2009 Toyota Highlander Complaint Log

MY VEHICLE HAS AN ISSUE WITH THE DOOR LOCKS WHICH IS A SAFETY CONCERN, THE POWER DOOR LOCK ACTUATORS HAVE REPEATEDLY FAILED ON MY VEHICLE. EACH OF THE FOUR DOOR LOCK ACTUATORS HAVE BEEN REPLACED AND SEVERAL MULTIPLE TIMES. THE MOST RECENT WAS A DRIVERS (LEFT) SIDE REAR WHICH WAS REPLACED IN MARCH 2014 AND FAILED AGAIN. THIS MAKES THE 6TH OR 7TH TIME AN ACTUATOR HAS FAILED ON MY VEHICLE. THE COST TO REPLACE THESE IS APPROXIMATELY $600. HOWEVER MY BIGGEST CONCERN IS THAT THE VEHICLE IS UNLOCKED WHEN I BELIEVE IT IS LOCKED. THIS IS A WORRY BOTH WHEN TRANSPORTING YOUNG CHILDREN (WHO CAN OPEN THE DOOR AS CHILD SAFETY LOCKS ARE INOPERATIVE) AND POTENTIAL UNAUTHORIZED ACCESS OR THEFT OF THE VEHICLE. I OPENED A CASE WITH TOYOTA #1701210527. TOYOTA REFUSE TO CONTINUE TO ASSIST WITH THIS OR DETERMINE WHY MY VEHICLE REPEATEDLY HAS DOOR LOCK ACTUATORS FAIL.

WHEN YOU DRIVE BACK AND TURN, THE TIRES MAKE A STRANGE MOVEMENT, IT SEEMS LIKE IT WILL BE DETACHED FROM THE AXLE.

2009 HIGHLANDER, PURCHASED NEW, HAD 105000 MILES ON 3.5L V6 ENGINE. OIL CHANGED EVERY 7000 MILES, FULLY SYNTHETIC. NO WARNING LIGHTS OR ENGINE NOISES PRIOR TO INCIDENT. CAR STARTED AFTER WORK, DROVE .6 MILE. STARTED RUNNING VERY ROUGH, PULLED OVER TO SHOULDER THINKING I HAD A FLAT TIRE. CAR DIED BEFORE FINISHING MANEUVER, COASTED TO SHOULDER. ENGINE WOULD NOT START. TOWED TO REPAIR SHOP, THEY DIAGNOSED "ENGINE FULLY SEIZED UP". CONTACTED TOYOTA, THEY OFFERED NO SATISFACTION AS " CAR NOT BEING REPAIRED BY DEALER, NOT UNDER WARRANTY". I FIND THIS ANSWER TO BE WRONG, DUE TO LOW MILEAGE, HISTORY OF MAINTENANCE, NO REASON FOR CATASTROPHIC FAILURE OF ENGINE. MECHANIC STATED THEORY OF "OIL PORTS CLOGGING UP", SINCE HEARD THEORY OF "OIL PUMP FAILURE".

MARCH 10, 2016 VEHICLE WAS TAKEN TO DEALER FOR OIL CHANGE. PARKED VEHICLE AFTER RETURN HOME (10 MILES DRIVE BETWEEN DEALERSHIP AND HOME) SAME DAY AND AFTER A FEW HOURS, NOTICED ALL OIL HAD LEAKED FROM VEHICLE. VEHICLE WAS TOWED BACK TO DEALER THAT DAY. UPON INVESTIGATION DEALER SAID THE PROBLEM WAS THE OIL COOLER PIPE. DEALER SAID TOYOTA ISSUED A TECHNICAL SERVICE BULLETIN T-SB-0201-11 OVER 5 YEARS PRIOR THAT ISSUED A REPAIR PROCEDURE TO REPLACE THIS OIL COOLER PIPE. DEALER REPLACED OIL COOLER PIPE UNDER WARRANTY PER TECHNICAL SERVICE BULLETIN AND ASSURED ME THAT NO DAMAGE TO THE ENGINE WAS "APPARENT" AFTER THE REPAIR. JULY 18, 2016 RETURNED TO SAME DEALER FOR A PROBLEM WITH THE ENGINE MAKING A LOUD KNOCKING SOUND UPON FAST ACCELERATION. DEALER DIAGNOSED PROBLEM AS A ROD KNOCK AND CONFIRMED IT WAS DUE TO THE OIL COOLER PIPE LEAK FROM MARCH. THE REPAIR INVOLVES REPLACING THE ENGINE AN EXTENSIVE AND VERY EXPENSIVE REPAIR. TOYOTA NEEDS TO MAKE THIS TECHNICAL SERVICE BULLETIN PROBLEM A RECALL TO AVOID UNNECESSARY ENGINE DAMAGE AND POTENTIAL SAFETY HAZARD TO THE 533500 ESTIMATED VEHICLES INCLUDED IN THE BULLETIN.

LIFTGATE WILL NOT CLOSE OR OPEN WHEN AUTOMATIC BUTTON IS PUSHED EITHER ON THE DASH OR THE BUTTON ON THE LIFTGATE ITSELF. STAYS OPEN AND HAVE TO FORCE THE LIFTGATE DOWN MANUALLY. AT TIMES LIFTGATE WILL OPEN BY ITSELF WHILE STATIONARY OR VEHICLE IS MOVING. CLOSING OR OPENING THE LIFTGATE AUTOMATICALLY PROBLEM HAS BE ONGOING FOR ABOUT 6 MONTHS. BROUGHT TO DEALERSHIP AND THEY COULD NOT REPAIR, BUT I COULD TAKE TO BODY SHOP FOR REPAIR. CURRENTLY A SERVICE BULLETIN HAS BEEN ISSUED, BUT SHOULD BE A SAFETY RECALL.

REAR DOOR MOTOR LIFT NOT WORKING

$7155 QUOTE TO REPLACE 2 ELECTRICAL HARNESSES. REASON: "WARNING: SRS AIRBAG CHECK. TAKE VEHICLE TO DEALER". THE JUNCTION BOX IS HIDDEN BEHIND THE DRIVER SIDE FRONT PANEL. THE PINS IN THE JUNCTION BOX BELONGING TO THE AIRBAG WIRING HARNESS (PART # 82141-48R51) THAT RUNS UNDERNEATH THE DASHBOARD WERE FRIED DUE TO ELECTRICAL SHORT (UNEXPLAINED). BECAUSE THE JUNCTION BOX ALSO BRINGS THE REAR WIRING HARNESS (PART # 82162-48D40 ) TO TAIL, HEADLINER, AND BACK OF THE VEHICLE, THIS MUST BE REPLACED AS WELL. I FEAR THAT THERE IS A MAJOR FLAW IN THE ELECTRICAL SYSTEM / SRS AIRBAGS OF THIS VEHICLE AND THE VEHICLE ELECTRICAL SYSTEM HAS EXPERIENCED PREMATURE FAILURE.

NOTICED LARGE OIL PUDDLE IN DRIVEWAY. HAD CAR TOWED AS OIL LOSS COULD HAVE CAUSED FATAL DAMAGE TO THE ENGINE. THE OIL LINE WAS DIAGNOSED AS DRY ROTTED AND NEEDED TO BE REPLACED. THE REPLACEMENT OIL LINE WAS VASTLY DIFFERENT THAN THAT OF THE ORIGINAL LINE INDICATING A PROBLEM WITH THE PREVIOUS DESIGN. THE LEAK BEGAN WHILE DRIVING AND WE WERE ABLE TO TRACE THE OIL FOR MILES LEADING HOME. THE OIL INDICATOR LIGHT DID NOT COME ON TO WARN OF LOW OIL. TOYOTA DID RECALL OTHER VEHICLES FOR THE SAME PROBLEM HOWEVER NOT THIS PARTICULAR MAKE AND MODEL. AFTER TALKING TO TOYOTA'S RECALL DEPARTMENT I WAS TOLD IF I HAD HAD THE REPAIRS TAKEN CARE OF AT A TOYOTA DEALERSHIP I MAY HAVE BEEN ABLE TO BE REIMBURSED SLIGHTLY (A PERCENTAGE OF THE BILL) HOWEVER SINCE I USED THE SHOP OF MY CHOICE THERE IS NO OPTION FOR ANY REIMBURSEMENT.

