2018 Toyota RAV4 Electrical System Problems

See attached document for complaint.

The contact owned a 2018 Toyota Rav4. The contact received notification of NHTSA Campaign Number: 23V734000 (Electrical System); and requested to be removed from the recall distribution list because she no longer owns the vehicle. The dealer and the manufacturer were not contacted.

The contact owns a 2018 Toyota Rav4. The contact received notice of NHTSA Campaign Number: 23V734000 (Electrical System). The contact stated that while changing the oil, he became aware that the battery was covered in corrosion and there was acid leaking from the battery tray. The vehicle was not diagnosed, but the contact was advised that the tray needed to be replaced. The vehicle was not repaired. The manufacturer was notified of the failure but refused to replace the battery. The failure mileage was approximately 66,327.

On October 27, 2025, I was housesitting and watching a friends' son and dropped him off at school. I returned to their house, shut off the car, went into the house, started cleaning home in preparation of returning to my home. I was in downstairs master suite on opposite end of home when I heard a car horn. I went to the door, looked out and saw fire emitting from under the driver’s side wheel well, front of engine, from under the engine hood and half way up the windshield of the RAV4. I called [XXX] and informed the dispatcher that my car was on fire. The [XXX] fire department responded and extinguished the vehicle. I called my insurance company and also reported the incident to Toyota BEC, they assigned the incident Liability Case# XXX. I had also received 2 recall notifications from Toyota (NHTSA# 23V734). The car had been serviced by Grappone Toyota (now known as McGovern Toytota) in [XXX] on August 14, 2025 and the recall was documented as fixed on that date. The vehicle was a total loss and towed to a Coparts Salvage Yard in Candia NH. An inspection was performed by an inspector assigned by Toyota. I later received a letter from Toyota stating that the cause of the fire could not be determined and Toyota assumes no reponsibility whatsoever. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

The contact owns a 2018 Toyota Rav4. The contact received notification of NHTSA Campaign Number: 23V734000 (ELECTRICAL SYSTEM). The dealer was contacted; however, the contact was informed that parts were unavailable to repair the vehicle. The vehicle was not repaired. The manufacturer was contacted about parts availability. The contact stated that while attempting to start the vehicle, the vehicle failed to start due to a severed wiring harness. There was no warning light illuminated. The vehicle was not repaired. The approximate failure mileage was 64,000.

My vehicle has a recall for the battery. I took my car into Toyota in San Juan Capistrano. Car was purchased and owner’s manual states this vehicle uses a size 35 battery. When I returned to pick up my vehicle the service technician told me that “Toyota will only honor the recall on vehicles with a size 36 battery, and in order for them to rectify the recall was for me to purchase a size 36 battery. There is no mention of that on our recall notice nor is there anything stating that on the NTSA website. What can i do to get this fix this issue. I believe this problem is also the reason we have had to replace our battery 3 times since 2021and also the cause of other malfunctions in our vehicle

The contact owns a 2018 Toyota RAV4. The contact received notification of NHTSA Campaign Number: 23V734000(Electrical System) however, the part to do the recall repair was not yet available. An unknown local dealer was contacted. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was made aware of the issue. The contact had not experienced a failure. Parts distribution disconnect.

The contact owns a 2018 Toyota Rav4. The contact stated that while parked at the residence, the contact turned off the vehicle and noticed that the vehicle lost power. No warning light was illuminated. The vehicle was repaired under NHTSA Campaign Number: 23V734000 (ELECTRICAL SYSTEM); however, the recall repair failed to fix the vehicle. The contact stated that the failure had occurred after the recall repair. The manufacturer was not notified of the failure. The failure mileage was 7,000.

The contact owns a 2018 Toyota Rav4. The contact received notification of NHTSA Campaign Number: 23V734000 (Electrical System); however, the dealer refused to perform the recall repair. The contact was informed that the correct size battery needed to be purchased to replace the current battery before the recall repair could be performed. The manufacturer was made aware of the issue and confirmed that battery was not the correct size, and a new battery was needed. The manufacturer declined to assist with the cost of replacing the battery. The contact had not experienced a failure. Parts distribution disconnect.

