2005 Toyota Highlander Complaint Log

I HAVE A 2005 TOYOTA HIGHLANDER AND THE TRANSMISSION HAS SLIPPED FROM ABOUT 45,000 MILES WHEN IT SHIFT FROM 3RD TO 4TH. TAKEN IT TO DEALER FOR UPGRADE ON ECM AND THIS DID NOT FIX PROBLEM AND IT IS GETTING WORSE. *TR

HEATER/AC FUNCTIONS INTERMITTENTLY THEN FAILS COMPLETELY. WELL KNOW PROBLEM WHERE PLACEMENT OF RIBBON CABLE TO POTENTIOMETER BREAKS LOOSE, PARTIALLY (INTERMITTENT FAILURE), THEN COMPLETELY (TOTAL FAILURE). QUOTED COST AT ANY DEALERSHIP $900-$1,000. I DID REPAIR MYSELF IN ONE HOUR FOR A COST OF $10. QUICK SEARCH ON THE WEB UNCOVERED MANY MANY OF SAME INCIDENT AND, FORTUNATELY, DETAILED REPAIR INSTRUCTIONS.

2005 HIGHLANDER V6 AWD. HAS A SURGING EFFECT SINCE DAY ONE. ALSO SURGES SLIGHTLY WHEN APPLYING BRAKES. IN TRAFFIC STOP AND GO SITUATION, VEHICLE DOES NOT RESPOND FOR A FEW SECONDS AND THEN LUNGES FORWARD. VERY DANGEROUS WHEN TRYING TO CHANGE LANES. DEALER SAID NOTHING WRONG WITH VEHICLE. TOYOTA SAID AT TIME TO CONTACT DEALER.

I'VE OWNED A 2005 TOYOTA HIGHLANDER SINCE NEW, ONCE IN A WHILE THIS CONDITION WOULD OCCUR, NOW IT IS ALL THE TIME. IT JUST TURNED OVER 80K MILES. I HAVE NOT BEEN NOTIFIED OF ANY RECALLS, NOT EVEN TOYOTA NO. 60F. WHEN YOU ARE COMING TO A STOP,AT NORMAL SPEEDS,NORMAL BRAKING PEDAL PRESSURE, JUST BEFORE THE VEHICLE STOPS, IT LAUNCHES FORWARD WITH YOUR FOOT PRESSURE ON THE BRAKE PEDAL. WHEN YOU APPLY MORE PRESSURE AS IF THERE WAS AN EMERGENCY, IT IS WORSE. MY WIFE AND I HAVE LEARNED TO COMPENSATE BY COASTING THEN STOPPING. I EMAILED TOYOTA.COM ABOUT THIS TWICE, NO ANSWERS. *TR

TOYOTA SHOULD RECALL ALL OLDER MODELS RELATING TO PEDAL ACCELERATOR. TOYOTA SHOULD BE RECALLING ALL RELATED VEHICLES AS FAR BACK AS 2003 MODELS IF IT ALREADY KNOWS THE COMPUTER COMPONENT IN THOSE CARS HAVE THE SAME PEDAL ACCELERATOR PROBLEMS AS THE NEWER MODELS. WHY AREN'T THEY MADE TO DO THAT? I HAVE A 2005 TOYOTA HIGHLANDER AND I AM WORRIED EVERYTIME I GET IN MY CAR NOW. *TR

I WISH TO REPORT A SAFETY DEFECT ON MY 2005 TOYOTA HIGHLANDER. WHEN TRAVELING AT SPEEDS ABOVE ABOUT 35 MPH I CANNOT HEAR THE TURN SIGNAL CLICKER. I AM 69 YEARS OLD, BUT DO NOT HAVE ANY SIGNIFICANT HEARING LOSS. NOT BEING ABLE TO HEAR THE CLICKER SOMETIMES CAUSES ME TO LEAVE THE TURN SIGNAL ON WHEN IT SHOULD BE OFF. ALTHOUGH I HAVE NOT HAD ANY ACCIDENTS DUE TO THIS PROBLEM, IT COULD CAUSE OTHER DRIVERS TO MAKE HAZARDOUS DECISIONS. FOR EXAMPLE, IF I HAD MY RIGHT TURN SIGNAL ON BY MISTAKE SOMEONE WAITING TO MAKE A RIGHT TURN ONTO THE ROADWAY COULD BE THINKING I WAS ABOUT TO MAKE A RIGHT TURN OFF THE ROAD. I'VE CONTACTED TOYOTA ABOUT CHANGING TO A LOUDER FLASHER, BUT THEY DO NOT HAVE ONE. THEY WERE NOT ABLE TO HELP ME AT ALL. YES, THE TURN SIGNAL INDICATOR LIGHTS WORK ON THE DASH, BUT THEY ARE NOT IN MY FIELD OF VIEW WHEN I'M LOOKING AT THE ROAD AND LOOKING AT THEM IS AN UNNECESSARY DISTRACTION. I THINK AUDIBLE TURN SIGNAL INDICATORS SHOULD BE ON ALL CARS AND THE SOUND LEVEL SHOULD BE ADEQUATE FOR ALL DRIVERS WHO CAN HEAR. PREFERABLY THE SOUND LEVEL WOULD BE MANUALLY ADJUSTABLE OR AUTOMATICALLY ADJUSTABLE ACCORDING TO THE CAR SPEED. *TR

MY TOYOTA HIGHLANDER 2005 WILL ACCELERATE BY ITSELF WHEN I START OUT AT A LIGHT MAKING IT REV THE ENGINE EXCESSIVELY. THIS HAPPENED ALOT WHEN I GOT THE CAR UNTIL LAST FALL I GOT FUEL SYSTEM CLEANED AND ALL CARBON REMOVED FROM LINES. IT WENT AWAY AFTER I GOT CARBON CLEANED OUT AND NOW IT HAS RECENTLY STARTED HAPPENING AGAIN. IT SOMETIMES MAKES MY FRONT TIRES SQUEAL. I HAVE ASKED THE JOE MEYERS TOYOTA IN HOUSTON, TX. ABOUT IT AND THEY SAY THERE IS NOTHING WRONG WITH MY CAR. I NEVER BROUGHT IT UP WITH THEM AGAIN. I NEED TO FIND OUT IF THERE IS ANY FIX FOR THIS PROBLEM ASAP SINCE THERE HAS BEEN ISSUES WITH THIS BEING WORSE AND CAUSING DEATHS. NOTE: AFTER BUYING THE CAR IN JAN 06 THE FLOOR MATS CONSTANTLY PUSHED FORWARD UPTO PEDALS SO I GOT MY HUSBAND TO USE A GROMMET ON THEM TO MAKE HOLES AND ATTACH VIA CLIPS FROM JOE MEYERS TOYOTA. NOW THEY DON'T MOVE. THIS WAS NEVER THE CAUSE OF THE ACCELERATION. IT WAS COMING FROM THE ENGINE - PEDAL WAS NOT STUCK. *TR

