2008 Toyota Sienna Tires & Wheels Problems

The contact owns a 2008 Toyota Sienna. The contact stated while driving approximately 15 MPH, the spare tire hatch control cable snapped and dropped the spare tire onto the roadway. The vehicle rode over the spare tire on the passenger’s side rear wheel causing a jolt to the vehicle. The contact pulled off the road safely and determined that the vehicle was drivable. The contact had not taken the vehicle to a dealer or independent mechanic to be diagnosed or repaired. The manufacturer had been informed of the failure. The failure mileage was approximately 195,000.

TL* THE CONTACT OWNS A 2008 TOYOTA SIENNA EQUIPPED WITH BF GOODRICH TIRE, TIRE LINE: ALL TERRAIN K02, TIRE SIZE: 215/65/R16, DOT NUMBER: BFAEAT11. THE CONTACT STATED THAT WHILE DRIVING AT 55 MPH, THE PASSENGER'S SIDE FRONT TIRE EXPERIENCED A BLOWOUT. THE VEHICLE WAS NOT TAKEN TO BE INSPECTED OR REPAIRED. NEITHER THE TIRE MANUFACTURER NOR THE VEHICLE MANUFACTURER WERE CONTACTED OR NOTIFIED OF THE FAILURE. THE VEHICLE FAILURE MILEAGE WAS 134,920; TIRE MILEAGE FAILURE WAS UNKNOWN.

MY LUG NUTS ARE SWOLLEN. THIS IS APPARENTLY A COMMON PROBLEM WITH TOYOTA BECAUSE THEY USE A TWO PART LUG NUT DESIGN. WATER GETS BETWEEN THE TWO PARTS, SWELLS AND I CANNOT REMOVE MY TIRE. THANK GOODNESS I WAS NEAR A MECHANIC AND NOT 60 MILES NOWHERE. I COULD NOT GET THE WHEEL OFF THE CAR WITH MY CAR BASED TOOLS.

8/20/10 BOUGHT GOODYEAR ASSURANCE TIRES, 80K WARRANTY. 10/3/14 AT 65K TIRES WORN OUT EARLY, REPLACED TIRES WITH MICHELIN DEFENDER TIRES, 90K WARRANTY. 9/14/17 AT 48K TIRES WORN OUT EARLY, ALL 4 AT OUTER EDGE WAS 1 OR 2, BUT REST OF TREDS ARE 3 OR 4. ROTATED AND INFLATED TIRES PER REQUIREMENTS. MANY SIENNA OWNER ARE REPORTING THIS ISSUE. MAJOR SAFETY ISSUE WITH THIS VAN DESIGN TO HAVE TIRES WEAR SO QUICKLY.

VAN HAS EXCESSIVE TIRE WEAR CHARACTERISTICS. NO MATTER WHAT THE RATING OR QUALITY OF THE TIRE, THEY ONLY LAST AT MOST 25,000 MILES. ALIGNMENT IS FINE.