AUGUST 6, 2015 I WAS DRIVING NORTHBOUND ON HWY 45. AFTER ABOUT 20 MINUTES ON THE ROAD MY 2009 TOYOTA HIGHLANDER BEGAN TO SMOKE, THE OIL PRESSURE WARNING LIGHT CAME ON AND I PULLED OVER TO THE SIDE OF THE ROAD. WITHIN A FEW MINUTES, BLACK SMOKE WAS POURING OUT FROM UNDERNEATH THE HOOD. WITHIN ANOTHER MINUTE OR TWO THE SUV WAS ON FIRE AND SOON THE FRONT HALF WAS COMPLETELY ENGULFED IN FLAMES. I THOUGHT IT WOULD EXPLODE. TWO MILWAUKEE FIRE DEPARTMENT TEAMS ARRIVED AND EXTINGUISHED THE FIRE. THANK GOD NO ONE WAS HURT AND MY CHILDREN WERE NOT IN THE CAR. ACCIDENT REPORT BMZ14XN WAS FILED WITH MILWAUKEE COUNTY. PRIOR TO THE FIRE THAT TOTALED THE HIGHLANDER, AN EMERGENCY REPAIR WAS MADE TO THE HIGHLANDER ON NOVEMBER 3, 2014. THAT NIGHT THE ENGINE BEGAN TO MAKE A STRANGE NOISE AND THE OIL WARNING LIGHT WENT ON. I PULLED INTO THE NEAREST AUTO REPAIR SHOP; THE TECH SAID IF I DROVE ANY FURTHER THE ENGINE WOULD HAVE BEEN SEVERELY DAMAGED BECAUSE THERE WAS NO OIL LEFT. THE ENGINE COOLANT PIPE SPRUNG A LEAK AND ALL OF THE OIL POURED OUT OF MY CAR. THAT WAS THE FIRST TIME MY HIGHLANDER LOST ALL OF ITS OIL BECAUSE OF A FAULTY OIL COOLANT PIPE- THE SECOND TIME IT RESULTED IN AN ENGINE FIRE. IN DECEMBER 2014 I RECEIVED A LETTER FROM TOYOTA STATING THEY REIMBURSE FOR REPAIRS RELATED TO LEAKING OIL OR ENGINE DAMAGE. TOYOTA DEALERS RECEIVED TECHNICAL SERVICE BULLETIN (TSB) #TSB-020-11 INDICATING THE REPLACEMENT PART SHOULD BE METAL; NOT RUBBER WHICH IS WHAT I HAD. I MENTIONED THE EMERGENCY REPAIR TWICE WHEN I WENT IN FOR SERVICE TO JACK SAFRO TOYOTA. NEITHER TIME DID A SERVICE TECH SUGGEST THAT THE OIL COOLANT PIPE BE CHECKED TO MAKE SURE IT WAS CORRECTLY REPAIRED. I BELIEVE THIS WAS A MAJOR OVERSIGHT ON THE PART OF THE SERVICE DEPARTMENT AND THAT TOYOTA SHOULD RECALL THE OIL COOLANT PIPE. THE FAULTY PART IS ON 2007-2010 HIGHLANDERS AND OTHER TOYOTA VEHICLES.

THE SUN VISOR REPEATEDLY FLOPS DOWN OBSCURING THE DRIVER'S VIEW. THE VISOR WILL NOT STAY IN THE "UP" POSITION. ALSO WHEN ENTERING THE VEHICLE, IF THE VISOR IS IN THE VERTICAL POSITION, I.E. NOT UP WHERE IT SHOULD BE, THE DRIVER WILL HIT HIS/HER HEAD ON THE EDGE OF THE VISOR. THIS ISSUE IS NOT NEW TO THIS VEHICLE, THERE HAS BEEN A RECALL FOR EARLIER YEAR MODELS AS WELL AS OTHER TOYOTA MODELS AS WELL.

WE WERE TRAVELING DOWN A STATE ROUTE HIGHWAY AT 50 MPH WHEN SUDDENLY WE LOST POWER TO THE CAR, WE WERE BETWEEN TWO MAC TRUCKS, AND THE OIL LIGHT STARTED FLASHING. WE HAD TO QUICKLY GET OFF THE ROADWAY (NO BREAKDOWN LANES) AND FIND A SAFE SPOT TO STOP ON SOME GRASS. THE RUBBER OIL LINE HAD CRACKED/RUPTURED AND DRAINED THE OIL FROM THE CAR RAPIDLY CAUSING THE ENGINE TO LOSE POWER AND MAKE NOISE. I FOUND OUT ONLINE THAT THIS IS A KNOWN ISSUE BUT NO RECALL HAS BEEN DONE AS TOYOTA CLAIMS THIS IS NOT SAFETY ISSUE. HOWEVER, IN MY CASE IT WAS VERY MUCH A SAFETY ISSUE AS THIS HAPPENED ON A HIGHWAY IN RAPID SUCCESSION WITH NO SAFE PLACE TO LEAVE THE ROADWAY.

REAR DOOR HATCH MADE A LOUD POPPING NOISE WHEN DOOR WAS LOWERED. DOOR NO LONGER OPENS OR CLOSES. DEALER STATES COST TO REPAIR $4,700 TO $5,400. TOYOTA HAS A TECHNICAL SERVICE BULLETIN COVERING THIS PROBLEM BUT DENIES RESPONSIBILITY IF VEHICLE IS BEYOND 36/36,000 WARRANTY. UPDATED 9/15/15*CW

THE POWER TAILGATE WILL NOT OPEN AND CLOSE AUTOMATICALLY. YOU HAVE TO FORCE IT TO OPEN MANUALLY AND FORCE IT TO CLOSE MANUALLY BECAUSE THE MOTOR GETS STUCK IN ONE POSITION. WE CALLED THE TOYOTA TO SEE IF THERE WAS ANY RECALLS AFTER READING SIMILAR COMPLAINTS ON THE INTERNET AND FEW LAWSUITS AGAINST TOYOTA FOR THE SAME PROBLEM, AND TOYOTA SAID NO THERE ARE NO RECALLS FOR THE TAILGATE MOTOR. THE MOTOR ITSELF COSTS ABOUT $1200 AND ONLY THE TOYOTA HAS IT, PLUS THE LABOR TO REPLACE IT WHICH COULD AMOUNTS UP TO $1500 IF YOU FIND AN OUTSIDE MECHANIC/BODY SHOP TO DO IT FOR YOU. IN ADDITION, YOU MIGHT NEED TO CHANGE THE RAILS AND SHOCKS THAT HOLD THE TAILGATE TO THE BODY OF THE CAR. IF YOU TAKE IT TO THE TOYOTA, IT COULD COST CLOSE TO $5000.00. SINCE THIS HAS OCCURRED WITH TOO MANY CONSUMERS, WE BELIEVE THERE SHOULD BE A RECALL FOR THIS PROBLEM BECAUSE IT COULD CAUSE SOME INJURIES IF SOMEONE GETS TRAPPED BETWEEN THE TAILGATE AND THE REAR BUMPER/CARGO AREA. *TR

TL* THE CONTACT OWNED A 2009 TOYOTA HIGHLANDER. THE CONTACT STATED THAT THE VEHICLE CAUGHT FIRE ON THE FRONT DRIVER'S SEAT. THE FIRE DEPARTMENT EXTINGUISHED THE FIRE. THE VEHICLE WAS DESTROYED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE AND STATED THE VEHICLE WAS NOT INCLUDED IN NHTSA CAMPAIGN NUMBER: 14V743000 (ELECTRICAL SYSTEM). THE FAILURE MILEAGE WAS 110,000.