TL* THE CONTACT OWNS A 2005 TOYOTA HIGHLANDER. THE CONTACT STATED THE FLOOR MATS BECAME TRAPPED BETWEEN THE BRAKE AND ACCELERATOR PEDAL ALMOST CAUSING TWO ACCIDENTS. ALSO THE CARPET IN THE VEHICLE WAS RIPPED WHERE THE FLOOR MATS WERE. THE VEHICLE WAS TAKEN TO THE DEALER AND CONTACT WAS TOLD TO CALL THE TOYOTA MANUFACTURER, INFORM THEM OF THE PROBLEMS SO SHE CAN GET TOTAL COMPENSATION FOR HER MATS. THE CONTACT CALLED AND IS WAITING FOR THEM TO CALL BACK. THE FAILURE MILEAGE WAS 71,000. UPDATED 03/08/10

GOING UP HILL ON HWY 24 LEAVING GEO INTO TN IN RAIN AT 55 MPH AND TOOK FOOT OF GAS PEDAL IT DID NOT SLOW DOWN. I DRIVE A 2005 TOYOTA HIGHLANDER. *TR

ON NUMEROUS OCCASIONS THIS VEHICLE STUTTERS WHEN MERGING ON TO TRAFFIC. ON THIS SPECIFIC INSTANCE I WAS MERGING FROM TURN IN LANE. THE THROTTLE WAS SLOW TO RESPOND AFTER DEPRESSING THE ACCELERATOR PEDAL 3/4 OF THE WAY. THEN IT JUMPED/LURCHED FORWARD. I WAS NEARLY HIT BUT THE TRAFFIC COMING UP FROM BEHIND. THIS HAS OCCURRED ON MULTIPLE OCCASSIONS IN THE PAST, BEGINNING WITH 20000 MILES ON THE CAR. HAD BROUGHT IT TO THE DEALERS ATTENTION IN THE PAST AND WAS TOLD THAT THIS IS A "DESIGN FEATURE" OF THE ELECTRONIC THROTTLE. THEY SEEMED TO BE AWARE OF THE PROBLEM BUT COULD NOT OFFER ANY SOLUTION. THE ECM WAS REPROGRAMMED ONCE UNDER WARRANTY BUT THAT ALSO DID NOT SOLVE THE PROBLEM. *TR

I OWN A 2005 TOYOTA HIGHLANDER AND WAS TRYING TO PARK IN FRONT OF MY HOME BETWEEN TWO CARS WHEN THE CAR SUDDENLY ACCELERATED AND HIT THE SIDE OF MY HOUSE. I AM NOT 100% SURE WHAT HAPPENED, WHETHER I ACCIDENTALLY PRESSED THE ACCELERATOR OR THERE WAS A MALFUNCTION OF SOME KIND. I HAD TO MAKE A 90 DEGREE LEFT TURN BETWEEN TWO OTHER PARKED CARS, SO I AM SURE I WAS NOT DRIVING FAST AT THE TIME OF THE ACCIDENT. *TR

WHILE COMING TO A RED LIGHT I APPLIED THE BRAKES BUT THE PEDAL WENT ALL THE WAY TO THE FLOOR AND THE CAR DID NOT STOP. TOOK MY FOOT OFF THE BRAKE PEDAL AND APPLIED THE BRAKES AGAIN AND THE SECOND TIME THE BRAKES WOKED. THIS HAS HAPPENED ONCE TO MY WIFE AND ONCE TO ME. *TR

TL* THE CONTACT OWNS A 2005 TOYOTA HIGHLANDER. THE CONTACT WAS DRIVING APPROXIMATELY 45 MPH AND APPLYING THE BRAKES BUT THE BRAKES WOULD NOT RESPOND. THE CONTACT STATED THAT AN UNKNOWN WARNING LIGHT ILLUMINATED. THE FAILURE PERSISTED AND THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC WHERE THE BRAKES WERE REPLACED. THE FAILURE RECURRED. THE DEALER WAS CONTACTED AND ADVISED THAT THEY WOULD NEED TO INSPECT THE VEHICLE TO ATTEMPT TO DIAGNOSE THE FAILURE PROPERLY. THE VEHICLE WAS NOT DIAGNOSED. THE MANUFACTURER WAS NOT CONTACTED. THE APPROXIMATE FAILURE MILEAGE WAS 60,000. THE VIN WAS NOT AVAILABLE.

2005 TOYOTA HIGHLANDER, CAR WILL ACCELERATE FROM A DEAD STOP ON ITS OWN. CHANGE TRANSMISSION FROM PARK TO DRIVE AND LET OFF BRAKE AND CAR WILL ACCELERATE WITHOUT TOUCHING GAS PEDAL FAST ENOUGH TO CHANGE GEARS AND CONTINUE. HAVE REACHED A SPEED OF 30 MPH BEFORE BRAKING. THE TACHOMETER DOES NOT SHOW THAT THE ENGINE IS REVVING HIGHER THAN A NORMAL IDLE WHEN IN PARK CHANGING INTO DRIVE SO IT SEEMS LIKE AN ELECTRONIC PROBLEM, ETC. ISSUE IS INTERMITTENT. THE CAR HAS BEEN TO 2 DEALERS OVER THE TIME IT HAS BEEN OWNED AND WE WERE TOLD THE ISSUE COULD NOT BE DUPLICATED SO NOTHING COULD BE DONE. I CALLED THE SAME DAY THIS EMAIL WAS SENT AND WAS TOLD THE SAME THING BY THE LOCAL TOYOTA DEALERSHIP. WELL, THE RECALLED GAS PEDALS DON'T STICK ALL THE TIME SO THEY ARE INTERMITTENT PROBLEMS SO WHERE IS THE DIFFERENCE BETWEEN THEIR CARS AND OURS! I HAVE TRIED EVERY CONTACT NUMBER FOR TOYOTA AND CANNOT GET ANYWHERE!!!!!! *TR

THE DRIVER'S SIDE SUNVISOR DOES NOT STAY UP IN MY 2005 TOYOTA HIGHLANDER. IT FLIPS DOWN FREQUENTLY BLOCKING DRIVER'S VIEW WHILE DRIVING AND CREATES DANGEROUS SITUATIONS. I WENT ONLINE AND DISCOVERED MANY MANY SAME COMPLAINTS ON MESSAGE BOARDS - ONLY ON DRIVER'S SIDE. THIS NEEDS TO BE LOOKED INTO. *TW