RECEIVED SAFETY RECALL #A9E A COUPLE YR.S AGO AND HAD THE RECOMMENDED REPAIR DONE ON THE SPARE TIRE CARRIER CABLE. THEN RECEIVED ANOTHER NOTIFICATION IN 10/15 THAT "THE ORIGINAL REMEDY PROCEDURE MAY NOT HAVE BEEN ADEQUATE." INFORMED THAT THE NEW SAFETY RECALL #E0S NOW SUPERSEDES A9E. TOOK VAN TO DEALER FOR THIS REPAIR ON 10/19/15. AFTER MECHANIC BEGAN WORK HE CAME TO WRITER AND ASKED WHERE THE SPARE TIRE WAS. MUCH TO MY SURPRISE THERE WAS NO LONGER A SPARE TIRE UNDER THE VAN-WE HAVE NEVER HAD A NEED TO USE THE SPARE AND HAVE NO IDEA WHEN IT FELL OFF. I WAS TOLD THAT THE CABLE WAS BROKEN AND THAT A NEW WHEEL AND TIRE WOULD HAVE TO BE ORDERED AND THAT I WOULD HAVE TO PAY FOR THIS. CONTACT WAS MADE WITH THE TOYOTA CUSTOMER CENTER AND AFTER MANY PHONE CALLS AND FAILURE OF THEIR REPRESENTATIVES TO RETURN CALLS WE WERE TOLD THAT THEY UNDERSTOOD THAT THE LOSS OF THE TIRE WAS DUE TO THE FAULTY SPARE TIRE CARRIER CABLE BUT THAT THEY ARE ONLY RESPONSIBLE FOR REPLACING THE CABLE. IT SEEMS ABSURD THAT OUR SAFETY AND THE SAFETY OF OTHERS WAS COMPROMISED BY THE SPARE TIRE FALLING OFF AND ALL THE COMPANY ASSUMES RESPONSIBILITY FOR IS THE CARRIER CABLE. WE HAVE NOW ORDERED A NEW WHEEL AND TIRE COSTING $300 TO $400 AND HOPE THAT THE MOST RECENT "FIX" WORKS.

TL* THE CONTACT OWNS A 2008 TOYOTA SIENNA. WHILE DRIVING APPROXIMATELY 5 MPH, THE SPARE TIRE ON THE REAR OF THE VEHICLE DETACHED FROM THE VEHICLE. THE CONTACT RECEIVED NOTIFICATION OF NHTSA CAMPAIGN NUMBER: 14V273000 (TIRES); HOWEVER, THE PART WAS UNAVAILABLE TO PERFORM THE REPAIRS. THE CONTACT STATED THAT THE MANUFACTURER EXCEEDED A REASONABLE AMOUNT OF TIME FOR THE RECALL REMEDY. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 130,000. UPDATED 2/4/16 *CN UPDATED 02/16/16.*JB

RECEIVED LETTER ADVISING THAT UNDER RECALL 14V27300 MY 2008 TOYOTA SIENNA HAD A POTENTIAL PROBLEM WITH THE CABLE, HOLDING THE SPARE TIRE UNDERNEATH THE VEHICLE WHICH NEEDED TO BE REPLACED. IN THE FALL OF 2014 MY SPARE TIRE WAS RELOCATED TO THE LUGGAGE COMPARTMENT OF MY VAN WHICH RENDERED THE AREA UNUSABLE FOR FOLDING THE REAR SEATS DOWN TO USE THAT AREA FOR TRANSPORTING LARGER ITEMS. I CHECKED WITH MY LOCAL DEALER REGARDING A PERMANENT SOLUTION/REPAIR AND WAS TOLD THEY HAD NOT YET RECEIVED NOTICE OF AND/OR REPAIR PARTS FOR THE IDENTIFIED PROBLEM. THIS HAS BEEN AN UNREASONABLE AMOUNT OF TIME TO WAIT TO REGAIN FULL USE OF MY MINIVAN.

TL* THE CONTACT OWNS A 2008 TOYOTA SIENNA EQUIPPED WITH COOPER CS5 GRAND TOURING (NA)TIRES, SIZE: 215/65R16 (NA). AFTER PARKING THE VEHICLE, THE FRONT DRIVER SIDE TIRE SUDDENLY EXPLODED. THE TIRE WAS TAKEN TO THE TIRE DEALER WHO INDICATED THAT THE FAILURE WAS DUE TO AN INTERNAL MANUFACTURING DEFECT. THE TIRES WERE PURCHASED ON 12/5/2015 AND THE FAILURE OCCURRED ON 4/19/2016. THE MANUFACTURER WAS NOTIFIED. THE VIN WAS UNKNOWN. THE VEHICLE AND TIRE FAILURE MILEAGE WAS 54,000.

