2004 Toyota Sienna Tires & Wheels Problems

I PURCHASED NEW TIRES ON MAY 22, 2018. IN JUNE 2019, I HAVE HAD TO REPLACE THREE OF THE FOUR GOODYEAR AQUA TREAD TIRES DUE TO CORD BREAKAGE AND PORCHES OCCURRING.

P225/60R17 98T: Tires create vibrations in the steering column. One tire in particular creates severe vibrations that mechanic states could lead to problems with the steering components. Mechanic http://www.japaneseautorepair.org/ e-mail john.japaneseautorepair@gmail.com (John). Coordinated w/ Sandy Boulevard Line up shop and one tire could not be aligned due to defect. 2004 Sienna van (140,900 odometer miles) is equipped with Toyo Observe GSi-5 195/65R15 91T (separate 16" rims purchased from Les Schwab) and there is no vibration at all. Les Schwab last tried to "balance" the defective tire in 2019. I have about the 4rth appointment Aug 21 2021 @ 9AM. I will also take the 2004 Sienna van to Japanese Auto repair (web site and e-mail above). to look for any defects. I probably need to put the Winter Observe GSi-5 tires on the car for safety, but they wear out quickly on summer hot roads.

I HAVE RECEIVED A NOTICE FROM TOYOTA ABOUT SPECIAL SERVICE CAMPAIGN FOR EXCESSIVE CORROSION OF THE SPARE TIRE CARRIER CABLE. SINCE THAT PART HAS ALREADY FAILED ON MY CAR I HAD IT REPLACED AND FOLLOWED TOYOTA PROCESS TO RECOVER COST OF THAT REPAIR. I HAVE PROVIDED REQUIRED DOCUMENTATION ( CERTIFIED MAIL) AND THEN AGAIN ADDITIONAL DOCUMENTATION (CERTIFIED MAIL) REQUESTED BY TOYOTA. I HAVE RECEIVED A LETTER THAT MY CASE HAS BEEN CLOSED BECAUSE TOYOTA DID NOT RECEIVE REQUIRED DOCUMENTATION. SINCE THEN I HAVE NOT RECEIVED ANY RESPONSES TO MY SUBSEQUENT LETTER OR COMPENSATION FOR THE REAIUR COST.

INSIDE OF SIDEWALL CRACKING, APPEARS DRY ROT POWDER RESIDUE FROM TIRE IN TRUNK AFTER REPLACING. PURCHASE AUGUST 22, 2013, SHOWN AS 90,000 MILE TIRE WHEN PURCHASED. FAILED 8-20-2016 DRIVEN APPROX. 40,489 MILES. LOOKS LIKE SIDING SEPARATED.. MULTIPLE HOLES AND SPLITS LOOKS SHREDDED. . NO APPEARANCE OF PROBLEMS ON OUTSIDE OF TIRE. CONSIDERED LUCKY TIRE FAILURE DID NOT CAUSE ACCIDENT HAVE PICTURES...

ON JUNE 17, 2016, I GOT INTO MY 2004 TOYOTA SIENNA XLE-IMS RAMPVAN (JOINT TOYOTA-IMS, FLOOR-LOWERED WHEELCHAIR VAN CONVERSION WITH RAMP). THERE WAS DEBRIS ON THE BACK SEAT (WHAT IN A NON-IMS SIENNA BE THE THIRD-ROW SEAT). I SAW TIRE BELTS STICKING UP FROM THE TREAD OF THE SPARE TIRE. THE TIRE HAD EXPLODED AND DEFLATED, STREWING DEBRIS FROM THE RUPTURED TIRE BELTS AND TREAD ON THE BACK SEAT. NOTE THAT IN THE IMS VERSION OF THE SIENNA, THE SPARE TIRE IS MOUNTED ON A BRACKET BEHIND THE BACK SEAT. THANKFULLY, NO ONE HAD BEEN IN THE VAN AT TIME OF EXPLOSION. THE RUPTURE OF THE TIRE COULD HAVE BEEN BEHIND THE HEAD OR NECK OF A PASSENGER SITTING IN THE LEFT-REAR POSITION. THE EXPLODED SPARE TIRE IS A FIRESTONE RADIAL TEMPA SPARE, T155/80R17 101M. IT IS THE ORIGINAL SPARE TIRE AND WAS INFLATED TO THE SPECIFIED 60 PSI. I STILL HAVE THE EXPLODED TIRE, WHICH I HAD DISMOUNTED AND REPLACED. I ALSO HAVE PHOTOS OF THE RUPTURED TIRED WHILE IT WAS STILL MOUNTED TO ITS BRACKET BEHIND THE BACK SEAT.

