2022 Acura MDX

I was at a stop light, when the lights turned green, I accelerated and heard a loud bang underneath the vehicle. The sound was so loud I thought I had been rear ended. I got out to inspect the vehicle and did not see any damages. I got back into the vehicle and put it in drive to get to the closed gas station. When I started driving, I heard clunking sounds underneath vehicle. I put on my hazards and drove slow. After about 50-100 ft the clunking sounds went away. No lights on the dash or anything. I then got vehicle towed to my father’s shop to inspect what was going or what happened due to not feeling safe driving. One of his employees looked up the cause of the noise and had found that the differential splines or transfer case would strip and cause a loud bang. Which happens on a lot of these acuras. He put vehicle on lift, and put it into drive. The front wheels would spin, but not the rear wheels. He said that indicates the transfer case is bad

RIGHT AND LEFT REAR STROKE SENSOR AND AFTER MARKET CONNECTOR WITH PIGTAILS FOUND CORROSION NEE REAR STROKE SENSOR CONNECTOR CAUSING DTC C1646-F0=== $872.13 right + $872.13 left They are using after market parts with this new Suspension system for Acuras MDX TYPE S. Any car wash or rain storm or snow storm this parts gets corrosion!

The AWD system failed and now its only FWD

Complete drivetrain failure while accelerating from a complete stop in the middle of a busy intersection. No warning lights or hazard messages were activated before or after the failure. The car made a massive clunking/banging sound and continued to clunk on acceleration. The car had to be towed to the dealership. My children were in the car with me, and we had just driven on the highway for 45 minutes before this failure. Luckily, my husband was behind me, and I activated hazards until I could pull over safely. It was jerking and clunking so badly that I was barely able to steer. It was terrifying since my two young children were in the car, and they were both screaming from the noise. I believe I would have been rear-ended if my husband had not been behind me due to the sudden jerk from the failure, as I was the first car in the left turn lane. This is not the first issue I have had with the transfer case in this vehicle. The affected transfer case and drive train were replaced only 7 months prior due to a faulty transfer case and a severe clunking sound. This vehicle has had repeated drivetrain failures without warning, resulting in loss of traction and control. The recent failure reflects a completely stripped spline connecting the transfer case and transmission. This will be the 4th transfer case this vehicle has had at only 64K miles. All recommended maintenance and care have been completed at the certified Acura dealership since the vehicle was purchased. Recently, the 60K services were completed just 3 months prior to the current failure. The vehicle is currently at the dealership for repairs under warranty, as it needs a new transmission and another transfer case. I have not yet received the documentation, as the car is not in my possession, but I will provide it once I receive it. See the attached documentation from the previous failure, dated 6/3/2025, to establish a pattern of catastrophic drivetrain failure.

Vehicle has a service bulletin issued by NHTSA and Honda/Acura of North America refuses to acknowledge it or fix the problem. for 4 years. Service Bulletin 24-025

My vehicle stopped handling as it usually had and I at a significant decrease in traction and slid off the road and slammed into a road sign. No injuries but significant damage to the vehicle. It seemed as though the all-wheel drive was not working. No warning lamps and computer system indicated that all four wheels were getting power. Took it to dealer and they confirmed that the all-wheel drive system has failed. Splines in the transfer case stripped and transmission needs to be replaced

Please add me to the compliant pool. My transfer case/transmission went out - 2022, 80,000 miles. March 6, 2026 NHTSA CAMPAIGN NUMBER: DP26001 OPEN INVESTIGATION All wheel drive allegation NHTSA Action Number: DP26001 Components: POWER TRAIN Opened From: March 6, 2026 – Present Summary The Office of Defects Investigation (ODI) received a Petition dated January 9, 2026, requesting an investigation into the loss of the optional all-wheel drive capability in model year (MY) 2021-2023 Acura TLX and MY 2022-2023 Acura MDX vehicles. The Petition contends that the interfacing splines between the transmission and the rear wheel drive power take off unit are failing. Failure of these splines prevents the transfer of drive power to the rear axle, making the vehicle front wheel drive only. The Petition further alleges that this failure results in a reduction of vehicle directional control. The Petitioner cites 48 complaints received by ODI alleging the same failure. ODI will evaluate these complaints to determine if they are related to the failure cited in the Petition and will conduct a technical review under 49 CFR Part 552. This Defect Petition is being opened to evaluate whether to grant or deny the Petition. The Petition can be viewed at NHTSA.gov under NHTSA Number 11712885.

MDX Type S with 63k miles. After performing diagnostic check there were several fault codes related to the vehicle's suspension system. Upon inspection, they identified issues with the ride height (stroke) sensors and wiring. The right rear, left rear, and right front sensors are affected. The right rear sensor has a broken pin, and part of that pin is stuck in the wiring connector. The left rear sensor also has a pin that is corroded. Additionally, the main wiring harness along the floor is corroded. This is due to poor location of wire harness in the Type S, and corrosion was due to salt exposure from icy roads. Dealership confirmed this was a known issue and had about a dozen of these replacements in the last few months.

I am filing a complaint regarding my 2022 Acura MDX Type S with approximately 70,700 miles. The vehicle developed a suspension system warning, and upon inspection by an Acura dealership, I was informed that the suspension stroke sensor and floor wiring harness are corroded and require replacement. I was quoted approximately $12,000 for the repair. This failure is extremely concerning because the vehicle is only a few years old and this type of corrosion affecting a major wiring harness should not occur under normal operating conditions. The affected components are part of the suspension system, which directly impacts vehicle handling and safety. Due to the failure, the suspension system may not function properly, potentially affecting ride height, stability, and overall control of the vehicle. This raises safety concerns, especially at highway speeds or during emergency maneuvers. There was no prior warning of water intrusion or external damage that would reasonably explain this level of corrosion. This appears to be a premature failure of a critical electrical component. Acura has only offered minimal goodwill assistance, leaving the majority of this extremely costly repair as the responsibility of the owner. I am concerned that this may be a broader issue affecting other vehicles and that it could pose a safety risk if not addressed. I am requesting that this issue be investigated. Thank you.