I OWN A 2005 TOYOTA HIGHLANDER. I WENT TO A FRIEND'S HOUSE AND PARKED VEHICLE IN FRONT OF THE HOUSE IN THE DRIVEWAY BY PLACING THE GEAR SHIFT IN THE PARK POSITION. I LEFT THE VEHICLE IDLING WHILE I WENT INTO MY FRIEND'S HOUSE TO GET A GROCERY LIST. I WENT IN AND OUT OF THE HOUSE ON 2 DIFFERENT OCCASIONS OVER A PERIOD OF ABOUT 10- 15 MINUTES TO RETRIEVE ITEMS FOR MY FRIEND THAT WERE OUTSIDE. ON BOTH OCCASIONS MY VEHICLE WAS IN THE DRIVEWAY IDLING. WHILE I WAS BACK INSIDE RETRIEVING THE GROCERY LIST MY FRIEND AND I OBSERVED MY VEHICLE MOVING THROUGH HER BACK YARD AND PROCEEDED INTO THE WOODS BEHIND HER HOUSE WHERE IT CAME TO A STOP AFTER HITTING A TREE. THIS VEHICLE SOMEHOW TOOK ITSELF OUT OF THE PARK POSITION AND INTO DRIVE!!!! I REPORTED THIS TO MY TOYOTA DEALER AND THE INSURANCE COMPANY. THE TOYOTA DEALER AND THE REGIONAL TOYOTA MANAGER SAID THERE WAS NO WAY THIS COULD HAVE HAPPENED AND THAT IT WAS NOT THE SAME ISSUE BEING INVESTIGATED (GAS PEDAL ISSUE). I WENT AHEAD AND HAD THE CAR REPAIRED AND THE INSURANCE COMPANY PAID FOR IT (EXCEPT FOR MY $500.00 DEDUCTIBLE) WITH NO INVESTIGATION OR QUESTIONS. I PICKED THE CAR UP TODAY AND NOW I AM HEARING ON THE NEWS THAT MANY OF THE SO CALLED GAS PEDAL INCIDENTS HAVE NOT BEEN EXPLAINED AND THAT IT IS POSSIBLE THAT MANY OF THE PREVIOUSLY REPORTED INCIDENTS CAN ONLY BE EXPLAINED BY A FAULTY COMPUTER. RIGHT AFTER THE ACCIDENT I ASKED THE TOYOTA DEALER/REGIONAL MANAGER SPECIFICALLY IF MY INCIDENT COULD HAVE BEEN CAUSED BY A COMPUTER MALFUNCTION. THE ANSWER WAS NO! *TR

TL* THE CONTACT OWNS A 2005 TOYOTA HIGHLANDER. WHILE ENTERING A PARKING SPACE, JUST BEFORE APPLYING THE BRAKE, THE VEHICLE ACCELERATED INTO A CONCRETE STEP. NO ONE WAS INJURED DURING THE CRASH BUT THE VEHICLE SUFFERED DAMAGE TO THE FRONT END. HE CALLED THE MANUFACTURER AND THEY COLLECTED ALL THE INFORMATION REGARDING THE INCIDENT. HOWEVER HIS VEHICLE WAS EXCLUDED FROM RECALL 09V388000 (VEHICLE SPEED CONTROL:ACCELERATOR PEDAL). THE CURRENT AND FAILURE MILEAGES WERE 40,892.

2005 TOYOTA HIGHLANDER HYBRID. DRIVING TO WORK IN A BLIZZARD ON 12/11/09 ALL DASH BOARD LIGHTS WENT ON. DEALERSHIP FOUND THAT THE SUNROOF HOUSING FAILED CAUSING $3,977.16 WORTH OF DAMAGE. BEING OUT OF WARRANTY THE DEALER AGREED TO PAY 2,000.00. TOYOTA CUSTOMER SERVICE ANOTHER 1,500 AND WE PAID 477.16. WE PICKED UP THE CAR ON 12/24/09. ON 2/2/10 WE RETURNED IT AFTER NOTICING A BURN SPOT ON EACH OF THE PLASTIC HEAD LIGHT COVERS. THE DEALER FOUND BOTH HIGHBEAM BULBS MELTED,AND SUGGESTED I HAD OVERUSED THEM CAUSING THE INTENSE HEAT THAT DID THE DAMAGE. I AM CONCERNED IT COULD BE A RESULT OF DELAYED WATER DAMAGE SHOWING UP. OUR CONCERNS WITH THIS CAR(WHICH WE PURCHASED NEW IN NOV. OF 2005)GOES BACK TO 9/7/06 WHEN THE CRUISE CONTROL DID NOT SLOW THE CAR GOING DOWN HILLS. ON 2/28/07 WE HAD BRAKE AND WIPER BLADE ISSUES. ON 4/20/07 THE BLADES LOCKED DURING A DOWNPOUR ON THE 5 FREEWAY. I HAD TO PULL OVER IN A PANIC. ON 7/12/07 THE CARGO CLIP HAD TO BE REPLACED. ON 9/10/07 THAT PARKING BRAKE DID NOT HOLD PROPERLY AND THERE WAS A RATTLE FROM THE RIGHT REAR. ON 11/6/07 WE COMPLAINED OF SQUEAKY BRAKES. DEALER TIGHTENED LOOSE NUTS AND BOLTS ON 4X4 ASSEMBLY. ON 4/1/08 THE BRAKES WERE REPLACED @ 29,080 MILES.ON 10/22/08 THE SOUND SYSTEM FAILED AND WAS REPLACED UNDER WARRANTY. NEXT WEEK WE ARE HAVING THE 5TH SET OF TIRES PUT ON THIS VEHICLE WHICH HAS ONLY 53,000 MILES ON IT. THE SET TO BE REPLACED HAS ONLY ABOUT 15,000 MILES ON THEM. THEY HAVE A 60,000 MILE WARRANTY. *TR

THE SIDE AIRBAGS FAILED TO DEPLOY. THE TOYOTA HIGHLANDER WAS INITIALLY STRUCK ON THE FRONT PASSENGER SIDE NEAR THE FRONT END OF VEHICLE. THE VEHICLE WAS THEN STRUCK (T-ED) ON THE DRIVER'S SIDE BY A LARGE PICKUP TRUCK (APPROX SPEED 60 MPH). THE IMPACT DENTED THE DOORS TO THE SEATS AND BOTH DRIVER'S SIDE DOORS WOULD NOT OPEN DUE TO THE IMPACT. VSC, ABS WERE ENGAGED AS EVIDENCED BY THE PANEL LIGHTS ON AT THE END OF THEE CRASH, HOWEVER NO AIRBAGS DEPLOYED RESULTING IN TRAUMATIC BRAIN INJURY (CLOSED HEAD INJURY), POST CONCUSSIVE SYNDROME, GRAND MAL SEIZURE, RETROGRADE AMNESIA FOR DRIVER. VEHICLE ALSO HAD A THIRD IMPACT AS IT WAS PUSHED INTO BARRIER WALL. *TR

