FJ'S. WORK/WARRANTY WORK IS BEING DENIED. WE ARE NOW LEFT WITH A VEHICLE THAT WILL MOST LIKELY FALL APART OR EVEN WORSE...WILL AFFECT US IN AN AUTO ACCIDENT...SINCE ITS RELATED TO THE CRUMPLE ZONE AND IS SHOWING WEAKNESS. PLEASE HELP US AND DO SOMETHING ABOUT IT FOR US. *TR

BULGES IN INNER FENDER-UNDER HOOD, FENDER APPEARS TO BE COMPRESSING OR COLLAPSING. *TR

TOYOTA FJ CRUISER FENDER FLARE PROBLEM..ENGINE BAY BODY RIPS...BIG PROBLEM SEEN IT ON 6 FJ WOW NEED A SERIOUS LOOK AT THIS PROBLEM BEFORE SOMEONE GETS HURT OR DIES... *TR

I HAVE A 2007 TRD FJ CRUISER WITH THE 100,000 MILE WARRANTY ON IT. AT 12,000 MILES I NOTICED A FENDER BULGE ON THE PASSENGER SIDE OF THE INNER FENDER UNDER THE HOOD. I HAVE NEVER TAKEN THE CAR OFFROADING AND ALREADY, AT 12,000 MILES HAVE A FENDER BULGE. THIS DESIGN FLAW CAN GREATLY AFFECT THE CARS INTEGRITY AND LIFE SPAN. THE LATEST QUOTE ON A FIX FROM A TOYOTA DEALER WAS $4,700. MANY PEOPLE ARE EXPERIENCING THIS TYPE OF BULGE OR CRACK IN THEIR INNER FENDERS AND IT CAN BE A HUGE PROBLEM IF YOU GET INTO A CAR ACCIDENT AND THE CRUNCH ZONE ALREADY HAS A CRACK IN IT. THIS IS A WIDESPREAD PROBLEM THAT NEEDS TO BE ADDRESSED BEFORE SOMEONE GETS HURT. *TR

THERE IS A PROBLEM WITH THE INNER FENDER OF THE TOYOTA FJ CRUISER. MY TRUCK HAS 34K MILES AND I HAVE NOTICED A LARGE BULGE IN THE DRIVERS SIDE INNER FENDER, IN THE CRUMPLE ZONE. THE PASSENGER SIDE IS ALSO SLIGHTLY BULGED. I HAVE SEEN IN OTHER FJ CRUISERS HOW THESE BULGES WILL SLOWLY CRACK AND CAUSE THE FENDER TO TEAR. AS THIS PROBLEM DEVELOPS IN A DESIGNED CRUMPLE ZONE, I AM CONCERNED THAT TOYOTA DOES NOT SEEM TO HAVE A SOLUTION, OR EVEN ACKNOWLEDGE THAT THERE IS A PROBLEM. *TR

METAL TEARS OF THE INNER FENDER APRONS ON BOTH SIDES AT THE CRUMPLE ZONES. *TR

TOYOTA FJ CRUISER CLUTCH PEDAL STICKS WHEN COLD. THE TRUCK BECOMES UNPREDICTABLE OF WHAT ITS GOING TO DO. TOYOTA SAID ITS BEEN WORKING ON A FIX FOR OVER A YEAR NOW AND I HAVEN'T HEARD ANYTHING. IF YOU LOOK AT TOYOTA FORUMS THERE ARE A LOT OF COMPLAINTS. *TR