After receiving a recall notice from Toyota for the battery mount I scheduled my appointment on June 24, 2025. After spending $916.31 on maintenance products all of a sudden the dealership did not have the battery mount for my vehicle. Is this legal? Why would a dealership schedule a repair and not have the product to complete the recall? I was informed that I would be called when they had the part available and I still have not heard from the Toyota dealership. Are three months later considered a timely matter to correct the problem?

The contact owns a 2018 Toyota Rav4. The contact received notification of NHTSA Campaign Number: 23V734000 (Electrical System); however, the part to do the recall repair was not yet available. The local dealer was contacted. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was made aware of the issue. The contact had not experienced a failure. Parts distribution disconnect.

The recall (Manufacturer Recall # 23TB13; NHTSA Recall # 23V734) has been un-repaired since 1 Nov 2023. The un-repaired recall did not cause a safety issue in this case, but I have moved to Canada and the recall has prevented me from registering and using the vehicle (it is not possible to complete the import process or register any vehicle that has an outstanding recall).

The recall (NHTSA Recall # 23V734) has been un-repaired since 1 Nov 2023. The un-repaired recall did not cause a safety issue in my case, but I have moved to Canada and the recall has prevented me from registering and using the vehicle for the last for the past year (it is not possible to complete the import process or register any vehicle that has an outstanding recall).

The vehicle's battery area caught fire. I was able to get out of the vehicle on time and call the fire department. Over 50% of the vehicle was consumed by the fire. Vehicle was my spouse's and she usually drives it alone with my [XXX] and she is [XXX]. Thankfully, I was driving it alone. NHTSA recall 23V734 came out on 11/2023 and they expected to have the fix by the end of 2024 but it never happened. The last vehicle maintenance by the dealer was in 02/15/2025. The vehicle has not been inspected yet but the insurance will make an appointment soon to do so. The preliminary findings of the fire department pinpointed the problem in the battery area. Prior to the fire, the vehicle shut down and the steering wheel locked. I turned it on and drove it out of the road and it did it again and when I came out of the vehicle, I saw smoke coming out of the hood and that's when I saw the fire. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

The contact owns a 2018 Toyota Rav4. The contact received notification of NHTSA Campaign Number: 23V734000 (Electrical System); however, the part to do the recall repair was unavailable. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was made aware of the issue. The contact had not experienced a failure. VIN tool confirms parts not available.

The contact owns a 2018 Toyota Rav4. The contact received notification of NHTSA Campaign Number: 23V734000 (Electrical System); however, the part to do the recall repair was not yet available. The local dealer was contacted. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was made aware of the issue. The contact had not experienced a failure. VIN tool confirms parts not available.

I took a video: for at least the 6th time since owning this vehicle a multi alert shows up on dash. “Brake Power Low, Visit your dealer”, “Antilock Brake System Malfunction, visit your dealer”, “Lame departure alert, visit your dealer”, “Pre-collision system malfunction, visit your dealer”, “AWD system malfunction, 2WD mode engaged, visit your dealer”, I have 2 other Rav 4s both of which have also shown this issue. A 2016 & a 2017. The 2017 this happened twice I believe. The 2016 at least twice. It’s currently on now in my 2018. Been on 2 days, but was off previous 2 days, but on 1 day before that.

See attached document for complaint.

The contact owned a 2018 Toyota Rav4. The contact stated while driving into a parking lot at a very low speed when the vehicles engine shut off, the contact proceeded to attempt to restart the vehicle however the engine would not start, and upon inspecting underneath the hood of the vehicle the contact noticed that a flame had began to arise from the battery. The contact immediately proceeded to extinguish the fire with a towel. The vehicle was unoccupied as soon as the fire was noticed. A fire department report was not filed. A police department report was not filed. The vehicle was not destroyed. The vehicle was towed to a local dealer, where the vehicle was diagnosed however, the contact was advised that further diagnosis was required in order to determine the cause for failure. The vehicle was not repaired. The contact referenced NHTSA Campaign Number: 23V734000 (ELECTRICAL SYSTEM) as pthe robable cause for the failure experienced. The approximate failure mileage was 78,000.

The contact owns a 2018 Toyota Rav4. The contact received notification of NHTSA Campaign Number: 23V734000 (ELECTRICAL SYSTEM); however, the part to do the recall repair was unavailable. The local dealer was contacted, and it was confirmed that the part was not yet available. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was made aware of the issue. The contact had not experienced a failure. VIN tool confirms parts not available.