THIS VEHICLE HAS AN ELECTRICAL PROBLEM, MOST MECHANIC SHOPS I TOOK IT WERE NOT ABLE TO FIND OUT THE NATURE OF THE PROBLEM. I'VE CHANGED THE BATTERY TWICE AND STILL EXPERIENCING THE SAME PROBLEM. AT THE HIGH WAY I NOTICED THE THAT THE TEMPERATURE OF THE ENGINE GETS HIGH, WHICH OBLIGED TO DRIVE IN A MUCH LOWER SPEED WITH THE FLASHERS ON WHICH ALWAYS INCREASES THE TRAFFIC SAFETY RISKS.

WHEN I LOCK THE CAR THE ALARM WILL GO OFF FOR NO REASON AT ALL. IT DOES THIS ALL THE TIME. IT IS VERY IRRITATING.

THE TAILGATE MOTOR UNEXPECTEDLY MALFUNCTIONED AND CLOSED THE DOOR IN AN UNBALANCED WAY CAUSING THE BREAKING OF THE TAILGATE HINGES / ARMS. THE TAILGATE STOPPED / FROZE AND REMAINED AJAR ABOUT 1 INCH ON RIGHT PASSENGER SIDE OF THE DOOR AND LATCHING ON DRIVER'S SIDE OF THE DOOR. THE DOOR WOULD NOT MANUALLY OR ELECTRONICALLY OPEN BACK UP. HAD TO HAVE THE DOOR PHYSICALLY REMOVED BY TOYOTA DEALERSHIP AND REPLACED ENTIRE TAILGATE HATCH, MOTOR AND HINGES. COSTING ME IN THE NEIGHBORHOOD OF $5,000 FOR PARTS, LABOR, AND A RENTAL CAR FOR 12 DAYS TO REPAIR AS MY INSURANCE WITH PROGRESSIVE INSURANCE DECLINED COVERAGE UNDER MY COMPREHENSIVE INSURANCE AS THEY RELATED BACK TO WEAR AND TEAR. POTENTIAL SEVERE CRUSHING INJURY OR FATALITY COULD HAVE RESULTED FROM WHAT OCCURRED. SINCE THE DOOR CONTINUED TO CLOSE AFTER MALFUNCTIONING AND FROZE IN PLACE (UNABLE TO PHYSICALLY OPEN), HAD SOMEONE'S HAND OR BODY PART BEEN CAUGHT UNDER COULD HAVE RESULTED IN BEING CAUGHT / TRAPPED BETWEEN THE DOOR AND THE LATCHING AREA. QUICK SEARCH ON THE INTERNET SHOWS THAT THIS IS NOT THE FIRST TIME THAT THIS HAS OCCURRED. ALL SHOWING SIMILAR COST ASSOCIATED WITH REPAIR AND ALL WITH THE SAME LIFE ALTERING OR SEVERE INJURY CONSEQUENCE. WOULD LIKE TO GET TOYOTA TO RECALL THE HIGHLANDER AND FIX THE FAULTY MOTOR BEFORE SOMEONE GETS HURT OR WORSE, KILLED BY THIS DEFAULT

THE POWER BACK DOOR/LIFTGATE DOES NOT CLOSE PROPERLY. THE READ DOOR OF THE HIGHLANDER WOULD COME WITHIN AN INCH OF CLOSING WHEN YOU OPERATED THE POWERED CLOSE FUNCTION AND STOP, REQUIRING A PHYSICAL NUDGE TO COMPLETELY ENGAGE THE LOCK AND CLOSE. THIS WENT ON FOR ABOUT A YEAR UNTIL ONE DAY THERE WAS A LOUD CRUNCHING NOISE WHEN IT WAS CLOSED AND WOULD NOT OPEN. AFTER SEARCHING THE INTERNET FOR SOLUTIONS AND FINDING THIS IS AN EXTREMELY COMMON PROBLEM (EVEN SEVERAL WEBSITES DEDICATED TO FORMING CLASS ACTION LAWSUITS) INCLUDING TOYOTA ISSUING T-SB-0091-12, I CALLED TOYOTA'S HELP LINE WHERE I WAS VERY RUDELY TOLD THAT SINCE THE WARRANTEE WAS OVER, THEY WOULD NOT COVER ANY OF IT. WE HAVE A 1 YEAR OLD BABY AND WE GOT THIS CAR WITH THAT IN MIND. WE CURRENTLY HAVE NO ACCESS TO THE TRUNK AND CANNOT FIT HER STROLLER IN THROUGH THE WINDOW. WE ARE NOW FACED WITH A SEVERAL THOUSAND DOLLAR REPAIR! I DISASSEMBLED THE PART MYSELF TO FIND OUT THAT THE METAL GEAR ABOUT 1/2 AN INCH THICK HAD SHEARED OFF AND BROKEN - EXACTLY AS SHOWN IN FIGURE 2 OF THEIR OFFICIAL BULLETIN. TOYOTA TRIED TO BLAME US FOR THE FAILURE SAYING WE PROBABLY TRIED TO CLOSE THE DOOR ON CARGO (WE DID NOT) AND THAT THIS IS NOT A KNOWN ISSUE (WHY WOULD THEY ISSUE A TSB IF THIS WAS NOT A FREQUENT ISSUE?). FROM RESEARCH ON THE INTERNET, THERE APPEARS TO BE MANY MANY PEOPLE WITH THIS PROBLEM AND UNFORTUNATELY FOR US, OUR OCCURRED OUTSIDE OF THE WARRANTEE PERIOD SO WE ARE LEFT WITH LITTLE RECOURSE. I THINK IT WOULD BE APPROPRIATE FOR TOYOTA TO EXTEND COVERAGE FOR THIS COMMON ISSUE SINCE ITS FAILURE MAKES THE TRUNK UNUSABLE AND BECAUSE IT HAS SUCH A COMMON OCCURRENCE. TSB: HTTP://MEDIA.FIXED-OPS.COM/TOY_SERVICEBULLETINS/SB0091T12.PDF