A HAIRLINE FRACTURE BEGAN GROWING FROM A CENTRAL MID-POINT AT THE BOTTOM EDGE OF THE WINDSHIELD RIGHT BEFORE MY EYES AS I WAS DRIVING. THERE WAS ABSOLUTELY NO ROAD DEBRIS THAT HIT MY WINDSHIELD THAT MADE THIS OCCUR, NOR HAVE I EVER TAKEN THE VEHICLE OFF-ROADING. FROM THE CENTRAL POINT THE CRACK GREW OVER THE COURSE OF 10 SECONDS IN BOTH LEFT AND RIGHT DIRECTIONS UNTIL ENDING AT THE LEFT AND RIGHT SIDES OF THE WINDSHIELD. I CAN'T EVEN BEGIN TO UNDERSTAND HOW THIS WOULD HAPPEN. I BELONG TO AN FJ CRUISER ENTHUSIAST WEBSITE FJCRUISERFORUMS.COM AND 33% OF 2007 OWNERS REPORT HAVING HAD/HAVE A CRACKED WINDSHIELD. NOW THAT I AM PART OF THAT GROWING PERCENTAGE, I'M NOT HAPPY THAT THERE IS NO TECHNICAL BULLETIN BY TOYOTA ABOUT THIS. NHTSA, YOU NEED TO GET INVOLVED. MANY OWNERS ALSO REPORT THE PROBLEM HAPPENING AGAIN SOON AFTER GETTING THE WINDSHIELD REPLACED. WHAT HAS TO HAPPEN TO GET A RECALL DONE HERE? A VEHICLE BUILT FOR RUGGED OFF-ROADING SHOULD BE ABLE TO NOT HAVE A PAPER-THIN WINDSHIELD AND NOT CRACK FOR ANY APPARENT REASON WHEN DRIVING DOWN THE HIGHWAY. THIS IS NOT COSMETIC DAMAGE THIS IS A SAFETY ISSUE AND NEEDS TO HAVE A RECALL ISSUE BEFORE SOME POOR SOUL GOES SAILING THROUGH THEIR WINDSHIELD BECAUSE IT HAS A DESIGN FLAW. *TR

ENGINE BAY OR FENDER APRON RIPS IN TOYOTA FJ CRUISER. *TR

FENDER APRON TEARS AND BULGES IN THE ENGINE BAY OF MY FJ CRUISER. *TR

VEHICLE WAS TRAVELING IN THE SNOW IN 4 WHEEL DRIVE MODE WHEN IT STARTED SHAKING AND VIBRATING AS IF IT HAD A FLAT TIRE. BECAUSE OF THE ROAD CONDITIONS VEHICLE WAS TRAVELING UNDER THE SPEED LIMIT. FAILURE WAS CATASTROPHIC AND DID NOT ALLOWED THE VEHICLE TO COAST TOO LONG AS THE VEHICLE JAMMED, AS IF THE TRANSMISSION HAD BROKEN SEVERAL GEARS AND BINDED. VEHICLE CAME TO A STOP ENGULFED IN SMOKE AND FLAMES WERE COMING FROM THE UNDERCARRIAGE. UPON A QUICK INSPECTION IT WAS NOTED THAT THE FRONT SHAFT HAD BROKEN OFF FROM THE TRANSFER CASE, OIL WAS POURING OUT OF THE CASE AND HEAT FROM THE EXHAUST PIPE, IMMEDIATELY NEXT TO IT, HAD IGNITED THE OIL INTO FLAMES. MUD AND SNOW WAS USED TO PUT OUT THE FLAMES. UNDER FURTHER INVESTIGATION IT WAS NOTICED THAT ONE OF THE TIRES HAD A BLOW OUT, THE REAR DRIVER TIRE. AFTER REPLACING THE FLAT TIRE WITH THE SPARE, AN ATTEMPT TO CARRY ON 2 WHEEL DRIVE MODE WAS MADE BUT RESULTED IN IMMEDIATE RESTART OF THE FLAMES. FLAMES WERE PUT OUT AGAIN USING SAME METHOD AS BEFORE AND VEHICLE WAS TOWED TO A TOYOTA DEALERSHIP. DEALERSHIP UPON CURSORY EVALUATION DECIDED THAT THE TRANSFER CASE HAD "INSUFFICIENT" LUBRICANT. THIS IS RIDICULOUS AS THE TRANSFER CASE LOST ITS OIL WHEN THE SHAFT POPPED OUT WITH THE FRONT PINION GEAR CAUSING THE FIRE. THERE IS NO HEAT SHIELD TO PROTECT OIL FROM IGNITING IN THESE VEHICLES. VEHICLE HAS NOT EVEN BEEN TAKEN APART AS TOYOTA IS NOT AUTHORIZING THE WARRANTY REPAIR. ALL PARTS ARE AVAILABLE FOR REVIEW. *TR

