2016 Volkswagen Jetta Engine Problems

My camshaft sensors went bad at 77k miles had it towed to auto repair. Auto shop said my timing tensioner and chain were worn and needed replacement. Cost was 6200.00. A month later the engine blew at 81k miles. This was a lease for the first 3 years so all maintenance was done by Volkswagen. I had it serviced three times after that. Sits in my garage half the year as I travel by airplane or tour bus for work so no need to drive all the time. This shouldn’t be happening.

I bought the car brand new in 2016 had the oil changed on its scheduled maintenance and at 77000 mile my timing chain made my car go into limp mode. Now I am looking at a 4700$ in mechanic and engine work.

The contact owns a 2016 Volkswagen Jetta. The contact stated that the vehicle failed to exceed 30 MPH while driving. The ignition, the check engine, the ABS, and the camshaft warning lights were illuminated. Additionally, the contact stated that after refueling the vehicle, the vehicle failed to restart as needed. The contact stated that the vehicle started temporarily and shut off after several attempts. The vehicle was towed to the residence. The contact notified the dealer the vehicle was purchased from of the failure. The dealer informed the contact that the warranty had expired. The vehicle was not diagnosed or repaired. The manufacturer was not notified of the failure. The failure mileage was approximately 71,000.

There is an issue with the amount of engine oil used. It is burned up at a rapid pace. This has caused my car to malfunction (EPC light turns on). This happened to me driving on the highway it put myself and my passengers in danger as the car would slow down and jerk abruptly. My car has been inspected by a VW dealership. They found no issue on it. However, when taking it to an independent VW mechanic shop, I was informed this is a common issue in this car. They engine oil burns drastically. This has caused me to spend a significant amount of money to replenish the oil level every week. My current situation is using about 3 quartz of oil every 1500 miles! Otherwise, my car will run with no oil which could lead to permanent engine problems and dangerous driving conditions. The low oil warning goes off almost all the time. I was quoted a repair cost from an independent shop of more than $3,000 to fix this well known issue by reconstructing parts of the car to mirror newer models for which VW fixed this problem. This indicates to me VW is aware of this factory defect. Moreover, tons of people are reporting this issue online. I recall is in order.

Water pump and thermostat housing inspected and needing to be replaced according to inspection by Volkswagen Welsey Chapel on this 2016 Jetta. The quoted repair needs immediate attention and costs $1025.46. A leaking water pump could also cause the engine to stop functioning while the car is in motion. Even if the driver pulled over, being stranded on the side of a highway waiting for a tow could be dangerous. I notified VW customer care and was directed NHTSA as there is no recall for this cars year. There were not warnings of this issue until noticed at inspection. Volkswagen has yet to issue a recall for this severe problem.

I got this vehicle at 36,000 miles and I have put 23,000 on it in one year. There have been no warning messages. I was in idle and my RPMs started jumping I put it in reverse ( jumping stopped) , then drive to have the vehicle get a mile or two down the road and completely die. I was rear ended . Got it into a repair shop to be told by a certified mechanic it was throwing codes for the camshaft as well as needing an evap purge at just under 60,000 miles.

Excessive oil consumption over a short period of time - inspected by auto mechanic and VW dealer - no leaks and no buring of oil noted. Loosing a quart over the period of one month after an oil change - warning light comes on but when you are alone on the highway at night you cant always pull over.

WE HAVE A 2016 VW JETTA TSI 1.4L (EA211 ENGINE) WITH A MANUAL TRANSMISSION. AT APPROXIMATELY 98,000 MILES, FUEL STARTED LEAKING FROM THE FUEL RAIL AREA, SLOWLY AT FIRST, JUST A SCENT OF FUEL. NEXT DAY, AT THE END OF THE DAY'S DRIVING, THE VEHICLE WENT INTO LIMP MODE JUST BEFORE MY EXIT ON THE HIGHWAY WITH A STRONG SMELL OF GAS. IT LIMPED 3 MILES HOME AND DIED AS I PULLED INTO THE DRIVE. WHEN WE MANAGED TO GET IT STARTED AGAIN IT GUSHED FUEL FROM THE FUEL RAIL AREA. THERE IS A PENDING RECALL ON THIS ISSUE BUT VOLKSWAGON DECLINED TO DO ANYTHING BEYOND A NORMAL PAID-FOR REPAIR WITH POTENTIAL REIMBURSEMENT (NOT GUARANTEED) UNTIL THE RECALL ISSUES LEAVING US WITHOUT A VEHICLE. WE HAVE A VIDEO DOCUMENTING THE FUEL LEAK.

TECHNICAL SERVICE BULLETIN FOR A KNOWN ISSUE THAT THE ACTIVE GRILL SHUTTERS ARE STUCK IN THE OPEN OR CLOSE POSITION. THIS COULD CAUSE THE ENGINE TO OVER HEAT. THIS CAN HAPPEN WHEN CAR IS STATIONARY OR IN MOTION.