TO WHOM IT MAY CONCERN IN EARLY 2015, THE DRIVER'S SIDE VISOR BEGAN TO FAIL IN MY 2009 TOYOTA HIGHLANDER VIN [XXX]. MY DESCRIPTION OF THE WORD FAIL, FOR THE VISOR, IS THAT IT WOULD NO LONGER STAY IN THE CLOSED STORED POSITION. WHILE DRIVING DOWN THE ROAD, A BUMP, ROAD VIBRATION, OR OTHER FACTOR WOULD CAUSE THE DRIVER'S SIDE VISOR TO LOWER FROM ITS CLOSED STORED POSITION AND THUS IMPAIRING DRIVER VISIBILITY. EVENTUALLY THE FAULTY VISOR WOULD LOWER TO THE POINT OF BEING A HAZARDOUS DISTRACTION. LOWERING ONLY PARTIALLY, IT WOULD FREQUENTLY IMPAIR THE DRIVER?S VISION OF THE ROAD. THIS FAILED VISOR IS NOT A CONDITION LIMITED TO THE 2009 TOYOTA HIGHLANDER. I HAVE ATTACHED A COPY OF WARRANTY ENHANCEMENT PROGRAM ZF1 WHICH DESCRIBES THE CONDITION I HAVE DEALT WITH. WHILE IT IS UNCLEAR WHY TOYOTA LIMITED THIS WARRANTY ENHANCEMENT TO CERTAIN 2010 TO 2013 HIGHLANDERS, I SEE LITTLE OR NO DIFFERENCE TO THE DESIGN FLAW WHICH HAS OCCURRENCE IN THE 2009 HIGHLANDER I OWN. AFTER READING THROUGH MANY FORUMS, IN REGARDS TO THE HIGHLANDER, THE FAILING VISOR IS A SAFETY/VISIBILITY PROBLEM, COMMON TO MANY NEWER AND OLDER MODEL YEARS IN THE TOYOTA HIGHLANDER AFTER DEALING WITH THE FAULTY EQUIPMENT FOR A SIGNIFICANT AMOUNT OF TIME, I PURCHASED A REPLACEMENT VISOR AT [XXX] TOYOTA. I PAID THE PRICE OF THE PART ONLY IN THE AMOUNT OF $89.11 PLUS TAX, NO LABOR. I INSTALLED THE PART MYSELF. ADDITIONALLY, I AM REQUESTING FULL REIMBURSEMENT FROM TOYOTA FOR THE REPLACEMENT PART TO RESOLVE THIS IMPAIRED VISIBILITY SAFETY CONDITION IN THE AMOUNT OF $89.11. PLEASE REMIT PAYMENT, AND RESOLUTION OF THE ENHANCED REVIEW TO [XXX] INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6). *TR

MASSIVE OIL LEAK FROM OIL COOLER LINE OF 2009 TOYOTA HIGHLANDER WITH TOW PACKAGE AT ~78,000 MILES. RUBBER HOSES BURST AND OIL LEAKED OUT FROM ENGINE.

THE DRIVER SIDE SUN VISOR DROOPS DOWN. TOYOTA IS NOT TAKING RESPONSIBILITY FOR THIS ISSUE. IT SEEMS TO BE HAPPENING ALOT. IT FALLS WHILE I'M DRIVING, AND I'M AFRAID IT WILL CAUSE ME TO GET IN A WRECK. TOYOTA NEEDS TO RECALL THIS VISOR. POOR DESIGN. *TR

I HAVE NOT HAD AN ACCIDENT WITH THIS VEHICLE, HOWEVER I WAS TOLD BY TOYOTA TO CHECK THIS WEBSITE TO SEE IF MY PARTICULAR YEAR AND MODEL IS ONE OF THE ONES AFFECTED BY THE AIRBAG MALFUNCTION. IF SO, I WANT TO GET IT IN TO BE REPAIRED AS SOON AS POSSIBLE IN CASE THERE IS AN ACCIDENT AND SOMEONE IN MY VEHICLE IS KILLED OR INJURED. I AM A SPORTS MOM SO AT TIMES I HAVE 6 CHILDREN IN MY VEHICLE AND 2 ARE MY GRANDCHILDREN. *TR

DOOR LOCK ON FRONT DRIVER DOOR DOES NOT LOCK WHEN REMOTE OR DOOR BUTTON INSIDE CAR PRESSED. GIVES IMPRESSION DOOR IS LOCKING WHEN IT IS NOT. *TR

LIFT GATE AND POWER DOOR MOTOR BROKE. THE DOOR STOCKED AND COULD NOT BE OPENED OR LOCKED. I WAS LUCKY THAT MY TODDLER WAS NOT AROUND. I AM HORRIFIED WHAT WOULD HAPPENED IF HIS HAND STOCK IN IT AND THE DOOR COULD NOT BE OPEN. WE TOOK IT TO MOLLE TOYOTA. THEY TOLD ME THAT BESIDE THE LIFT GATE AND MOTOR THE WHOLE REAR DOOR AND HINGE HAS TO BE REPLACE. THEY SAID THAT IF I DON'T REPLACE THE DOORS I WILL HAVE SAME PROBLEM FEW MONTHS LATER. THEY SAID THAT TOYOTA MODIFIED THE NEW REAR DOOR THAT THEY ARE AWARE THAT THE DOOR IN MY VEHICLE CAUSING PROBLEMS. THEY REFUSED TO PAY FOR THE DOOR BECAUSE IT'S OUTSIDE WARRANTY. THE COST OF MOTOR AND LIFT GATE REPAIR IS $1500 THE COST WITH NEW DOOR IS $3500. I DON'T UNDERSTAND WHY TOYOTA DOES NOT PAY FOR DOOR THAT THEY ARE AWARE THAT ARE DEFECTIVE AND NEEDED TO BE MODIFIED. I ALSO THINK THAT THERE SHOULD BE A RECALL ON THIS PART BECAUSE SOMEONE CAN GET INJURED.

THE RUBBER HOSE BETWEEN THE OIL PUMP AND THE VVT KEEPS BREAKING. I WAS DOING SOME RESEARCH AND FOUND THAT THE RUBBER HOSE HAS BEEN REPLACE WITH A METAL ONE. CAN YOU PLEASE HELP ME? IS THIS SOMETHING THAT IS POSSIBLY STILL UNDER WARRANT AND CAN BE FIXED? THANK YOU FOR HELP IN ADVANCE. *TR

LIFTGATE DOES WILL NOT OPEN. SCHAUMBURG TOYOTA REPORTED THE FOLLOWING ON THEIR SERVICE REPORT THE FOLLOWING: "FOUND AUTO OPEN & CLOSE MOTOR SEIZED. NEED: TO GO TO BODYSHOP - REPLACE L/HINGE, MOTOR-DOOR". TOYOTA SCHAUMBURG IS SPECULATING (PURE SPECULATION) THAT THE CAR WAS BUMPED INTO AND THEREFORE THE DISTANCES (WHICH DISTANCES ?) ARE SKEWED. WE (OWNERS) BELIEVE THAT NO SUCH INCIDENCE HAPPENED. WE E-MAILED TOYOTA (CASE # [XXX].) WHO REFERRED US BACK TO [XXX]. [XXX] DID CALL BUT OFFERED NO PROOF OF THEIR SPECULATION (THAT THE CAR WAS BUMPED INTO), NEITHER DID [XXX] PROVIDE THE MISALIGNMENT NUMBERS. [XXX] DID MENTION THAT TOYOTA HAS KNOWN ABOUT THIS PROBLEM BUT THEY WILL HONOR THE PROBLEM ONLY WITHIN 3 MONTHS/36,000 MILES. THE POWER TO MY LIFTGATE IS NOW DISABLED AND I WOULD LIKE FOR TOYOTA TO ACKNOWLEDGE THAT THEY HAVE KNOWN ABOUT THIS PROBLEM AND THEREFORE MAKE THE LIFTGATE FULLY FUNCTIONAL (POWER CONNECTED) FOR ME. WE (OWNERS) ARE HONEST WHEN WE SAY THAT THE CARE WAS NOT BUMPED INTO FROM REAR-SIDE AND WE SHOULD NOT BE PAYING FOR THESE REPAIRS. I HAVE TRIED MY BEST TO WORK IT OUT WITH TOYOTA CORPORATION AND SCHAUMBURG TOYOTA, HOWEVER, BOTH ARE TRYING TO DEFLECT THE RESPONSIBILITY AWAY FROM THEMSELVES. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6). *TR