UNRESPONSIVE BRAKES WHEN GOING OVER POTHOLES . OVERLY SENSITIVE BRAKES AT LOW SPEED . *TR

MY INNER FENDERWELLS HAVE CRACKED ALL THE WAY THROUGH AT THE CRUMPLE ZONES. I HAVE MENTIONED THIS TO TOYOTA, AND THEY SAY IT IS BECAUSE OF MY AFTERMARKET BUMPER EVEN THOUGH HUNDREDS OF DOCUMENTED CASES HAVE BEEN FOUND ON STOCK FJ CRUISERS OF SAME YEAR AS MINE. I FEEL THIS ISSUE NEGATES THE STRENGTH OF THE FENDERS AND WOULD NOT REACT FAVORABLY IN A CRASH. *TR

I AM CONCERNED ABOUT CRACKS DEVELOPING IN MY TOYOTA FJ CRUISER WHICH COULD AFFECT THE SAFETY OF MYSELF AND OTHERS IN VEHICLE. *TR

2007 FJ CRUISER WAS SERVICED BY BIG ISLAND TOYOTA MULTIPLE TIMES IN 2008. FEBRUARY 11, 2008 - 31649 MILES ' 30,000 MILE SERVICE, INCLUDES UNDER VEHICLES INSPECTION. APRIL 16, 2008 - 33007 MILES ' SAFETY CHECK INSPECTION, SPARK PLUG REPLACEMENT, CABIN FILTER REPLACEMENT AUGUST 20, 2008 - 34418 MILES ' STEREO INSPECTION FOR WARRANTY ISSUE AUGUST 27, 2008 ' 34582 MILES - WARRANTY REPLACEMENT OF BROKEN STEREO THE FEBRUARY 11 SERVICE STATES THE FOLLOWING PARTS UNDER VEHICLE WERE MARKED "CHECKED AND OKAY": SHOCK ABSORBERS / SUSPENSION STEERING GEAR BOX / LINKAGE AND BOOTS / BALL JOINTS / DUST COVERS MUFFLER / EXHAUST PIPES / MOUNTINGS ENGINE OIL AND FLUID LEAKS BRAKE LINES / HOSES / PARKING BRAKE CABLE DRIVE SHAFT BOOTS / CONSTANT VELOCITY BOOTS / U-JOINTS / TRANSMISSION LINKAGE TRANSMISSION / DIFFERENTIAL / TRANSFER CASE FUEL LINES AND CONNECTIONS / FUEL TANK BAND / FUEL TANK VAPOR VENT SYSTEM HOSES INSPECT NUTS AND BOLTS ON BODY CHASSIS THE APRIL 16 SERVICE MARKED ALL COMPONENTS AS APP'D, INCLUDING MULTIPLE COMPONENTS THAT WOULD HAVE REQUIRED THE TECHNICIAN TO BE UNDER THE VEHICLE. WE CHOSE BIG ISLAND TOYOTA TO PERFORM OUR SERVICE AS WE WERE UNDER THE IMPRESSION THAT WE WERE GETTING THE BEST SERVICE FOR OUR TOYOTA VEHICLE. THE CORROSION DISCOVERED IN DECEMBER WAS SO COMPLETE THAT THERE WAS NO WAY IT WASN'T PRESENT DURING PREVIOUS SERVICES AND TOYOTA DID NOT POINT IT OUT WHEN THEY WERE UNDER THE VEHICLE. NEGLECTING TO CALL ATTENTION TO THE PROBLEM DURING PREVIOUS PAID SERVICES PREVENTED US FROM BEING ABLE TO ADDRESS THE CORROSION ISSUE BEFORE PARTS BEGAN TO FALL OFF AND PERFORATE THE FRAME. AT THIS POINT BIG ISLAND TOYOTA HAS DECLARED THAT THE VEHICLE HAS NO VALUE WHATSOEVER AND THEY WILL NO LONGER PROVIDE SERVICE TO US AT THE DEALERSHIP. *TR