TL* THE CONTACT OWNS A 2008 TOYOTA SIENNA. THE CONTACT RECEIVED NOTIFICATION OF NHTSA CAMPAIGN NUMBER: 14V273000 (WHEELS). THE VEHICLE WAS TAKEN TO THE DEALER. THE TECHNICIAN STRAPPED THE SPARE TIRE TO THE LUGGAGE COMPARTMENT OF THE VEHICLE AS A TEMPORARY REMEDY BECAUSE THE PART NEEDED TO REPAIR THE VEHICLE WAS UNAVAILABLE. THE CONTACT STATED THAT THE MANUFACTURER EXCEEDED A REASONABLE AMOUNT OF TIME FOR THE RECALL REPAIR. THE MANUFACTURER WAS NOTIFIED OF THE ISSUE. THE CONTACT HAD NOT EXPERIENCED A FAILURE. UPDATED 3/24/15*CN

TL*THE CONTACT OWNS A 2008 TOYOTA SIENNA. THE CONTACT RECEIVED NOTIFICATION OF NHTSA CAMPAIGN NUMBER: 14V273000 (TIRES). HOWEVER, THE CONTACT STATED THAT THE MANUFACTURER EXCEEDED A REASONABLE AMOUNT OF TIME FOR THE RECALL REPAIR. THE MANUFACTURER WAS MADE AWARE OF THE ISSUE. THE CONTACT HAD NOT EXPERIENCED A FAILURE.

TL* THE CONTACT OWNS A 2008 TOYOTA SIENNA. THE CONTACT RECEIVED NOTIFICATION OF NHTSA CAMPAIGN NUMBER: 14V273000 (WHEELS) HOWEVER, THE PART NEEDED TO PERFORM THE REPAIR WAS UNAVAILABLE. THE CONTACT STATED THAT THE MANUFACTURER EXCEEDED A REASONABLE AMOUNT OF TIME FOR THE RECALL REPAIR. THE MANUFACTURER WAS NOT NOTIFIED OF THE ISSUE. THE CONTACT HAD NOT EXPERIENCED A FAILURE.

TL* THE CONTACT OWNS A 2008 TOYOTA SIENNA. THE CONTACT RECEIVED NOTIFICATION OF NHTSA CAMPAIGN NUMBER: 14V273000 (TIRES); HOWEVER, THE PART NEEDED TO DO THE REPAIR WAS UNAVAILABLE. THE CONTACT STATED THAT THE MANUFACTURER EXCEEDED A REASONABLE AMOUNT OF TIME FOR THE RECALL REPAIR. THE MANUFACTURER WAS MADE AWARE OF THE ISSUE. THE VIN WAS NOT PROVIDED. THE CONTACT HAD NOT EXPERIENCED A FAILURE.

TL* THE CONTACT OWNS A 2008 TOYOTA SIENNA. THE CONTACT STATED THAT THE VEHICLE WAS INCLUDED AND PARTIALLY REMEDIED UNDER NHTSA CAMPAIGN NUMBER: 14V273000 (TIRES) HOWEVER, THE REMAINING PART TO DO THE RECALL REPAIR WAS UNAVAILABLE. THE CONTACT STATED THAT THE MANUFACTURER EXCEEDED A REASONABLE AMOUNT OF TIME FOR THE RECALL REPAIR. THE MANUFACTURER WAS NOTIFIED OF THE ISSUE. THE CONTACT HAD NOT EXPERIENCED A FAILURE. ..UPDATED 06-08-15 *BF THE CONSUMER STATED THERE WAS EXCESSIVE CORROSION OF THE SPARE TIRE CARRIER CABLE. SPARE TIRE AND CABLE WERE REMOVED FROM THE VEHICLE. THE SPARE TIRE WAS PLACED IN THE OPEN CARGO AREA NEAR THE REAR OF THE VEHICLE CAUSING BOTH A SAFETY ISSUE AND INCONVENIENCE IN THE USE OF THE CARGO AREA AND REAR SEATS. UPDATED 11/23/15 *JS