THE REAR HATCH IN MY 2009 TOYOTA HIGHLANDER STOPPED WORKING - WITHOUT MISUSE OR HANDLING ON MY PART. AFTER PUSHING THE AUTOMATIC CLOSE BUTTON, THERE WAS A LOUD CLUNK SOUND. THERE WAS NOTHING OBSTRUCTING THE BACK AREA. THE BACK DOOR/HATCH WOULD NOT OPEN, NOR COULD I CLOSE IT. I IMMEDIATELY DROVE IT TO THE DEALERSHIP - ON A SATURDAY. I WAS AFRAID MY BACK DOOR WAS GOING TO FLY OPEN. THEY WERE ABLE TO CLOSE THE HATCH BUT IT CANNOT BE OPENED. THE TECHNICIAN CONFIRMED THAT THEY HAD SEEN A LOT OF THESE AND SAID TOYOTA WOULD TAKE CARE OF IT. HE SAID THE PROBLEM IS THE HINGES WERE BENDING AND THEREFORE CAUSING THE DOOR NOT TO SHUT. I WAS ASKED TO RETURN ON MONDAY. AFTER A DIAGNOSTIC TEST, THE SERVICE MANAGER CONFIRMED THAT THE HINGES WERE BENT AND I WOULD NEED A WHOLE NEW DOOR. THE TOTAL COST OF THE PROBLEM COULD BE CLOSE TO $3,000 (DEPENDS ON WHETHER THE MOTOR CAN BE SALVAGED). I WAS ALSO TOLD THIS IS MY RESPONSIBILITY SINCE I AM OUT OF THE 3YR/36K MILE WARRANTY (59K MILES). THERE HAS BEEN A TSB ISSUED FOR THIS SAME PROBLEM, BUT AS HE POINTED OUT, IT IS FOR MALFUNCTION WITHIN THE TIMEFRAME. I HAVE NOT BEEN SUCCESSFUL WITH TOYOTA USA, BUT WILL CONTINUE TO PURSUE THIS. THIS IS A KNOW DEFECT AND SHOULD BE A RECALL ISSUE OR AT THE VERY LEAST, AN EXTENSION ON THE TIME ASSOCIATED WITH THE TSB. TOYOTA IS REPLACING THE SUBPAR HINGES WITH BETTER ONES. AN ISSUE IS AN ISSUE - EVEN IF IT DOESN'T HAPPEN WITHIN A TIMEFRAME. I HAVE DONE NOTHING TO CAUSE THIS ISSUE. AND NOW BECAUSE TOYOTA USED SUBPAR HINGES, I HAVE TO PAY $3K! *TR

LEFT DRIVER'S DOOR ACTUATOR WORKS SOMETIMES WHEN PRESSING REMOTE CONTROL TO UNLOCK DOOR. LEFT REAR DOOR WORKS SOMETIMES WHEN PRESSING REMOTE CONTROL TO UNLOCK DOOR. *TR

TL*THE CONTACT OWNS A 2009 TOYOTA HIGHLANDER. THE CONTACT RECEIVED A RECALL NOTIFICATION FOR NHTSA CAMPAIGN NUMBER: 14V168000 (STEERING) AND STATED THAT THE PART NEEDED WAS UNAVAILABLE TO PERFORM THE RECALL REPAIR. THE MANUFACTURER WAS NOTIFIED OF THE ISSUE. THE CONTACT HAD NOT EXPERIENCE A FAILURE. THE VIN WAS NOT AVAILABLE.

THE DRIVER'S SIDE VISOR NO LONGER STAYS UP, SO IT HAS PROGRESSIVELY DROPPED DOWN TO ABOUT A 30-45 DEGREE ANGLE TOWARD THE DRIVER'S HEAD. THIS IS A LARGE SAFETY HAZARD BOTH FOR GENERAL VISIBILITY WHEN DRIVING AND POTENTIAL CAUSE OF INJURY TO THE HEAD IN THE CASE OF AN ACCIDENT. THE VEHICLE WAS PURCHASED CERTIFIED USED FROM A TOYOTA DEALERSHIP. SUCH A PART SHOULD NOT BECOME FAULTY JUST OVER 3 YEARS FROM THE TIME IT WAS ORIGINALLY PUT ON THE MARKET. THE VISOR IS NOT USED AGGRESSIVELY OR EXCESSIVELY. BOTH THE DEALERSHIP AND TOYOTA MOTORS WERE CONTACTED REGARDING THIS PROBLEM. TOYOTA ADVISED THIS PART WAS NOT COVERED UNDER ANY TYPE OF STANDARD WARRANTY, DESPITE THE FACT THAT IT IS A SAFETY AND VISIBILITY ISSUE. BOTH PARTIES WERE OF NO ASSISTANCE AND REQUIRED OWNER OF VEHICLE TO PAY FOR COST OF PARTS AND LABOR. THANK YOU FOR YOUR TIME AND CONSIDERATION TO THIS MATTER. *TR

ABOUT EIGHTY MILES/TWO DAYS PRIOR TO THE FAILURE, AN INTERMITTENT WHINE/HUMMING NOISE WAS HEARD IN THE VICINITY OF THE DRIVER SIDE DASH AREA WHILE TURNING AT SLOW SPEEDS. I WAS TOLD THIS WAS NOT UNUSUAL AS THE POWER STEERING IS ELECTRICALLY ASSISTED AND THE ELECTRIC MOTOR WAS LIKELY MAKING THE NOISE. TWO DAYS AFTER THE FIRST SOUNDS, THE POWER STEERING FAILED UPON ENGINE START. THE STEERING WHEEL IS NEARLY IMPOSSIBLE TO TURN NOW. *JB

WHILE DRIVING DOWN THE EXPRESSWAY WITH THE FAMILY (50MPH), CHECK ENGINE LIGHT AND TRACTION CONTROL SUDDENLY TURN ON AND FLICKER ON AND OFF RANDOMLY. ENGINE POWER HESITATES. AT THE STOPLIGHT, CHECK ENGINE LIGHT CONTINUES TO TURN ON, AND OFF RANDOMLY, AS WELL AS TRACTION CONTROL LIGHT. ENGINE APPEARS TO BE STALLING AT TIMES, AND RPM BOUNCES BETWEEN 500-900. ACCELERATION WHEN PRESSING AGAINST GAS PEDAL RESULTS IN UNEVEN ACCELERATION. PULLED VEHICLE OFF TO THE SIDE, TURNED ENGINE OFF, AND EXAMINED VEHICLE. EXAMINED VEHICLE AND DO NOT SEE ANYTHING SUSPICIOUS. TURNED VEHICLE BACK ON, AND CHECK ENGINE LIGHT WITH TRACTION CONTROL OFF. MOMENTS LATER, LIGHTS TURN BACK ON. LIMPED VEHICLE BACK TO RESIDENCE VIA LOCAL ROADS. CONTINUED TO EXPERIENCE INTERMITTENT ON/OFF CHECK ENGINE LIGHT AND TRACTION CONTROL. AFTER ARRIVING AT RESIDENCE, PARKED VEHICLE AND PERFORMED ADDITIONAL EXAMINATION. NOTICED BURNING SMELL AT REAR BRAKE SHOES, POSSIBLY FROM TRACTION CONTROL HOLDING ON TO BRAKES. WILL BRING CAR TO DEALERSHIP ON 08/05/13 FIRST THING IN THE MORNING. *TR