I HAVE A 2007 TOYOTA FJ CRUISER. I HAVE THE TRUCK LIFTED WITH A DEALERSHIP APPROVED LIFT KIT, AND DEALERSHIP APPROVED TIRES. I HAVE ABOUT 50K MILES ON IT, AND I JUST NOTICED THE INNER FENDER INSIDE THE ENGINE COMPARTMENT ON THE DRIVERS SIDE BEGAN TO BULGE OUT TOWARDS THE ENGINE. I TOOK IT INTO TOYOTA AND THEY ONE SALES REP SAYS I MUST OF HAD AN ACCIDENT TO CAUSE THIS, I HAVE NOT! ANOTHER REP SAYS HE HAS HEARD OF THIS ISSUE BUT HAS NEVER SEEN IT BEFORE. THEY ARE GOING TO HAVE AN ENGINEER COME AND TAKE A LOOK AT IT. I HAVE DONE MY OWN RESEARCH AND HAVE FOUND THAT TOYOTA HAS SINCE REDESIGNED THIS SECTION NOW 3 TIMES BUT ARE STILL CLAIMING IT TO BE USER FAULT. I HAVE 127 OTHER PEOPLE THAT HAVE NOW CLAIMED THIS ISSUE MANY OF WHICH HAVE STOCK VEHICLES AND HAVE NEVER BEEN OFF ROAD OR HAD THE SUSPENSION OR TIRES MAX OUT. THIS BULGE LEADS TO CRACKS RIGHT IN THE CRUMPLE ZONE OF THE ENGINE COMPARTMENT. WHICH COULD SERIOUSLY AFFECT HOW THE VEHICLE REACTS TO AN ACCIDENT AND CAUSE FURTHER HARM TO ITS OCCUPANTS. *TR

TL* THE CONTACT OWNS A 2007 TOYOTA FJ CRUISER. THE INNER FENDER LINER METAL FRACTURED AT THE CRUMPLE ZONE. THE VEHICLE WAS TAKEN TO THE DEALER, AND A TECHNICIAN STATED THAT HE WOULD HAVE TO PAY FOR THE REPAIRS. THE MANUFACTURER WAS NOTIFIED, BUT NO ASSISTANCE WAS PROVIDED. THE FAILURE MILEAGE WAS 102,000.

MY 2007 TOYOTA FJ CRUISER WITH AN EXPEDITION ONE FRONT BUMPER AND 6" ROUGH COUNTRY LIFT HAS GOTTEN INNER FENDER BULGES. IT HAS NEVER BEEN JUMPED OR INVOLVED IN AN ACCIDENT. THE DRIVERS SIDE INNER FENDER HAS BEGUN TO BULGE UP IN THE CRUMPLE ZONE. I HAVE TAKEN IT TO YOKEM TOYOTA, AND THEY ARE WAITING TO HEAR FROM THE NATIONAL TOYOTA OFFICE BEFORE FIXING IT UNDER WARRANTY. THEY HAVE BEEN HELPFUL, BUT SINCE TOYOTA HAS NOT ISSUED A SERVICE BULLETIN, THEY DON'T KNOW HOW TO HANDLE IT. *TR

TL*THE CONTACT OWNS A 2007 TOYOTA FJ CRUISER. WHILE DRIVING 80 MPH, THE CONTACT NOTICED THAT THE CRUISE CONTROL STOPPED WORKING. HE ALSO NOTICED THAT THE SPEEDOMETER WAS MOVING CONSTANTLY. HE PULLED THE VEHICLE TO THE SIDE OF THE ROAD AND NOTICED FLAMES COMING FROM THE BACK SEATS OF THE VEHICLE. THE FIRE DEPARTMENT EXTINGUISHED THE FIRE AND A POLICE REPORT WAS FILED. THE CONTACT DID NOT NOTICE ANY DIFFERENCES BEFOREHAND. THE VEHICLE HAS NOT BEEN DIAGNOSED BY THE DEALER. THE VIN WAS UNKNOWN. THE CURRENT AND FAILURE MILEAGES WERE 9,800.

