2022 Toyota RAV4 Electrical System Problems

When I put my car on park. The driver side (left door) lock actuator makes a long click noise. Also when I press on unlock it makes that sound as well

The driver side door lock actuator makes a long click noise. Also when I unlock my car it makes the same sound

My infotainment screen went black while I was driving at night and it will not come back on. There was no warning. I took it to the dealer and they said that the system had failed. I saw on line that there was a recall for this very issue but my car is a '22 and not included in the recall, but I think it should be. This poses a safety hazard and I don't believe that this should happen under normal circumstances for a car of its age and relatively low mileage. I think this model year should be included in the recall and that Toyota should pay for the repair, which is quite expensive. The receipt on the diagnostic says the radio works, but it does not. It goes on when you push the power and immediately goes off.

I was driving home in the rain for about 75 minutes and when I arrived in my driveway I saw steam coming from the front grille area. It wasn't due to a high engine coolant temperature so I decided to carefully open the hood and check for the source. I saw water inside the bottom of the engine bay behind the radiator steaming from the heat of the engine. A few seconds later, the engine stalled and the following message appeared: "Engine Stopped, Steering Power Low" which came on with a check engine light, red battery light, and steering light. I used my scan tool and obtained the code: P0171, System Too Lean. After doing research, I've come up with a conclusion to the potential cause. Starting with the 2022 model year RAV4 non-hybrid (and onwards to the 2025 model year RAV4), the air intake inlet was redesigned from the prior one in the 2019-2021 RAV4 non-hybrid models, as seen in numerous comparison images online. This new design presents a dangerous fault. When driving in rainy conditions, especially at higher speeds with mist kicked up from cars in front, the air intake will take in water. The water will flow to the air filter and then reach the Mass Air Flow sensor (MAF). The MAF sensor monitors the amount of air entering the engine and sends signals to the car's computer to help determine how much fuel to send to the engine to maintain an ideal ratio for optimal efficiency. Considering that water is getting to the MAF sensor, it thinks that the water is excess air, so less fuel is sent to the engine as a result. Since I came to a stop in my driveway, the engine is now at its idle speed and only commands a small amount of fuel to remain running. Now, when combined with the water, that lower fuel flow is practically cut off, leading to the stall. This happened to me before when driving in the rain, but in more dangerous conditions in stop-and-go traffic. Toyota must follow up on T-TT-0763-24 because it has been well over a year since their initial investigation.

The contact is an attorney concerned about a crash involving a 2022 Toyota Rav4. The attorney stated that the vehicle had a comma.ai device installed on the vehicle. The attorney stated that while 2 couples were occupying the vehicle and driving at night on an expressway, there was a police vehicle on the side of the road responding to a separate vehicle crash. The driver of the vehicle may have been asleep, along with the front passenger, while relying on the comma.ai device to operate the vehicle. The vehicle failed to engage the brakes in order to avoid crashing into the police vehicle, and as a result, the Toyota Rav4 crashed into the rear of the police vehicle. The vehicle speed was unknown at the time of the crash. The owner of the vehicle rear-ended a Louisiana state trooper. Air bags deployed in the front and on both sides of the vehicle. The vehicle was towed to a tow yard and then to a Progressive Insurance lot. No warning lights were noticed. All occupants were wearing seat belts. The driver of the vehicle sustained concussion injuries, and the front passenger occupant sustained arm and leg injuries. The two rear occupants succumbed to their injuries at the hospital. No other injuries were reported as the police officer was not occupying the vehicle during the impact. The comma.ai device failed to avoid the f vehicle in front. The manufacturer was not notified of the failure. The failure mileage was unknown.

I attempted to remote start my 2022 Toyota RAV4 Hybrid from inside my home using the Toyota mobile app. I received a confirmation notification stating that the vehicle had started and would automatically shut off in 10 minutes. Approximately six minutes later, I exited my home and approached the vehicle, which was not running. After unlocking and entering the vehicle, the interior temperature confirmed that the vehicle had not been running. I attempted to start the vehicle by pressing the brake pedal and pushing the start button. No dashboard lights illuminated, no warning messages appeared, and the vehicle was completely unresponsive. I attempted this process two additional times with the same result. After exiting the vehicle and closing the driver’s door, I attempted to lock the vehicle using the touch sensor on the driver-side door handle. The vehicle would not lock. I attempted this a second time and it still would not lock, indicating a complete loss of electrical power. This failure occurred in cold weather conditions and involved the hybrid battery and associated electrical system. The loss of power created a safety risk because the vehicle could not be secured and could have left me stranded in cold weather. Later that day, I contacted my insurance company for roadside assistance. A tow truck arrived and jump-started the vehicle using a portable jump box, which allowed the vehicle to start and the battery to recharge. A Toyota service appointment is scheduled to inspect the vehicle. The issue has not yet been confirmed by a dealer. The vehicle has not been inspected by the manufacturer or other representatives. Only the roadside assistance tow truck driver responded. The vehicle and battery are available for inspection upon request.