MY 2005 TOYOTA HIGHLANDER V6 4WD, WHICH I PURCHASED NEW, HAS BEEN EXPERIENCING A HESITATION/SHIFTING PROBLEM FOR NEARLY AS LONG AS I HAVE OWNED THE VEHICLE. WHILE THE PROBLEM DOES NOT ALWAYS OCCUR, IT IS QUITE PRONOUNCED WHEN IT DOES AND HAS RESULTED IN VERY DANGEROUS SITUATIONS. THE PROBLEM HAS BEEN BROUGHT TO THE DIRECT ATTENTION OF TOYOTA MOTOR SALES IN CALIFORNIA, AND THEIR RESPONSE HAS BEEN DISTURBINGLY POOR. THE TOYOTA DEALER THAT HAS BEEN SERVICING MY VEHICLE HAS BEEN VERY HELPFUL, BUT APPARENTLY CANNOT TAKE ACTION TO CORRECT THE PROBLEM WITHOUT CORPORATE AUTHORIZATION. HERE IS A SUMMARY OF THE PROBLEM: THE VEHICLE CANNOT ALWAYS DECIDE WHEN TO ACCELERATE FROM A STOP - THERE HAVE BEEN MANY INSTANCES OF INITIAL HESITATION/LACK OF ADEQUATE POWER UPON APPLYING THE GAS PEDAL. FOR EXAMPLE, I HAVE EXPERIENCED A DELAY OF A SECOND OR TWO WHEN APPLYING THE GAS PEDAL TO PROCEED. THIS HAS RESULTED IN SOME VERY CLOSE CALLS WITH ONCOMING TRAFFIC. ALSO, THERE ARE OCCURRENCES WHERE THE VEHICLE CANNOT SEEM TO DECIDE BETWEEN GEARS (IT WILL SOMETIMES JUMP UP/DOWN BETWEEN THE LOWER GEARS, SUCH AS 1ST TO 2ND GEAR AND/OR 2ND TO 3RD GEAR). FURTHERMORE, I HAVE NOTICED A GENERAL LACK OF ADEQUATE ACCELERATION/GAS PEDAL RESPONSE, ESPECIALLY DURING CITY DRIVING (IE. LOWER SPEEDS). MY LOCAL TOYOTA DEALER HAS RECORDS OF THE PROBLEM SINCE APPROXIMATELY 16,000 MILES (THE VEHICLE NOW HAS ABOUT 44,000 MILES). I BELIEVE THE ISSUE IS THE ECM, WHICH WAS REPROGRAMMED BUT THE PROBLEM RETURNED. BASED ON MY RESEARCH, I BELIEVE THE ECM MAY BE DEFECTIVE AND THAT REPLACING THE UNIT MAY SOLVE THE PROBLEM. TOYOTA WILL NOT REPLACE THE ECM. ABOUT A MONTH AGO, THE TOYOTA DEALER WAS ABLE TO VERIFY THE HESITATION PROBLEM DURING A SERVICE VISIT. HOWEVER, THEY COULD NOT DUPLICATE IT LATER WITH THE SCAN TOOL ATTACHED - THEY HAD THE VEHICLE FOR TWO DAYS TRYING TO GET A SNAP SHOT BECAUSE THE TOYOTA FIELD SERVICE TECHNICIAN TOLD THEM "NO REPAIRS ARE TO BE MADE UNTIL THE PROBLEM OCCURS MORE OFTEN." TW*

TL* THE CONTACT OWNS A 2005 TOYOTA HIGHLANDER. THE CONTACT STATED THAT WHILE DRIVING AT APPROX 65 MPH, SHE PRESSED DOWN ON THE ACCELERATOR AND WHEN SHE TOOK HER FOOT OFF, THE PEDAL DID NOT RELEASE FROM THE DEPRESSED POSITION. SHE KEPT PUMPING THE PEDAL BUT IT CONTINUED TO STICK TO THE FLOOR UNTIL SHE CRASHED INTO THE WALL OF SOMEONE'S HOME. THE CONTACT WAS INJURED AS A RESULT OF THE CRASH (BROKEN RIBS AND HEAD INJURIES). A POLICE REPORT WAS TAKEN AT THE SCENE. THE VEHICLE WAS TOTALED. SHE CALLED THE MANUFACTURER AND THEY DID NOT OFFER ANY ASSISTANCE. THE CURRENT AND FAILURE MILEAGES WERE APPROXIMATELY 97,000.

ACCIDENT OCCURRED IN CHARLOTTESVILLE VA. SUDDEN ACCELERATION WHILE CAR WAS IN REVERSE. RIGHT CAR SIDE DAMAGED ALONG WITH 2 OTHER CARS. MODEL OF CAR IS 2005 TOYOTA HIGHLANDER VS AWD LIMITED. TOTAL COST TO REPAIR THE TOYOTA WAS $6,900. *TR

2005 TOYOTA HIGHLANDER 4X4 V6. THE STEERING BECAME JERKY WHEN TURNING AND ESPECIALLY WHEN GOING OVER BUMPS. THE INTERMEDIATE SHAFT ASSEMBLY HAD TO BE REPLACED TO FIX THE ISSUE. THE TECHNICIAN RESEARCHED IT AND THERE HAVE BEEN TWO TECHNICAL BULLETINS PUT OUT BY TOYOTA AND THEY HAVE REDESIGNED THE ORIGINAL PART SO THAT IT IS NO LONGER AVAILABLE AND HAS A NEW PART NUMBER. THE TOYOTA DEALERSHIP ALSO STATED THAT JUST LUBRICATING THE ASSEMBLY DOES NOT WORK. MY MECHANIC STATED THAT HE HAS FIXED A NUMBER OF THESE ON HIGHLANDERS, RAV4S, AND AVALONS. IN MY OPINION THE OLD PART ADVERSELY AFFECTS THE STEERING AND SAFE HANDLING OF THE VEHICLE AND SHOULD HAVE BEEN RECALLED BY TOYOTA WHEN THE PART WAS REDESIGNED. *TR

DRIVER SIDE VISOR IS BLOCKING THE VIEW OF DRIVER. THE VISOR OF MY 2005 TOYOTA HIGHLANDER IS MALFUNCTION WHICH IS RESULT OF FLIPPING DOWN ALL THE TIME AND BLOCKING THE VIEW OF DRIVER, SPECIAL DURING THE NIGHT TIME OR RAINING. THIS FAULTY IS CAUSING US OF NEAR ACCIDENT SITUATIONS. *TR

TL*THE CONTACT OWNS A 2005 TOYOTA HIGHLANDER HYBRID. WHILE APPROACHING A RED LIGHT, THE VEHICLE ACCELERATED TWICE BEFORE COMING TO A COMPLETE STOP. THE VEHICLE WAS TAKEN TO A DEALER BUT THE ISSUE HAS NOT BEEN REMEDIED. THE VEHICLE WAS NOT INCLUDED IN THE FLOOR MAT RECALL #06V253000. THE CONTACT IS AWARE OF THE SAFETY RISK SINCE HE COULD HAVE INJURED SOMEONE. THE FAILURE MILEAGE WAS 86,000.