MY 2007 TOYOTA FJ CRUISER DEVELOPED TWO, UNDER THE HOOD, WHEEL WELL/INNER FENDER CRACKS, AT THE CRUMPLE DIMPLES. THE VEHICLE EXHIBITED THE BODY CRACKS AT 18,000 MILES. EACH CRACK, ONE ON THE LEFT AND RIGHT, DIRECTLY ABOVE EACH UPPER WHEEL WELL, WHERE ATTACHED TO THE INNER FENDER, ARE ABOUT 4" LONG AND 1/16"-1/8" WIDE. I TOOK THE TRUCK TO TOYOTA WHERE, WITHOUT BATTING AN EYE, SENT THE TRUCK TO A BODY SHOP AND REPLACED BOTH THE LEFT AND RIGHT INNER FENDER ASSEMBLY. THIS WAS A VERY MAJOR REPAIR, COSTING TOYOTA ABOUT $8K IN MATERIALS AND LABOR. I AM VERY CONCERNED THAT THIS PROBLEM WILL REAPPEAR, AFTER MY WARRANTY EXPIRES AT 36,000 MILES. I DO NOT SPORT OFF-ROAD THIS TRUCK. *TR

THE WINDSHIELD HAS BEEN CRACKED MULTIPLE TIMES BY NORMAL ROAD DEBRIS. *TR

I NOTICED MY WINDSHIELD WAS GETTING "HAZED" OVER WITH A SANDBLASTED LOOK WITHIN THE FIRST 6 MONTHS OF OWNING MY VEHICLE. THE WINDSHIELD BECAME POKED WITH LITTLE CHIPS FROM ROAD DEBRIS WITHIN THE FIRST YEAR IN ADDITION TO NUMEROUS CRACKS. THE VEHICLE IS NOW 2 YEARS OLD AND THE WINDSHIELD NEEDS REPLACEMENT DUE TO EXTENSIVE CHIPS, POCK, AND CRACKS. *TR

RUST. UNUSUAL RUST EVERYWHERE IN MY 2007 FJ CRUISER. EVEN THE FRONT MOTOR MOUNTS ARE RUSTED. THE REAR BUMPER INSIDE, FRAME, REAR DIFFERENTIAL EVERYTHING IS EXTREMELY RUSTED. EVEN THE TRAILER LIGHT PLUGS ARE FALLING OFF DUE TO RUST. THIS IS A CITY CAR AND WE DON'T TAKE IT TO OFFROAD, AND BEING ONLY 74000 MILES, IT'S SCARY TO LOOK UNDER. IF GIVES THE FEELING THAT ONE DAY WHEELS MAY FALL OFF FROM THE FRAME. I HAVE SEARCHED IN THE INTERNET AND REALIZED THAT MOST FJ CRUISER OWNERS HAVE SAME ISSUE. WE PAID 30+ THOUSAND FOR A CAR WHICH IS FALLING APART WITH RUST IN 7 YEARS. HOPE SOMETHING CAN BE DONE.

I OWN A 2007 TOYOTA FJ CRUISER SPORT UTILITY VEHICLE. I'VE OWNED THE VEHICLE FOR 24 MONTHS AND CURRENTLY HAVE 16,000 MILES DRIVEN. THE SAFETY PROBLEM IS THE DESIGN OF THE FJ CRUISER WINDSHIELD. I HAVE NOW REPLACED THE WINDSHIELD SIX (6) TIMES DUE TO SMALL ROCKS HITTING THE WINDSHIELD. THE SAFETY ISSUE IS THAT THE VERTICAL POSITION OF THIS WINDSHIELD ABSORBS THE FULL IMPACT OF ANY ROAD DEBRIS AS OPPOSED TO DEFLECTING. OF THE SIX WINDSHIELD INCIDENTS, 2 OF THOSE HAVE BEEN SEVERE ENOUGH TO COMPLETELY PENETRATE THE WINDSHIELD AND IN TO THE PASSENGER CABIN. THIS POSES A VERY SERIOUS SAFETY ISSUE IF A ROCK SHOULD PIERCE THE WINDSHIELD ON THE DRIVERS SIDE AND INJURE OR DISTRACT THE DRIVER THUS POSING A SAFETY RISK TO OTHERS IN THE VEHICLE OR IN CLOSE PROXIMITY. IN ADDITION, THE IMPACT IS SEVERE ENOUGH THAT THE NOISE OF THE IMPACT POSES A DANGEROUSLY HIGH DISTRACTION. THE IMPACT IS VIOLENT ENOUGH THAT I WOULD EQUATE THE SOUND TO EXPLODING FIREWORKS OR A HANDGUN SOUND IN THE CABIN OF THE VEHICLE. *TR