Short in the steering wheel heater mat leads to localized hot spot of greater than or equal to 134° F. Risk of burn injury to customer and risk of electrical fire.

After driving for 35 minutes (in the rain), I pulled up to work and let someone out. While car was sitting there in park, it bucked in the back, I then put it into park and almost immediately, it shut off with this on the display "Engine Off, Steering Power Low, Do Not Drive". My lights and windshield wipers remained on. I tried to turn it back and and it shut off again. I waited a few minutes, turned it on and went to pull out onto main road and the car shut off again with the same message. Thankfully I was turning onto the main road so close to shoulder and able to keep my car pretty close to side of the road. I called the Toyota dealer who told me not to drive it and it would need to be towed. I towed it to the closest dealer and when they checked the codes (the next day), they said there were no codes and they could not replicate the problem. As a note, the rain was off and on, nothing that was worse than anything I have driven in previously. I drive main roads and did not go through any large puddles or anything similar. This is a major safety issue and I am terrified that it could happen while driving on a highway where I may not have time to get out of the way of other traffic (car literally stopped with no option of continuing to coast). I am also shocked that there were NO codes triggered as there was obviously some event and that the car is only one month outside of warranty.

The infotainment screen and its buttons do not work. All I see when parked or driving is an unresponsive black screen. There was no warning prior to the screen not functioning.

When wet, during rain or after a car wash. The engine will rev, the car will shake, and then shut off. I believe it’s the alternator.

While driving in stop-and-go traffic on a major highway, the auto braking system engaged and the brake would not release. The car came to an abrupt halt and the brake would not release, the gas pedal would not depress. I had to turn the car off, place the car in park and restart the car, the car then continued driving. There was a message on the dash about EPB.

The Multimedia dashboard is completely blank. Not able to use sound, gps, music, etc. Cant set time or any adjustments to vehicle. This seems to be a manufacturing issue. Dealer said there is nothing they can do about it. Was told will need to pay $1600 to replace it. Don't know how long a new won will last. Can't keep spending $1600 everytime the electrical system Malfunctions. Please help.

Vehichle has stranded me twice with multiple error messages when I try to start it. All kinds of lights go on and off on the dash and messages include: Parking Brake Unavailable, Voltage Abnormality Steering Power Low, Hybrid System Not Available, Braking Power Low-Stop in a Safe Place, Antilock Brake System Malfuntion, Rear Cross Traffic Alert Unavailable, Blindspot Monitoring Unavailable, Pre-Collision System Unavailable, Visit Dealer. It makes all kind of weird noises and vibrations in the break peddle also during this. I have been told this is a problem with low battary of the 12V but that battery is charged by the Hybrid battary and does nothing but run electronic features, does not start the vehichle. Have read this has happened to people while actually driving the vehichle, I am scared this will cause an accident. 2 year old vehicle.

I was driving on I-91 in stop-and-go traffic when, all of a sudden, my RAV4 stalled. A warning chime sounded and the battery light, check engine light, and power steering light all illuminated. In the 4.2 inch screen in the gauge cluster, the following message displayed: "Steering Power Low"..."Shift to P". A second message displayed and said: "Engine Stopped"..."Shift to P". I attempted to restart the vehicle up to 8 times and it finally restarted. I quickly drove the car to the shoulder and out of the way of traffic. There were three of us in the car (myself and my two kids) and we almost got hit two times because visibility was poor due to rainy conditions and mist from passing cars. Throughout all this, I had the Auto Start/Stop feature disabled, so the car should not have shut off on its own. We had to get the car towed because we were worried that the problem would reoccur. We hope the problem could be rectified by our local Toyota dealer, because we do not want to drive it again in fear of the problem reoccurring while on the roadway. We are reporting this to bring awareness to this issue, and to make sure nobody else will have to face this situation and potentially be put in harm's way. (The attached photo is a general picture from somebody else, but my car had the same EXACT warning lights and messages. We could not take a picture because we were focusing on trying to get the car to turn on and move it to the shoulder by any means possible).

The contact owns a 2022 Toyota Rav4. The contact stated while driving 50 MPH, the vehicle ESC became inoperable. The vehicle was taken to the dealer and the ESC system was updated but the failure reoccurred. The manufacturer was contacted, and a case was filed. The failure mileage was 4,800.

"The total fuel dispensed is less than expected when the fuel nozzle automatically clicks off when refueling. [Some customer reports] have also noted the "Distance to Empty" shown on the multi-information display is less than expected."