2022 Acura MDX Transfer Case and Transmission Failure – Spline Shearing ​Description of Incident: I am reporting a catastrophic drivetrain failure on my 2022 Acura MDX. This failure occurred at approximately 50,000 miles. The vehicle initially exhibited a leak at the front differential/transfer case gasket. Upon inspection by the dealership, it was confirmed that both the transfer case and the transmission require complete replacement. ​This failure matches the technical details in the recently opened NHTSA Action Number DP26001. The interfacing splines between the transmission and the power take-off unit (transfer case) have failed, which is a known defect currently under investigation. ​Safety Concern: This defect causes a sudden and unexpected loss of all-wheel-drive capability. This results in a significant reduction in vehicle directional control and traction, particularly in wet or slippery conditions, posing an unreasonable safety risk to myself and my family. This occurred well within the expected lifespan of a modern powertrain. ​Resolution: The vehicle is currently undergoing a full transmission and transfer case replacement at the dealership under warranty.

The rear passenger door actuators have both failed. The rear hatch will not unlock using the touch button. We just received notice that our transmission/transfer case needs replacing. $13K for this.

The car threw several warning lights on the dash. The main indicator was that there was a problem with the air suspension: "Adaptative air suspension problem. Please see your dealer." The left airbag on the suspension then popped, rendering the car undriveable as the compressor would constantly blow air to try to inflate the airbag. The car was repaired at an independent facility at the cost of $2900.00 to replace the suspension airbag and the height sensor, as well as recalibrating ADAS. The car had 66k miles at the time of the incident.

The AWD does not work on the vehicle. Multiple mechanics have been unable to diagnose any problems. We assume it has never worked until needed this season

Driving on the interstate merging from a ramp to go into the highway , heard a loud bang and the car drivetrain started to wobble . Next noticed more torque in front wheels . Transfer case failed internally , all services done at the right mileage by dealer , transmission spline end got wiped out 66,000 miles on vehicle never was abused just going from point A to B.

The battery drains quickly. Have replaced the battery twice since 2022. something in the car is draining the battery and making it fail. infotainment screen sometimes stays grey and doesn't go black when car is off. many 2022 mdx owners are having similar battery drain issues requiring frequent battery replacements. please push Acura for a recall and fix.

All Wheel Drive system failure. My vehicle's all wheel drive system failed during a snow storm, it reverted to Front wheel drive only.

My Acura service department notified me at my last oil change that they discovered (accidentally) my transmission / transfer case is damaged and is not transferring power to the rear wheels, rendering the vehicle as 2 wheel drive only. This requires a total replacement costing 16,000 /-. My research indicates this is likely caused by a faulty splined shaft inside the transmission-transfer case assembly used in the early 2022 MDX vehicles.The dashboard info system for SH-AWD indicates that the car IS in All Wheel Drive and there are no messages indicating a problem with the All Wheel Drive. This has not been a problem during non-snow or other slippery conditions, but recent storms have made this a major safety problem for me. The fact that the car sensing system does not detect this problem could cause serious driving danger for unsuspecting drivers. This also prevents Acura/Honda from acting on this issue publicly as owners of this vehicle have no way of knowing the problem exists until it is too late.

In January of 2026, when driving under normal conditions, the 2022 Acura MDX made a loud clunking noise and power was temporarily disrupted. The vehicle had to be stopped on the side of the road as the clunking noise persisted. This occurred on a major highway and put the driver and passengers at risk as we had to quickly get to the shoulder. After inspecting the vehicle for any visible signs of damage we continued home without issues. Now, March of 2026, we took the car for routine service and was contacted by the dealership and informed the transfer case and transmission needed to be replaced. The dealership indicating they were in contact with Honda USA to see what they could do for us. A quick search of the Internet revealed NHTSA DP26001, so we now know this issue has occurred on many Acura MDX's of the same year. No warning lamps illuminated. We were unaware that the vehicle was running in 2erWD instead of 4WD. There were no warnings leading up to the event.

While driving in snow and in light rain noticed the MDX pulling and slipping. I realized that only the front tires were trying to drive the vehicle which was causing the car to pull sideways and slip all over the road. I made an appointment with the ACURA dealership and they found the transmission splines stripped out that drive the rear wheels. There was no warning lamps or indication that anything was broke other than very hard to drive in any kind of snow or rain. Talking with the dealer and looking online this seems to be happening to other MDX s also. My car was fixed under the manufacturer warranty and the transmission and transfer case were replaced.

The component that malfunctioned was the transfer case, the vehicle was already repaired so an inspection isn't possible anymore. The vehicle behaved as normal until the accelerator was pressed enough to make the front wheels lose traction, in which the vehicle couldn't send power to the rear, because the transfer case was shredded up. When needing to accelerate quickly in traffic, the vehicle would completely spin up the front tires, not being able to put the power down. The dealer reproduced the problem, but initially stated that it was most likely due to the salt on the road (it was winter). As spring arrived, the problem still persisted, in which the dealer checked the transfer case and found it was shredded. They replaced the transmission and transfer case under warranty. There were no warning lights, but accelerating quickly would cause the car to spin up the front tires uncontrollably. In corners, this meant severe understeer that could be dangerous in the wrong circumstances.