MY 2007 TOYOTA FJ CRUISER HAS A DEFINITE AND VERY SERIOUS BRAKE PROBLEM! ON AT LEAST 6 TO 8 OCCASIONS BRAKES HAVE LOCKED UP AND CAUSED TEMPORARY LOSS OF CONTROL OF THE VEHICLE! ON SOME OCCASIONS, I FEEL THAT A LESS-EXPERIENCED DRIVER COULD HAVE CRASHED!! ONE OCCASION WAS AT 55 MPH WHILE PASSING ANOTHER VEHICLE. THIS OCCASIONAL SCARY EXPERIENCE HAS BEEN REPORTED BY NUMEROUS OWNERS OF THIS VEHICLE ON THE FJ CRUISER FORUM, BUT THIS DANGEROUS CONDITION IS NOT BEING ADDRESSED BY TOYOTA!!! HELP!!!!! *TR

2007 TOYOTA FJ CRUISER FENDER BULGES AND CRACKING ON MY VEHICLE WITHOUT MODIFICATION ON THE VEHICLE. FENDER CRACKING/BULGES WAS NOT ALSO DUE TO EXCESSIVE OR EVEN OFF-ROADING, JUMPING OR OTHER VEHICLE ACTIVITIES. *TR

DRIVING ALONG THE ROAD. HEARD A POP IN THE BACK OF VEHICLE. THEN CONSTANT BANGING FROM BACK OF VEHICLE THAT VARIES WITH SPEED. WAITING TO HEAR BACK FROM DEALER, BUT SUSPECTING A BROKEN REAR DIFFERENTIAL WHICH HAS BEEN KNOWN TO HAPPEN ON MANY OTHER EARLY PRODUCTION FJ CRUISERS. WILL UPDATE AS SOON AS I HEAR BACK. *TR

WHILE DOING ROUTINE MAINTENANCE I NOTICED CRACKS IN BOTH INNER FENDER WELLS OF MY 1 YEAR OLD TOYOTA FJ CRUISER. I THEN STARTING DOING RESEARCH AND FOUND MANY PEOPLE WITH THE SAME PROBLEM. I CONTACTED MY LOCAL DEALER AND SCHEDULED AN APPOINTMENT AND AT THE TIME THEY SAID THAT IT WOULD BE COVERED UNDER WARRANTY WHEN A FIX OR REPAIR WAS AVAILABLE. SEVERAL MONTHS WENT BY WITHOUT A RESPONSE AND DURING THAT TIME I HAD INSTALLED NEW TIRES AND SUSPENSION. I THEN HAD SOME MORE SERVICE AT ANOTHER DEALER SEVERAL MONTHS LATER AND I WAS TOLD THAT THE FENDERS WOULD NOT BE COVERED UNDER WARRANTY AND ANY ALTERATIONS FROM STOCK WOULD VOID ALL WARRANTY. THIS WAS NOTED WELL BEFORE ANY MODIFICATIONS AND I DON'T SEE WHERE DIFFERENT TIRES, BUMPERS, OR SUSPENSION WOULD HAVE ANYTHING TO DO WITH FENDERS. THE REPAIR WOULD REQUIRE REPLACEMENT OF THE INNER FENDER WELLS. MANY OTHER PEOPLE ARE EXPERIENCING THIS ISSUE AS NOTED ON HTTP://WWW.FJCRUISERFORUMS.COM/FORUMS/TOYOTA-FJ-CRUISER-POLLS/37556-DO-YOU-HAVE-INNER-FENDER-BULGES-CRACKING.HTML AND HTTP://WWW.FJCRUISERFORUMS.COM/FORUMS/PROBLEMS-DEALER-SERVICE/33440-ENGINE-BAY-BODY-RIPS.HTML THIS REPAIR HAS BEEN DONE ON SEVERAL FJ CRUISERS THAT I AM AWARE OF AND THE CRACKS COULD BE CONSIDERED A SAFETY ISSUE AS THEY ARE IN THE CRUMPLE ZONE AREA. *TR