TL* THE CONTACT OWNS A 2004 TOYOTA SIENNA. THE CONTACT STATED THAT WHILE DRIVING AT 25 MPH, THE SPARE TIRE UN-LODGED FROM THE UNDERCARRIAGE OF THE VEHICLE AND ONTO THE ROAD. THE CONTACT RECEIVED NOTIFICATION OF NHTSA CAMPAIGN NUMBER: 14V273000 (TIRES) HOWEVER, THE PART TO DO THE REPAIR WAS UNAVAILABLE. THE CONTACT STATED THAT THE MANUFACTURER EXCEEDED A REASONABLE AMOUNT OF TIME FOR THE RECALL REPAIR. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE. THE FAILURE MILEAGE WAS 200,000.

TL* THE CONTACT OWNS A 2004 TOYOTA SIENNA. THE CONTACT STATED THAT NHTSA CAMPAIGN NUMBER: 14V273000 (TIRES) EXCEEDED A REASONABLE AMOUNT OF TIME FOR REPAIR. THE DEALER STATED THAT THE PARTS NEEDED WERE NOT AVAILABLE. THE MANUFACTURER WAS MADE AWARE OF THE DELAY. THE VEHICLE WAS NOT REPAIRED. THE CONTACT HAD NOT EXPERIENCED A FAILURE. MA 10/2 *CN

TL* THE CONTACT OWNS A 2004 TOYOTA SIENNA EQUIPPED WITH FIRESTONE TIRES, SIZE: 155/80/R17 (NA). THE CONTACT RECEIVED NOTIFICATION OF NHTSA CAMPAIGN NUMBER: 14V273000 (TIRES); HOWEVER, THE RECALL PART WAS NOT AVAILABLE. THE CONTACT STATED THAT THE MANUFACTURER EXCEEDED A REASONABLE AMOUNT OF TIME FOR THE RECALL REPAIR. THE MANUFACTURER WAS NOT NOTIFIED OF THE ISSUE. THE CONTACT HAD NOT EXPERIENCED A FAILURE.

WHAT GOOD IS HAVING AN AUTO RECALLED IF NOTHING IS DONE TO CORRECT THE PROBLEM? I AM REFERRING TO THE SPARE TIRE STORAGE CABLES THAT HAVE BEEN IN A RECALLED STATE SINCE 2010 AND HAS STILL NOT BEEN CORRECTED. I FEEL THAT BOTH THE TOYOTA MOTOR CAR COMPANY AND THE U.S. GOVERNMENT HAVE LET ME DOWN ONCE AGAIN. IS ANYTHING BEING DONE TO CORRECT THIS PROBLEM?