1. TRAVELING AT ABOUT 45-55 MILES PER HOUR, GAS PEDAL STICKS. ALSO, THE DEALER SOLD ME THE CAR WITH OUT A DRIVER FLOOR MAT. SINCE I PURCHASED THE CAR IN 2007, I'VE NOTICED A GRADUAL EROSION OF THE FLOOR MAT BENEATH MY RIGHT FOOT AND JUST BELOW THE GAS PEDAL. THERE IS NOW A HOLE IN THE CARPET AND AN INDENTATION IN THE FLOOR OF THE CAR. ALSO, THERE IS A SMALL TOGGLE TYPE OBJECT JUTTING OUT FROM UNDER THE CARPET JUST BELOW THE GAS PEDAL 2. IT OCCURS EVERY TIME I DRIVE THE CAR. 3. NOTHING HAS BEEN DONE TO CORRECT THE FAILURE. *TR

UNDER A SPECIFIC SET OF CIRCUMSTANCES, THE CRUISE CONTROL CAUSES THE CAR TO SURGE PAST THE SET CRUISE SPEED. I'VE NEVER LET THE SURGE GET PAST 10 MPH ABOVE THE SET CRUISE SPEED, I ALWAYS TURN OFF THE CRUISE WHICH CANCELS THE SURGE. I CANNOT FORCE THE REPLICATION OF THE PROBLEM BUT IT HAS HAPPENED A NUMBER OF TIMES OVER THE LIFE OF THE CAR. THE CIRCUMSTANCES I CAN IDENTIFY ARE THE CRUISE IS SET ON A SPECIFIC SPEED (LIKE 60 MPH), THE CRUISE IS DISENGAGED TO SLOW DOWN (WELL BELOW 60 MPH), USING THE GAS PEDAL TO SPEED UP ON A LONG UPHILL GRADE, ENGAGE THE CRUISE TO TAKE THE CAR BACK TO THE SET SPEED (60 MPH) AND THE CRUISE BLOWS PAST 60 MPH. IN THE SECONDS IT TAKES TO DISENGAGE THE CRUISE CONTROL, I'VE REACHED 70 MPH. *TR

I AM WRITING ABOUT A PROBLEM I ENCOUNTERED WITH MY 2005 TOYOTA HIGHLANDER. WE PURCHASED IT BRAND NEW IN JANUARY OF 2005. BEAVERTON TOYOTA HAS ADJUSTED THE COMPUTER ON MY CAR SEVERAL TIMES SINCE THE FIRST OIL CHANGE AS MY HIGHLANDER FEELS LIKE IT IS CHANGING GEARS BY ITSELF. THE CAR HAD NOT DONE THIS UNTIL AFTER THE FIRST OIL CHANGE. ON SUBSEQUENT SERVICE CALLS, I WOULD DISCUSS THE PROBLEM AND THEY WOULD TELL ME THAT THEY ADJUSTED THE CAR'S COMPUTER. ON SEPTEMBER 10, 2009, I WAS DRIVING THROUGH THE STORE PARKING LOT AND WAS ABOUT TO PULL INTO A PARKING PLACE BY THE FRONT OF THE STORE WHEN I HEARD A SURGING SOUND AND MY CAR QUICKLY WENT FORWARD AND SMASHED INTO A BRICK COLUMN IN FRONT OF THE STORE AND THEN IT WENT BACKWARDS AND STOPPED. THE FRONT OF THE CAR WAS SMASHED AND WAS NOT DRIVABLE. I HAD NOT SPOKEN ON MY CELL PHONE SINCE THE NIGHT BEFORE, I HAD NO ONE ELSE IN THE CAR WITH ME TO DISTRACT ME, AND I WAS NOT SPEEDING OR SWERVING TO AVOID ANOTHER PERSON OR CAR. I THANK GOD THAT I HIT THE BRICK COLUMN IN FRONT OF THE STORE INSTEAD OF A PERSON OR ANOTHER CAR. MY SHOULDER, NECK AND TEETH STILL HURT FROM HITTING THE BRICK COLUMN SO HARD. I HAD JUST GOTTEN GAS, AND I HAD MY TIRES ROTATED A FEW DAYS BEFORE THIS INCIDENT. I ASKED THE BODY SHOP WHO FIXED MY CAR AND BEAVERTON TOYOTA TO CHECK THE ACCELERATOR. AT THE TIME OF MY ACCIDENT, THEY WERE LOOKING FOR CAR MATS THAT WEREN'T PROPERLY INSTALLED. I WAS TOLD THERE WAS NOTHING WRONG. IT SEEMS STRANGE THAT WITH ALL THE RECALLS NOW, EVEN TOYOTA CANNOT FIGURE OUT WHAT THE PROBLEM IS WITH THE ACCELERATORS. I THINK IT MIGHT HAVE BEEN A GLITCH IN THE COMPUTER. I CAN STILL HEAR THAT SURGING SOUND AND AM AFRAID IT MIGHT HAPPEN AGAIN. THERE IS NO REASON FOR IT TO HAVE SURGED AND SMASHED INTO A BRICK COLUMN AS I WASN'T STOMPING ON THE ACCELERATOR OR BRAKE WHEN I WAS DRIVING THROUGH A PARKING LOT TO PARK MY CAR. I HAVEN'T BEEN IN AN ACCIDENT FOR 38 YEARS. *TR

2005 TOYOTA HIGHLANDER. CONSUMER STATES UNINTENDED ACCELERATION CAUSED A CRASH. *TGW THE CONSUMER STATED AS SHE WAS ABOUT TO PULL INTO A PARKING SPACE, SHE HEARD A SURGING SOUND AND SUDDENLY THE VEHICLE QUICKLY ACCELERATED FORWARD AND CRASHED INTO A BRICK COLUMN IN FRONT OF THE STORE AND THEN IT WENT BACKWARDS AND STOPPED. *JB