PAINT FAILURE IS IMMEDIATE. VEHICLE IS A TOYOTA 2007 FJ CRUISER. CAR WAS PARKED UNDER MESQUITE TREE FOR SHADE. TREE SAP FROM TREE CAUSED PAINT TO IMMEDIATELY BUBBLE AND CRACK AND COME OFF. LITERALLY EVERYWHERE DROP HITS BODY AND BUMPER IS DAMAGED, APPROXIMATELY 50 SPOTS OR MORE. PAINT RELEASES COMPLETELY TO PRIMER. *TR

2007 TOYOTA FJ CRUISER: THE INNER FENDER APRON/LINER UNDER THE HOOD IS BULGING. APPEARS TO BE A MANUFACTURER DEFECT. THERE HUNDREDS OF OTHERS WITH THE SAME VEHICLE, SAME PROBLEM. IN MANY CASES THAT I'VE SEEN THE METAL BEGINS TO TEAR. SEE WWW.FJCRUISERFORUMS.COM FOR PICTURES, MORE INFO, ETC.... *TR

TL* THE CONTACT OWNS A 2007 TOYOTA FJ CRUISER. THE CONTACT STATED THAT WHEN DRIVING AT SPEEDS OF 25 MPH AND TRAVELING OVER A BUMP OR POTHOLE, THE ANTI-LOCK BRAKING SYSTEM WOULD ACTIVATE BUT THE BRAKES WOULD NOT ENGAGE. THE CONTACT STATED THAT THE FAILURE WOULD OCCUR AT LEAST FIVE TIMES WHENEVER THE VEHICLE WAS IN OPERATION. THE CONTACT HAS NOT TAKEN THE VEHICLE TO THE DEALER. THE CONTACT WAS CONCERNED WITH THE BRAKES POTENTIALLY CAUSING A CRASH TO OCCUR WITHOUT WARNING. THE FAILURE MILEAGE WAS 31,500 AND THE CURRENT MILEAGE WAS UNKNOWN.

TOYOTA FJ CRUISER 2007: INNER FENDER RAILS / ENGINE BAY (STRUCTURAL VEHICLE BODY PANEL) BULGES AND CRACKS UNDER REGULAR OPERATION CONDITION. AFTER AN FIRST REPLACEMENT AT ~ 5000MI, THE NEW PARTS CRACKED AGAIN AT ~ 11000MI. TOYOTA REFUSES TO REPAIR THAT STRUCTURAL DEFECT UNDER WARRANTY, WHICH IS A ~ $10000 REPAIR. THIS CONCERN HAS BEEN REPORTED UNDER A SIGNIFICANT NUMBER OF FJ CRUISER OWNERS (SEE FJ CRUISER FORUM ENGINE BAY RIPS). *TR

MY 2007 FJ CRUISER IS CRACKING AND BULGING IN THE INNER FENDER FRAME / BODY. *TR

INNER FENDER APRON CRACKING ON DRIVERS SIDE. THIS IS AT A PINT ABOUT 8" FORWARD OF THE FIREWALL. *TR

PAINT IS CHIPPING ALL OVER CAR. CAR IS 2007 FJ. BY TOYOTA. I HAVE NEVER HAD THIS HAPPEN ON ANOTHER CAR. *TR