2010 Toyota FJ Cruiser Tires & Wheels Problems

TL* THE CONTACT OWNS A 2010 TOYOTA FJ CRUISER EQUIPPED WITH FOUR GOODYEAR TRAILMARK AT TIRES, SIZE: P265/65/R18 (NA). THE CONTACT INDICATED THAT ALL FOUR TIRES EXPERIENCED SIDEWALL RUBBER SEPARATION AND CRACKED. THE FAILURE CAUSED THE TIRES TO DEFLATE APPROXIMATELY 1 TO 2 LBS PER WEEK. WALMART INSPECTED THE TIRES AND DID NOT IDENTIFY A DEFECT. THE MANUFACTURER WAS ALSO NOTIFIED AND REFERRED THE OWNER TO A DEALER. THE TIRE AND VEHICLE FAILURE MILEAGE WAS 5,000. THE VIN WAS UNKNOWN.

2 WHEEL STUDS FAILED ON TWO DIFFERENT WHEELS AFTER APPLYING 80 FOOT POUNDS TORQUE TO THE LUG NUTS. ROUTINE RE-TORQUE AFTER THE DEALER ROTATED THE TIRES FOR A 10,000 MILE SERVICE. THE STUD METAL APPEARS TO BE TOO SOFT. EVEN IF THESE STUDS WERE OVER TIGHTENED AT THE DEALERSHIP, THEY SHOULD BE ABLE TO HANDLE WAY MORE THAN 80 FP BEFORE BREAKING. THIS IS EXTREMELY DANGEROUS. TOYOTA SHOULD REPLACE ALL THE STUDS ON THE VEHICLE AS A PRECAUTIONARY MEASURE. TAKING THE ISSUE UP WITH THE DEALER TOMORROW. I WILL NOT FEEL SAFE DRIVING THIS VEHICLE UNTIL ALL THE STUDS HAVE BEEN INSPECTED AND REPLACED AS NECESSARY. *TT

WHEEL STUD BROKE OFF WHEN CHANGING TO WINTER TIRES. A TORQUE WRENCH WAS USED TO PREVENT OVERTORQUEING. THE CAR HAS 3247 MILES. NO ONE HAD TOUCHED THE WHEELS UNTIL TODAY. ACCORDING TO MY RESEARCH, THIS IS A COMMON PROBLEM SEEN WITH 2010 TOYOTA FJ CRUISER AND 2010 TOYOTA 4RUNNER MODELS. NHTSA SHOULD ASK TOYOTA TO INSTITUTE A SAFETY RECALL FOR THE DEALERS TO INSPECT AND REPLACE ANY DAMAGED WHEEL STUDS. HTTP://WWW.FJCRUISERFORUMS.COM/FORUMS/PROBLEMS-DEALER-SERVICE/85927-BROKEN-WHEEL-STUDS.HTML HTTP://WWW.TOYOTA-4RUNNER.ORG/5TH-GEN-T4RS/66780-WHEEL-LUG-STUD-BROKE-90-FT-LBS-2010-4RUNNER.HTML

2010 TOYOTA FJ CRUISER WHEEL STUDS FAILED WHEN REMOVING BOLTS TO ROTATE TIRES. AMERICAN TIRE CENTER OF PALMDALE CALIFORNIA ORIGINALLY INSTALLED FOUR NEW TIRES WITH LESS THAN 10K MI. ON ODOMETER. AT APPROXIMATELY 15K MI. WHEN SAME COMPANY ATTEMPTED TO REMOVE WHEELS FOR ROUTINE TIRE ROTATION THE WHEEL STUDS BEGAN BREAKING ONE AFTER THE OTHER. 4 OUT OF 6 WHEEL STUDS FAILED ON FRONT RIGHT WHEEL ALONE. AMERICAN TIRE CENTER REPLACED THE BROKEN STUDS, HOWEVER, WHEN OWNER TOOK VEHICLE TO DEALER TO PERFORM PRECAUTIONARY WHEEL STUD REPLACEMENT THE DEALER, (WITHOUT PERFORMING INSPECTION) SAID IT WAS AMERICAN TIRE CENTER WHO LIKELY OVERTORQUED BOLTS AND THAT IT WOULD NOT BE COVERED UNDER FACTORY WARRANTY. LUGS WERE ALL DEFORMED AT SPECIFIC POINT ALONG THE MIDDLE OF THE SHAFT AND HAD A STRETCHED "TAFFY-LIKE" APPEARANCE BUT ONLY IN THE MIDDLE OF THE LUG. REPLACEMENT COST FOR COMPLETE WHEEL LUG REPLACEMENT WAS ESTIMATED AT $600.00 BY HUNTINGTON BEACH TOYOTA DEALERSHIP. BROKEN WHEEL STUDS RETAINED BY OWNER FOR FURTHER INVESTIGATION. FURTHER ACTION SUSPENDED UNTIL OWNER RETURNS FROM MILITARY DUTY OVERSEAS. VIN NOT IMMEDIATELY AVAILABLE TO COMPLAINANT DUE TO OVERSEAS DEPLOYMENT. *TR

BROKEN WHEEL STUDS ON 2010 TOYOTA FJ CRUISER. 3 WHEEL STUDS ON REAR TIRES BROKE DURING A NORMAL TIRE ROTATION AND BALANCE. DEFECTIVE STUDS WERE REPLACED W/ AFTERMARKET STUDS. CONSEQUENCES COULD BE A LOSS OF A WHEEL DURING VEHICLE OPERATION. *LN

TL* THE CONTACT OWNS A 2010 TOYOTA FJ CRUISER. THE CONTACT STATED THAT THE FRONT END ALIGNMENT WAS NOT ADEQUATE BECAUSE THE TIRES WEIGHED SIGNIFICANTLY MORE THAN WHAT WAS INDICATED IN THE OWNER'S MANUAL. THE CONTACT ALSO STATED THAT THE MANUFACTURER INSTALLED THE INCORRECT SIZED TIRES ON THE VEHICLE. NEITHER THE DEALER NOR THE MANUFACTURER OFFERED ASSISTANCE BECAUSE THE REPAIRS ASSOCIATED WITH NHTSA CAMPAIGN ID NUMBER 11V148000 (TIRES:PRESSURE MONITORING AND REGULATING SYSTEMS), HAD ALREADY BEEN PERFORMED. THE CONTACT BELIEVED THAT THIS WAS NOT THE CORRECT REMEDY FOR THE FAILURE. NO ADDITIONAL REPAIRS WERE PERFORMED. THE FAILURE MILEAGE WAS 1,500 AND THE CURRENT MILEAGE WAS 17,000.