TL* THE CONTACT OWNS A 2008 TOYOTA SIENNA. THE CONTACT RECEIVED A NOTIFICATION OF NHTSA CAMPAIGN NUMBER: 14V273000 (TIRES) HOWEVER, THE PART TO DO THE REPAIR WAS UNAVAILABLE. THE CONTACT STATED THAT THE MANUFACTURER EXCEEDED A REASONABLE AMOUNT OF TIME FOR THE RECALL REPAIR. THE MANUFACTURER WAS MADE AWARE OF THE DELAY. THE CONTACT HAD NOT EXPERIENCED A FAILURE. MAILOUT 1/13/15*LJ

WHEN I WAS DRIVING ON THE HIGHWAY , THE TIRE ON THE RIGHT SIDE IN THE BACK ON THE SIDE OF THE PASSENGER SIDE EXPLODE AND BROKE THE PIPES OF THE HEATER AND THE ANTI FREEZE OF THE AIR CONDITION THAT WERE NEXT TO THE WHEEL THAT EXPLODED ON THE PASSENGER SIDE ON THE BACK WHEEL. *TR

TPMS BROKE WHILE INFLATING TIRES FOR A CUSTOMER. *TR

TL* THE CONTACT OWNS A 2008 TOYOTA SIENNA. THE CONTACT STATED THAT THE TIRE VALVE STEM DETACHED WHILE ADDING AIR TO THE TIRES. THE VEHICLE WAS NOT TAKEN TO THE DEALER. THE MANUFACTURER WAS CONTACTED AND THE VEHICLE WAS REPAIRED. THE FAILURE AND THE CURRENT MILEAGES WERE 35,000. THE VIN WAS NOT AVAILABLE.

THE RUN-FLAT TIRES START TO MAKE NOISE, AND THEN ONE DAY BEGIN TO VIBRATE BADLY. THE STEEL BELTS SEPARATE ON THE INSIDE OF THE TIRE, AND CATASTROPHICALLY FAIL WITH POTENTIAL TO CAUSE AN ACCIDENT. WE PULL OVER AND HAVE THE CAR TOWED TO A DEALER WHO REPLACES THE TIRES. THIS HAPPENS EVERY 10,000-30,000 MILES. WE HAVE TO BUY NEW TIRES TO REPLACE ALL 4 TIRES. *TR

TL*THE CONTACT OWNS 2008 TOYOTA SIENNA. THE CONTACT NOTICED THAT HIS TIRES AREN'T LASTING LONG. THE TIRES ARE GENERALLY SUPPOSE TO BE GOOD QUALITY TIRES AND SHOULD NOT EXPERIENCE WEAR AND TEAR UNTIL AT LEAST 25,000 MILES. AS OF 16,000 MILES THE TIRES SEEMED AS IF THEY WERE ON THE VEHICLE FOR YEARS. THE MANUFACTURER OF THE TIRES WERE CONTACTED AND THEY REFERRED THE CONTACT TO THE VEHILCE MANUFACTURER. THE VEHICLE MANUFACTURER INFORMED THE CONTACT TO CONTACT AN AUTHORIZED DEALER. AUTHORIZED DEALER INFORMED THE CONTACT THAT THEY WOULD HAVE TO WAIT UNTIL THE DISTRICT MANAGER CAME IN TO SEE WHAT THEY COULD DO TO ASSIST HIM. AS OF NOW THE CONTACT STILL HAS YET TO GET ASSISTANCE WITH THE TIRE FAILURE. THEY ALSO INFORMED THE CONTACT THAT HE WOULD HAVE TO WAIT UNTIL ALL THE RECALLS WERE TAKEN CARE OF BEFORE HE WOULD BE ASSISTED. THE VIN WAS NOT AVAILABLE. THE FAILURE MILEAGE WAS 16,000 AND THE CURRENT MILEAGE WAS 21000.