VOLKSWAGON RELEASED RECALL NUMBER 24GI ON OCTOBER 14, 2020, THE SUMMARY OF WHICH STATES, "THE FUEL RAIL BOLTS ON AFFECTED VEHICLES MAY BECOME LOOSE OVER TIME. THIS CAN RESULT IN A FUEL LEAK. SAFETY RISK: LEAKING FUEL, IN THE PRESENCE OF AN IGNITION SOURCE, MAY RESULT IN A VEHICLE FIRE." AS OF THE DATE JANUARY 19,2021, A REMEDY FOR THIS ISSUE IS STILL NOT AVAILABLE FROM EITHER THE MANUFACTURER OR THE DEALER

I DRIVE A 2016 VW JETTA ,MY EPC LIGHT CAME ON.WHEN I MADE AN APPT WITH THE VW DEALER, THEY DID A DIAGNOSTIC ON MY CAR WITH THE CODE P22630,WHICH IS THE TURBOCHARGER /BOOST. THE COST FOR THE PART IS ABOUT $ 2500. FOR A CAR THAT IS ONLY A FEW YEARS OLD AND HAVING A MAJOR REPAIR ISSUE ,IAM SO DISAPPOINTED AND FEEL NOT SAFE AT ALL. HOW CAN A TURBO CHARGER BOOST BREAK ALREADY!!!! THATS MY COMPLAINT. ANYONE ELSE HAS A PROBLEM LIKE THAT?

SHORTLY AFTER I PURCHASED MY VEHICLE (USED AT AROUND 73K MILES) THE TURBO FAILED. I THOUGHT THAT WAS ODD AT THE MILEAGE SO I ATTEMPTED TO SUBMIT A CLAIM TO VOLKSWAGEN. I WAS DENIED. MY HUSBAND WAS ON THE FREEWAY WHEN THE TURBO FAILED AND THE CAR BEGAN TO SLOW AND LAG WHEN HE ATTEMPTED TO ACCELERATE. HE PULLED OVER AND CALLED TGE TOW TRUCK AND WHEN I TOOK IT IN TO VOLKWAGEN THE SERVICE MANAGER SUGGESTED THAT I REACH OUT TO VOLKSWAGEN TO SUBMIT A CLAIM BECAUSE HE THOUGHT IT WAS TOO EARLY FOR THAT KIND OF FAILURE.

BEGINNING AT 60K MILES I REALIZED THAT MY JETTA SPORT 1.8L BEGAN TO CONSUME OIL AT A MUCH HIGHER RATE THAN USUAL SO MUCH SO THAT I TOOK IT TO MY NEARBY DEALERSHIP AND HAD IT LOOKED AT. I WAS TOLD THAT THERE WERE NO LEAKS AND THAT THE OLDER VW'S GET THE MORE THEY BURN OIL. HOWEVER, THEY REFERRED TO THE OIL BURNING AT AROUND A QUART EVERY 5,000 MILES BUT MY CAR IS BURNING OIL AT 5 TIMES THAT SPEED OF A QUART EVERY 1,000 MILES. I HAVE TO KEEP A QUART OF OIL IN MY CAR AT ALL TIMES AND IT IS BEGINNIGN TO BECOME EXPENSIVE. I TRAVEL BETWEEN STATES OFTEN AND DO THE ARIZONA-INDIANA AND BACK TRIP ONCE A YEAR SO IT DOES HAVE MOSTLY HIGHWAY MILES ON IT.

TL* THE CONTACT OWNS A 2016 VOLKSWAGEN JETTA. THE CONTACT STATED THAT SEVERAL HOURS AFTER THE VEHICLE WAS PARKED, THE VEHICLE CAUGHT ON FIRE. THE FIRE DEPARTMENT WAS NOTIFIED AND WAS ABLE TO EXTINGUISH THE FIRE. THE FIRE STARTED IN THE ENGINE COMPARTMENT. A FIRE REPORT WAS NOT FILED. THE CONTACT WAS INFORMED THAT THE FIRE WAS CAUSED BY AN ELECTRICAL FAULT UNDER THE HOOD OF THE VEHICLE. THE VEHICLE REMAINED AT THE RESIDENCE. THERE WAS NO ADDITIONAL INSPECTION DONE ON THE VEHICLE. SERRA VOLKSWAGEN LOCATED AT 1490 CENTER POINT PKWY, BIRMINGHAM, AL 35215, WAS CONTACTED BY PHONE AT 205-286-9924, AND THE CONTACT WAS REFERRED TO VOLKSWAGEN CUSTOMER CARE. VOLKSWAGEN CUSTOMER CARE WAS CONTACTED AND INFORMED OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 46,000. AT PRESENT THE VEHICLE WAS NOT DEEMED TO BE DESTROYED.

WHILE DRIVING THE CAR ON CITY STREETS AND ON THE HIGHWAY AT 65 MPH THE CAR SUDDENLY BECOMES UNRESPONSIVE AND SLOWS TO A STOP. THE STEERING WHEEL LOCKS AND THE ACCELERATOR DOES NOT WORK. THE CAR WILL NOT IMMEDIATELY RESTART. IF THE CAR IS TURNED OFF AND ALLOWED TO SIT FOR 10-15 MINUTES IT WILL USUALLY RESTART. THIS HAS HAPPENED AT LEAST THREE TIMES.

NHTSA CAMPAIGN ID 16V4030000.VOLKSWAGON IA WARE OF RECALL