CAMPAIGN 14V273000 (SPARE TIRE CABLE CORROSION) WAS INITIATED IN MAY 2014. IT'S NOW A YEAR LATER AND THERE IS NO PERMANENT FIX, NOR HAS TOYOTA EVEN PROVIDED A DATE WHEN THERE WILL BE A PERMANENT FIX. THE INTERIM FIX I HAVE BEEN LIVING WITH FOR THE PAST YEAR WAS TO REMOVE THE SPARE TIRE FROM UNDER MY MINIVAN AND PUT IT IN THE PASSENGER COMPARTMENT. TOYOTA HAS GONE WAY TOO LONG WITHOUT PROVIDING A FIX. BUT WHAT TROUBLES ME TODAY IS THAT WHEN I LOOK UP MY VIN ([XXX]) IN TOYOTA'S DATABASE AND IN YOURS (SAFERCAR.GOV), THE RESPONSE IS NO OPEN RECALLS. HOW CAN THIS BE? "NO OPEN RECALLS," YET THE PROBLEM STILL EXISTS. I WONDER IF ANYONE IS WORKING ON IT. BTW, I'D BE HAPPY TO HAVE A NEW CABLE SAME AS THE ORIGINAL INSTALLED, BUT APPARENTLY THE DEALER ISN'T ALLOWED TO USE THE SAME PART AS ORIGINAL BECAUSE IT COULD CORRODE AGAIN, WHICH IN MY OPINION IS UNLIKELY BECAUSE AT THIS POINT IN MY MINIVAN'S LIFE, ANY CABLE WILL OUTLAST THE REST OF THE VEHICLE. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6). *TR

TL* THE CONTACT OWNS A 2004 TOYOTA SIENNA. THE CONTACT RECEIVED NOTIFICATION OF NHTSA CAMPAIGN NUMBER: 14V273000 (TIRES) HOWEVER, THE PART NEEDED TO DO THE REPAIR WAS UNAVAILABLE. THE CONTACT STATED THAT THE MANUFACTURER EXCEEDED A REASONABLE AMOUNT OF TIME FOR THE RECALL REPAIR. THE MANUFACTURER WAS MADE AWARE OF THE ISSUE. THE CONTACT HAD NOT EXPERIENCED A FAILURE. THE VIN WAS UNAVAILABLE.

TL*THE CONTACT OWNS A 2004 TOYOTA SIENNA. THE CONTACT STATED THAT THE VEHICLE WAS TAKEN TO A DEALER WHERE IT WAS SERVICED UNDER NHTSA CAMPAIGN NUMBER: 14V273000 (TIRES). THE CONTACT STATED THAT THE DEALER TOOK THE TIRE FROM UNDERNEATH THE VEHICLE AND PUT THE TIRE INSIDE THE VEHICLE. THE CONTACT STATED THAT THE PART WAS NOT AVAILABLE. THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 60,000.

TL* THE CONTACT OWNS A 2004 TOYOTA SIENNA. THE CONTACT RECEIVED NOTIFICATION OF NHTSA CAMPAIGN NUMBER: 14V273000 (TIRES); HOWEVER, THE PART NEEDED WAS NOT AVAILABLE FOR MONTHS AND THE DEALER REMOVED THE SPARE TIRE CARRIER AS A TEMPORARY ADJUSTMENT. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOTIFIED OF THE DELAY. THE MANUFACTURER WAS UNABLE TO DETERMINE WHEN THE PART WOULD BECOME AVAILABLE. THE CONTACT HAD NOT EXPERIENCED A FAILURE.

THE FOLLOWING IS AN EMAIL WE SENT TO TOYOTA. WE BELIEVE TOYOTA HAS FAILED TO REMEDY THE DEFECT WITHIN A REASONABLE TIME. REQUEST YOUR HELP TO RESOLVE THE ISSUE. THANK YOU, EMAIL: "12/12/14 WE HAD THE TEMPORARY REMEDY FOR THE 2004 SIENNA SPARE TIRE RECALL (#E1S) DONE AT YOUR DEALERSHIP OCTOBER 2, 2014. WE WERE TOLD THAT WE COULDN'T LEAVE THE DEALERSHIP WITH THE SPARE TIRE IN ITS CURRENT LOCATION UNDER THE CAR. SUBSEQUENTLY, THE SPARE TIRE CABLE WAS CUT AND THE SPARE TIRE PUT IN THE TRUNK. WE WERE TOLD THIS WAS A TEMPORARY REMEDY AND THAT TOYOTA WOULD HAVE A SOLUTION BY DECEMBER 2014. WE WANT TO KNOW WHEN THE PERMANENT SOLUTION WILL BE AVAILABLE. PLEASE KEEP US UPDATED AS TO THE STATUS OF THIS RECALL SO THE INCONVENIENCE OF THE SPARE TIRE TAKING UP SPACE IN THE TRUNK AND THE INABILITY TO STOW THE BACK SEAT CAN BE RESOLVED. WE APPRECIATE TOYOTA S CONCERN FOR SAFETY AND THAT THIS IS BEING ADDRESSED." *TR