AN AFTERNOON DURING AUGUST OR EARLY SEPTEMBER 2009 I WAS DRIVING MY 2005 HIGHLANDER IN A HIGH TRAFFIC ROUTE WHEN THE ACCELERATOR PEDAL GOT STUCK DOWN, LEADING TO AN INITIAL HIGH SPEED AND STEADILY HIGH RPMS (6-7000). I WAS ABLE TO CONTROL THE SPEED BY STEPPING DOWN THE BRAKE PEDAL WITH BOTH FEET WHILE KEEPING EXCEEDINGLY HIGH RPMS ON HEAVY TRAFFIC. IN THE EMOTIONAL AND PHYSICAL STRESS OF THE MOMENT, I WAS ABLE TO DRIVE TO A BUILDING ENTRANCE. WITH THE CAR ON "PARKING" POSITION, THE RPMS KEPT HIGH AND DID NOT DECREASE DESPITE STEPPING FURTHER ON THE ACCELERATOR PEDAL TRYING TO "UNSTUCK" IT, WHICH WAS UNSUCCESSFUL. FINALLY I TURNED OFF THE IGNITION. AFTER TURNING THE CAR BACK ON, THE PROBLEM DID NOT RECURRED. I TOOK THE CAR TO ITS REGULAR MAINTENANCE SERVICE IN HARR TOYOTA (100 GOLD STAR BLVD., WORCESTER, MA) IN SEPT. 19, 2009, EXPLAINED THE EVENT, THEY DOCUMENTED IT, AND APPLIED THE 60F CARPET CLIP RECALL. THERE HAS BEEN NO SIMILAR INCIDENT SINCE THEN. I REPORTED THE INCIDENT TO TOYOTA COMPANY WITH DOCUMENTATION # 1002135597. TOYOTA CLAIMS THEY WILL NOT APPLY THE CURRENT RECALL ACCELERATOR FIX TO MY CAR BECAUSE IT IS NOT ON THE OFFICIAL RECALL AND THE CAR WAS BUILT IN JAPAN (BASED ON VIN), WITH A DIFFERENT ACCELERATOR PEDAL DESIGN AND CONSTRUCTION. *TR

TL*THE CONTACT OWNS A 2005 TOYOTA HIGHLANDER. WHILE DRIVING 25 MPH AND MAKING A TURN, THE CONTACT HEARD A CLICKING SOUND COMING FROM THE STEERING COLUMN INCLUDING THE SOUND OF METAL RUBBING TOGETHER. THE CONTACT SAID THAT THERE WAS A FLAW IN THE MANUFACTURERS DESIGN. THE CONTACT TOOK THE VEHICLE TO THE DEALER AND WAS ADVISED THAT THE STEERING COLUMN NEEDED TO BE REPLACED. THE CONTACT WAS ALSO ADVISED TO FILE A COMPLAINT. THE FAILURE MILEAGE WERE 59,000. THE VIN WAS NOT AVAILABLE. THE CURRENT MILEAGE WAS NOT AVAILABLE.

IN A 2005 TOYOTA HIGHLANDER, WHILE PARKING THE VEHICLE FRONT BUMPER CORNER HIT ANOTHER VEHICLE. THE BRAKES IN THIS PARTICULAR VEHICLE FEEL VERY SPONGY MAKING IT VERY DIFFICULT TO CONTROL THE SPEED AND TRAJECTORY OF THIS VEHICLE AT SLOW SPEEDS. *TR

AUTOMATIC TRANSMISSION IS FORCING FLUID OUT THROUGH VENT CAUSING LOSS OF FLUID AND POSSIBLE DAMAGE TO TRANSMISSION. DEALER SAID IT IS CAUSED BY BEARING GOING BAD IN THE TRANSMISSION. VEHICLE HAS ALMOST 90,000 MILES. DEALERSHIP SAID PROBLEM IS COVERED UNDER EXTENDED WARRANTY SINCE IT WAS A CERTIFIED USED VEHICLE. *TR

TL* THE CONTACT OWNS A 2005 TOYOTA HIGHLANDER. WHILE DRIVING 2-3 MPH IN REVERSE, THE VEHICLE ABNORMALLY ACCELERATED. THE CONTACT ATTEMPTED TO BRAKE BUT TO NO AVAIL AS THE VEHICLE CRASHED INTO HER GARAGE. THE AIR BAGS DID NOT DEPLOY BUT THE CONTACT WAS NOT INJURED AND THERE WAS MINIMAL DAMAGE TO THE VEHICLE AND MODERATE DAMAGE TO THE CONTACTS HOME. THE VEHICLE WAS TAKEN TO THE DEALER YET THE DEALER WAS UNABLE TO DUPLICATE THE FAILURE. THERE WERE THREE ADDITIONAL OCCURRENCES OF THE FAILURE AND THE VEHICLE WAS TAKEN BACK TO THE DEALER WHERE REPAIRS WERE MADE TO THE FLOOR MAT AND THE BRAKE COVERS. THE CONTACT STATED THAT SHE WAS STILL AFRAID TO DRIVE THE VEHICLE. SHE LATER RECEIVED NOTIFICATION OF NHTSA CAMPAIGN ID NUMBER: 11V112000 (VEHICLE SPEED CONTROL:ACCELERATOR PEDAL) AND THE RECALL REPAIR WAS PERFORMED ON THE VEHICLE. THE FAILURE MILEAGE WAS 2,000 AND THE CURRENT MILEAGE WAS 20,000.

TL*THE CONTACT OWNS A 2005 TOYOTA HIGHLANDER. THE CONTACT STATED THAT THE REAR WINDOWS HAD BEEN FALLING OFF TRACK SINCE MAY 2009. THE REAR DRIVER SIDE WINDOW AND REAR PASSENGER SIDE WINDOW HAD BEEN REPLACED THREE TIMES. THE DEALER STATED THAT THE CAUSE OF THE FAILURE WAS WITHIN THE MECHANISM THAT LOWERED AND RAISED THE WINDOWS. THE VEHICLE HAD NOT BEEN REPAIRED. THE VIN WAS UNAVAILABLE. THE FAILURE MILEAGE WAS APPROXIMATELY 50,000 AND THE CURRENT MILEAGE WAS APPROXIMATELY 71,000.