AS MY WIFE CAME HOW WITH MY DAUGHTER, SHE PROCEEDED TO REVERSE THE CAR INTO OUR DRIVEWAY TO PARK THE CAR IN OUR GARAGE AS SHE NORMALLY DOES EVERYDAY. IN THE DRIVEWAY WAS ALSO MY CAR WHERE IT IS PARKED EVERYDAY. AS SHE WAS PROCEEDING TO GO BACK, THE CAR ALL OF A SUDDEN ACCELERATED ON ITS OWN AND TOOK OFF. SHE TRIED TO PRESS THE BRAKE BUT TO NO AVAIL. SHE CONTINUED TO PRESS THE BRAKE, HOWEVER THE CAR WOULD NOT STOP. SHE PROCEEDED TO HIT MY CAR AND DAMAGED BOTH CARS FROM FRONT TO BACK. HER CAR ON THE PASSENGER SIDE, AND MINE ON THE DRIVER SIDE. AFTER HITTING BOTH CARS, HER CAR PROCEEDED TO GO FURTHER BACK AND CRASH INTO THE HOUSE CAUSING MAJOR DAMAGE. THAT IS WHEN THE CAR ACTUALLY STOPPED. IT WAS AT THIS TIME THAT SHE WAS ABLE TO PUT THE CAR IN PARK AND TURN THE CAR OFF. BOTH CARS AND THE HOUSE NOW NEED MAJOR REPAIRS. MY DAUGHTER WAS SITTING IN THE BACK AT THE TIME OF THE INCIDENT. *TR

I'M CONTACTING YOU ABOUT AN ISSUE RECENTLY ENCOUNTERED ON MY 2009 HIGHLANDER. THE OIL HOSE ATTACHMENT LOCATED AT THE BOTTOM OF THE CAR HAD PIN SIZE HOLE THAT PUSHED ALL THE OIL OUT OF MY CAR. THE OIL HOSE IS IN A LOCATION THAT WOULD NOT BE EXPOSED TO ANY ELEMENT. I TRULY FEEL THAT THIS IS A MANUFACTURE DEFECT BUT CAN'T FIND RECALL INFORMATION ON THE SITE. I HAD THE CAR TOWED TO THE DEALERSHIP THAT SAID THIS PART WILL TAKE UP TO 3 WEEKS TO RECEIVE. THEY ALSO HAD A FEW OTHER TOYOTA CARS IN REPAIR FOR THE SAME ISSUE. THIS IS ALARMING SINCE IT LOOKS LIKE A KNOWN ISSUE AND THE HOSE LOCATION IS NOT EXPOSED. THE DEALERSHIP ALSO TOLD ME ONCE REPAIRED THEY DON''T KNOW THE EXTENT OF THE DAMAGE SINCE THE OIL WAS DRAINED OUT AT FAST PACE. PLEASE LOOK INTO THIS ISSUE AND HELP PROTECT OTHERS THAT MIGHT NOT BE AWARE OF THIS DEFECT. *TR

TL* THE CONTACT OWNS A 2009 TOYOTA HIGHLANDER. THE CONTACT STATED THAT WHILE DRIVING 20 MPH, THE VEHICLE BEGAN TO ACCELERATE INDEPENDENTLY. THE CONTACT APPLIED AN IMMENSE AMOUNT OF PRESSURE TO THE PEDAL BUT THE VEHICLE DID NOT STOP. AFTER SOME TIME, THE CONTACT WAS ABLE TO STOP THE VEHICLE. THE VEHICLE WAS TAKEN TO A DEALER WHERE THE CONTACT WAS AWAITING DIAGNOSIS OF THE FAILURE. THE FAILURE AND CURRENT MILEAGE WAS 46,132.

I PURCHASED A 2009 TOYOTA HIGHLANDER IN OCTOBER 29, 2013. EVERYTHING WAS FINE,THEN STARTED HAVING PROBLEMS WITH WINDOW ON THE DRIVER'S SIDE, IT KEPT GOING OFF LINE, SO I ROLLED UP THE WINDOW AND DIDN'T USE IT UNTIL I WAS ABLE TO GO FOR SERVICE. I TOOK IT IN TO BE SERVICE IN APRIL /MAY 2013 FOR A OIL CHANGE AND ETC. I TOLD THE GUY IN THE SERVICE DEPARTMENT WHAT WAS WRONG AND HE SAID HE WOULD CHECK IT FOR ME. AFTER SERVICING THE SUV, HE TOLD ME IT WOULD COST $ 400.00 PLUS DOLLARS TO FIX. I HAD THE CAR LESS THAN 6MONTHS. HE TOLD ME THERE WAS A PIECE THAT WAS BROKEN DUE TO RESTING THE ARM ON THE GLASS AND HE HAD TO REPLACE THE PIECE AND THE GLASS. IT'S FINE ONE MINUTE AND THEN THE NEXT IT'S OFF THE TRACT. SO I TOLD THE SERVICE GUY TO UNPLUG IT. I 'M NOT TALL ENOUGH TO REST MY ARM ON THE GLASS TO BREAK ANYTHING. I'M THE ONLY ONE THAT DRIVES THIS CAR. I TRULY BELIEVE THIS PART/PIECE WAS ALREADY BROKEN WHEN I PURCHASE THIS VEHICLE, BUT I CAN'T PROVE IT. I DON'T HAVE $ 400. 00 DOLLARS IN MY BUDGET PLUS MONTHLY BILL. HELP! *TR

THE VEHICLE IS A 2009 TOYOTA HIGHLANDER. THE POWER ARM BROKE OFF OF THE REAR POWER LIFTGATE WHEN CLOSING. THE DRIVER SIDE HINGE ON THE REAR POWER LIFTGATE BOWED AND WOULD NOT ALLOW US TO CLOSE THE DOOR. THIS HATCHBACK/LIFTGATE SUPPORT DEVICE ISSUE OCCURRED MARCH 2013. WE FILED A FORMAL COMPLAINT TO TOYOTA WHO WOULD NOT ACCEPT RESPONSIBILITY BUT WITH JUST A GOOGLE SEARCH YOU WILL FIND HUNDREDS OF PEOPLE WITH THE SAME COMPLAINT. THE SAFETY ISSUE HERE IS THAT DOOR CAN CLOSE ON A SMALL CHILD AND NOT BE ABLE TO RELEASE BECAUSE THE PART THAT BECOMES BOWED MAKES IT STICK IN POSITION. *TR

T-SB-0201-11 FROM TOYOTA STATES "SOME VEHICLES EQUIPPED WITH 2GR-FE/FXE TOWING PACKAGE ENGINES MAY EXHIBIT AN OIL SEEP FROM THE ENGINE OIL COOLER PIPES." THIS TSB AFFECTS TOYOTA AND LEXUS VEHICLES GOING BACK TO AT LEAST 2008-PRESENT. THIS IS A MAJOR ISSUE, AND I FEEL THIS SHOULD BE HANDLED AS A RECALL INSTEAD OF A TSB DUE TO THE SEVERITY OF THE ISSUE IF/WHEN THE PIPE BREAKS. I RECENTLY ELECTED TO HAVE MY VEHICLE REPAIRED ON MY OWN JUST SO I WOULDN'T HAVE TO WORRY ABOUT THIS ISSUE HAPPENING TO ME OR MY WIFE, AND THUS BLOWING UP MY HIGHLANDER'S ENGINE CAUSING THOUSANDS OF DOLLARS IN DAMAGES. SEEMS PRETTY BAD THAT A RECALL CAN BE ISSUED FOR FLOOR MATS AND ACCELERATOR ISSUES, BUT NO RECALL IS ISSUED FOR THIS ISSUE WHICH CAN DRAIN THE OIL FROM YOUR ENGINE IN A MINUTE, BLOW UP YOUR ENGINE, AND THEN POSSIBLY WRECK YOUR VEHICLE. CONSUMER'S ENGINES ARE NOW BEING DESTROYED, AND THIS IS SHOWING UP IN DIFFERENT ONLINE FORUMS. I FEEL THAT THE NHTSA NEEDS TO FORCE TOYOTA TO REPLACE ALL OF THE DEFECTIVE ENGINE OIL COOLER PIPES WITH THE NEWER METAL ONES THAT THE TSB ADDRESSES. THEY SHOULD ALSO BE FORCED TO REIMBURSE ALL COSTS TO THOSE INDIVIDUALS THAT EITHER NEEDED TO HAVE THE REPAIR DONE, OR DECIDED TO PREVENTATIVELY HAVE THE REPAIR DONE ON THEIR OWN BEFORE THOSE PIPES BURST ON THEIR OWN. *TR