TL* THE CONTACT OWNS A 2004 TOYOTA SIENNA. THE CONTACT RECEIVED NOTIFICATION OF NHTSA CAMPAIGN NUMBER: 14V273000 (TIRES); HOWEVER, THE PART NEEDED TO DO THE REPAIR WAS UNAVAILABLE. THE CONTACT STATED THAT THE MANUFACTURER EXCEEDED A REASONABLE AMOUNT OF TIME FOR THE RECALL REPAIR. THE MANUFACTURER WAS MADE AWARE OF THE ISSUE. THE CONTACT HAD NOT EXPERIENCED A FAILURE.

TL* THE CONTACT OWNS A 2004 TOYOTA SIENNA. THE CONTACT RECEIVED NOTIFICATION OF NHTSA CAMPAIGN NUMBER: 14V273000 (TIRES); HOWEVER, THE PART NEEDED TO PERFORM THE REPAIR WAS UNAVAILABLE. THE CONTACT STATED THAT THE MANUFACTURER EXCEEDED A REASONABLE AMOUNT OF TIME FOR THE RECALL REPAIR. THE MANUFACTURER WAS NOTIFIED OF THE ISSUE. THE CONTACT HAD NOT EXPERIENCED A FAILURE.

TL*THE CONTACT OWNS A 2004 TOYOTA SIENNA. THE CONTACT RECEIVED A NOTIFICATION OF NHTSA CAMPAIGN NUMBER: 14V273000 (TIRES) HOWEVER, THE PART TO DO THE REPAIR WAS UNAVAILABLE. THE CONTACT STATED THAT THE MANUFACTURER EXCEEDED A REASONABLE AMOUNT OF TIME FOR THE RECALL REPAIR. THE MANUFACTURER WAS MADE AWARE OF THE DELAY. THE CONTACT HAD NOT EXPERIENCED A FAILURE.

TL* THE CONTACT OWNS A 2004 TOYOTA SIENNA. THE CONTACT RECEIVED NOTIFICATION OF NHTSA CAMPAIGN NUMBER: 14V273000 (TIRES); HOWEVER, THE PART TO DO THE REPAIR WAS UNAVAILABLE. THE CONTACT STATED THAT THE MANUFACTURER EXCEEDED A REASONABLE AMOUNT OF TIME FOR THE RECALL REPAIR. THE MANUFACTURER WAS NOT MADE AWARE OF THE ISSUE. THE CONTACT HAD NOT EXPERIENCED A FAILURE.

SPARE TIRE FAILURE. TT

TL* THE CONTACT OWNS A 2004 TOYOTA SIENNA WITH DUNLOP RUN FLAT TIRES, SIZE 225/60/17, DOT NUMBER 3T6R2508. THE CONTACT WAS DRIVING 55 MPH WHEN THE FRONT AND REAR PASSENGER TIRES BLEW. THE CONTACT STATED THAT THERE WERE ABNORMAL BUBBLES IN THE TIRES. THE VEHICLE WAS TOWED TO THE DEALER WHO ADVISED THAT ALL OF THE TIRES NEEDED REPLACING. THE TIRES WERE REPLACED. THE CURRENT AND FAILURE MILEAGE WAS 48,000.