THERE HAS BEEN A NOTICEABLE INCREASE IN STEERING WHEEL NOISE AND PLAY IN MY 2005 TOYOTA HIGHLANDER. THE ISSUE WAS NOTICED AROUND 40,000 MILES BECOMING INCREASINGLY WORSE IN A ONLY A FEW MONTHS. MILEAGE NOW IS 46,000. TOOK VEHICLE TO DEALERSHIP AND WAS TOLD THE INTERMEDIATE STEERING SHAFT NEEDED TO BE REPLACED. AFTER RESEARCHING THIS ISSUE IT APPEAR THERE IS A DEFECT IN THIS PART OR DESIGN POSING A SERIOUS SAFETY RISK. *TR

I HAVE A 2005 HIGHLANDER AND IT HAS 45K ON IT. I HAVE JUST RECENTLY NOTICED THIS CLUNK/KNOCK NOISE EVERY TIME I TURN THE STEERING WHEEL LEFT OR RIGHT 5 DEGREES OFF CENTER. THE TOYOTA DEALERSHIPS SERVICE DEPARTMENT ADVISED SPENDING $140 ON GREASING THE INTERMEDIATE STEERING SHAFT AND THE PROBLEM SHOULD GO AWAY, BUT THE MORE I READ UP ON THIS PARTICULAR ISSUE, THE MORE I'M REALIZING THAT THIS IS A DESIGN FLAW AND THAT IF I BANDAGE THE PROBLEM NOW, IT'LL ONLY COME UP AGAIN IN FUTURE MILEAGE. THIS SHOULD TOTALLY BE A TOYOTA RECALL BECAUSE IT DIRECTLY AFFECT SAFE DRIVING. I'M JUST WONDERING HOW I CAN ESCALATE THIS COMPLAINT TO THE TOP? *TR

HEATER RUNS ERRATICALLY--BLOWING FINE AND THEN SWITCHING TO COLD AIR AND THEN IF I "JIGGLE" THE CONTROL CAN GET HEAT AGAIN. HAD THE DEALER REPAIR IN FALL OF 2009 (ABOUT $95), BUT IT HAS STARTED ACTING UP AGAIN. *TR

I NOTICED A LOOSENESS & CLICKING NOISE IN MY STEERING WHILE EITHER PARKED OR MOVING VERY SLOWLY. A LOCAL MECHANIC I USE DIAGNOSED IT AS A WORN RACK & PINION (R&P) GEAR WHERE IT MEETS THE STEERING COLUMN. I HAVE AN EXTENDED WARRANTY ON MY '05 TOYOTA HIGHLANDER V6 WITH 60K MILES. I BROUGHT CAR TO KING TOYOTA IN DEERFIELD BEACH, FL AND THEY SAID THERE IS A TOYOTA SERVICE BULLETIN ON THIS PROBLEM WHICH DISASSEMBLES & LUBRICATES THE STEERING COLUMN. THEY SAID IF THAT DOESN'T FIX PROBLEM THEN THEY WOULD CHANGE THE R & P ASSEMBLY. AS A FORMER AIRLINE MAINTENANCE PLANNER I DON'T KNOW HOW A LUBE WOULD FIX NOISE & LOOSENESS IN A STEERING ASSEMBLY...IT FELT LIKE A WORN PART. IF TRUE, WHY DID THE STEERING COLUMN LOSE ITS LUBE AFTER ONLY 60K MILES.. WAS THE LUBE MISSING FROM NEW & THAT'S WHAT CAUSED THE WEAR...IF IT WAS LUBED WAS IT A DEFECTIVE SEAL. IS THE LUBE A STOP GAP WAY TO DELAY A RECALL? MY MECHANIC SAID & MY OWN EXPERIENCE TELLS ME SOMETHING ISN'T RIGHT...THIS IS A STEERING & POSSIBLE VEHICLE CONTROL ISSUE. MOST OF MY DRIVING IS HIGHWAY ABOVE 40-70MPH, SO I WAS CONCERNED BECAUSE MY FAMILY & MY LIFE ARE AT STAKE. *TR

I HAVE A TOYOTA HIGHLANDER 2005 .THE DRIV ERR S SIDE SUN VISOR WILL NOT STAY UP.IT IS A SAFETY HAZARD WE HOLE DRIVING.TOYOTA, THOUGH THIS IS A PROBLEM FOR MANY HIGHLAND ERR OWN ERR 3RD WILL NOT FIX OR REPLACE IT. *TR

THE DRIVER'S SIDE SUN VISOR ON OUR 2005 HIGHLANDER IS FAILING TO HOLD POSITION FOR THE SECOND TIME. THE DEALER REPLACED THE VISOR AFTER THE FIRST FAILURE BUT HAS NOT REPLACED THE SECOND FAILING VISOR. THE VISOR FALLS TO THE FULL DOWN POSITION AND BLOCKS A SIGNIFICANT SHARE OF THE DRIVER'S FIELD OF VISION. *TR

ON NOVEMBER 26TH 2008 WHILE TRAVELING EAST ON INTERSTATE 70 FROM DENVER, 75 MILE AN HOUR, AND APROX TWENTY MILES EAST OF BENNET COLORADO, WE EXPERIENCED BOTH FRONT AND REAR PASSENGER TIRE BLOWOUTS AT THE SAME TIME. THE BACK PASSENGERS TIRE WAS DESTROYED. WE WERE ABLE TO CHANGE IT OUT WITH OUR SPARE. THE FRONT PASSENGERS TIRE WAS EXTREMELY LOW (1" OFF PAVEMENT) AND HAD A BUBBLE ON THE SIDE WALL OF THE TIRE. IT HAD NOT BROKEN THE AIR SEAL AROUND THE RIM, AND SO WE WERE ABLE TO RETURN VERY SLOW BACK APROX .25 MILES TO AN EXIT AND RETRIEVE AIR FOR THAT TIRE. AS THE SIDE WALL BUBBLE GREW IN SIZE WE STOPPED THE AIR AT ABOUT TWENTY POUNDS. WE THEN RETURNED APROX TWENTY MILE BACK TO DENVER, TO A DISCOUNT TIRE STORE. WE THEN REPLACED ALL OF THE TIRES ON OUR 2005 TOYOTA HIGHLANDER. PRIOR TO DEPARTING ON THIS TRIP WE HAD ROTATED THE ORIGINAL TIRES AS WELL AS CHECKED AND CONFIRMED ALL AIR PRESSURES, (THE PRESSURE WAS CHECKED THIRTY MINUTES BEFORE LEAVING TOWN) WHEN CHECKING THE TIRES WE HAD HEARD A HISSING SOUND AT THE VALVE STEMS ON BOTH OF THE PASSENGER TIRES. THOUGHT THIS WAS JUST THE AIR HOSE, BUT NOW BELIEVE THAT THE VALVE STEMS WERE CRACKED AND LEAKING AIR. I HAVE DOCUMENTED THE TIRE CONDITION AND HAVE THE ORIGINAL VALVE STEMS FROM THE TIRE STORE. THESE TIRES WERE ORIGINAL EQUIPMENT MICHELIN TIRES WITH 28644 MILE ON THEM. WE BELIEVE THAT THIS CONDITION WAS A RESULT OF FAULTY VALVE STEMS, AND MAY BE A SERIOUS SAFETY CONCERN FOR OTHERS. MY TOYOTA DEALER SERVICE CENTER REFERS ME TO MICHELIN TIRE COMPANY, AND MICHELIN REFERS ME BACK TO THEM. TOYOTA MOTOR COMPANY HAS DOCUMENTED A REPORT, BUT WILL NOT ADDRESS THE ISSUE AS A CONCERN. WE HAD THREE ADULTS - (500 POUNDS) AND THREE SUIT CASES - (150 POUNDS) AND THEREFORE DON'T BELIEVE THAT AT 750 - 800 POUND THAT WE WERE OVERLOADED. *TR

