2019 Volvo XC60 Electrical System Problems

On 9/1/25 while driving 25 mph in the neighborhood the car started shifting very hard. Upon getting back in the driveway and put in park all dashboard light came on. Car would not leave park, parking brake would not work. Windows would not roll down, dash would not turn on, car would not turn off. Got it to the dealership and the told me it was a software update that needed to be done.

I am submitting this report to formally document a significant safety issue involving the Driver Display Module (DIM) on my Volvo XC60. Prior to reaching 45,000 miles, the DIM began to intermittently glitch, displaying only a barcode-like screen. This eventually progressed to complete failure of the unit with complete lack of digital driver display without analog back-up. As a result of this malfunction, all critical vehicle information became inaccessible, including the speedometer, odometer, fuel level, gear selection, and dashboard warning indicators. This failure severely impairs the driver’s ability to safely operate the vehicle, as it removes access to essential operational data necessary for safe driving and decision-making. I reported this issue to Volvo Customer Support, but they were dismissive of the concern and offered no meaningful resolution. In researching the problem, I found multiple similar complaints documented in online automotive forums, suggesting that this is not an isolated incident but rather a recurring defect among Volvo XC60 vehicles. Given the safety-critical nature of the driver display and the fact that this failure occurred in a relatively low-mileage vehicle, I believe this issue warrants investigation by NHTSA. The frequency of these failures and the serious risk they pose to driver awareness and vehicle control support the need for a safety recall. Thank you for your attention to this matter.

The right side module buttons on steering wheel stops working

Water intrusion via a faulty sunroof seal and drain system. Water drains into the vehicle and collects under the flooring carpets and is not detectable. Water then disables and shorts out electrical components and computer modules eventually rendering the vehicle completely inoperable … including airbags, suspension system and electronic engine components. All control is lost. System also displays a number of random and often times confusing and erroneous error message to display console. This is an extremely dangerous problem, and extremely expensive to remedy, and appears to be related to a significant design flaw. According to internet reports, this is a known issue. Dealer is the one who diagnosed the problem. Given this problem affects electronics - there is a threat of fire.

Any switch on the right side of the steering wheel - Up/down/Left/Right/Center switches not functioning or intermittently functioning. It is available for inspection upon request As the buttons are not warning, any signs or anything which comes on the center display cannot be removed or moved The vehicle or component has not been inspected but the technical journal (REF NO: TJ 32033.5.0) for the same was issued - [XXX] There are other forums who have brought the same issue as well [XXX] INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

Driving down the interstate in rush hour at 30 mph, the entire entertainment system as well as the dashboard went black and went through a system restart. The dashboard, including spedometer and related controls were black and unusable for approximately 10 seconds. Approximately 3 minutes later, the system reboot again and all visual aids were unusable for 10 seconds or so.

WHILE I WAS DRIVING IN A BUSY MULTILANE CITY TRAFFIC SITUATION, THE CAR'S CENTER CONSOLE WENT COMPLETELY BLANK AND THE TURN SIGNALS, HAZARD LIGHTS, AND VOLVO ON CALL WERE NOT FUNCTIONING PROPERLY. I AM NOT SURE WHAT ELSE WAS AFFECTED. THIS CONTINUED FOR A FULL 1-2 MINUTES, UNLIKE TIMES BEFORE WHEN THE SYSTEM HAS DONE THE SAME THING BUT QUICKLY RE-BOOTED. THE SAFETY OF OTHERS AND MYSELF WAS COMPROMISED, AS I NEEDED TO CHANGE LANES TO GET ONTO THE INTERSTATE. I COULD NOT TELL IF MY SIGNALS WERE FUNCTIONING BECAUSE THE SIGNALS WERE NOT MAKING A CLICKING SOUND AND THE FLASHING SIGNAL INDICATOR LIGHTS WERE COMPLETELY NONFUNCTIONAL. I TRIED THE HAZARD LIGHTS AS WELL, WHICH DID NOT FUNCTION. I PRESSED THE VOLVO ON CALL BUTTON, BUT NOTHING HAPPENED. WHEN I TOOK THE CAR TO THE DEALERSHIP, THE SERVICE MANAGER STATED THAT A "SOFTWARE UPDATE" WAS PERFORMED TO FIX THE PROBLEM, AND WHEN I QUESTIONED HOW I WAS TO KNOW IF THIS WOULD BE A PROBLEM IN THE FUTURE, I WAS TOLD THAT I "WOULDN'T KNOW UNLESS THERE WAS A PROBLEM" AND THEY CLAIMED TO KNOW NOTHING ABOUT WHETHER THE INCIDENT WOULD BE REPORTED TO THE NHTSA. I FEEL UNSAFE DRIVING THIS CAR NOW, WHICH IS IRONIC CONSIDERING THAT I BOUGHT A VOLVO FOR ITS PURPORTED SAFETY.

SAFETY ISSUE THE AUTO-HOLD BRAKE FUNCTION MALFUNCTIONED. I AM USING THIS FEATURE A LOT. WHEN ENTERING A PAID PARKING GARAGE THE CAR STOPPED CORRECTLY BEFORE THE GATE . BUT WHEN OPENING THE DOOR AND UNBUCKLING THE DRIVER'S BELT THE SYSTEM MALFUNCTIONED- INSTEAD OF ENTERING AUTO PARKING MODE AND BE STOPPED IF MOVED FORWARD FAST, BREAKING THE PARKING GATE COMPLETELY, DAMAGING CITY'S PROPERTY, BREAKING MY MIRROR AND GETTING DENTS ON THE HOOD, DRIVER'S DOOR AND B-PILLAR TRIM PANEL. ALSO MY LEFT ANKLE HAD A BIG BRUISE AND LUMP AFTER THAT, BUT LUCKILY WAS NOT BROKEN . THIS CASE WAS REPORTED TO POLICE. THE VEHICLE WAS STOPPED. PARKING GARAGE ENTRANCE