TOYOTA HAS ISSUED A T-SB-0201-11 WHICH STATES "SOME VEHICLES EQUIPPED WITH 2GR-FE/FXE TOWING PACKAGE ENGINES MAY EXHIBIT AN OIL SEEP FROM THE ENGINE OIL COOLER PIPES." THIS AFFECTS TOYOTA AND LEXUS VEHICLES GOING BACK TO AT LEAST 2008-PRESENT. THIS SHOULD HAVE BEEN HANDLED AS A RECALL VS. A T-SB WITH A DEFINED EXPIRATION DATE BECAUSE CONSUMERS ENGINES ARE BEING DESTROYED WHEN THIS 'SEEP' OCCURS. THIS HAPPENS WITH A MINUTE AND ALL OF THE ENGINE OIL IS LEFT ON THE ROAD AND THE ENGINE IS DESTROYED. IMAGINE A FAMILY WHO'S DRIVING ALONG THE HIGHWAY, THEIR ENGINE STOPS WORKING AND AN 18-WHEELER REAR ENDS THEM. THAT IS WHY THE NHTSA NEEDS TO FORCE TOYOTA TO REPLACE ALL OF THE DEFECTIVE ENGINE OIL COOLER PIPES WITH THE METAL ONES THAT THE T-SB ADDRESSEE. *TR

TL* THE CONTACT OWNS A 2009 TOYOTA HIGHLANDER. THE CONTACT STATED THAT THE DRIVER'S SIDE SEAT BELT WOULD NOT RETRACT AND BECAME JAMMED. THE VEHICLE WAS TAKEN TO THE DEALER WHERE THEY ADVISED THE CONTACT THAT THE RETRACTION MECHANISM NEEDED TO BE REPLACED. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS CONTACTED AND OFFERED NO ASSISTANCE. THE FAILURE MILEAGE WAS APPROXIMATELY 68,520. THE CURRENT MILEAGE WAS APPROXIMATELY 68,674. THE VIN WAS UNAVAILABLE. *TR

WHILE DRIVING VEHICLE, A SNAP WAS HEARD FROM THE REAR. UPON INSPECTION, THE REAR PASSENGER SWAY BAR LINK (JOINING THE SWAY BAR TO THE STRUT) WAS SNAPPED AT THE LOWER END. THIS LINK IS APPROXIMATELY 10 MM IN DIAMETER, NECKING DOWN TO 8 MM WITH A 1 MM RADIUS AT TRANSITION OF THE DIAMETERS. IT WAS OBSERVED THE FAILURE WAS NOT COMPLETELY IMMEDIATE AS APPROXIMATELY HALF THE DIAMETER WAS RUSTED. THE RUST HAD TWO DISTINCT ZONES; AN APPROXIMATE 3 MM LIGHTER YELLOW-BROWN REGION AT THE OUTER SIDE, AND A 1 MM DARK BROWN ZONE ON THE INNER SIDE SUGGESTING THE OUTER HAD BEEN FAILING FOR SOME TIME, THE INNER PROPAGATING MORE RECENTLY. FINAL FAILURE OF THE REMAINING PORTION WAS SUDDEN. UPON INSPECTION UNDER MAGNIFICATION, THE FAILURE BEGAN WITH SOME TYPE OF CRACK INITIATING AT THE ROOT OF THE FILLET, PROPAGATING DOWNWARDS AT AN APPROXIMATE 30 DEGREE ANGLE. BENDING OF THE 8 MM SECTION APPEARS TO HAVE BEEN CAUSED BY THE SUDDEN FINAL FAILURE OF THE SECTION. NO OTHER DAMAGE UNDER THE VEHICLE WAS FOUND RULING OUT THE FAILURE WAS NOT CAUSED BY ANY DRIVER. TOYOTA CORPORATE IN CALIFORNIA WAS CONTACTED (CASE # 1301222906) BUT THEY CLAIMED NO RECALL ON THIS PART OR ISSUES. THE PART APPEARS TO HAVE INSUFFICIENT FATIGUE STRENGTH OR THIS SPECIFIC LINK HAD A QUALITY ISSUE. THE PART IS IN MY POSSESSION AND AVAILABLE UPON REQUEST SHOULD FURTHER INVESTIGATION VIA SEM/EDX, OR OTHER IS HELPFUL. I ALSO CAN PROVIDE PICTURES UPON REQUEST. THIS FAILURE CONCERNS ME AS THE PART LINKS REAR SUSPENSION CONTROL AND IT FAILED SHORTLY PAST WARRANTY. *TR

THE POWER ARM BROKE OFF OF THE REAR POWER LIFT GATE WHEN CLOSING. THE DRIVER SIDE HINGE ON THE REAR POWER LIFTGATE IS BOWED. *TR

THE VEHICLE SUDDENLY LOST POWER ON THE HIGHWAY. THE CAR WAS STILL RUNNING, BUT THERE WAS NO POWER TO THE WHEELS. THE FRONT DIFFERENTIAL HAD FAILED DUE TO A LEAK IN THE FRONT OF THE TRANSFER CASE. THIS FAILURE CAUSED THE TRANSMISSION TO FAIL AS WELL. *TR

I WAS TRAVELING 50 -60 MILES PER HOUR ON THE NEW JERSEY GARDEN STATE PARKWAY. WHILE DRIVING ALL OF A SUDDEN A HUGE VIBRATION OCCURRED THROUGH OUT THE VEHICLE. WHILE IT VIBRATED A LOUD NOISE OCCURRED. IT WAS SO LOUD MY DOG BEGAN TO BARK AND MY EARS COULD NOT TAKE THE NOISE OF THE VEHICLE. I TRIED TO BRAKE AND THE NOISE CONTINUED AS WELL AS THE VIBRATION. I CONTINUED TO TRY AND GET IN THE RIGHT LANE HOWEVER THE NOISE AND VIBRATION CONTINUED. THE VIBRATION FELT LIKE WHEN YOU GO ACROSS SPEED BUMPS THAT GIVES A RUMBLE SOUND. THE ROAD WAS SMOOTH AND THERE WERE NO SPEED BUMPS HOWEVER IT FELT AS IF I WAS GOING OVER SPEED BUMPS. ON 10/25/12 I TOOK THE VEHICLE TO TOYOTA OF HACKENSACK NJ WHERE THE VEHICLE WAS PURCHASED ON. I INFORMED THE SERVICE GUY ABOUT THE SITUATION. THEY DID A MULTI-POINT INSPECTION AND NOTHING CAME UP. THEY TEST DROVE THE VEHICLE IN CITY LIMITS AND NOTHING CAME UP. I THEN INFORMED THEM THAT THE VIBRATION DOES NOT OCCUR UNTIL YOU ARE ON THE HIGHWAY. THE TECHNICIAN THEN TEST DROVE WITH ME IN THE VEHICLE. THE VIBRATION DID NOT OCCUR. THIS SPECIFIC VIBRATION AND NOISE HAS ONLY OCCURRED TWICE SINCE I PURCHASED THE VEHICLE. I PURCHASED THE VEHICLE OVER A MONTH AGO DUE TO A FAULTY 2005 KIA SORENTO CRANKSHAFT BOLT DESIGN. IF IT HAPPENS AGAIN I WILL FILE ANOTHER COMPLAINT. *TR