TOYOTA HIGHLANDER 2005 4CYL. THE HEATER CONTROL WILL ONLY BLOW EXTREMELY HOT AIR THAT MAKES THE VENTS ALMOST TO HOT TO EVEN TOUCH. NO EVENTS LED UP TO THIS PROBLEM, THOUGH IN RESEARCHING ONLINE FORUMS, OTHER TOYOTA HIGHLANDER OWNERS ARE HAVING THE SAME DEFECT. I TOOK IT TO MY LOCAL TOYOTA DEALER AND THE SERVICE ASSOCIATE ACKNOWLEDGED THIS IS A PROBLEM WITH THIS VEHICLE. THE COST TO REPAIR IS $899.00. THIS IS EXCESSIVE FOR A HEATER ON A VEHICLE A LITTLE OVER THREE YEARS OLD AND A LITTLE OVER 30,000 MILES. IT APPEARS THIS IS A DEFECTIVE DESIGN AND THE WIRES ARE NOT WELDED PROPERLY. THE CENTER NUT BELOW THE HEATER CONTROL KNOB LOOSENS OVER TIME AND THE WIRES THEN BREAK FREE FROM THE CONTACTS. *TR

2005 TOYOTO HIGHLANDER, 40,000 MILES TO DATE. ABRUPT ACCELERATION OCCURRED TWICE FOR NO REASON-CAR DOES NOT HAVE FLOOR MATS THAT COULD INTERFERE WITH THE ACCELERATOR, FIRST OCCURRANCE IN 2006 WAS WHILE DRIVING ON HIGHWAY, BRAKING SOLVED THE PROBLEM SECOND OCCURANCE IN 2008- CAR WAS MOVING AT IDLE SPEED-FOOT WAS NOT OR NEAR THE ACCELERATOR BUT ABOVE BUT NOT TOUCHING THE BRAKE. BRAKING SOLVED THE PROBLEM. INFORMED TOYOTA DEALER-THEY WERE CLUELESS AND HAD NO KNOWLEDGE OF A PROBLEM. *TR

I HAVE A TOYOTA HIGHLANDER 2005 V6 4WD, WHICH SUFFERS FROM A TRANSMISSION SHIFT DELAY AND HESITATION ,WHICH NORMALLY OCCURS WHEN UPSHIFTING OR DOWNSHIFTING BETWEEN 2ND AND 3RD GEAR. THIS SHIFT DELAY IS NOT ONLY A HEADACHE, BUT A SAFETY CONCERN TO ME AND MANY OTHER FELLOW HIGHLANDER OWNERS AS SEEN ON VARIOUS ONLINE FORUMS. WHILE DRIVING MY VEHICLE I HAVE TO CONSTANTLY TRY TO ANTICIPATE HOW IT MIGHT REACT IN ORDER TO PREVENT AN ACCIDENT FROM HAPPENING,WHILE IN TRAFFIC. IT SEEMS AS IF THIS PROBLEM HAS BEEN KNOWN BY TOYOTA SINCE 2000 AND THEY HAVE NOT DONE ENOUGH TO GET IT FIXED. *TR

MY TOYO TIRES HAVE FAILED AFTER ONLY 18,000 MILES OF USE ON MY TOYOTA HIGHLANDER. *TR

I NOTICED A CLUNKING NOISE AND ODD VIBRATION IN THE STEERING WHEEL WHEN TRAVELING AT A SLOW SPEED ESPECIALLY WHEN TURNING CORNERS OR ON A BUMPY ROAD. I DO BELIEVE THAT IF THE STEERING INTERMEDIATE SHAFT IS NOT REPLACED, IT COULD EASILY CAUSE UNNECESSARY ACCIDENTS DUE TO LOSS OF STEERING. TOYOTA HAS ISSUED 2 TSB CONCERNING THIS PROBLEM, HOWEVER THEY SHOULD BE FORCED TO HAVE THIS PART REPLACED. I WAS ABLE TO HAVE MINE REPLACED UNDER WARRANTY, BUT I'M REALLY WRITING FOR ALL OF THOSE OWNERS WHO MIGHT BE DRIVING WITH THIS PROBLEM, BECAUSE THEY DON'T HAVE THE MONEY TO HAVE IT REPLACED.

SECOND TIRE TO HAVE A BUBBLE SHOW UP ON THE WHITE WALL SIDE. 2 OTHER TIRES HAD SEPARATION STARTED AND WAS A MATTER OF TIME BEFORE THE BUBBLES WOULD SHOW UP. *TR

TOYOTA HIGHLANDER, 2005 YR, DEFECTIVE RIBBON ELECTRICAL CABLE BETWEEN HEAT/AIR CONTROL ON DASH AND COMPUTER IN CAR. HEAT ON, HIT A BUMP IN THE ROAD AND AIR CONDITIONING COMES ON FULL BLAST OR THE REVERSE IN THE SUMMER. OTHER REPORTS ON INTERNET INDICATE SAME PROBLEM WITH 2001 & 2002 YEAR VEHICLES. COMMENTS ARE THE ELECTRICAL CABLE BECOME HARD AND BRITTLE WITH AGE AND BREAKS OR CROSS CONNECTS CAUSING PROBLEM. DEALER COST IS $600 - $900 TO CORRECT -- REPLACE WHOLE UNIT -- ALTHOUGH ONE COMMENT IS THAT NEW WIRE CAN BE SOLDERED. IT IS MY OPINION THAT CONSUMERS SHOULD NOT HAVE TO BEAR THE COST OF A MANUFACTURER'S DEFECTIVE PART. *TR

TIE RODS SEPARATED WHILE DRIVING, CAUSING TOTAL LOSS OF CONTROL OF VEHICLE. WHEELS TURNED SIDEWAYS. GOING 30 MILES PER HOUR, WAS ABLE TO BRING VEHICLE TO A STOP. VEHICLE WAS TOWED TO DEALERSHIP. THEY CLAIMED RUST, BUT WE RECEIVED VERBAL AFFIRMATION THAT NO RUST WAS FOUND. *TR