2009 TOYOTA HIGHLANDER LIMITED DOOR ACTUATORS HAVE ALL BROKE, BEEN REPLACED AND BROKE AGAIN. SOME ARE BEING REPLACED FOR THE 3RD TIME SINCE I OWED THE VEHICLE (MAKING IT THE 4TH LOCK ON THE CAR). AT THE MOMENT ONLY 1 DOOR LOCK WORKS AND I HAVE TO CLIMB ACROSS TO OPEN THE OTHER DOORS. I AM EXTREMELY CONCERNED THAT THEY WILL ALL BREAK AND I WILL NOT BE ABLE TO GET MY DAUGHTER OUT OF THE CAR. I STARTED CONTACTING TOYOTA IN 2013 WHEN THEY ALL STARTED BREAKING. I ALSO CAN NOT OPEN THE CAR WITH THE KEY. 8/2012- DRIVERS LOCK AND ACTUATOR REPLACED AND WINDOW 6/2013- RIGHT REAR DOOR ACTUATOR REPLACED 7/2013- PASSENGER DOOR ACTUATOR REPLACED 3/2014- LEFT REAR DOOR ACTUATOR REPLACED 4/2014- DRIVERS LOCK ACTUATOR REPLACED (AGAIN) 5/2014- RIGHT REAR DOOR ACTUATOR REPLACED (AGAIN) 2015- LEFT REAR ACTUATOR BROKE AGAIN THIS TIME MY EXTENDED WARRANTY IS UP AND THEY WANT 600 TO FIX. 2016- PASSENGER ACTUATOR BROKE 9/2018- DRIVERS ACTUATOR BROKE FOR THE 3RD TIME. I AM LEFT WITH LEAVING THE CAR UNLOCKED AND HOPING NO ONE GOES IN OR CLIMB ACROSS MY VEHICLE. I HAVE CONTACTED TOYOTA NUMEROUS TIMES TO TRY AND GET THEM TO HELP AND THEY HAVENT DONE ANYTHING BUT TELL ME I'M NOW OUT WARRANTY EVEN THOUGH I CONTACTED THEM REGARDING THE ISSUES BEFORE MY EXTENDED WARRANTY WAS UP.

OUR CAR HAS 17,000. MILES AND TURNS OUT THE TIRES ARE BARE IN SPOTS AND THE CAR HYDROPLANED AND SKIDDED AND WOULD NOT HOLD THE ROAD IN A LIGHT SNOWSTORM. WE OFTEN SKIDDED RIGHT INTO ONCOMING TRAFFIC. WE HAVE DRIVEN MANY SUVS OVER THE YEARS -WE ARE 69- AND NEVER HAD A PROBLEM. TOYOTA EMAILED TO US THAT THE TOYO A20 P245/55R19 OPEN COUNTRY TIRES THE CAR CAME WITH ARE NOT MEANT FOR DRIVING IN SNOW. WE LIVE IN VT AND THE CAR WAS SOLD TO US AS AN ALL WHEEL DRIVE CAR FOR DRIVING IN SNOW. I HAVE LOOKED AT THE INTERNET AND OTHERS HAVE HAD THE SAME PROBLEM WITH THESE TIRES. I FEEL THERE SHOULD BE A RECALL ON THEM BEFORE SOMEONE IS KILLED. MY SON JUST PURCHASE A NEW HIGHLANDER AND I WORRY HIS TIRES ARE THE SAME. *TR

WITHOUT PREJUDICE MY VEHICLE WAS REAR -ENDED BY ANOTHER VEHICLE AT SPEED OF APPROXIMATELY 75, AND GOT CRASHED ON TO THE CAR IN FRONT AT SPEED OF 40 TO 50. AIR BAGS FAILED TO DEPLOY AND DASH BOARD INDICATOR LIGHT CAME ON AND IT DOES NOT GO OFF. I STRONGLY BELIEVE THIS IS A MANUFACTURER DEFECT. THIS SUV CONSISTS WITH SIX AIR BAGS. NON OF THEM RESPONDED. I PURCHASE WITH CONFIDENCE THAT AIR BAGS ARE IN WORKING ORDER. MANUFACTURER RISK OUR LIFE FOR NEARLY TWO YEARS. I DESERVE COMPENSATION FOR RISKING 6 LIVES. *TR

REAR DOOR/HATCH ELECTRIC MOTOR AND LATCH/LOCK ASSEMBLY FAILED. SEVERAL INCIDENCES OF THE REAR ELECTRIC HATCH FAILING TO SEAT/CLOSE OCCURRED PRIOR TO THE FAILURE. THE DOOR WOULD START DOWN BUT WOULD NOT CLOSE/LATCH. TOYOTA SERVICE DEPARTMENT (DOTHAN, AL) SAID THE DOOR NEEDED TO BE ADJUSTED AND DID SO. ABOUT ONE MONTH LATER THE DOOR CLOSED WITH A LOUD NOISE AND WOULD NOT OPEN AFTERWARDS. UPON OUTSIDE INSPECTION, I SAW THE DOOR WAS OFFSET ABOUT A QUARTER OF AN INCH TOWARD THE PASSENGER SIDE AND SEATED ABOUT THE SAME (1/4 INCH) FURTHER IN THAN NORMAL. THE DOOR WOULD NOT OPEN AT ALL AT THAT POINT. THE SAME SERVICE DEPARTMENT INITIALLY ACCUSED ME OF DAMAGING THE CAR IN AN ACCIDENT (UNTRUE). THEY PRIED THE DOOR OPEN, AND RECOMMENDED I DISABLE THE ELECTRIC DOOR MOTOR AND ONLY OPERATE THE DOOR MANUALLY. LATER THE SAME SERVICE PERSONNEL ADMITTED THERE WAS A DESIGN PROBLEM WITH THE DOOR HINGES THAT CAUSED THE FAILURE. *JB

2009 TOYOTA HIGHLANDER CLEARANCE BETWEEN BOTH REAR "SHOCK BASE PLATE" AND BOTH REAR TIRES ARE TOO CLOSE. EVERY TIME WHEN YOU HIT A "BUMP", BOTH REAR TIRES ARE HITTING THE "REAR SHOCK BASE PLATE". THIS WILL DAMAGE BOTH REAR TIRES AND CAUSE ACCIDENT !! DEFECTIVE ENGINEERING DESIGN !! TOYOTA SHOULD RECALL ALL HIGHLANDERS WITH THIS DEFECTIVE DESIGN !!! YOU DON'T WANT TO WAIT FOR AN ACCIDENT TO HAPPEN THEN MAKE A MANDATORY RECALL. THANKS FOR READING MY MESSAGE AND CONCERN OF SAFETY FOR ALL HIGHLANDER OWNERS. *TR

THE WATER PUMP WENT ON MY TOYOTA HIGHLAND. I LOOKED IT UP ONLINE AND FOUND OUT THE WATER PUMPS ARE FAULTY AND WILL MAKE A SOUND LIKE THERE IS GRAVEL IN THE MOTOR. I HAD TOYOTA FIX THE PROBLEM UNDER WARRANTY, BUT I LOOKED ONLINE AND FOUND THAT OTHER PEOPLE HAVE THE SAME PROBLEM. SHOULD BE LOOKED INTO DUE TO BEING BAD PUMPS.